Professional Documents
Culture Documents
Semiconductors
DPP-01 Discussion
IIT
BY : TANUJ BANSAL
1.
When P-N junction diode is forward biased, then
IIT
2.
When npn transistor, emitter base junction and collector base junction are:
IIT
3.
A piece of copper and another of germanium are cooled from room temperature to
77 K, the resistance of :
IIT
4.
The electrical conductivity of a semiconductor increases when electromagnetic
radiation of wavelength shorter than 2480 nm, is incident on it. The band gap in
(eV) for the semiconductor is:
𝑎 1.1 eV 𝑏 2.5 eV
𝑐 0.5 eV 𝑑 0.7 eV
IIT
5.
In a full wave rectifier circuit operating from 50 Hz mains frequency, the
fundamental frequency in the ripple would be :
𝑎 50 Hz 𝑏 25 Hz
𝑐 100 Hz 𝑑 70.7 Hz
IIT
6.
If the ratio of the concentration of electrons to that of holes in a semiconductor is
7/5 and the ratio of currents is 7/4, then what is the ratio of their drift velocities ?
𝑎 5/8 𝑏 4/5
𝑐 5/4 𝑑 4
4/7
2 He
IIT
7.
In the following, which one of the diodes is reverse biased?
𝑎 𝑏
𝑐 𝑑
IIT
8.
A common emitter amplifier has a voltage gain of 50 and current gain is 25. The
power gain of the amplifier is :
𝑎 500 𝑏 1000
𝑐 1250 𝑑 100
IIT
9.
A p-n photodiode is made of a material with a band gap of 2.0 eV. The minimum
frequency of the radiation that can be absorbed by the material is nearly
𝑎 10 × 1014 Hz 𝑏 5 × 1014 Hz
𝑐 1 × 1014 Hz 𝑑 20 × 1014 Hz
IIT
10.
A zener diode, having breakdown voltage equal to 15V, is used in a voltage regulator
circuit shown in figure. The current through the diode is:
𝑎 10 mA 𝑏 15 mA
𝑐 20 mA 𝑑 5 mA
IIT
11.
The circuit has two oppositely connected ideal diodes in parallel. What is the
current flowing in the circuit?
𝑎 2.31 A 𝑏 1.33 A
𝑐 1.71 A 𝑑 2.00 A
IIT
12.
If in p-n junction diode, a square input signal of 10 V is applied as shown. Then the
output signal across R will be
𝑎 𝑏
𝑐 𝑑
IIT
THANK YOU
IIT