Professional Documents
Culture Documents
10. Which of the following components list belongs to air generation system?
A.Actuator, check valve, air service unit, compressor
B.Tank, actuator, pressure switch, electric motor
C.Pressure switch, electric motor, compressor, check valve
D.Directional control valve, line filter, compressor, auto drain
Introduction to Pneumatic System
"After final compression the air will be hot, when it cools it will deposit water in
considerable quantities in the airline (pipe system) system which should be avoided.”
4. Which of the following statement describes best about the diagram shown below?
A. air flows from the compressor to an aftercooler that lowers the temperature (within
10-15°C of the cooling medium), causes condensation and removes the majority
of water.
B. a steel shell housing tubes with water circulating on one side and air on the other,
usually arranged so that the flow is in opposite directions through the cooler.
C. The cold dry air return pipe passes through air heat exchanger and gains heat
from the incoming high temperature air.
C. To remove moisture from the air after air is cooled down by air dryers.
Introduction to Pneumatic System
A. mechanically B. manually
C. hydraulically D. combination
6.
Name the component shown in the figure.
7.
What is the name of the component shown in the figure?
A. 3/2 way single button DCV B. 3/2 way NC pushbutton DCV with
spring return
C. 3/2 way NO pushbutton DCV with
D. 3/2 way double pilot with spring
spring return
return DCV
8.
What is the name of this component?
A. 5/2 way double pilot B. 4/2 way double pilot DCV with
spring return
C. 5/2 way single pilot DCV with
D. 4/2 way single pilot DCV with
spring return
spring return
9.
A. 5/3 way hand lever valve with B. 4/3 way hand lever valve with
closed mid position open mid position
C. 4/3 way hand lever valve with D. 5/3 way hand lever valve with
closed mid position closed mid position
12.
A. Drain B. Filter
C. Cooler D. Heat exchanger
13.
A. 5 B. 2
C. 3 D. 4
17.
What is the function of this component?
A. control flow of air in one direction B. control direction of the air in one
direction
C. control flow of air in both direction
D. allow flow of air in one direction only
A. 5 B. 2
C. 3 D. 4
A. allow flow of air to the outlet when there B. allow flow of air to the outlet when
are pressure at both inlets there is pressure at any of the inlet
C. exhaust the cylinder air quickly to D. unidirectional valve and permit the
atmosphere. free flow in one direction only