Professional Documents
Culture Documents
Dwnload Full Fundamentals of Hydraulic Engineering Systems 4th Edition Houghtalen Solutions Manual PDF
Dwnload Full Fundamentals of Hydraulic Engineering Systems 4th Edition Houghtalen Solutions Manual PDF
https://testbankfan.com/download/fundamentals-of-hydraulic-engineering-systems-4th
-edition-houghtalen-solutions-manual/
P = γ·h; where γ = (1.03)(9810 N/m3) = 1.01x104 N/m3 The percentage error if the direct reading is used and
the vapor pressure is ignored is:
(using the specific weight of water at standard
conditions since water gets very cold at great depths) Error = (Patm - Pcolumn)/(Patm)
(Note: 1 slug = 1 lb·sec2/ft) The force exerted on the tank bottom is equal to the
pressure on the bottom times the area of the bottom.
b) The force exerted on the tank bottom is equal to the
pressure on the bottom times the area of the bottom. P = γ·h = (9.79 kN/m3)(6 m) = 58.7 kN/m2
P = γ·h = (62.3 lb/ft3)(3 ft) = 187 lb/ft2 F = P·A = (58.7 kN/m2)(36 m2)
F = 1.47 x 104 lbs The force exerted on the sides of the tank may be found
_________________________________________ in like manner (pressure times the area). However, the
pressure is not uniform on the tank sides since P = γ·h.
Therefore, the average pressure is required. Since the
2.2.3 pressure is a linear relationship, the average pressure
occurs at half the depth. Now,
γwater at 30°C = 9.77 kN/m3
Pavg = γ·havg = (9.79 kN/m3)(3 m) = 29.4 kN/m2
2
Pvapor at 30°C = 4.24 kN/m
F = Pavg ·A = (29.4 kN/m2)(36 m2)
Patm = Pcolumn + Pvapor
F = 1,060 N
Patm = (9.8 m)(9.77 kN/m3) + (4.24 kN/m2)
Obviously, the force on the bottom is greater than the
Patm = 95.7 kN/m2 + 4.24 kN/m2 = 99.9 kN/m2 force on the sides by a factor of two.
© 2010 Pearson Education, Inc., Upper Saddle River, NJ. All rights reserved. This publication is protected by Copyright and written permission should be obtained
from the publisher prior to any prohibited reproduction, storage in a retrieval system, or transmission in any form or by any means, electronic, mechanical, photocopying,
Visit
recording, orTestBankFan.com topermission(s),
likewise. For information regarding get complete for
write to: Rights and all Department,
Permissions chapters Pearson Education, Inc., Upper Saddle River, NJ 07458.
2.2.6 2.2.8
Wtotal = (Volcontainer)(γwater) + (Volpipe)(γwater) Ptank = 6.06 x 104 N/m2 (Pascals) = 8.79 psi
_________________________________________
Wtotal = (3 ft)3(62.3 lb/ft3)
+ [(π)(0.50 ft)2(30 ft)](62.3 lb/ft3)
2.2.9
Wtotal = 1680 lb + 1470 lb = 3,150 lb
γoil = (SG)(γwater) = (0.85)( 62.3 lb/ft3) = 53.0 lb/ft3
Pbottom = γh = (62.3 lb/ft3)(33 ft) = 2060 lb/ft2
P10ft = Pair + (γoil)(10 ft)
Fbottom = (2060 lb/ft2)(9 ft2) = 18,500 lb
Pair = P10ft - (γoil)(10 ft)
Note: The weight of the water is not equal to the force
on the bottom. Why? (Hint: Draw a free body diagram Pair = 23.7 psi (144 in2/ft2) – (53.0 lb/ft3)(10 ft)
of the 3 ft x 3 ft x 3 ft water body labeling all forces
(vertical) acting on it. Don’t forget the pressure from Pair = 2.88 x 104 lb/ft2 (20.0 psi); Gage pressure
the container top. Now, to determine the side force:
Pabs = Pgage + Patm = 20.0 psi + 14.7 psi
Pavg = γ·havg = (62.3 lb/ft3)(31.5 ft) = 1960 lb/ft2
2 2
Pabs = 34.7 psi (5.00 x 104 lb/ft2); Absolute pressure
F = Pavg ·A = (1960 lb/ft )(9 ft ) _________________________________________
F = 17,600 lb
_________________________________________ 2.2.10
γliquid = (SG)(γwater) = (0.80)(9790 N/m3) = 7830 N/m3 The pressure developed in the system is:
∴Pbottom = 4.50x104 N/m2 + (7830 N/m3)(1.4 m) Pinput = F/A = (450 N)/(25 cm2) = 18 N/cm2
The pressure at the bottom of the liquid column can be From Pascal’s law, the pressure at the input piston
determined two different ways which must be equal. should equal the pressure at the two output pistons.
Hence,
∴ The force exerted on each output piston is:
(h)(γliquid) = Pgage + (γliquid)(1 m)
Pinput = Poutput equates to: 18 N/cm2 = Foutput/250 cm2
h = (Pgage)/(γliquid) + 1m
Foutput = (18 N/cm2)(250 cm2)
4 2 3
h = (4.50x10 N/m )/7830 N/m + 1 m = 6.75 m
Foutput = 4.50 kN
© 2010 Pearson Education, Inc., Upper Saddle River, NJ. All rights reserved. This publication is protected by Copyright and written permission should be obtained
from the publisher prior to any prohibited reproduction, storage in a retrieval system, or transmission in any form or by any means, electronic, mechanical, photocopying,
recording, or likewise. For information regarding permission(s), write to: Rights and Permissions Department, Pearson Education, Inc., Upper Saddle River, NJ 07458.
2.4.1 2.4.5
Since the line passing through points 7 and 8 represents A surface of equal pressure can be drawn at the
an equal pressure surface; mercury-water meniscus. Therefore,
hoil = (hwater)/(SGoil) = (52.3 cm)/(0.85) = 61.5 cm (2.42 x 103 lb/ft2) + (2 ft)(62.3 lb/ft3) =
_________________________________________ (h)(13.6)(62.3 lb/ft3)
h = 3.00 ft (manometer is correct)
_________________________________________
2.4.2
h = (26.3 cm)(13.6)/(4 + 0.82) = 74.2 cm Ppipe = - 15.0 kN/m2 Pressure can be converted to
_________________________________________
height (head) of any liquid through P = γ·h. Thus,
© 2010 Pearson Education, Inc., Upper Saddle River, NJ. All rights reserved. This publication is protected by Copyright and written permission should be obtained
from the publisher prior to any prohibited reproduction, storage in a retrieval system, or transmission in any form or by any means, electronic, mechanical, photocopying,
recording, or likewise. For information regarding permission(s), write to: Rights and Permissions Department, Pearson Education, Inc., Upper Saddle River, NJ 07458.
Another random document with
no related content on Scribd:
"Eikö äiti nytkään ole kotona?"
"Uskotteko, etten ole enään sama tyhjä, itsekäs olento, mikä olin
vielä toissapäivänä, eilen…"
"Näen sen."
"Voi sanokaa!"
"Kiitän teitä!"
"Ei enään! Nyt tuntuu kuin olisin saanut kiinni kultaisen langan
päästä, jota seuraamalla aavistan löytäväni sen suuren, kaivatun…
sen, jota sanotaan elämäntehtäväksi. —"
"Kaikesta siitä mitä minulla on, kiitän teitä, — kiitän teitä vaan!"
virkkoi Helvi lämpimästi ja salataksensa mielenliikutustaan kääntyi
hän nopeasti taloon vievälle puistotielle.
Suurin osa siitä opista, jota hän koulun penkillä oli päähänsä
puinut, näytti niin tuiki tarpeettomalta, tyhjältä. — — Sen sijaan että
sielläkin olisi opastettu kaikkeen siihen, elävään välttämättömyyteen,
innostutettu suuriin aatteisiin, hyviin töihin ja käytännöllisyyteen,
pantiin pääpaino kuolleisiin, homehtuneisiin numeroihin ja
ijänikuisten tapausten häirähtämättömään muistamiseen, joista henki
ei kohonnut, eikä järki avartunut.
Miksei ollut kotikaan antanut hänelle niitä aatteita, joita hän oli
tietämättään janonnut?
(Koskenlaskijan morsiamet).
"Petturi!"
"Kätke kaikkien katseilta se, joka kirveltää, moni muu ennen sinua
on tehnyt niin…"
Sydänmaan rakkautta.
"No ei sinne niin pitkä matka ole", vastasi hän sitten lapselle,
yhtäkkiä rohkaistuen ja ottaen tämän syliinsä.
"Anna toki pojan istua… Tämähän on niin hyvä poika tämä pikku
Kaapro."
Tuskin oli Jaakko päässyt ovesta ulos, kun kalvava kaiho täytti
hänen rintansa ja hän olisi tahtonut jälleen lämpimään, armaaseen
tupaan katselemaan Hiljaa ja pitelemään poikaa polvillansa…
*****
Sitten alkoi siellä ja täällä kuulua lisäksi ääniä, että isäntä aikoo
ottaa häneltä mökin pois, kun saapi sen annetuksi toiselle
paremmilla ehdoilla.
"Voiko sitä olla vieras, vaikka on oma —-?" kysyi lapsi ja hänen
silmiinsä tuli miettivä, lohduton ilme.
Kun hän kerran tällaisella retkellään sai kuulla että merten takaa
oli Kaapro Kalposen kuoleman viesti saapunut, — tunsi hän suurta
levotonta iloa sydämessänsä, sellaista ikiääretöntä, joka vain
aniharvoin ihmissieluun hulvahtaa, loistavana, mahtavana,
rinnanääriä repien, — niinkuin tila siellä olisi asunnoksi ahdas ja
matala riemun suurelle majesteetille…!
*****
Miina.
Miinalla oli tapana iltasin, kun tupa oli lämmitetty ja pelti pantu
kiinni, lähteä sukanneuleineen vähäksi aikaa kylään "häkää pakoon."
Niitä varten pani Miina aina oluen, keitti lämpimät ruuat ja kahvin
— ja jos sattui olemaan jouluinen aika, saattoi hänellä toisinaan olla
ryypytkin.
"Vaikka teidän nenänne olisi sata syltä pitkä, niin kyllä mie sen
niistän…" huusi hän niin että musta yö raikui.