Professional Documents
Culture Documents
Rocker Shaft Install D7R AEC
Rocker Shaft Install D7R AEC
Installation Procedure
PPS
NOTICE 202 -0009
18: 3/06/2 2CAF
Keep all parts clean from contaminants.
3
RE 0:34- 0
Contaminants may cause rapid wear and shortened component
life.
N 0
©2 R 122 7:00
023 3
1. Inspect the condition of the following items: rocker arms, valve bridges, and push rods. Replace the
parts, if necessary.
Cat
erp
illa
r In
c.
Illustration 1 g00515542
https://sis2.cat.com/#/print-preview/service/%257B%2522title%2522%253A%2522Rocker%2520Shaft%2520and%2520Pushrod%2520-%2520Install… 1/2
20/6/23, 11:30 SIS 2.0
Illustration 2 g00515374
3. Install valve bridges (4). Lubricate the top surface of the valve bridges with clean engine oil.
4. Place rocker arms (2) in the correct locations that were marked during removal. Install bolts (1) and
tighten to a torque of 100 ± 20 N·m (74 ± 15 lb ft).
End By:
a. Install the valve mechanism cover. Refer to Disassembly and Assembly, "Valve Mechanism Cover -
Remove and Install".
PPS-00092CAF
2023/06/20
18:29:49-07:00
i01005113
© 2023 Caterpillar Inc.
https://sis2.cat.com/#/print-preview/service/%257B%2522title%2522%253A%2522Rocker%2520Shaft%2520and%2520Pushrod%2520-%2520Install… 2/2