Professional Documents
Culture Documents
Installation Diagrams
HVAC PRODUCTS
• The room temperature controller should be fitted in • The unit can be fitted to most commercially available
the main living room. recessed conduit boxes or directly on the wall.
• The place of installation should be chosen so that • For the electrical installation, the local safety
the sensor can capture the room temperature as regulations and standards must be complied with.
accurately as possible, without being affected by
direct solar radiation or other heating or cooling • If the reference room is equipped with thermostatic
sources. radiator valves, they must be set to their fully open
position.
• Mounting height is approx. 1.5m above the floor.
An optional sub-base is available on request, to If you have any difficulty or require further
assemble unit just follow these five simple steps and information, please contact our helpline telephone:
the information on the following page. 01527 406224
Step 1. Step 3.
F
B
Step 2. Step 4.
C
24°C
11°C
Step 5.
ELECTRICAL CONNECTIONS
Thread the cables through the slot in the base, 2 3 1
make the connections to the terminals as Load
Pump
shown on the diagram inside the cover and U
Valve
illustrated on the right.
etc.
N
L
No neutral required
Must be earthed
NOTES