Professional Documents
Culture Documents
1. The tenderer is required to fulfil his Mechanical/Electrical Contractors for this tender, whose
particulars shall be given below.
2. The tenderer must ensure that the nominated Mechanical/Electrical Contractors are registered
with UPKJ under the correct Head and Class as stated in Clause A.1 of this specification, and that
at the time of tendering, no disciplinary action has been imposed on them by the Chief Electrical
Inspector. Failure to comply with the above will cause the whole tender to be rejected.
3. The tenderer shall note that once accepted, the Mechanical/Electrical Contractors shall not be
changed unless with the prior written approval of the Superintending Officer.
4. (a) Name of Mechanical/Electrical Contractor : …………………………………………
Date : ..................................................
SCHEDULE ‘A’
SUMMARY OF WORKS
PROPOSED CONSTRUCTION OF NEW PONTOON INTAKE AND JETTY AT NANGA SEKUAU WATER
TREATMENT PLANT, SIBU DIVISION, SARAWAK
The amount entered shall include supply and delivery, erection and installation, testing and commissioning, and all duties and
taxes necessary to complete the whole installation as per drawing and specification. Claims due to omissions of item shall not be
entertained. Remarks: Source of electricity supply from Sesco and Genset.
Unit rate Amount
Item Scope of works Qty (RM) (RM)
A GENSET ROOM
2................................................................................
Address :............................................................................................................................
............................................................................................................................
PROPOSED CONSTRUCTION OF NEW PONTOON INTAKE AND JETTY AT NANGA SEKUAU WATER
TREATMENT PLANT, SIBU DIVISION, SARAWAK
Pump
Manufacturer
Country of Manufacture
Brand/Model
Suction Size (mm)
Delivery Size (mm)
Impeller Size (mm)
Speed (RPM)
Discharge (l/s)
Total Head (m)
Efficiency
Shaft Power
Casing Material
Impeller Material
Shaft Material
Mechanical Seal Material
Motor
Manufacturer
Country of Manufacture
Brand/Model
Type
Type of Enclosure IP
Rated Power kW
Full Load Speed RPM
Voltage/Cycle/Phase
Full Load Current
Insulation Class
Efficiency At :
100%
75%
50%
Power Factor at :
100%
75%
50%
Bearing Type DE/NDE
Cooling Jacket Provided
Pump Control Panel
Manufacture of Switch Board
MCCB Manufacturer
Type
Short Circuit Capacity Kit
TPN Rating (A)
Auto Transformer Manufacturer
Power Rating (kW)
Protection Class
Type of Motor Projection
SCHEDULE ‘C’
Failure to complete this schedule may render the tenderer to be rejected. Once this schedule is
accepted, the contractor shall not change any item. Its acceptance does not relieve the Contractor of
responsibility to ensure that equipment concerned meets the characteristic and performance specified.
The unit rate shall refer to the brand of item and model offered and shall fairly represent its market
value. Otherwise the Contractor may require adjusting the rate. Unit rate shall include delivery,
installation and testing.
ELECTRICAL INSTALLATION:
SCHEDULE ‘D’
The original catalogues for the following equipment must be attached with the Tender Document: