Professional Documents
Culture Documents
Filtration Unit Manual Book
Filtration Unit Manual Book
Operation Instructions
I. Introduction
This equipment can be used for the filtration of liquid materials in the chemical industry. The PP melt spinning cartridge is
used from the inside to the inside. The nominal filtering accuracy ranging from I micron to 50 microns. The cartridge will
not be influenced by the inlet pressure fluctuates, thus its filtration accuracy will not be affected. Its unique low pressure
drop, high flux, good filter accuracy and economic costs have become a new type of filter element that replaces non-fixed
filter elements such as wire bypass and cardboard and is welcomed by users.
II. Features
I.Wide chemical compatibility, large circulation, low pressure difference and long service life.
2. Wide range of filtering accuracy and large selection degree can meet various application occasions.
3.Using hot-melt technology, it is firm and does not pollute the raw material.
-------+-�
!�..u
Flange
¢M,,-\:'.c:s•,
Ill
'brllMs line
y + ror
2. Filter A stops and B runs; valves BI, B2 are opened, valves AI, A2, and C are closed; fluid flows in the pipeline as
shown in the figure below, blue indicates dirty liquid before filtration, and cyan indicates clear liquid after filtration;
-------o-�
:·;:
Flange
�},-'t�,
II!
Al
'( y cm
3. Filters A and B are running; valves Al, A2, BI, and 82 are opened, and valve C is closed; fluid flows in the pipeline as
shown in the figure below, blue indicates the dirty liquid before filtration, and cyan indicates the clear liquid after
filtration;
bnas! llne
4. When the filter A, B is maintained or fails, the fluid will bypass: valve C is opened. and valves AI. A2, BI. B2 arc
closed;
----�
Pressure gag�
§l
.. .. C
-- Flange
�,\','.;,.,
Di
:A
VI. Maintenance
For filters that have been out of service for a long time. the inside and outside of the tilter must be cleaned, the filter element
must be removed, washed and dried, and stored in a plastic bag to avoid damage. Do not use corrosive substances such as
hydrochloric acid as the cleaning agent, and the temperature should not be too high to prevent deformation of polypropylene.
Avoid contamination and impact when storing.