Professional Documents
Culture Documents
Page 1 of 3
Shutdown SIS
Previous Screen
Product: EXCAVATOR
Model: 319D LN EXCAVATOR WBJ00255
Configuration: 319D L & 319D LN Excavators WBJ00001-UP (MACHINE) POWERED BY C4.2 Engine
Specifications
C4.2 and C6.4 Engines for Caterpillar Built Machines
Media Number -KENR6740-23 Publication Date -01/02/2014 Date Updated -24/02/2014
i02876647
Illustration 1 g01358113
1. Put the main bearing caps in position in the cylinder block. Apply clean engine oil on the
main bearing bolts. Install the main bearing bolts and tighten the main bearing bolts to a
torque of 137 ± 5 N·m (100 ± 4 lb ft).
https://127.0.0.1:442/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/siswe... 22.11.2023
319D L & 319D LN Excavators WBJ00001-UP (MACHINE) POWERED BY C4.2 E... Page 2 of 3
2. Measure the main bearing bores with a dial indicator. Subtract the diameter of the
crankshaft journal from the inside diameter of the main bearing in order to determine the
bearing clearance on the main journal. Clearance between the crankshaft journal and the
main bearing is 0.050 to 0.118 mm (0.0020 to 0.0047 inch).
Note: Replace the bearings or refinish the crankshaft to the next undersize bearing if the main
bearing clearance exceeds 0.20 mm (0.008 inch).
Note: The allowable tolerance for main bearing journals that are out of round is 0.010 mm (0.0004
inch). The maximum repair limit is 0.030 mm (0.0012 inch). If the repair limit is exceeded,
regrind the bearing journals to the specified dimension.
Illustration 2 g01358114
(3) Bolts
Table 1
Thickness for Crankshaft Main Bearing
Size of Crankshaft Main Bearing Journal Bearing Thickness
https://127.0.0.1:442/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/siswe... 22.11.2023
319D L & 319D LN Excavators WBJ00001-UP (MACHINE) POWERED BY C4.2 E... Page 3 of 3
Undersize
0.50 mm (0.020 inch) 2.727 to 2.740 mm (0.1074 to 0.1079 inch)
Undersize
0.75 mm (0.030 inch) 2.852 to 2.865 mm (0.1123 to 0.1128 inch)
Table 2
Main Bearing Journal
Copyright 1993 - 2023 Caterpillar Inc. Wed Nov 22 09:00:40 UTC+0100 2023
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1:442/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/siswe... 22.11.2023