Professional Documents
Culture Documents
Pivot
Pivot
Patented technology
Technical specifications
Functionality: Minimum pivot point distance:
180° swing operation with a silent 90° hold function The axis point can be positioned at either 80 mm or 178 mm by
90° / 0° / -90° simply turning the hinge around in the cavity inside the door
panel.
Maximum weight & dimensions:
75 kg - 165 lbs Closed door positioning (0°)
Max. door width 1250 mm The self-closing technology will position the door at 0° when
( approx. 49.21 inches | 25.4 mm = 1 inch ) installed perfectly. The hinge mounts feature a correction &
adjustability system with octagonal bolts to fine-tune the door
Closure force: leaf position at 0° after initial installation.
The closing force is influenced by environmental aspects such as room and joint
dimensions, air tightness, overall weight of the door,... and has to be adjusted Joint dimensions:
accordingly by trial and error. The gas springs are exchangeable to adjust the
The advised joint dimensions are based on a completely square
closing force of the hinge as necessary.
(rectangular)opening. Please read our detailed instructions
regarding dimensions & joint calculation in the instruction
Suitable for: manual.
Interior doors made from any type of material, with a minimal thickness of 30
mm, for hinge integration purposes. Bottom: 11 mm
Top: 12.5 mm (necessary for optional magnets & 1-way)
Left and right: 4 - 5 mm advised (up to 50 mm thick panel)
Larger panels need to be recalculated accordingly
Cavity dimensions
25.25 172.00
5.00
43.00
38.00
142.00
R5.00
25.25
Ø3.00 R5.00
142.00
172.00
Integration
We advise the pivot axis to be placed at a minimum
of 80 mm from the door leaf edge.
5 mm
5 mm
11 mm
min = 2 mm
50 mm
85 + 5 + 6 = 96 mm
min = 2 mm
5 mm
85 mm
50 mm
6 mm
(=502-496)
advised = 5* mm
96 mm
(=85+5+6)
502 mm 500 mm *See page 2 for detailed information
Mark pivot axis
Apply masking tape on the floor.
Ø 8 mm
45 mm deep
Ø 8 mm
45 mm deep
Use a laser to project and mark both holes to the ceiling. Drill holes and insert Hilti plugs.
Synchronize pivot axis height in doorway
difference
with the doorway measurements,
and synchronize them if necessary.
difference
Adjust bottom hinge height
The default bottom joint dimension is 11 mm
) (=distance between floor and door leaf edge).
s h own
is
NL
Pivot
alth
(Ste
DOOR
11 mm
12,5 mm )
n
show
L is
DOOR alth
Pivot
X
(Ste
(StealthPivot NL is shown)
(Stea
lthPiv
ot NL
is sho
wn)
BOTTOM
Adjust pivot axis
Use a laser to check if the pivot axis is
perfectly level.
1,35 mm
m
m
20
1,05 mm
1,
Loosen the screws, and use pliers to
lift the insert out of the pivot foot.
#1 #2 #1 #2 #1 #2
(StealthPivot NL is shown)
Finished product examples