Professional Documents
Culture Documents
Q2. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes.
Q3. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes.
Q4. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes.
Q5. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes.
Q6. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes.
Q7. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes.
Q8. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes. Complete Drawing file must be provided.
Q9. Draw the front view, top view and side view of isometric drawing. The hidden line must be included
for the holes. Complete Drawing file must be provided.
Q10. Draw the front view, top view and side view of isometric drawing. The hidden line must be
included for the holes. Complete Drawing file must be provided.
Q11. Draw the M27 bolt and nut size with left hand V Thread of the fine pitch 2mm which has the
150mm distance.
=16 =36
=27 =42
Q12. Draw the 6 inches long bolt with thread per inch (TPI) 9 of 1 ¼ nominal inches and nut size with
right hand Square Thread.
=25/32 =1 103ൗ128
=2 ¼
Q13. Draw the 30mm long bolt with 1/2” - 10 ACME and nut size with right hand ACME Thread.
Q14. Draw the complete spur gear with detailed dimension of front view and side view. The required data
are given follows.
No of P.D. D D1 L
d d1 m
Teeth Pitch Outside Hub Hub S
Bore Dia. Module
Dia. Dia. Dia. Proj.
36 36 38 8 18 9 4.6 28 1
Q15. Draw the complete spur gear and rack with detailed dimension of front view. The required data are
given follows. Some dimensions are shown in figure.