Professional Documents
Culture Documents
1)
Make sure the connection line of the water tank basis panel load
on the U-bar steel basis line. The U-bar basis after weld is
1m*1m square.
3)Bottom panel installation.
Find out the water tank panel which marked these numbers on the
4) Weld the fixed angle steel on the U-bar basis. This is used for
connect and fix the steel basis and the water tank bottom panels.
5)
with ABCDEFGHIJKL )
Like this :
Assemble the water tank side panel (wall) which marked with
“S”“ S1,S2,S3,~~S28”;
In sequence:
1/2/3/4/5/6/7/8/9/28/27/26/25/24/23/22/21/20/19/18/17/16/15/
The “L:7930mm"lacing bars, 3 pcs, should be weld on site. Because, it is too long,
the 20 ft container not enough to fill it.
1) Insert into it (the bigger tube), and to the bottom directly. This has been measured
well, just insert to the bottom. Then, well it.
2) When u weld it, please make sure put these two parts on the flat ground, so that,
the connect panel at the end of the lacing bar will match the holes on the wall well.
This lacing bar is SS316 material, so we send you some pcs of “SS316 welding stick”.
Please try to find it out in the parts box.
(for the bottom support frame is the normal Q235 steel, so no give you the welding
stick.)
Here bellow is the connection of the 2 lacing bar panels which middle is the
“partition wall”:
Here bellow is the connection of the lacing bar panels and the “ wall” of the tank:
7) Install the screen, and short pipes for the partition room.
The screen after install should be like this:
Connect the short pipes:
8)Install the cover:
To find out the water tank panel which mark “R”, to connect them
Please take the protection rubber cap on the two end of the
support bar. This support bar will put at the connection part
The square tube ladder for inside of the tank, which no need
to fix.
The round tube ladder for outside of the tank, which should
8)
These 3 points like here bellow in the drawing, will be little difficult
to install the plug in. Just try. And add one more layer “rubber
sleant belt” / and add more “structural adhesive” Because, one side
Please :
1, worker should wear soft sole shoes to go inside to install.
by one step.
5, All the parts quantity is very precise, Avoid waste and loss.
Best regards!