Professional Documents
Culture Documents
DEVELOPMENT SPEC
Style Name: GEORGE T-SHIRT Fabric/Yarn: Dot Jacqurd DATE: 11/6/2015
Style #: 104.2854 Delivery: Content: Yarn Mill:
Season: ANNIVERSARY 16 Factory: SOURCING PARTNERSample Size: MEDIUM
BILLY REID
DEVELOPMENT SPEC
Style Name: GEORGE T-SHIRT Fabric/Yarn: DATE: 11/6/2015
Style #: 104.2854 Delivery: Content: Yarn Mill:
Season: ANNIVERSARY 16 Factory: SOURCING PARTNERS Sample Size: MEDIUM
3-thread 3/16 Overlock + Overlock seam allowance together, press towards bottom hem, and apply
NECK SEAM
Single Needle Topstitch a 1/16" topstitch. Use overlock of 3/16"
NECK TAPE Edgestitch Interior back neck seam is covered with 10mm herringbone tape.
4-thread Overlock With mobilon ,Overlock seam allowance together, press towards back and
SHOULDER SEAM
+Single Needle Topstitch apply 3/16" topstitch (Single Needle chain stitch)
1. SIDE SEAMS
2. ARMHOLE 4-thread Overlock Overlock seam allowance together
1/8 Single Needle Chest pocket is top applied and clean finished with 1/8" topstitch. Hem of
CHEST POCKET
(WEARER'S LEFT)
Topstitch / 1/8" 2N pocket is finished with 2N coverstitch, 1/8" spacing between stitch lines.
Coverstitch Interfacing in the inside hem (01 layer)
1. HEM 2N Coverstitch Turned hem for clean finish ,1" hem @ bottom hem and sleeve sleeve,
2. SLEEVE HEM 1 /8" gg apply 2N coverstitch, 1/8 gg
Stitch around 4 sides. Main Label is at CB, 1/4" below twill tape at back
LABEL Single needle edge stitch neck seam.
Applied to half-moon.
12/4 - NO BARTACKS
ON POCKET FOR ND
SMS
DATE MODIFIED:
APPRVD Y/N DESCRIPTION SUPPLIER LOCATION SIZE QUANTITY VER #1 VER #2 VER #3 VER #5 COMMENTS
BILLY REID
GEORGE T-SHIRT
ANNIVESARY 16
MEN'S
**PLEASE DATE AND INITIAL ALL COMMENTS; NOTE ANY RELEVANT ATTACHMENTS, ILLUSTRATIONS, or PACKAGES
SAMPLE I DATE INITIALS COMMENT/REVISION VENDOR REPLY ATTACHMENTS
SOURCING PARTNERS LIMA COMMENTS 1ST PROTO AUIDT REPORT
1ST PROTO 27 .November .15 Ketty T MATERIALS
1.- FABRIC: Used in this proto quality is correct, color is available.
2.- COTTON SHEETING : Used in this proto quality and color are correct.
3.- HERRINGBONE 10MM: Used in this proto quality and color are correct.
4.- HEIRLOOM RIBBON 10MM: Used in this proto quality and color are correct.
5.- THREAD : Used in this proto is correct.
6.- LABELS: Used in this proto are correct.
Please see attached the measure audit report in the following page
BILLY REID
FISHER CREW PULLOVER
FALL 16
MEN'S
CONTRUCTION
1.- All is according to spec
MEASUREMENT
1.- Sleeve length from CB : +5/8" / +3/4" Tolerance is 3/8".
2.- Please see the Measurement Audit report in the next page.