Professional Documents
Culture Documents
C941/ES9451
Set up Procedure
Oct.7,2013
Okidata co. ltd.,
Rev1 2013.10.7
Rev2 2013.10.16
Image Drum
LED
Holding the carrying levers while grasping the carrying handles, and at least 4 people to lift printer.
C911/C931/ES9411dn/ES9431dn
approx.97Kg
C941/ES9451:approx.117Kg
Refer to Page 44
in “Basic Preparing the printer To print
The C941/ES9641dn Spot Color Kit is a separate package. For the set up method,
see “Separate Volume Spot Color Guide”
1.Open the toner replacement 2.Check the position of the slot 3.Check toner
cover. that is labeled with the same cartridge location
text and colors, and securely
push in the toner cartridge
all the way
toner replacement cover.
Raise lever
Hold
this location
Pull out
with Holding
lever
Pull out
Place ID on a flat surface, and then remove the stopper (Orange Color)
Stopper
(Orange)
Caution
Turn on the power with Stopper installing on ID ,
toner sensor error shows on operation panel.
Because Stopper interrupt a light on disk and
Disk to prism for toner low detection sensor.
Detect
toner
The C941/ES9641dn Spot Color Kit is a separate package. For the set up method,
see “Separate Volume Spot Color Guide”
Shutter
1.Remove sheet 2.Take the Duck from 3.Put the duck on printer
package
Caution
The procedure
when Duct removes from printer
2. Slide the paper guide(1)and paper stopper(2) to align to the size of the paper that has been set.
Note
The power Switch
Location :Left - Front Refer to page 58 in “Basic Preparing the printer To print
so that Turing OFF the power Supply
As a purpose to make sure an initial print, print the following print or print a sample that a
customer requests.
B C D