Professional Documents
Culture Documents
Power cable size Model Fuse Size Cable Size 5 Negative Power
Connection
and fusing
ZA1-320.4 2-25A atc 63($.(5 287387 63($.(5 287387
negative battery
terminal
Place terminal in a secure
7 Positive Power
position so that it won’t
Connection
accidentally contact the
negative battery post
Attach the main power cable
to the amplifier +12V. The
cable must run directly to
11 Positive Battery
Connection
2 Run Cables
the battery and be properly
fused and be very tight.
Connect the power cable to the
8 Signal Input
positive battery terminal. The
Properly route power, power cable must be fused
speaker and RCA cables
Connection within 18 inches of the battery
through the vehicle. terminal.
Connect the RCA cables to Be prepared to disarm your vehicle’s alarm and
the INPUT connectors. The to enter your radio / source unit code.
OUTPUT can be used to
3 Mount Amplifier provide input for a second
amplifier. 12 Re-connect
Negative Battery
Terminal
Choose a mounting location 9 Level Control Turn the LEVEL control completely
counter-clockwise to minimum.
,1387
/(9(/ Re-connect the negative
that will provide adequate air battery terminal making sure it
ventilation. Mount the amplifier to is securely tightened.
a secure surface. Do not mount 9 9
the amplifier upside down.
A
The input MODE switch will “sum” or 2ch - Full Range
02'(
combine the right and left channel signals
in the MONO position to improve bass
Input Mode performance. Select MONO only when the ;29(5 02'(
amp is being used for subwoofers. 0212 67(5(2
63($.(5 287387
B
The XOVER Mode switch sets the type
;29(5
of crossover that will be active. 4 channel
models will have two switches, one for each
Xover Mode set of channels. 4ch - Full Range
)8// /3) +3)
Quick Start
C Installation Guide
63($.(5 287387 63($.(5 287387
The HPF(high pass filter) control will limit the +3)
output below the selected frequency. This
High pass is typically used to protect midrange and hi
frequency speakers from damage and to
Adjustment allow a smooth transition from a subwoofer. .+]
D
The LPF(low pass filter) control
/3)
will limit output above the selected
Low pass frequency. This is used to allow 4ch - Mixed Mono
a smooth transition to the higher
Adjustment frequency speakers. +]
E
The Bass EQ control will increase the power
output at 45Hz for more pronounced bass. %$66(4
Exercise caution when using this control.
Bass Boost Increase the level in small amounts until
distortion is noticed, then back off a little. G%
F
Some models include a bass
remote. Avoid adjusting the bass
remote while operating vehicle. Mono
Remote Level
Control
63($.(5 287387