You are on page 1of 192

*DCY*

5045D (Argentina Edition)


*OMSU37537*

OPERATOR'S MANUAL
5045D (Argentina Edition)
OMSU37537 ISSUE G1 (INGLÉS)

*omsu37537*

Industrias John Deere Argentina S.A.


Argentina Edition
PRINTED IN U.S.A.
Introduction
Foreword
READ THIS MANUAL carefully to learn how to operate BEFORE DELIVERING THIS MACHINE, your dealer
and service your machine correctly. Failure to do so performed a predelivery inspection. After operating for
could result in personal injury or equipment damage. This the first 100 hours, schedule an after-sale inspection with
manual and safety signs on your machine may also be your dealer to ensure best performance.
available in other languages (see your John Deere dealer
to order). THIS TRACTOR IS DESIGNED SOLELY for use in
customary agricultural or similar operations ("INTENDED
THIS MANUAL SHOULD BE CONSIDERED a permanent USE"). Use in any other way is considered as contrary to
part of your machine and should remain with the machine. the intended use. The manufacturer accepts no liability
MEASUREMENTS in this manual are given in both for damage or injury resulting from this misuse, and these
metric and customary U.S. unit equivalents. Use only risks must be borne solely by the user. Compliance
correct replacement parts and fasteners. Metric and inch with and strict adherence to the conditions of operation,
fasteners may require a specific metric or inch wrench. service and repair as specified by the manufacturer also
constitute essential elements for the intended use.
RIGHT-HAND AND LEFT-HAND sides are determined by
facing the direction of forward travel. THIS TRACTOR SHOULD BE OPERATED, serviced and
repaired only by persons familiar with all its particular
WRITE TRACTOR SERIAL (CHASSIS) NUMBER in characteristics and acquainted with the relevant safety
the Specification or Identification Numbers section. rules (accident prevention). The accident prevention
Accurately record all the numbers to help in tracing the regulations, all other generally recognized regulations
machine should it be stolen. Your dealer also needs these on safety and occupational medicine and the road traffic
numbers when you order parts. File the identification regulations must be observed at all times. Any arbitrary
numbers in a secure place off the machine. modifications carried out on this tractor will relieve the
manufacturer of all liability for any resulting damage or
SETTING FUEL DELIVERY BEYOND PUBLISHED
injury.
factory specifications or otherwise overpowering will result
in loss of warranty protection for this machine.
DP97633,0000246 -19-31JUL18-1/1

071321

PN=2
Introduction

Identification Views

APY41946 —UN—02JUL21
5045D Tractor

NOTE: Tractor shown may have optional equipment.


WKJQUWJ,0000B6B -19-05JUL21-1/1

071321

PN=3
Introduction

071321

PN=4
Contents
Page
Page
Safety
Recognize Safety Information ............................05-1 Service Tires Safely..........................................05-21
Understand Signal Words...................................05-1 Service Front-Wheel Drive Tractor Safely ........05-21
Follow Safety Instructions...................................05-1 Tightening Wheel Retaining Bolts/Nuts ............05-22
Prepare for Emergencies....................................05-2 Avoid High-Pressure Fluids ..............................05-22
Wear Protective Clothing....................................05-2 Do Not Open High-Pressure Fuel System........05-22
Protect Against Noise .........................................05-2 Store Attachments Safely .................................05-23
Handle Fuel Safely—Avoid Fires........................05-3 Decommissioning — Proper Recycling
Handle Starting Fluid Safely ...............................05-3 and Disposal of Fluids and Components .....05-23
Fire Prevention ...................................................05-3
In Case of Fire ....................................................05-4 Safety Signs
Avoid Static Electricity Risk When Refueling......05-4 Pictorial Safety Signs..........................................10-1
Keep ROPS Installed Properly ...........................05-5 Warning Decal - Read Operator’s Manual..........10-1
Use Foldable ROPS and Seat Belt Properly ......05-5 Riders .................................................................10-2
Stay Clear of Rotating Drivelines........................05-6 Use Seat Belt......................................................10-3
Use Steps and Handholds Correctly ..................05-6 ROPS in Normal Position (Applicable if
Read Operator’s Manuals for ISOBUS tractor is equipped with ROPS)......................10-4
Controllers......................................................05-7
Use Seat Belt Properly .......................................05-7 Controls and Instruments
Operating the Tractor Safely ..............................05-8 Tractor Controls..................................................15-1
Avoid Backover Accidents ..................................05-9 Instrument Panel ................................................15-5
Limited Use in Forestry Operation......................05-9
Operating the Loader Tractor Safely ..................05-9
Keep Riders Off Machine .................................05-10
Lights
Light Switch Positions.........................................20-1
Instructional Seat..............................................05-10
Use Headlights ...................................................20-1
Use Safety Lights and Devices.........................05-10
Use High Beam Indicator....................................20-2
Transport Towed Equipment at Safe Speeds ... 05-11
Use Tail Lights ....................................................20-2
Use Caution on Slopes, Uneven
Use Turn Signals ................................................20-3
Terrain, and Rough Ground..........................05-12
Use Hazard Lights ..............................................20-4
Freeing a Mired Machine..................................05-12
Use Flood Lamp .................................................20-5
Avoid Contact with Agricultural Chemicals .......05-13
Seven-Terminal Outlet ........................................20-6
Handle Agricultural Chemicals Safely ..............05-14
Handling Batteries Safely .................................05-15
Avoid Heating Near Pressurized Fluid Lines ....05-15 Operator's Platform
Remove Paint Before Welding or Heating........05-16 Operate Foldable ROPS.....................................25-1
Handle Electronic Components and Select Seat Position ...........................................25-2
Brackets Safely ............................................05-16 Adjust Ride Comfort ...........................................25-2
Practice Safe Maintenance...............................05-17 Operate Park Brake Lever..................................25-3
Avoid Hot Exhaust ............................................05-17 Mobile Charger Pocket .......................................25-3
Clean Exhaust Filter Safely ..............................05-18
Work In Ventilated Area....................................05-19 Break-In Period
Support Machine Properly ................................05-19 Observe Engine Operation Closely ....................35-1
Prevent Machine Runaway...............................05-19 Break-In Service .................................................35-1
Park Machine Safely.........................................05-20
Transport Tractor Safely ...................................05-20 Prestarting Checks
Service Cooling System Safely ........................05-20 Service Daily Before Start-Up.............................40-1
Service Accumulator Systems Safely...............05-21 Hood Lock Mechanism .......................................40-2

Continued on next page

Original Instructions. All information, illustrations and specifications in this


manual are based on the latest information available at the time of publication.
The right is reserved to make changes at any time without notice.
COPYRIGHT © 2021
DEERE & COMPANY
Moline, Illinois
All rights reserved.
A John Deere ILLUSTRUCTION ™ Manual
Previous Editions
Copyright © 2015,2016,2017,2018

i 071321

PN=1
Contents

Page Page

Rear SCV Dust Plug Identification......................60-1


Operating the Engine Connect Cylinder Hoses.....................................60-2
Before Starting the Engine .................................45-1 Connect Single-Acting Cylinder..........................60-3
Start the Engine..................................................45-2 Correct Reversed Cylinder Response ................60-3
Check Instruments After Starting........................45-3 Neutral Lever Position ........................................60-3
Oil Pressure Indicator .........................................45-3 Extend/Retract Cylinder—SCV I.........................60-4
Charge System Indicator ....................................45-3
Air Restriction Sensor.........................................45-3 Drawbar and PTO
Coolant Temperature Gauge ..............................45-4 Use Swinging Drawbar .......................................65-1
Watch Fuel Level................................................45-4 Adjustable Drawbar ............................................65-2
Change Engine Speeds......................................45-4 Proper Use of Drawbar.......................................65-2
Warm Up the Engine ..........................................45-5 Observe Drawbar Load Limitations ....................65-2
Restart Stalled Engine........................................45-5 Stay Clear of Rotating Drivelines........................65-3
Avoid Idling the Engine.......................................45-5 Attach PTO-Driven Implement............................65-3
Observe Engine Work and Idle Speeds .............45-5 Operate Tractor PTO ..........................................65-4
Working With Speed/Hour Meter........................45-6 Adjust PTO Clutch Operating Rod......................65-5
Stop the Engine ..................................................45-6
Use Booster Battery ...........................................45-7 Ballast
Plan for Maximum Productivity ...........................70-1
Driving the Tractor Use Proper Ballast..............................................70-1
Reduce Fuel Consumption .................................50-1 Select Ballast Carefully.......................................70-1
Operator Training Required................................50-3 Match Ballast to Load Work................................70-1
Driving on Public Roads .....................................50-3 Check for Correct Ballast....................................70-2
Operate Transmission ........................................50-5 Measure Wheel Slip—Manually .........................70-3
Shifting Transmission .........................................50-5 Ballast Limitations...............................................70-3
Select a Gear......................................................50-6 Ballast Front End for Transport ..........................70-4
Use Brakes .........................................................50-6 Ballast Tractor ....................................................70-4
Use Differential Lock ..........................................50-7 Ballast MFWD Equipped Tractors ......................70-4
Operating Mechanical Front Wheel Determine Maximum Rear Ballast......................70-5
Drive (If Equipped) .........................................50-7 Determine Maximum Front Ballast .....................70-5
Stopping Tractor .................................................50-8 Use Cast Iron Weights........................................70-5
Install Rear Cast Iron Weights............................70-6
Rockshaft and 3-Point Hitch Use Liquid Weight ..............................................70-7
Match Tractor Power to Implement ....................55-1 Use Implement Codes ........................................70-7
3-Point Hitch Components..................................55-1
Rockshaft Control Levers ...................................55-2 Wheels, Tires, and Treads
Set Position Control Lever Stop .........................55-2 Service Tires Safely............................................75-1
Use Rockshaft Position Control..........................55-3 Check Implement-to-Tire Clearance...................75-1
Use Draft Control................................................55-4 Check Tire Inflation Pressure .............................75-2
Adjust Rockshaft Rate-of-Drop/ Tire Inflation Pressure Chart...............................75-2
Implement Lock..............................................55-5 Tighten Wheel/Axle Hardware Correctly ............75-3
Attach Tipping Trailer..........................................55-6 Tighten Bolts— Front Axle..................................75-3
Prepare Implement .............................................55-6 Tighten Bolt Adjustable Front Axle––If
Preparation for Wet Land Cultivation .................55-6 Equipped ........................................................75-3
Position Center Link ...........................................55-7 Tighten Bolts—Rear Axle (M-20 Stud) ...............75-4
Attach Implements to 3-Point Hitch ....................55-8 Observe Rear Wheel Tread Width Limitations ...75-4
Adjust Hitch Side Sway ......................................55-9 Tread Settings—Multi-Position Rear Wheels .....75-5
Level the Hitch..................................................55-10 Tread Settings—Adjustable Front
Adjust Lateral Float...........................................55-10 Axle––If Equipped ..........................................75-6
Adjust Rockshaft Control Lever Adjust Front Axle Tread Width............................75-7
Friction- JD Rockshaft.................................. 55-11 Check Toe-In ......................................................75-7
Warm Hydraulic System Oil.............................. 55-11 Adjust Toe-In.......................................................75-8
Check Toe-in (MFWD Tractor)............................75-8
Remote Hydraulic Cylinders (If Equipped) Adjust Toe-in (MFWD Tractor)............................75-9
Use Correct Hose Tips .......................................60-1 Adjust Toe-In - Adjustable Front
Control Lever and Coupler Identification ............60-1 Axle––IF Equipped.........................................75-9
Use Correct Tire Combinations ........................75-10

Continued on next page

ii 071321

PN=2
Contents

Page Page

Tire Compatibility Chart ....................................75-10 Replace Fuel Filter Inserts................................ 110-2


Inspect and Adjust Alternator/Fan Belt ............. 110-2
Transporting Lubricate 3-Point Hitch ..................................... 110-2
Use Safety Lights and Devices...........................80-1 Check Neutral Start System ............................. 110-3
Driving Tractor on Roads....................................80-1 Check and Adjust Clutch Pedal Free Play........ 110-3
Transport on Carrier ...........................................80-3 Check and Adjust Brake Pedal Free Play ........ 110-4
Tow Tractor.........................................................80-4
Service—Every 500 Hours
Fuels, Lubricants and Coolant Replace Transmission-Hydraulic Filter ............. 112-1
Handle Fuel Safely—Avoid Fires........................85-1
Handle Fluids Safely—Avoid Fires .....................85-1 Service—Every 600 Hours
Fuel Storage .......................................................85-1 Change Oil in MFWD Axle (If Equipped) .......... 115-1
Fuel Saving Tips.................................................85-1 Clean Engine Crankcase Vent Tube ................ 115-2
Diesel Fuel..........................................................85-2 Check Hoses and Hose Clamps for Tightness .. 115-2
Fuel Saving Tips.................................................85-3 Lubricate Rear Axle Bearings........................... 115-3
Diesel Fuel Filters...............................................85-3 Check Engine Idle Speeds ............................... 115-3
Fill Fuel Tank ......................................................85-3 Check Front Axle Pivot Pin............................... 115-3
Lubricant Storage ...............................................85-4 Check Water Separator Trap............................ 115-4
Diesel Engine Oil — Tier 3 and Stage IIIA .........85-4 Tighten MFWD Axle Front Trunnion Bolt.......... 115-4
Diesel Engine Break-In Oil —
Non-Emissions Certified and Service—Every 1250 Hours
Certified Tier 1, Tier 2, Tier 3, Stage Change Transmission-Hydraulic Oil
I, Stage II, and Stage III .................................85-5 and Filter ......................................................120-1
Tractor Engine Coolant.......................................85-5 Clean Transmission-Hydraulic Pickup Screen ..120-2
Use Correct Transmission-Hydraulic
Filter Element .................................................85-6
Transmission and Hydraulic Oil ..........................85-6
Service—Annually
Replace Air Cleaner Elements .........................125-1
Multipurpose Extreme Pressure (EP) Grease ....85-7

Service and Maintenance Service—2 Years/2000 Hours


Flush Cooling System.......................................130-1
Observe Service Intervals ..................................90-1
Break-In Service .................................................90-1
Service IntervalsFilter Overview With Service—As Required
Service Intervals.............................................90-2 Service Air Cleaner...........................................135-1
Adjust Throttle Friction......................................135-1
Service—Every 10 Hours
Check Engine Oil Level ......................................95-1 Service
Check Coolant Level ..........................................95-1 Additional Service Information..........................140-1
Drain Water and Sediment From Fuel Filter .......95-2 Service Tractor Safely ......................................140-1
Lubricate as Necessary ......................................95-2 Engine Break-In Oil ..........................................140-2
Work In Ventilated Area....................................140-2
Use High-Pressure Washers ............................140-2
Service—Every 50 Hours
Raise Hood.......................................................140-3
Check Transmission-Hydraulic System
Air Intake System Components (With
Oil Level .......................................................100-1
Turbocharger)...............................................140-3
Check MFWD Axle Oil Level ............................100-1
Air Intake System Components(With-
Clean and Check Battery..................................100-1
out Turbocharger).........................................140-3
Lubricate Front Axle Pivot Pin ..........................100-2
Service Air Cleaner at Regular Intervals ..........140-4
Lubricate Steering Spindles..............................100-2
Check Air Intake System(With Turbocharger) ..140-4
Lubricate Steering Spindles
Check Air Intake System (Without
(Adjustable Front Axle—If Equipped)...........100-2
Turbocharger)...............................................140-4
Lubricate Clutch Pedal and Brake Pedal..........100-3
Remove Primary Air Cleaner Element..............140-5
Inspect Tires and Loose Hardware...................100-4
Clean Primary Element.....................................140-5
Wash Primary Element.....................................140-6
Service—Every 250 Hours Inspect Element................................................140-6
Change Engine Oil and Filter ........................... 110-1 Store Element...................................................140-6
Service Air Cleaner........................................... 110-1

Continued on next page

iii 071321

PN=3
Contents

Page Page

Replace Alternator/Fan Belt .............................140-7 Annual Service Chart .......................................165-4


Fuel System Components ................................140-7 2000 Hour Service Chart .................................165-5
Do Not Modify Fuel System..............................140-7 As Required Service Chart ...............................165-6
Bleed Fuel System ...........................................140-8
Bleed Fuel System At Fuel Injection Nozzles...140-8 John Deere Service
Engine Cooling System ....................................140-9 John Deere Parts..............................................170-1
Clean Grille, Screens and Radiator ................140-10 The Right Tools.................................................170-1
Prevent Battery Explosions ............................140-10 Well Trained Technician....................................170-1
Observe Electrical Service Precautions ......... 140-11 Prompt Service .................................................170-2
Battery Access................................................ 140-11
Remove Battery..............................................140-12
Check Battery Condition.................................140-12
Service Battery ...............................................140-13
Charge Battery ...............................................140-15
Battery Replacement Specifications...............140-15
Connect Starter Wiring ...................................140-15
Connect Alternator Wiring ..............................140-16
Locate Fuses ..................................................140-16
Fuse Size and Function..................................140-16
Aim Headlights ...............................................140-17
Adjust Headlights............................................140-17
Replace Headlight Bulb ..................................140-18
Replace Tail Light and Warning Light Bulbs ...140-19
Replace Flood Lamp Bulb ..............................140-19
Check Tires ....................................................140-19
Keep ROPS Installed Properly .......................140-20

Troubleshooting
Engine Troubleshooting....................................145-1
Transmission Troubleshooting..........................145-4
Hydraulic System Troubleshooting...................145-5
Brakes Troubleshooting....................................145-5
Rockshaft and 3-Point Hitch Troubleshooting ..145-6
Remote Hydraulic Cylinders Troubleshooting ..145-7
Electrical System Troubleshooting ...................145-8

Tractor Storage
Tractor Storage.................................................150-1
Remove Tractor From Storage.........................150-4

Specifications
John Deere 5045D Tractor ...............................155-1
Ground Speeds ................................................155-2
Metric Bolt and Screw Torque Values...............155-3
Unified Inch Bolt and Screw Torque Values......155-4

Identification Numbers
Identification Plates ..........................................160-1
Record Tractor Serial (Chassis) Number .........160-1
Record Front Axle Serial Number.....................160-1
Record Engine Serial Number..........................160-2
ROPS Serial Number .......................................160-2
Record Transmission Serial Number................160-2

Lubrication Maintenance Record Charts


50, 250 Hour Service Chart ..............................165-1
500,600 Hour Service Chart .............................165-2
1250 Hour Service Chart ..................................165-3

iv 071321

PN=4
Safety
Recognize Safety Information
This is a safety-alert symbol. When you see this symbol
on your machine or in this manual, be alert to the potential
for personal injury.
Follow recommended precautions and safe operating

T81389 —UN—28JUN13
practices.

DX,ALERT -19-29SEP98-1/1

Understand Signal Words


DANGER; The signal word DANGER indicates a
hazardous situation which, if not avoided, will result in
death or serious injury.
WARNING; The signal word WARNING indicates a
hazardous situation which, if not avoided, could result in

TS187 —19—30SEP88
death or serious injury.
CAUTION; The signal word CAUTION indicates a
hazardous situation which, if not avoided, could result in
minor or moderate injury. CAUTION may also be used
to alert against unsafe practices associated with events
which could lead to personal injury.
A signal word—DANGER, WARNING, or CAUTION—is precautions are listed on CAUTION safety signs.
used with the safety-alert symbol. DANGER identifies CAUTION also calls attention to safety messages in this
the most serious hazards. DANGER or WARNING manual.
safety signs are located near specific hazards. General
DX,SIGNAL -19-05OCT16-1/1

Follow Safety Instructions


Carefully read all safety messages in this manual and on
your machine safety signs. Keep safety signs in good
condition. Replace missing or damaged safety signs. Be
sure new equipment components and repair parts include
the current safety signs. Replacement safety signs are

TS201 —UN—15APR13
available from your John Deere dealer.
There can be additional safety information contained on
parts and components sourced from suppliers that is not
reproduced in this operator's manual.
Learn how to operate the machine and how to use controls
properly. Do not let anyone operate without instruction.
Keep your machine in proper working condition.
If you do not understand any part of this manual and need
Unauthorized modifications to the machine may impair the
assistance, contact your John Deere dealer.
function and/or safety and affect machine life.
DX,READ -19-16JUN09-1/1

05-1 071321

PN=9
Safety

Prepare for Emergencies


Be prepared if a fire starts.
Keep a first aid kit and fire extinguisher handy.
Keep emergency numbers for doctors, ambulance service,
hospital, and fire department near your telephone.

TS291 —UN—15APR13
DX,FIRE2 -19-03MAR93-1/1

Wear Protective Clothing


Wear close fitting clothing and safety equipment
appropriate to the job.
Operating equipment safely requires the full attention of
the operator. Do not wear radio or music headphones
while operating machine.

TS206 —UN—15APR13
DX,WEAR2 -19-03MAR93-1/1

Protect Against Noise


There are many variables that affect the sound level
range, including machine configuration, condition and
maintenance level of the machine, ground surface,
operating environmental, duty cycles, ambient noise, and
attachments.

TS207 —UN—23AUG88
Exposure to loud noise can cause impairment or loss of
hearing.
Always wear hearing protection. Wear a suitable
hearing protective device such as earmuffs or earplugs
to protect against objectionable or uncomfortable loud
noises.
DX,NOISE -19-03OCT17-1/1

05-2 071321

PN=10
Safety

Handle Fuel Safely—Avoid Fires


Handle fuel with care: it is highly flammable. Do not refuel
the machine while smoking or when near open flame or
sparks.
Always stop engine before refueling machine. Fill fuel

TS202 —UN—23AUG88
tank outdoors.
Prevent fires by keeping machine clean of accumulated
trash, grease, and debris. Always clean up spilled fuel.
Use only an approved fuel container for transporting
flammable liquids.
Never fill fuel container in pickup truck with plastic bed
liner. Always place fuel container on ground before
refueling. Touch fuel container with fuel dispenser nozzle Do not store fuel container where there is an open flame,
before removing can lid. Keep fuel dispenser nozzle in spark, or pilot light such as within a water heater or other
contact with fuel container inlet when filling. appliance.
DX,FIRE1 -19-12OCT11-1/1

Handle Starting Fluid Safely


Starting fluid is highly flammable.
Keep all sparks and flame away when using it. Keep
starting fluid away from batteries and cables.
To prevent accidental discharge when storing the

TS1356 —UN—18MAR92
pressurized can, keep the cap on the container, and store
in a cool, protected location.
Do not incinerate or puncture a starting fluid container.
Do not use starting fluid on an engine equipped with glow
plugs or an air intake heater.
DX,FIRE3 -19-14MAR14-1/1

Fire Prevention Operator’s Manual greatly reduce the risk of fire and the
chance of costly downtime.
To reduce the risk of fire, your tractor should be regularly
inspected and cleaned.
• Do not store fuel container where there is an open
flame, spark, or pilot light such as within a water heater
• Birds and other animals may build nests or bring other or other appliance.
flammable materials into the engine compartment • Check fuel lines, tank, cap, and fittings frequently for
or onto the exhaust system. The tractor should be damage, cracks or leaks. Replace if necessary.
inspected and cleaned prior to the first use each day. Follow all operational and safety procedures posted on
• A build up of grass, crop material and other debris may the machine and the Operator’s Manual. Be careful of hot
occur during normal operation. This is especially true engine and exhaust components during inspection and
when operating in very dry conditions or conditions cleaning. Before carrying out any inspection or cleaning,
where airborne crop material or crop dust is present. always shut OFF the engine, place the transmission in
Any such build up must be removed to ensure proper PARK or set parking brake, and remove the key. Removal
machine function and to reduce the risk of fire. The of the key will prevent others from starting the tractor
tractor must be inspected and cleaned periodically during inspection and cleaning.
throughout the day.
• Regular and thorough cleaning of the tractor combined
with other routine maintenance procedures listed in the
DX,WW,TRACTOR,FIRE,PREVENTION -19-12OCT11-1/1

05-3 071321

PN=11
Safety

In Case of Fire
CAUTION: Avoid personal injury.

Stop machine immediately at the first sign of fire. Fire


may be identified by the smell of smoke or sight of flames.
Because fire grows and spreads rapidly, get off the

TS227 —UN—15APR13
machine immediately and move safely away from the fire.
Do not return to the machine! The number one priority
is safety.
Call the fire department. A portable fire extinguisher can
put out a small fire or contain it until the fire department
arrives; but portable extinguishers have limitations.
Always put the safety of the operator and bystanders first.
If attempting to extinguish a fire, keep your back to the 1. Pull the pin. Hold the extinguisher with the nozzle
wind with an unobstructed escape path so you can move pointing away from you, and release the locking
away quickly if the fire cannot be extinguished. mechanism.
Read the fire extinguisher instructions and become familiar 2. Aim low. Point the extinguisher at the base of the fire.
with their location, parts, and operation before a fire starts.
Local fire departments or fire equipment distributors may 3. Squeeze the lever slowly and evenly.
offer fire extinguisher training and recommendations.
4. Sweep the nozzle from side-to-side.
If your extinguisher does not have instructions, follow
these general guidelines:
DX,FIRE4 -19-22AUG13-1/1

Avoid Static Electricity Risk When Refueling


The removal of sulfur and other compounds in Ultra-Low
Sulfur Diesel (ULSD) fuel decreases its conductivity and
increases its ability to store a static charge.
Refineries may have treated the fuel with a static

RG22142 —UN—17MAR14
dissipating additive. However, there are many factors that
can reduce the effectiveness of the additive over time.
Static charges can build up in ULSD fuel while it is flowing
through fuel delivery systems. Static electricity discharge
when combustible vapors are present could result in a
fire or explosion.
Therefore, it is important to ensure that the entire system
used to refuel your machine (fuel supply tank, transfer
pump, transfer hose, nozzle, and others) is properly
grounded and bonded. Consult with your fuel or fuel
system supplier to ensure that the delivery system is in
compliance with fueling standards for proper grounding
RG21992 —UN—21AUG13

and bonding practices.

DX,FUEL,STATIC,ELEC -19-12JUL13-1/1

05-4 071321

PN=12
Safety

Keep ROPS Installed Properly


Make certain all parts are reinstalled correctly if the
roll-over protective structure (ROPS) is loosened or
removed for any reason. Tighten mounting bolts to proper
torque.

TS212 —UN—23AUG88
The protection offered by ROPS will be impaired if ROPS
is subjected to structural damage, is involved in an
overturn incident, or is in any way altered by welding,
bending, drilling, or cutting. A damaged ROPS should be
replaced, not reused.
The seat is part of the ROPS safety zone. Replace only
with John Deere seat approved for your tractor.
Any alteration of the ROPS must be approved by the
manufacturer.
DX,ROPS3 -19-12OCT11-1/1

Use Foldable ROPS and Seat Belt Properly


Avoid crushing injury or death during rollover.
• If this machine is equipped with a foldable rollover
protective structure (ROPS), keep the ROPS in the fully
extended and locked position. USE a seat belt when

TS1729 —UN—24MAY13
you operate with a ROPS in the fully extended position.
- Hold the latch and pull the seat belt across the body.
- Insert the latch into the buckle. Listen for a click.
- Tug on the seat belt to make sure that the belt is
securely fastened.
- Snug the seat belt across the hips.
• If this machine is operated with the ROPS folded (for
example, to enter a low building), drive with extreme
caution. DO NOT USE a seat belt with the ROPS folded.
• Return the ROPS to the raised, fully extended position
as soon as the machine is operated under normal
conditions.
DX,FOLDROPS -19-22AUG13-1/1

05-5 071321

PN=13
Safety

Stay Clear of Rotating Drivelines


Entanglement in rotating driveline can cause serious
injury or death.
Keep tractor master shield and driveline shields in place
at all times. Make sure rotating shields turn freely.

TS1644 —UN—22AUG95
Only use power take-off driveshafts with adequate guards
and shields.
Wear close fitting clothing. Stop the engine and be sure
that PTO driveline is stopped before making adjustments,
connections, or cleaning out PTO driven equipment.
Do not install any adapter device between the tractor and
the primary implement PTO driveshaft that will allow a
1000 rpm tractor shaft to power a 540 rpm implement at
speeds higher than 540 rpm.
Do not install any adapter device that results in a portion of
the rotating implement shaft, tractor shaft, or the adapter
to be unguarded. The tractor master shield shall overlap
the end of the splined shaft and the added adaptor device
as outlined in the table.
The angle at which the primary implement PTO driveshaft
can be inclined may be reduced depending on the shape
and size of the tractor master shield and the shape and
size of the guard of the primary implement PTO driveshaft.

H96219 —UN—29APR10
Do not raise implements high enough to damage the
tractor master shield or guard of primary implement PTO
driveshaft. Detach the PTO driveline shaft if it is necessary
to increase implement height. (See Attching/Detaching
PTO Driveline)
When using Type 3/4 PTO, inclination and turning angles
may be reduced depending on type of PTO master shield
and coupling rails.
PTO Type Diameter Splines n ± 5 mm (0.20 in.)
1 35 mm (1.378 6 85 mm (3.35 in.)
in.)
2 35 mm (1.378 21 85 mm (3.35 in.)
in.)
3 45 mm (1.772 20 100 mm (4.00 in.)
in.)
4 57.5 mm (2.264 22 100 mm (4.00 in.)
in.)

DX,PTO -19-28FEB17-1/1

Use Steps and Handholds Correctly


Prevent falls by facing the machine when getting on and
T133468 —UN—15APR13

off. Maintain 3-point contact with steps, handholds, and


handrails.
Use extra care when mud, snow, or moisture present
slippery conditions. Keep steps clean and free of grease
or oil. Never jump when exiting machine. Never mount or
dismount a moving machine.

DX,WW,MOUNT -19-12OCT11-1/1

05-6 071321

PN=14
Safety

Read Operator’s Manuals for ISOBUS Controllers


In addition to GreenStar™ Applications, this display can Some of these functions could pose a hazard to either
be used as a display device for any ISOBUS Controller the operator or a bystander. Read the Operator’s Manual
that meets ISO 11783 standard. This includes capability provided by the ISOBUS Controller manufacturer and
to control ISOBUS implements. When used in this observe all safety messages in manual and on ISOBUS
manner, information and control functions placed on the Controller product prior to use.
display are provided by the ISOBUS Controller and are
the responsibility of the ISOBUS Controller manufacturer. NOTE: ISOBUS refers to the ISO Standard 11783

GreenStar is a trademark of Deere & Company


DX,WW,ISOBUS -19-15JUL15-1/1

Use Seat Belt Properly


Avoid crushing injury or death during rollover.
This machine is equipped with a rollover protective
structure (ROPS). USE a seat belt when you operate with
a ROPS.

TS1729 —UN—24MAY13
• Hold the latch and pull the seat belt across the body.
• Insert the latch into the buckle. Listen for a click.
• Tug on the seat belt latch to make sure that the belt
is securely fastened.
• Snug the seat belt across the hips.
Replace entire seat belt if mounting hardware, buckle,
belt, or retractor show signs of damage.
discoloration, or abrasion. Replace only with replacement
Inspect seat belt and mounting hardware at least parts approved for your machine. See your John Deere
once a year. Look for signs of loose hardware or belt dealer.
damage, such as cuts, fraying, extreme or unusual wear,
DX,ROPS1 -19-22AUG13-1/1

05-7 071321

PN=15
Safety

Operating the Tractor Safely • Pump brakes when stopping on slippery surfaces.
You can reduce the risk of accidents by following these
• Regularly clean fenders and fender valances (mud
flaps) if installed. Remove dirt before driving on public
simple precautions: roadways.
• Use your tractor only for jobs it was designed to perform, Heated and Ventilated Operator’s Seat
for example, pushing, pulling, towing, actuating, and
carrying a variety of interchangeable equipment • An overheated seat heater can cause a burn injury
designed to conduct agricultural work. or damage to the seat. To reduce the risk of burns,
• Operators must be mentally and physically capable of use caution when using the seat heater for extended
accessing the operator’s station and/or controls, and periods of time, especially if the operator cannot feel
operating the machine properly and safely. temperature change or pain to the skin. Do not place
• Never operate machine when distracted, fatigued, objects on the seat, such as a blanket, cushion, cover,
or impaired. Proper machine operation requires the or similar item, which can cause the seat heater to
operator’s full attention and awareness. overheat.
• This tractor is not intended to be used as a recreational
vehicle. Towing Loads
• Read this operator’s manual before operating the
• Be careful when towing and stopping heavy loads.
tractor and follow operating and safety instructions in
the manual and on the tractor. Stopping distance increases with speed and weight
of towed loads, and on slopes. Towed loads with or
• Follow operation and ballasting instructions found in the
without brakes that are too heavy for the tractor or are
operator’s manual for your implements/attachments,
such as front loaders. towed too fast can cause loss of control.
• Follow the instructions outlined in the operator’s • Consider the total weight of the equipment and its load.
manual of any mounted or trailed machinery or trailer. • Hitch towed loads only to approved couplings to avoid
Do not operate a combination of tractor-machine or rearward upset.
tractor-trailer unless all instructions have been followed. Parking and Leaving the Tractor
• Make sure that everyone is clear of machine, attached
equipment, and work area before starting engine or • Before dismounting, shut off SCVs, disengage PTO,
operation. stop engine, lower implements/attachments to ground,
• Stay clear of the three-point linkage and pickup hitch (if place implement/attachment control devices in neutral,
equipped) when controlling them. and securely engage park mechanism, including the
• Keep hands, feet, and clothing away from power-driven park pawl and park brake. In addition, if the tractor is
parts. left unattended, remove key.
Driving Concerns
• Leaving transmission in gear with engine off will NOT
prevent the tractor from moving.
• Never get on or off a moving tractor. • Never go near an operating PTO or an operating
implement.
• Complete any required training prior to operating • Wait for all movement to stop before servicing
vehicle.
machinery.
• Keep all children and nonessential personnel off tractors
and all equipment. Common Accidents
• Never ride on a tractor unless seated on a John Deere
approved seat with a seat belt. Unsafe operation or misuse of the tractor can result in
• Keep all shields/guards in place. accidents. Be alert to hazards of tractor operation.
• Use appropriate visual and audible signals when
The most common accidents involving tractors are:
operating on public roads.
• Move to side of road before stopping. • Tractor rollover
• Reduce speed when turning, applying individual brakes, • Collisions with motor vehicles
or operating around hazards on rough ground or steep • Improper starting procedures
slopes. • Entanglement in PTO shafts
• Stability degrades when attached implements are at • Falling from tractor
high position. • Crushing and pinching during hitching
• Couple brake pedals together for road travel.
DX,WW,TRACTOR -19-08MAY19-1/1

05-8 071321

PN=16
Safety

Avoid Backover Accidents


Before moving machine, be sure that all persons are clear
of machine path. Turn around and look directly for best
visibility. Use a signal person when backing if view is

PC10857XW —UN—15APR13
obstructed or when in close quarters.
Do not rely on a camera to determine if personnel or
obstacles are behind the machine. The system can be
limited by many factors including maintenance practices,
environmental conditions, and operating range.

DX,AVOID,BACKOVER,ACCIDENTS -19-30AUG10-1/1

Limited Use in Forestry Operation applications beyond these applications, such as forwarding
and loading, requires fitment of application-specific
The intended use of John Deere tractors when used components including Falling Object Protective Structure
in forestry operations is limited to tractor-specific (FOPS) and/or Operative Protective Structures (OPS).
applications like transport, stationary work such as log Contact John Deere dealer for special components.
splitting, propulsion, or operating implements with PTO,
hydraulic, or electrical systems.
These are applications where normal operation does not
present a risk of falling or penetrating objects. Any forestry
DX,WW,FORESTRY -19-12OCT11-1/1

Operating the Loader Tractor Safely


When operating a machine with a loader application,
reduce speed as required to ensure good tractor and
loader stability.
To avoid tractor rollover and damage to front tires and

TS1692 —UN—09NOV09
tractor, do not carry load with your loader at a speed over
10 km/h (6 mph).
To avoid tractor damage do not use a front loader or a
sprayer tank if the tractor is equipped with a 3 Meter Front
Axle.
Never allow anyone to walk or work under a raised loader.
Do not use loader as a work platform. falling onto the operators station. To prevent loads from
Do not lift or carry anyone on loader, in bucket, or on falling onto the operators station, always use appropriate
implement or attachment. implements for specific applications (that is, manure forks,
round bale forks, round bale grippers, and clampers).
Lower loader to ground before leaving operators station.
Ballast tractor in accordance to Ballast Recommendations
The Rollover Protective Structure (ROPS) or cab roof, if in PREPARE TRACTOR section.
equipped, may not provide sufficient protection from load
DX,WW,LOADER -19-18SEP12-1/1

05-9 071321

PN=17
Safety

Keep Riders Off Machine


Only allow the operator on the machine. Keep riders off.
Riders on machine are subject to injury such as being
struck by foreign objects and being thrown off of the
machine. Riders also obstruct the operator’s view resulting

TS290 —UN—23AUG88
in the machine being operated in an unsafe manner.

DX,RIDER -19-03MAR93-1/1

Instructional Seat
The instructional seat, if so equipped, has been provided
only for training operators or diagnosing machine
problems.

TS1730 —UN—24MAY13
DX,SEAT,NA -19-22AUG13-1/1

Use Safety Lights and Devices


Prevent collisions between other road users, slow moving
tractors with attachments or towed equipment, and
self-propelled machines on public roads. Frequently
check for traffic from the rear, especially in turns, and use
turn signal lights.
Use headlights, flashing warning lights, and turn signals
day and night. Follow local regulations for equipment
lighting and marking. Keep lighting and marking visible,
clean, and in good working order. Replace or repair
lighting and marking that has been damaged or lost. An
implement safety lighting kit is available from your John TS951 —UN—12APR90

Deere dealer.

DX,FLASH -19-07JUL99-1/1

05-10 071321

PN=18
Safety

Transport Towed Equipment at Safe Speeds


Do not exceed the maximum transport speed. This towing
unit may be capable of operating at transport speeds that
exceed the maximum allowable transport speed for towed
implements.
Before transporting a towed implement, determine from
signs on the implement or information provided in the
implement's operator manual the maximum transport
speed. Never transport at speeds that exceed the
implement's maximum transport speed. Exceeding the
implement's maximum transport speed can result in:
• Loss of control of the towing unit/implement combination

TS1686 —UN—27SEP06
• Reduced or no ability to stop during braking
• Implement tire failure
• Damage to the implement structure or its components
Implements shall be equipped with brakes if the maximum
fully loaded weight is greater than 1500 kg (3307 lbs) and
greater than 1.5 times the weight of the towing unit.
Example: Implement mass is 1600 kg (3527 lbs) and
towing unit mass is 1600 kg (3527 lbs), example • When transporting at speeds between 40—50 km/h
implement is not required to have brakes. (25—31 mph) the fully loaded implement must weigh
less than 3.0 times the towing unit weight.
Implements without brakes: Do not transport at speeds
greater than 32 km/h (20 mph). When towing a trailer, become familiar with the braking
characteristics and ensure the compatibility of the
Implements with brakes: tractor/trailer combination in regard to the deceleration
rate.
• If the manufacturer does not specify a maximum
transport speed, do not tow at speeds greater than 40
km/h (25 mph).
• When transporting at speeds up to 40 km/h (25 mph)
the fully loaded implement must weigh less than 4.5
times the towing unit weight.
DX,TOW1 -19-28FEB17-1/1

05-11 071321

PN=19
Safety

Use Caution on Slopes, Uneven Terrain, and


Rough Ground
Avoid holes, ditches, and obstructions which cause the
tractor to tip, especially on slopes. Avoid sharp uphill turns.

RXA0103437 —UN—01JUL09
Driving forward out of a ditch, mired condition, or up a
steep slope could cause the tractor to tip over rearward.
Back out of these situations if possible.
Danger of overturn increases greatly with narrow tread
setting, at high speed.
Not all conditions that can cause a tractor to overturn are
listed. Be alert for any situation in which stability may be
compromised.
Slopes are a major factor related to loss-of-control and Choose a low ground speed so you will not have to stop
tip-over accidents, which can result in severe injury or or shift while on a slope.
death. Operation on all slopes requires extra caution. Avoid starting, stopping, or turning on a slope. If the tires
Uneven terrain or rough ground can cause loss-of-control lose traction, disengage the PTO and proceed slowly,
and tip-over accidents, which can result in severe injury straight down the slope.
or death. Operation on uneven terrain or rough ground Keep all movement on slopes slow and gradual. Do not
requires extra caution. make sudden changes in speed or direction, which could
Never drive near the edge of a gully, drop-off, ditch, steep cause the machine to roll over.
embankment, or a body of water. The machine could
suddenly roll over if a wheel goes over the edge or the
ground caves in
DX,WW,SLOPE -19-28FEB17-1/1

Freeing a Mired Machine


Attempting to free a mired machine can involve safety
hazards such as the mired tractor tipping rearward, the
towing tractor overturning, and the tow chain or tow bar
(a cable is not recommended) failing and recoiling from
its stretched condition.

TS1645 —UN—15SEP95
Back your tractor out if it gets mired down in mud. Unhitch
any towed implements. Dig mud from behind the rear
wheels. Place boards behind the wheels to provide a solid
base and try to back out slowly. If necessary, dig mud
from the front of all wheels and drive slowly ahead.
If necessary to tow with another unit, use a tow bar or
a long chain (a cable is not recommended). Inspect the
chain for flaws. Make sure all parts of towing devices are
of adequate size and strong enough to handle the load.
Always hitch to the drawbar of the towing unit. Do not
hitch to the front pushbar attachment point. Before
moving, clear the area of people. Apply power smoothly
TS263 —UN—23AUG88

to take up the slack: a sudden pull could snap any towing


device causing it to whip or recoil dangerously.

DX,MIRED -19-07JUL99-1/1

05-12 071321

PN=20
Safety

Avoid Contact with Agricultural Chemicals


This enclosed cab does not protect against inhaling
vapor, aerosol or dust. If pesticide use instructions require
respiratory protection, wear an appropriate respirator
inside the cab.
Before leaving the cab, wear personal protective

TS220 —UN—15APR13
equipment as required by the pesticide use instructions.
When re-entering the cab, remove protective equipment
and store either outside the cab in a closed box or some
other type of sealable container or inside the cab in a
pesticide resistant container, such as a plastic bag.
Clean your shoes or boots to remove soil or other
contaminated particles prior to entering the cab.

TS272 —UN—23AUG88
DX,CABS -19-25MAR09-1/1

05-13 071321

PN=21
Safety

Handle Agricultural Chemicals Safely


Chemicals used in agricultural applications such
as fungicides, herbicides, insecticides, pesticides,
rodenticides, and fertilizers can be harmful to your health
or the environment if not used carefully.
Always follow all label directions for effective, safe, and

TS220 —UN—15APR13
legal use of agricultural chemicals.
Reduce risk of exposure and injury:
• Wear appropriate personal protective equipment as
recommended by the manufacturer. In the absence
of manufacturer's instructions, follow these general
guidelines:
- Chemicals labeled 'Danger': Most toxic. Generally
require use of goggles, respirator, gloves, and skin
protection.
- Chemicals labeled 'Warning': Less toxic. Generally
require use of goggles, gloves, and skin protections.

A34471 —UN—11OCT88
- Chemicals labeled 'Caution': Least toxic. Generally
require use of gloves and skin protection.
• Avoid inhaling vapor, aerosol or dust.
• Always have soap, water, and towel available when
working with chemicals. If chemical contacts skin,
hands, or face, wash immediately with soap and water.
If chemical gets into eyes, flush immediately with water.
• Wash hands and face after using chemicals and before
eating, drinking, smoking, or urination.
• Do not smoke or eat while applying chemicals. • Store chemicals in a secure, locked area away from
human or livestock food. Keep children away.
• After handling chemicals, always bathe or shower and
• Always dispose of containers properly. Triple rinse
change clothes. Wash clothing before wearing again.
empty containers and puncture or crush containers and
• Seek medical attention immediately if illness occurs
dispose of properly.
during or shortly after use of chemicals.
• Keep chemicals in original containers. Do not transfer
chemicals to unmarked containers or to containers used
for food or drink.
DX,WW,CHEM01 -19-24AUG10-1/1

05-14 071321

PN=22
Safety

Handling Batteries Safely


Battery gas can explode. Keep sparks and flames away
from batteries. Use a flashlight to check battery electrolyte
level.
Never check battery charge by placing a metal object
across the posts. Use a voltmeter or hydrometer.

TS204 —UN—15APR13
Always remove grounded (-) battery clamp first and
replace grounded clamp last.
Sulfuric acid in battery electrolyte is poisonous and strong
enough to burn skin, eat holes in clothing, and cause
blindness if splashed into eyes.
Avoid hazards by:
• Filling batteries in a well-ventilated area
• Wearing eye protection and rubber gloves
• Avoiding use of air pressure to clean batteries
• Avoiding breathing fumes when electrolyte is added
• Avoiding spilling or dripping electrolyte
• Using correct battery booster or charger procedure.
If acid is spilled on skin or in eyes:
1. Flush skin with water.
2. Apply baking soda or lime to help neutralize the acid.
3. Flush eyes with water for 15—30 minutes. Get
medical attention immediately.
If acid is swallowed:
1. Do not induce vomiting.
2. Drink large amounts of water or milk, but do not
exceed 2 L (2 qt.).
3. Get medical attention immediately.
WARNING: Battery posts, terminals, and related

TS203 —UN—23AUG88
accessories contain lead and lead compounds, chemicals
known to the State of California to cause cancer and
reproductive harm. Wash hands after handling.

DX,WW,BATTERIES -19-02DEC10-1/1

Avoid Heating Near Pressurized Fluid Lines


Flammable spray can be generated by heating near
pressurized fluid lines, resulting in severe burns to yourself
and bystanders. Do not heat by welding, soldering,
or using a torch near pressurized fluid lines or other
flammable materials. Pressurized lines can accidentally
TS953 —UN—15MAY90

burst when heat goes beyond the immediate flame area.

DX,TORCH -19-10DEC04-1/1

05-15 071321

PN=23
Safety

Remove Paint Before Welding or Heating


Avoid potentially toxic fumes and dust.
Hazardous fumes can be generated when paint is heated
by welding, soldering, or using a torch.
Remove paint before heating:

TS220 —UN—15APR13
• Remove paint a minimum of 100 mm (4 in.) from area
to be affected by heating. If paint cannot be removed,
wear an approved respirator before heating or welding.
• If you sand or grind paint, avoid breathing the dust.
Wear an approved respirator.
• If you use solvent or paint stripper, remove stripper with
soap and water before welding. Remove solvent or
paint stripper containers and other flammable material
Do all work in an area that is well ventilated to carry toxic
from area. Allow fumes to disperse at least 15 minutes
fumes and dust away.
before welding or heating.
Do not use a chlorinated solvent in areas where welding Dispose of paint and solvent properly.
will take place.
DX,PAINT -19-24JUL02-1/1

Handle Electronic Components and Brackets


Safely
Falling while installing or removing electronic components
mounted on equipment can cause serious injury. Use a
ladder or platform to easily reach each mounting location.
Use sturdy and secure footholds and handholds. Do not

TS249 —UN—23AUG88
install or remove components in wet or icy conditions.
If installing or servicing a RTK base station on a tower or
other tall structure, use a certified climber.
If installing or servicing a global positioning receiver mast
used on an implement, use proper lifting techniques and
wear proper protective equipment. The mast is heavy and
can be awkward to handle. Two people are required when
mounting locations are not accessible from the ground
or from a service platform.
DX,WW,RECEIVER -19-24AUG10-1/1

05-16 071321

PN=24
Safety

Practice Safe Maintenance


Understand service procedure before doing work. Keep
area clean and dry.
Never lubricate, service, or adjust machine while it is
moving. Keep hands, feet, and clothing away from
power-driven parts. Disengage all power and operate
controls to relieve pressure. Lower equipment to the
ground. Stop the engine. Remove the key. Allow machine
to cool.
Securely support any machine elements that must be
raised for service work.
Keep all parts in good condition and properly installed.
Fix damage immediately. Replace worn or broken parts.
Remove any buildup of grease, oil, or debris.
On self-propelled equipment, disconnect battery ground
cable (-) before making adjustments on electrical systems
or welding on machine.
On towed implements, disconnect wiring harnesses from
tractor before servicing electrical system components or

TS218 —UN—23AUG88
welding on machine.
Falling while cleaning or working at height can cause
serious injury. Use a ladder or platform to easily reach
each location. Use sturdy and secure footholds and
handholds.

DX,SERV -19-28FEB17-1/1

Avoid Hot Exhaust


Servicing machine or attachments with engine running
can result in serious personal injury. Avoid exposure and
skin contact with hot exhaust gases and components.
Exhaust parts and streams become very hot during

RG17488 —UN—21AUG09
operation. Exhaust gases and components reach
temperatures hot enough to burn people, ignite, or melt
common materials.

DX,EXHAUST -19-20AUG09-1/1

05-17 071321

PN=25
Safety

Clean Exhaust Filter Safely


During exhaust filter cleaning operations, the engine
may run at elevated idle and hot temperatures for an
extended period of time. Exhaust gases and exhaust
filter components reach temperatures hot enough to burn
people, or ignite or melt common materials.

TS227 —UN—15APR13
Keep machine away from people, animals, or structures
which may be susceptible to harm or damage from hot
exhaust gases or components. Avoid potential fire or
explosion hazards from flammable materials and vapors
near the exhaust. Keep exhaust outlet away from people
and anything that can melt, burn, or explode.
Closely monitor machine and surrounding area for
smoldering debris during and after exhaust filter cleaning.
Adding fuel while an engine is running can create a fire
or explosion hazard. Always stop engine before refueling
machine and clean up any spilled fuel.

TS271 —UN—23AUG88
Always make sure that engine is stopped while hauling
machine on a truck or trailer.
Contact with exhaust components while still hot can result
in serious personal injury.
Avoid contact with these components until cooled to safe
temperatures.
If service procedure requires engine to be running:
• Only engage power-driven parts required by service
procedure
• Ensure that other people are clear of operator station
and machine

TS1693 —UN—09DEC09
Keep hands, feet, and clothing away from power-driven
parts.
Always disable movement (neutral), set the parking brake
or mechanism and disconnect power to attachments or
tools before leaving the operator’s station.
Shut off engine and remove key (if equipped) before
leaving the machine unattended.

TS1695 —UN—07DEC09

DX,EXHAUST,FILTER -19-12JAN11-1/1

05-18 071321

PN=26
Safety

Work In Ventilated Area


Engine exhaust fumes can cause sickness or death. If
it is necessary to run an engine in an enclosed area,
remove the exhaust fumes from the area with an exhaust
pipe extension.
If you do not have an exhaust pipe extension, open the

TS220 —UN—15APR13
doors and get outside air into the area.

DX,AIR -19-17FEB99-1/1

Support Machine Properly


Always lower the attachment or implement to the ground
before you work on the machine. If the work requires
that the machine or attachment be lifted, provide secure
support for them. If left in a raised position, hydraulically
supported devices can settle or leak down.

TS229 —UN—23AUG88
Do not support the machine on cinder blocks, hollow tiles,
or props that may crumble under continuous load. Do not
work under a machine that is supported solely by a jack.
Follow recommended procedures in this manual.
When implements or attachments are used with a
machine, always follow safety precautions listed in the
implement or attachment operator's manual.
DX,LOWER -19-24FEB00-1/1

Prevent Machine Runaway


Avoid possible injury or death from machinery runaway.
Do not start engine by shorting across starter terminals.
Machine will start in gear if normal circuitry is bypassed.
NEVER start engine while standing on ground. Start

TS177 —UN—11JAN89
engine only from operator’s seat, with transmission in
neutral or park.

DX,BYPAS1 -19-29SEP98-1/1

05-19 071321

PN=27
Safety

Park Machine Safely


Before working on the machine:
• Lower all equipment to the ground.
• Stop the engine and remove the key.
• Disconnect the battery ground strap.
• Hang a "DO NOT OPERATE" tag in operator station.

TS230 —UN—24MAY89
DX,PARK -19-04JUN90-1/1

Transport Tractor Safely


A disabled tractor is best transported on a flatbed carrier.
Use chains to secure the tractor to the carrier. The axles
and tractor frame are suitable attachment points.

RXA0103709 —UN—01JUL09
Before transporting the tractor on a low-loader truck or
flatbed rail wagon, make sure that the hood is secured
over the tractor engine and that doors, roof hatch (if
equipped) and windows are properly closed.
Never tow a tractor at a speed greater than 10 km/h (6
mph). An operator must steer and brake the tractor under
tow.

DX,WW,TRANSPORT -19-19AUG09-1/1

Service Cooling System Safely


Explosive release of fluids from pressurized cooling
system can cause serious burns.
Shut off engine. Only remove filler cap when cool enough
to touch with bare hands. Slowly loosen cap to first stop
to relieve pressure before removing completely.

TS281 —UN—15APR13

DX,WW,COOLING -19-19AUG09-1/1

05-20 071321

PN=28
Safety

Service Accumulator Systems Safely


Escaping fluid or gas from systems with pressurized
accumulators that are used in air conditioning, hydraulic,
and air brake systems can cause serious injury. Extreme
heat can cause the accumulator to burst, and pressurized
lines can be accidentally cut. Do not weld or use a torch

TS281 —UN—15APR13
near a pressurized accumulator or pressurized line.
Relieve pressure from the pressurized system before
removing accumulator.
Relieve pressure from the hydraulic system before
removing accumulator. Never attempt to relieve hydraulic
system or accumulator pressure by loosening a fitting.
Accumulators cannot be repaired.
DX,WW,ACCLA2 -19-22AUG03-1/1

Service Tires Safely


Explosive separation of a tire and rim parts can cause
serious injury or death.
Do not attempt to mount a tire unless you have the proper

RXA0103438 —UN—11JUN09
equipment and experience to perform the job.
Always maintain the correct tire pressure. Do not inflate
the tires above the recommended pressure. Never weld
or heat a wheel and tire assembly. The heat can cause
an increase in air pressure resulting in a tire explosion.
Welding can structurally weaken or deform the wheel.
When inflating tires, use a clip-on chuck and extension
hose long enough to allow you to stand to one side and
NOT in front of or over the tire assembly. Use a safety Wheels and tires are heavy. When handling wheels and
cage if available. tires use a safe lifting device or get an assistant to help
Check wheels for low pressure, cuts, bubbles, damaged lift, install, or remove.
rims, or missing lug bolts and nuts.
DX,WW,RIMS -19-28FEB17-1/1

Service Front-Wheel Drive Tractor Safely


When servicing front-wheel drive tractor with the rear
wheels supported off the ground and rotating wheels by
engine power, always support front wheels in a similar
manner. Loss of electrical power or transmission hydraulic
system pressure will engage the front driving wheels, L124515 —UN—06AUG94
pulling the rear wheels off the support if front wheels are
not raised. Under these conditions, front drive wheels can
engage even with switch in disengaged position.

DX,WW,MFWD -19-19AUG09-1/1

05-21 071321

PN=29
Safety

Tightening Wheel Retaining Bolts/Nuts


Torque wheel retaining bolts/nuts at the intervals specified
in section Break-In Period and Service.

L124516 —UN—03JAN95
DX,WW,WHEEL -19-12OCT11-1/1

Avoid High-Pressure Fluids


Inspect hydraulic hoses periodically – at least once
per year – for leakage, kinking, cuts, cracks, abrasion,
blisters, corrosion, exposed wire braid or any other signs
of wear or damage.

X9811 —UN—23AUG88
Replace worn or damaged hose assemblies immediately
with John Deere approved replacement parts.
Escaping fluid under pressure can penetrate the skin
causing serious injury.
Avoid the hazard by relieving pressure before
disconnecting hydraulic or other lines. Tighten all
connections before applying pressure.
with this type of injury should reference a knowledgeable
Search for leaks with a piece of cardboard. Protect hands medical source. Such information is available in
and body from high-pressure fluids. English from Deere & Company Medical Department in
Moline, Illinois, U.S.A., by calling 1-800-822-8262 or +1
If an accident occurs, see a doctor immediately. Any fluid 309-748-5636.
injected into the skin must be surgically removed within
a few hours or gangrene may result. Doctors unfamiliar
DX,FLUID -19-12OCT11-1/1

Do Not Open High-Pressure Fuel System


High-pressure fluid remaining in fuel lines can cause
serious injury. Do not disconnect or attempt repair of fuel
lines, sensors, or any other components between the
high-pressure fuel pump and nozzles on engines with
High Pressure Common Rail (HPCR) fuel system.
TS1343 —UN—18MAR92

Only technicians familiar with this type of system can


perform repairs. (See your John Deere dealer.)

DX,WW,HPCR1 -19-07JAN03-1/1

05-22 071321

PN=30
Safety

Store Attachments Safely


Stored attachments such as dual wheels, cage wheels,
and loaders can fall and cause serious injury or death.
Securely store attachments and implements to prevent
falling. Keep playing children and bystanders away from

TS219 —UN—23AUG88
storage area.

DX,STORE -19-03MAR93-1/1

Decommissioning — Proper Recycling and


Disposal of Fluids and Components
Safety and environmental stewardship measures must
be taken into account when decommissioning a machine
and/or component. These measures include the following:

TS1133 —UN—15APR13
• Use appropriate tools and personal protective
equipment such as clothing, gloves, face shields or
glasses, during the removal or handling of objects and
materials.
• Follow instructions for specialized components.
• Release stored energy by lowering suspended machine
elements, relaxing springs, disconnecting the battery
or other electrical power, and releasing pressure in
hydraulic components, accumulators, and other similar filters; batteries; and, other substances or parts.
systems. Burning of flammable fluids or components in other than
• Minimize exposure to components which may have specially designed incinerators may be prohibited by law
residue from agricultural chemicals, such as fertilizers and could result in exposure to harmful fumes or ashes.
and pesticides. Handle and dispose of these • Service and dispose of air conditioning systems
components appropriately. appropriately. Government regulations may require
• Carefully drain engines, fuel tanks, radiators, hydraulic a certified service center to recover and recycle air
cylinders, reservoirs, and lines before recycling conditioning refrigerants which could damage the
components. Use leak-proof containers when draining atmosphere if allowed to escape.
fluids. Do not use food or beverage containers. • Evaluate recycling options for tires, metal, plastic,
• Do not pour waste fluids onto the ground, down a drain, glass, rubber, and electronic components which may be
or into any water source. recyclable, in part or completely.
• Observe all national, state, and local laws, regulations, • Contact your local environmental or recycling center, or
or ordinances governing the handling or disposal of your John Deere dealer for information on the proper
waste fluids (example: oil, fuel, coolant, brake fluid); way to recycle or dispose of waste.
DX,DRAIN -19-01JUN15-1/1

05-23 071321

PN=31
Safety Signs
Pictorial Safety Signs
Safety signs are affixed at several important places on this
machine. They are intended to point out potential danger.
The hazard is identified by a pictorial in a warning triangle.
An adjacent pictorial provides information on how to avoid
personal injury. These safety signs, their location on the

TS231 —19—07OCT88
machine and a brief explanatory text are shown below.

AK50421,00000E0 -19-02JUN11-1/1

Warning Decal - Read Operator’s Manual

PY15859 —UN—23SEP13
PY13091 —UN—21DEC11

Left-Hand Side of the Fender

safety signs. Carefully observe all safety rules to avoid


CAUTION: Avoid the risk of injury. accidents.
This Operator’s Manual contains important information
necessary for safe machine operation and explanation of
VP52664,00000D5 -19-27JAN15-1/1

10-1 071321

PN=32
Safety Signs

Riders

PY11234 —UN—12NOV10

PY11235 —UN—12NOV10
On Top of Both Fenders

A—Riders Safety Sign

off of the machine. Riders also obstruct the operator's


CAUTION: Avoid falling and being struck. view resulting in the machine being operated in an unsafe
manner.
Keep riders off. Riders on machine are subject to injury
such as being struck by foreign objects and being thrown
SV86979,00006CD -19-17DEC13-1/1

10-2 071321

PN=33
Safety Signs

Use Seat Belt


Use Foldable ROPS and Seat Belt Properly

CAUTION: Avoid crushing injury or death


during rollover

PY15863 —UN—24SEP13
• If this machine is equipped with a roll-over protective
structure (ROPS).USE a seat belt when you operate
with a ROPS.
- Hold the latch and pull the seat belt across the body.
- Insert the latch into the buckle. Listen for a click.
- Tug on the seat belt latch to make sure that the belt is
securely fastened.
Right Side of the Fender
- Snug the seat belt across the hips.
• If this machine is operated with the ROPS folded (e.g.
to enter a low building), drive with extreme caution. DO
NOT USE a seat belt with the ROPS folded.
• Return the ROPS to the raised, fully extended position
as soon as the machine is operated under normal
conditions.

PY16929 —UN—15JUL13
ROPS Safety Decal

VP52664,00000D6 -19-08FEB16-1/1

10-3 071321

PN=34
Safety Signs

ROPS in Normal Position (Applicable if


tractor is equipped with ROPS)

CAUTION: Avoid crushing injury or death


during rollover.

Use Foldable ROPS and Seat Belt Properly.


If this machine is equipped with a foldable rollover

PY27270 —UN—22DEC15
protective structure (ROPS), keep the ROPS in the fully
extended and locked position.
USE a seat belt when you operate with a ROPS in the
fully extended position.
• Hold the latch and pull the seat belt across the body.
• Insert the latch into the buckle. Listen for a click. On Right Side of ROPS
• Tug on the seat belt to make sure that the belt is
securely fastened
• Snug the seat belt across the hips.
If this machine is operated with the ROPS folded (e.g: to
enter a low building.),drive with extreme caution. DO NOT
USE a seat belt with the ROPS folded.

PY15860 —UN—23SEP13
Return the ROPS to the raised, fully extended position as
soon as the machine is operated under normal conditions.

VP52664,0000329 -19-01APR16-1/1

10-4 071321

PN=35
Controls and Instruments
Tractor Controls

PY27258 —UN—11DEC15
Controls of Tractor
A—Steering Wheel E—Park Brake Lever H—Hazard Switch K—Horn Switch
B—Hand Throttle F— Brake Pedals I— Turn Signal Switch L— Mobile Charger
C—Light Switch G—foot Throttle J— Clutch Pedal
D—Key Switch
Continued on next page DP97633,0000218 -19-01AUG18-1/4

15-1 071321

PN=36
Controls and Instruments

PY27259 —UN—11DEC15
Controls of Tractor
A—Steering Wheel E—Park Brake Lever H—Hazard Switch K—Horn Switch
B—Hand Throttle F— Brake Pedals I— Turn Signal Switch L— Mobile Charger
C—Light Switch G—Foot Throttle J— Clutch Pedal
D—Key Switch
Continued on next page DP97633,0000218 -19-01AUG18-2/4

15-2 071321

PN=37
15-3
PY22833 —UN—26FEB15 PY4947 —UN—19MAY05 PY22123 —UN—08JAN15
Controls and Instruments

Continued on next page


Rockshaft
PY8003 —UN—31OCT18 PY6081 —UN—31OCT18 PY13077 —UN—16DEC11

DP97633,0000218 -19-01AUG18-3/4

PN=38
071321
Controls and Instruments

A—Gear Shift Lever G—SCV I Control Lever (If


B—Rockshaft Position Control Equipped)
Lever H—Rate of Drop of Knob
C—Rockshaft Draft Control I— EPTO (If Equipped)
Lever J— PTO Lever, Single Clutch
D—PTO Lever K—MFWD Lever (If equipped)
E—Range Shift Lever L— PTO Lever, Single Clutch (If
F— Differential Lock Equipped)

PY15870 —UN—07OCT13
EPTO Lever (If Equipped)

PY31179 —UN—10MAY17
Single Clutch PTO Lever (If Equipped)

PY31176 —UN—25APR17

PY31177 —UN—25APR17
DP97633,0000218 -19-01AUG18-4/4

15-4 071321

PN=39
Controls and Instruments

Instrument Panel
K
G H G

PY22122 —UN—02JAN15
J

C
A B D E

A—Air Restriction Indicator E—Engine Oil Pressure Indicator H—Tachometer


B—High Beam Indicator F— Coolant Temperature Gauge I— Fuel Gauge
C—Hour Meter G—Turn Signal Direction J— Reverse PTO Indicator (If
D—Charging System Indicator Indicators Equipped)
K— Economy PTO (If Equipped)
VP52664,00000D7 -19-02JAN15-1/1

15-5 071321

PN=40
Lights
Light Switch Positions
Tractor light switch has five positions:
A—Turns off all lights.

PY25214 —UN—04AUG15
B—Turns on parking only. Use for parking the vehicle
C—Turns on dim headlights, tail lights, and warning lights.
Turn switch to this position before meeting other vehicles.
D—Turns on bright headlights, tail lights, and warning
lights. For highway driving during night time
E— Turns on Flood Light. Light Switch
F— Switch on flood light . For field use only. Do not use
on roads. Flood light might blind or confuse other drivers

A— Lights Off D— Full-Beam , Tail Lights and


B— Parking Light Position Warning Lights Position
C— Low-Beam , Tail Lights and E— Flood Light Position

PY4107 —UN—21AUG04
Warning Lights Position F— c Switch

VP52664,00001EE -19-21AUG15-1/1

Use Headlights

PY25215 —UN—04AUG15
PY7064 —UN—20NOV18

A— Headlights C— Full-Beam, Tail Lights and D— Low-Beam, Tail Lights and


B— Flood Light Position Warning Lights Position Warning Lights Position

Dual-beam headlights (A) are switched on by either Keep headlights adjusted properly, (see Adjusting
“Low-Beam Headlights” (D), “Full-Beam Headlights” (C) Headlights in Service section).
or “Flood Light ” (B), light switch positions.
Always dim lights before meeting another vehicle.
VP52664,00001EF -19-19AUG15-1/1

20-1 071321

PN=41
Lights

Use High Beam Indicator


High beam indicator (A) should glow when light switch
is turned to “Bright Headlight” position or “Flood Light”
position. Bright headlights, tail lights, flood light, and

PY15867 —UN—03OCT13
warning lights should be on.

A—High Beam Indicator

A
Without PTO Indicator

SV86979,00005D8 -19-03OCT13-1/1

Use Tail Lights


Red tail lights (F) are switched on by either bright headlight
or dim headlight light switch position.
Be sure that tail light lenses are clean before driving on a
road, so other drivers can see it easily.

PY15887 —UN—01JAN14
CAUTION: Prevent collisions between other road
users, slow moving tractors with attachments or
towed equipment, and self-propelled machines
on public roads. Frequently check for traffic
from the rear, especially in turns, and use
hand signals or turn signal lights.
Use headlights, flashing warning lights, and
turn signals day and night. Follow local
regulations for equipment lighting and marking.
Keep lighting and marking visible and in good
working order. Replace or repair lighting

PY4128 —UN—26AUG04
and marking that has been damaged or lost.
An implement safety lighting kit is available
from your John Deere dealer.

F— Tail Lights H—Reflex Reflector


G—Turn Signal Lights I— Flood Light Switch

SV86979,00006E2 -19-01JAN14-1/1

20-2 071321

PN=42
Lights

Use Turn Signals

PY5008 —UN—09JUN06
PY12205 —UN—06JUN11
Move turn signal lever towards left to indicate left-hand D
turn and towards right for right-hand turn. Indicator lights
will flash to signal turn direction in cluster meter
When lever is in right front and rear facing lights on

PY15868 —UN—03OCT13
right-hand side (C) will flash while left-hand lights (B) glow
steady. Left-hand lights (B) flash and right-hand lights (C)
glow steady when lever is in left.
NOTE: Be sure to manually return lever to center
position after turning.

A—Turn Signal Lever C—Right-Hand Lights


B—Left-Hand Lights D—Dash Indicator Lights

DP97633,0000219 -19-30JUL18-1/1

20-3 071321

PN=43
Lights

Use Hazard Lights

PY5009 —UN—09JUN06

PY5010 —UN—09JUN06
All four turn signal lights (two front and two rear) start to
blink when hazard light switch (C) is pushed out. Use
hazard lights to warn incoming vehicles when tractor is
stopped on the road

A—Turn Signal Light on Rear C— Hazard Light Switch


Side
B— Turn Signal Light on Front
Side

PY12226 —UN—22JUN11
DP97633,000021A -19-30JUL18-1/1

20-4 071321

PN=44
Lights

Use Flood Lamp


Flood lamp (G) is switched on by flood light switch (H).

CAUTION: When operating on a road, move


light switch to either “Bright or Dim Head
Lamp” positions Never use flood lamp when

PY5365 —UN—20FEB06
transporting. A clear, bright light at the rear
of the tractor could confuse drivers of other
vehicles as they approach from the rear.

A— Lights Off E— Flood Light Position


B— Parking Light Position F— Horn
C— Low-Beam, Tail Lights and G—Flood Lamp
Warning Lights Position H—Flood Light switch
D— Full-Beam, Tail Lights and
Warning Lights Position

PY4150 —UN—20FEB06
VP52664,00001F2 -19-19AUG15-1/1

20-5 071321

PN=45
Lights

Seven-Terminal Outlet
Outlet (A) is used to connect lights, turn signals and
remote electrical equipment on trailers or implements.
Always use auxiliary light on towed implement when
tractor rear signals and other lights are obscured.

PY4132 —UN—09DEC05
NOTE: Matching plug is available through your
John Deere dealer.

Terminal Function Wire Color


1 Turn LH Green / White
2 Accessory Red
3 Ground Black
4 Turn RH Green
5 Tail Light RH Gray
6 Brake Light Orange

PY22172 —UN—24MAR15
7 Tail Light LH Gray
Latin America and Europe

Terminal Function Wire Color


1 Turn LH Yellow
2 Flood Lamp Blue
3 Ground White Seven-Terminal Outlet
4 Turn RH Green
5 Tail Light RH Brown A—Seven-Terminal Outlet

6 Brake Light Red


7 Tail Light LH Brown
Asia
VP52664,00001F3 -19-05AUG15-1/1

20-6 071321

PN=46
Operator's Platform
Operate Foldable ROPS

LV14503 —UN—29JUL11

LV14502 —UN—29JUL11
ROPS—Folded

APY41940 —UN—25JUN21

ROPS—Vertical Operating Position

A—ROPS Crossbar B—Quick-Lock Pins C—Headed Pins

CAUTION: Make certain all parts are installed Lift the ROPS up again and pin in vertical
correctly if roll-over protective structure (ROPS) is position as soon as the tractor is operated
loosened or removed for any reason. Replace and under normal conditions.
tighten mounting cap screws to proper torque.
Lower ROPS Crossbar (A):
The protection offered by ROPS will be impaired
if ROPS is subjected to structural damage, 1. Remove quick-lock pins (B) and headed pins (C).
as in an overturn incident, or is in any way
altered by welding, bending, drilling, or cutting. 2. Lower crossbar (A) of ROPS onto stops.
A damaged ROPS should be replaced, not 3. Reinstall pins (C and B) into holes in ROPS to lock
reused. Any alteration to the ROPS must down crossbar.
be manufacturer approved.
Raise ROPS Crossbar (A):
Always keep upper part of ROPS pinned in
vertical position (as pictured) when operating 1. Remove headed pins (C) and quick-lock pins (B).
tractor. If tractor is operated with ROPS folded
(for example, to enter a low building) drive with 2. Lift crossbar (A) of ROPS to vertical position.
extreme caution and DO NOT use seat belt.
3. Reinstall pins (C and B) into holes in ROPS to lock
in position.
Continued on next page WKJQUWJ,0000B6C -19-05JUL21-1/2

25-1 071321

PN=47
Operator's Platform

WKJQUWJ,0000B6C -19-05JUL21-2/2

Select Seat Position


Standard Seat

PY4126 —UN—25AUG04
PY1047 —UN—25JUN01
A—Cap Screws

Loosen two cap screws (A) and move seat forward or


backward depending on operator's requirement. After
getting right position, tighten both cap screws.
SA61034,00002AA -19-17MAR08-1/2

Deluxe Seat
Seat can be moved forward or backward depending on
operator's requirement. To move seat on either side, just
lift lever (A) and push the seat.

A—Seat Adjustment Lever

PY1032 —UN—24JUN01
SA61034,00002AA -19-17MAR08-2/2

Adjust Ride Comfort


Adjustment knob is located behind seat.
Weight markings are given on the rear of seat. Turn
adjustment knob (A) for a firm or soft ride. Seat
suspension functions properly relative to operator weight.
PY1033 —UN—24JUN01

A—Weight Adjustment Knob

SA61034,00002AB -19-17MAR08-1/1

25-2 071321

PN=48
Operator's Platform

Operate Park Brake Lever


1. Engage brake pedal lock (A).
2. Press brake pedals (B).
3. Pull park brake lever (C) and move it upwards to the
full length.
4. Finally stop pulling the park brake lever (C) and hence

PY15892 —UN—01JAN14
lock the park brake.
5. Pull park brake lever (C) & move it downwards to the
full length to disengage the park brake.

A—Brake Pedal Lock C—Brake Lever


B—Brake Pedal

SV86979,00006DF -19-01JAN14-1/1

Mobile Charger Pocket


Mobile charger pocket (A) is provided to keeping the
mobile phone safely while connecting to mobile charging
point.

PY27403 —UN—24NOV15
NM61126,0000123 -19-08FEB16-1/1

25-3 071321

PN=49
Break-In Period
Observe Engine Operation Closely
IMPORTANT: The engine is ready for normal
operation. Be extra cautious during the first 100
C

PY15869 —UN—03OCT13
hours, until you become thoroughly familiar
with the sound and feel of your new tractor.
Stay extra attentive and alert.

NOTE: Observe coolant temperature gauge (C) carefully


to avoid over heating of tractor.
A B
Warm up tractor carefully. Check charging (A) and
oil pressure (B) warning indicator lights and coolant
temperature gauge (C). A— Charging Indicator C— Coolant Temperature
B— Oil Pressure Indicator Indicator
Avoid unnecessary engine idling.
Check engine oil, coolant, and transmission/hydraulic fluid
levels frequently. Watch for fluid leaks.
NOTE: If engine oil must be added, use seasonal viscosity
grade oil. Use only lubricants meeting specifications
given in the Fuels, Lubricants and Coolant section.
SV86979,00005DA -19-03OCT13-1/1

Break-In Service
IMPORTANT: Keep wheel hardware tight to avoid Lubricate front wheel bearings.1
tractor damage. Check wheel hardware torque
before operating, twice during first ten hours After the First 50 hours of Operation:
of operation, after fifty hours of operation,
and periodically thereafter. Tighten wheel hardware. (See Wheels, Tires, and Treads
section.)
During the First 10 hours of Operation: Check alternator/fan belt tension and tighten air intake
Perform daily or 10 hours service. (See Service Intervals and cooling system hose clamps.
in Lubrication and Maintenance section.) Perform 50 Hours Service.
Tighten wheel hardware. (See Wheels, Tires, and Treads After the First 100 hours of Operation:
section.)
Replace transmission-hydraulic filter element.
Check engine oil and coolant levels. (See Service—Every
10 hours Section.) Change engine oil and filter.2
1
Only necessary when operating in wet and muddy condition
2
See Engine Break-In Oil in Service section for additional information.
SV86979,00004D6 -19-23JUL13-1/1

35-1 071321

PN=50
Prestarting Checks
Service Daily Before Start-Up
1. Check the engine oil level. Wipe off dipstick and
reinsert it fully. Remove and locate oil level. Safe
operating range is between two marks on dipstick. Do
not operate engine when oil level is below lower mark
on dipstick. Add seasonal viscosity grade oil through

PY15823 —UN—03JUL13
filler hole (A). (See Fuel, Lubricants, and Coolant
section for oil specifications.)
2. Drain water and sediment from fuel filter drain (C).
(See Drain Water and Sediment from Fuel Filter in
Service—10 hours).

CAUTION: DO NOT remove radiator cap or drain


coolant until coolant is cold. Always loosen
radiator cap slowly to relieve any excess pressure.

3. Check coolant level in recovery tank (D). If engine is


COOL and level is below “LOW” mark, add coolant to
recovery tank to bring level to “LOW” mark.
NOTE: Coolant level with a cold engine should be at the
“LOW” mark. A tractor at operating temperature

PY25296 —UN—06NOV15
should have a coolant level at the “FULL” mark.

4. Lubricate the following items at 10 hour intervals if


operating in extremely wet or muddy conditions.
• Front axle pivot pin(s)
• Steering spindles
• Tie rod ends
Use multipurpose grease. For detailed information
see Lubrication and Maintenance section.

A—Engine Oil Filler Cap D—Recovery Tank


B—Engine Oil Dipstick E—Radiator Cap

PY5370 —UN—09DEC05
C—Fuel Filter Drain

NM61126,0000125 -19-08FEB16-1/1

40-1 071321

PN=51
Prestarting Checks

Hood Lock Mechanism


Make sure that hood is locked and removed the key (A)
and keeps the key safely with operator only.

PY27245 —UN—10DEC15
NM61126,0000126 -19-10DEC15-1/1

40-2 071321

PN=52
Operating the Engine
Before Starting the Engine

TS220 —UN—15APR13

PY4953 —UN—27MAY05
Dual Clutch Tractor

CAUTION: Prevent asphyxiation. Engine


exhaust fumes can cause sickness or death
to you or someone else.
If you must operate engine in a building, be
positive there is adequate ventilation. Either

PY13078 —UN—16DEC11
use an exhaust pipe extension to remove the
exhaust fumes or open doors and windows to
bring enough outside air into the area.

1. Check fuel gauge to be sure tractor has plenty of fuel.


2. Place range shift lever (A) in neutral (N) position.
Starter will not operate if range shift lever is not in this
position.
A— Range Shift Lever C— Rockshaft Position Control
3. Place rockshaft control levers (C and D) in lowered B— PTO Lever Lever
position. D— Rockshaft Draft Control
Lever
4. Check indicator lights. Indicators should illuminate
when key switch is turned to the “ON” position.
If any indicator does not function properly, see your
John Deere dealer.
DP79986,0000081 -19-19DEC11-1/1

45-1 071321

PN=53
Operating the Engine

Start the Engine


1. Push hand throttle (A) forward off idle position
(approximately 1/3 of full throttle). Engine may not
start with throttle pulled completely down.
2. Make sure fuel shut-off knob (C) is pushed in.

TS177 —UN—11JAN89
CAUTION: Avoid possible injury or death
from a machine runaway.
Do not start engine by shorting across starter
terminals. Machine will start in gear and move
if normal circuitry is bypassed.
Machinery Runaway
Start engine only from operator's seat with
transmission in NEUTRAL.
NEVER start engine while standing on ground.

IMPORTANT: DO NOT run a cold engine at full throttle.

3. Depress clutch pedal and turn key switch fully


clockwise (B) to engage starter. Release key when
engine starts. If key is released before engine starts,
wait until starter and engine stop turning before trying

PY4497 —UN—13JAN05
again.
IMPORTANT: DO NOT operate starter more than
20 seconds at a time. If engine does not
start, wait at least two minutes for the starter
motor to cool before trying again. If engine
does not start in four attempts, refer to
“Troubleshooting” section. Hand Throttle and Key Switch

A—Hand Throttle C—Fuel Shut Off Knob


B—Key Switch On

PY6082 —UN—06AUG06
Fuel Shut-off Knob

VP27597,0000012 -19-08FEB16-1/1

45-2 071321

PN=54
Operating the Engine

Check Instruments After Starting


IMPORTANT: If charging system (A) or oil pressure
(B) indicators fail to go out, or temperature
C

PY15869 —UN—03OCT13
gauge (C) indicates hot, stop engine and
determine the cause.

A— Charging System Indicator C— Coolant Temperature


B— Oil Pressure Indicator Gauge

A B

SV86979,00005DC -19-03OCT13-1/1

Oil Pressure Indicator


Oil pressure indicator (A) will light if engine oil pressure is
low. Indicator should light when key is turned to engage

PY15871 —UN—03OCT13
starter and go out when engine starts.
IMPORTANT: NEVER operate engine without sufficient
oil pressure. If indicator stays lit for longer
than five seconds under normal operating
conditions, stop engine and check for cause.
A
If low oil level is not the problem, see your John Deere
dealer.
A— Oil Pressure Indicator

SV86979,00005DD -19-03OCT13-1/1

Charge System Indicator


Charging system indicator (A) will light when alternator
output is low. Indicator should light when key is turned to
engage starter, and go out when engine starts.

PY15872 —UN—03OCT13
If indicator stays lit for longer than five seconds in normal
operation, stop engine and check for cause. If loose or
broken fan belt is not the cause, see your John Deere
dealer.

A— Charging System Indicator


A

SV86979,00005DE -19-03OCT13-1/1

Air Restriction Sensor


Air restriction indicator (A) will light if air cleaner becomes
plugged. Service air cleaner as soon as possible.
PY15873 —UN—03OCT13

Indicator should light momentarily when key is turned


slowly to starter engagement position.

A— Air Restriction Sensor

SV86979,00005DF -19-03OCT13-1/1

45-3 071321

PN=55
Operating the Engine

Coolant Temperature Gauge


The needle on the temperature gauge (A) rises as engine
warms up. If needle reaches red zone, stop engine and

PY15874 —UN—03OCT13
determine the cause.
A
CAUTION: DO NOT remove radiator cap or drain
coolant until coolant is cold. Always loosen
radiator cap slowly to relieve any excess pressure.

Check coolant level in radiator when engine cools.


Also check grille, radiator, and radiator side screens
for plugging. Check fan belt tension. If problem is not A— Coolant Temperature
corrected, see your John Deere dealer. Gauge

SV86979,00005E0 -19-03OCT13-1/1

Watch Fuel Level


Stop to refuel before gauge (A) reaches empty mark.

PY15875 —UN—03OCT13
IMPORTANT: Use diesel fuel only. See Fuel and
Lubricants section for fuel specifications.
A
Should tractor runout of fuel and not start in several
tries, air must be bled from fuel system. (See Bleed Fuel
System in Service section).

A— Fuel Gauge

SV86979,00005E1 -19-03OCT13-1/1

Change Engine Speeds

PY9940 —UN—24AUG10
PY4111 —UN—21AUG04

Foot Throttle
Hand Throttle

A— Hand Throttle B— Foot Throttle

To increase speed, push hand throttle (A) forward. To temporarily increase engine speed above hand throttle
setting, depress foot throttle (B).
DP79986,0000088 -19-24AUG10-1/1

45-4 071321

PN=56
Operating the Engine

Warm Up the Engine


Do not place tractor under full load until it is properly
warmed up.

PY15876 —UN—03OCT13
1. Idle engine at about 1500 rpm for several minutes.
2. Run engine at about 1900 rpm and under light load
until engine reaches normal operation condition.

SV86979,00005E2 -19-03OCT13-1/1

Restart Stalled Engine


Should the engine stall when operating under load,
depress clutch pedal (A) and restart it immediately to
prevent abnormal heat build up and continue with normal
operation or operate at slow idle for one or two minutes
before stopping.

A—Clutch Pedal

PY27243 —UN—10DEC15
NM61126,0000129 -19-10DEC15-1/1

Avoid Idling the Engine

PY15876 —UN—03OCT13
Allowing engine to idle at low rpm uses fuel inefficiently,
and can cause a buildup of carbon in the engine.
If tractor must be left with the engine running more than
three or four minutes, minimum engine speed should be
1200 rpm.

SV86979,00005E3 -19-03OCT13-1/1

Observe Engine Work and Idle Speeds PY15876 —UN—03OCT13

Slow idle speed should be 850 ± 50 rpm At light or no


load, full throttle speed will increase to 2300 rpm.
Normal working speed is 1400—2100 rpm rated speed.
Within these limits engine can be put under full load.
For correct PTO speed, run engine at 2200 rpm for
standard 540 rpm operation (load requiring full engine
power).
SV86979,00005E4 -19-17OCT13-1/1

45-5 071321

PN=57
Operating the Engine

Working With Speed/Hour Meter A


B
Tachometer (A) shows engine rpm, read in hundreds.
For 540 rpm PTO speed, increase engine speed until
tachometer needle is aligned with 2050 rpm for standard
and for economy PTO operation increase engine speed

PY15877 —UN—03OCT13
until tachometer needle is aligned with 1600 rpm mark (B).
Hour meter (C) shows hours of operation in full hours and
tenths.

A— Tachometer C— Hour Meter


B— 2400 rpm Mark (540) C

SV86979,00005E5 -19-07OCT13-1/1

Stop the Engine


1. Pull hand throttle (A) down to slow idle position. Allow
engine to idle for one to two minutes.
2. Put range shift lever in neutral (N) and set brakes.
IMPORTANT: Cooling of certain engine parts is
provided by engine oil. Stopping a hot engine
suddenly could cause damage to these parts
by overheating or lack of lubrication.

PY4501 —UN—13JAN05
3. Turn key switch to the OFF position (B).
4. Pull manual fuel shut-off knob (C) (at lower left side
of control support) rearward and hold until engine has
completely stopped.

CAUTION: Remove key from key switch to prevent


operation by untrained personnel.

A—Hand Throttle C—Fuel Shut Off Knob


B—Key Switch OFF Position

PY6082 —UN—06AUG06

VP27597,0000013 -19-08FEB16-1/1

45-6 071321

PN=58
Operating the Engine

Use Booster Battery


IMPORTANT: Be sure polarity is correct before
making connections. Reversed polarity
may damage electrical system or possibly
cause battery to explode.

IMPORTANT: When using two or more booster


batteries, batteries MUST be connected

TS204 —UN—15APR13
in PARALLEL. DO NOT connect batteries
in SERIES.

CAUTION:
Battery gas is explosive:
• DO NOT smoke while charging battery.
• Keep all flames and sparks away.
• DO NOT charge frozen battery.
• DO NOT connect booster battery negative (—)
cable to starting vehicle negative (—) terminal.

1. Access battery. (See procedure in Service section.)

PY5821 —UN—12JUL06
2. Connect positive (+) booster cable to booster battery
positive (+) post (D).
3. Connect the other end of positive (+) booster cable to
tractor battery positive (+) post (A).
4. Connect negative (—) booster cable to booster battery
negative (—) post (C).
A—Tractor Battery Positive (+) C—Booster Battery Negative
5. Connect the other end of negative (—) booster cable Post (—) Post
to engine ground (B), away from battery and starter. B—Engine Ground D—Booster Battery Positive (+)
Post

DP79986,00000CE -19-25AUG10-1/1

45-7 071321

PN=59
Driving the Tractor
Reduce Fuel Consumption
Service Correctly
Replace air cleaner element and fuel, engine oil, and
transmission/hydraulic filter elements at specified service

LX007829 —UN—15AUG94
intervals (see “Service” section).
Use only John Deere filters!

SV86979,00005D4 -19-26SEP13-1/7

Use recommended oils and lubricants only (see “Fuel,


Lubricants, Hydraulic Oil, and Coolant” section).

PY15862 —UN—24SEP13
SV86979,00005D4 -19-26SEP13-2/7

Have the fuel system checked regularly by your John


Deere dealer.

LX000347 —UN—15AUG94

Continued on next page SV86979,00005D4 -19-26SEP13-3/7

50-1 071321

PN=60
Driving the Tractor

Have function of rockshaft control checked regularly by


your John Deere dealer.

LX1026059 —UN—18MAY01
SV86979,00005D4 -19-26SEP13-4/7

Drive with Correct Tire Pressures


Adapt tire pressures to type of work and ground conditions
(consult your John Deere dealer or local tire agent).

L103645 —UN—15AUG94
SV86979,00005D4 -19-26SEP13-5/7

Choose Correct Ballast


Choose ballast to obtain 10 to 15% wheel slip. Use no
more ballast than necessary, reduce ballast for light work.

A—Too much ballast C—Correct ballast


B—Too little ballast
LX009185 —UN—01SEP94

LX009186 —UN—01SEP94

Continued on next page SV86979,00005D4 -19-26SEP13-6/7

50-2 071321

PN=61
Driving the Tractor

Select Correct Gear


Always drive in the highest possible gear with reduced
engine speed.
Choose a gear so that engine speed (A) with engine
not under load drops 150—250 rpm when the tractor is
operating and the engine is under load (B).

PY15865 —UN—26SEP13
SV86979,00005D4 -19-26SEP13-7/7

Operator Training Required

• Study the Operation section of this manual before • Learn use of all controls.
operating tractor. • Operator experience is required to learn moving,
• Operate tractor in an open, unobstructed area under stopping, turning and other operating characteristics
direction of an experienced operator. of tractor.
NR25796,000034A -19-04AUG06-1/1

Driving on Public Roads

CAUTION: When transporting on a public road or


highway, use accessory lights and devices for
adequate warning to operators of other vehicles.
Check local governmental regulations. Various

PY9945 —UN—24AUG10
safety devices are available from your John Deere
dealer. Keep safety items in good condition.
Replace missing or damaged items.

Observe the following precautions when operating the


tractor on the road:
Brake pedals
CAUTION: Before operating tractor on a road,
lock brake pedals together. Use brake lightly
and cautiously at transport speeds. A— Brake Locking bar

1. Couple brake pedals together using brake locking bar


(A). Avoid hard applications of brakes. Reduce speed or braking on inclines. Be sure that wheel tread is
if towed load weighs more than the tractor and is not adjusted wide to provide maximum stability.
equipped with brakes.
IMPORTANT: To prevent unnecessary wear, never ride
Use additional caution when transporting towed loads the brakes by resting a foot on the pedals.
under adverse surface conditions and when turning
Continued on next page DP97633,000021B -19-30JUL18-1/2

50-3 071321

PN=62
Driving the Tractor

2. Check local laws and regulations for lighting


requirements. Be sure Slow Moving Vehicle (SMV)
emblem (G), turn signal lights (B) and tail lights (F) are
clean and visible. If towed or rear-mounted equipment
obstructs these safety devices, install SMV emblem
and warning lights on equipment. (See your John

PY15893 —UN—01JAN14
Deere dealer)
3. Turn light switch to position (D).
Always turn light switch to dim lights position (A) when
meeting another vehicle. Never use flood lights or any
other lights which could blind or confuse other drivers.
4. Use turn signal when turning. Be sure to return lever
(E) to center position after turning.
5. Drive slowly enough to maintain safe control at all
times. Before descending a hill, shift to a gear low
enough to control speed without using brakes. Slow
down for rough ground, and sharp turns, especially
when transporting heavy, rear mounted equipment.

PY15843 —UN—23JUL13
A— Low-Beam, Tail Lights and E— Turn Signal Lever
Warning Lights Position F— Tail Light
B— Turn Signal Light G— SMV Emblem
C— Reflex Reflector
D— Full-Beam, Tail Lights and
Warning Lights Position

PY25221 —UN—19AUG15
DP97633,000021B -19-30JUL18-2/2

50-4 071321

PN=63
Driving the Tractor

Operate Transmission

PY5807 —UN—13FEB19

PY5824 —UN—13FEB19
Range Shift Lever Speed Shift Lever

A—Range Shift Lever B—Speed Shift Lever

Range shift lever (A) provides two forward speed ranges,


Range shift must be in neutral for the engine to be started.
(A and B) and one reverse range (R).
Speed shift lever (B) provides four travel speeds.
Using range and speed shift levers in different
combinations, eight forward speeds and four reverse
speeds can be obtained.
SA61034,00002DE -19-18MAR08-1/1

Shifting Transmission
IMPORTANT: To prevent transmission damage, do
not use speed shift on-the-go. To prevent
unnecessary wear, never “ride” the clutch
by resting a foot on the pedal.

Depress clutch pedal (A) and stop tractor before shifting


either range shift lever or speed shift lever. Release clutch
pedal gradually to take up load smoothly.

PY27243 —UN—10DEC15
A—Clutch Pedal

NM61126,000012B -19-10DEC15-1/1

50-5 071321

PN=64
Driving the Tractor

Select a Gear
IMPORTANT: To extend drive train life and avoid
excessive soil compaction and rolling

PY15876 —UN—03OCT13
resistance when using ballast, operate one
gear lower than normal.

The tractor may be operated in any gear with engine


speeds between 1400 rpm and 2100 rated engine rpm
Within these limits the engine can be put under full load.
For light load operation, use a higher gear and lower
engine speed. This saves fuel and reduces wear.
Ground Speed Estimates for different tire sizes are
located in Specifications section.
SV86979,00005E6 -19-03OCT13-1/1

Use Brakes
CAUTION: Before operating tractor on a road,
lock pedals together. Use brake lightly and
cautiously at transport speeds.

PY9945 —UN—24AUG10
Use individual brakes to assist in making sharp turns.
Disengage brake pedal locking bar (A) and depress only
one brake pedal.
To stop tractor, depress both brake pedals.
IMPORTANT: To prevent unnecessary wear, never ride
the brakes by resting a foot on the pedals. Brake Pedals

Reduce speed if towed load is not equipped with brakes


and weighs more than the tractor. Avoid hard braking A— Brake Pedal Locking Bar
applications. Consult implement operators manual for
recommended transport speeds.
Use additional caution when transporting towed loads
under adverse conditions, when turning or stopping on
inclines.
DP79986,000008F -19-23AUG10-1/1

50-6 071321

PN=65
Driving the Tractor

Use Differential Lock


CAUTION: DO NOT operate tractor at high speed
or attempt to turn with differential lock engaged.

IMPORTANT: To prevent damage to drive train, DO

PY6081 —UN—31OCT18
NOT engage differential lock when one wheel is
spinning and the other is completely stopped.

When one wheel starts to lose traction, engage differential


lock by depressing pedal (F) down.
Unequal traction will keep the lock engaged. When
traction equalizes, lock will disengage itself by spring Differential Lock Pedal
action. If lock does not disengage, depress one brake
pedal and then the other.
F— Differential Lock Pedal
If tyres repeatedly slip, then get traction, then slip again,
hold pedal in the engaged position.
DP79986,0000090 -19-19DEC11-1/1

Operating Mechanical Front Wheel Drive (If


Equipped)
Use mechanical front wheel drive (MFWD) as required
for better traction

CAUTION: Mechanical front wheel drive greatly


increase traction. When this option is used
extra caution is needed on slopes. Compared to
two-wheel drive a mechanical front wheel drive
traction maintains traction on steeper roads,
increasing the possibilities of tip over
When driving on icy, wet, graveled surfaces,
reduce speed and be sure that tractor is properly
ballasted to avoid skidding and loss of steering

PY12249 —UN—28JUL11
controls, engage mechanical front wheel drive.

IMPORTANT: To extend tire life engage mechanical


front wheel drive when needed. Do not engage
when driving on hard surface
DO NOT install tire chains on tractor front
wheels, chains will strike and damage tractor.
To prevent transmission damage, DO NOT A—MFWD lever
engage or disengage mechanical front
wheel drive on the go.

Depress clutch pedal & stop tractor before engaging or


disengaging MFWD. Push shift lever forward to engage &
pull lever back to disengage MFWD
AK50421,0000127 -19-31DEC13-1/1

50-7 071321

PN=66
Driving the Tractor

Stopping Tractor

CAUTION: Always place the range shift lever in


neutral (N) and set brakes before dismounting.
Leaving transmission in gear with engine off
MAY NOT prevent tractor from moving.

PY6080 —UN—06AUG06
1. Stop the tractor and place range shift lever (A) in
neutral.
2. Apply brakes.
3. Lower all equipment to ground using rockshaft position
control lever (D) and rockshaft draft control lever (C),
4. Pull hand throttle (B) down to slow idle position. Allow
engine to idle for one to two minutes.
IMPORTANT: Cooling of certain engine parts is
provided by engine oil. Stopping a hot engine
suddenly could cause damage to these parts
by overheating or lack of lubrication.

CAUTION: Remove the key from key switch to

PY4911 —UN—14APR05
prevent operation by untrained personnel.

5. Turn key switch to OFF position.


6. Pull manual fuel shut-off knob (E) (at lower left side
of control support) rearward and hold until engine has
completely stopped.

A— Range Shift Lever D— Rockshaft Draft Control


B— Hand Throttle Lever Lever
C— Rockshaft Position Control E— Fuel Shut Off Knob
Lever

PY13078 —UN—16DEC11
PY6086 —UN—06AUG06

VP27597,0000014 -19-08FEB16-1/1

50-8 071321

PN=67
Rockshaft and 3-Point Hitch
Match Tractor Power to Implement implement can damage the tractor. (Refer
to your implement operator's manual for
IMPORTANT: Tractor power must match to the minimum and maximum power requirements
size of certain implements. Excessive power before attaching an implement.)
can damage an implement, and too large an
PY80265,05GO845 -19-10SEP05-1/1

3-Point Hitch Components

APY41947 —UN—05JUL21
A—Lift Arms C—Sway Chains E— Draft Links
B—Lift Links D—Center Link
WKJQUWJ,0000B64 -19-02JUL21-1/1

55-1 071321

PN=68
Rockshaft and 3-Point Hitch

Rockshaft Control Levers


The rockshaft position is controlled by two levers, the
rockshaft position control lever (A) and the rockshaft draft
control lever (B)
The rockshaft position control lever (A) raises the hitch

PY9946 —UN—24AUG10
when pulled rearward, and lowers the hitch when moved
forward. (See Use Rockshaft Position Control in this
section for more information.)
The rockshaft draft control lever (B) controls hitch position
relative to draft loads. (See Use Draft Control in this
section for more information.)

A— Rockshaft Position Control B— Rockshaft Draft Control


Lever Lever

DP79986,0000093 -19-23AUG10-1/1

Set Position Control Lever Stop


NOTE: Position control lever stop is used when operating
depth or height needs to be repeated.

1. Operate implement for a few minutes to determine


proper depth or height.

PY9947 —UN—24AUG10
2. Loosen lever stop (A), and slide against position control
lever. Lock stop in position by turning in a clockwise
direction. Rockshaft will now lower to same position
each time control lever is pushed forward to the stop.

A— Lever Stop

DP79986,0000094 -19-23AUG10-1/1

55-2 071321

PN=69
Rockshaft and 3-Point Hitch

Use Rockshaft Position Control


CAUTION: To prevent unexpected movement of
rockshaft, place draft control lever (B) in a full
forward position before attaching an implement.

PY9946 —UN—24AUG10
Put draft control lever (B) forward when you DO NOT
want rockshaft to adjust automatically to draft load, such
as attaching implement to tractor.
Use position control lever (A) to control hitch movement
and depth. Position control should be used for the
following applications:
TRANSPORT of implements and end of field turn-around.
Position control lever should be moved fully rearward (C)
for transport for both load and non-load sensing usage.
CONSTANT DEPTH of implements on level terrain and for
non- ground engaging implements such as spreaders or
sprayers. Place position control lever at depth desired (D).
FLOAT operation for implements with skids or depth
gauge wheels designed to carry full implement weight.
Push both levers all the way forward (E) so implement can
follow the ground contour.
NOTE: Lift links can be adjusted for lateral float. (See
Adjust Lateral Float in this section.)

A— Rockshaft Position Control D— Position Control Lever in


Lever Desired Depth Position
B— Rockshaft Draft Control E— Position Control Lever and
Lever Draft Control Lever in Float
C— Position Control Lever in Position
Rearward Position

M47168 —UN—31JAN92
DP79986,0000095 -19-23AUG10-1/1

55-3 071321

PN=70
Rockshaft and 3-Point Hitch

Use Draft Control


The rockshaft may be equipped with variable draft control
system.
Use draft load sensing when:
• Operating with a fully mounted implement in hill and

PY9948 —UN—25AUG10
swale terrain. The implement will raise and lower to
follow the ground contours while maintaining a nearly
constant depth.
• Operating in varying soil conditions. The implement is
raised slightly to get through tough spots so you do not
have to shift to a lower gear.
Draft control lever (B) controls amount of load required
before hitch responds. With lever placed fully forward to
the position marked “off” (C), there is no draft sensing.
Placing the lever toward the rear position reduces the
amount of draft load required to override the position
setting set by the position control lever (A) and raise the
rockshaft.
Draft sensitivity ranges can be changed by repositioning
the center link. (See Position Center Link in this section
for additional information.)
For draft load sensing operation:
• Initially place position control lever (A) in its fully
rearward position and the draft control lever (B) in the
fully forward (least draft) position.
• With tractor moving, push position control lever (A)
forward to set implement operating depth. Set position
control lever stop (D) so control lever can be brought
back to the same position. The operating depth set-up
will prevent the rockshaft from lowering all the way
when the tractor begins to slip. Then pull draft sensing

M47169 —19—29JAN92
lever (B) rearward until desired draft sensing sensitivity
is obtained.
• The position control lever (A) can also be raised slightly
to override the draft control setting to help get through
slippery spots without getting stuck.
• The position control lever (A) can be moved fully
rearward to raise the hitch at the end of the field.

A— Rockshaft Position Control C— Draft Sensing OFF Position


Lever D— Position Control Lever
B— Rockshaft Draft Control Stop
Lever

DP79986,0000096 -19-23AUG10-1/1

55-4 071321

PN=71
Rockshaft and 3-Point Hitch

Adjust Rockshaft Rate-of-Drop/ Implement Lock

CAUTION: Excessive rate-of-drop may cause


damage or injury. Fully lowering implement
should require at least two seconds.

Rockshaft drops faster when a heavy implement is


attached. Adjust rate-of-drop knob so that it is slow
enough to be safe and prevent implement damage.

PY7079 —UN—20NOV18
JD Rockshaft - Turn rockshaft rate-of-drop knob (A),
located under right hand rear of the seat, clockwise to
slow rockshaft drop.
Turn knob counterclockwise to increase rate-of-drop.
Refer decal (B) for increase or decrease the rate-of-drop.
Rate-of-drop knob is also called implement lock. When JD Rockshaft
knob is fully screw in, implement will not lower down even
if position control lever is fully down. Use implement lock
while transporting implement.

A—Rockshaft Rate-of-Drop B—Decal


Knob cum Implement Lock

PY27402 —UN—23NOV15
NM61126,000012E -19-10DEC15-1/1

55-5 071321

PN=72
Rockshaft and 3-Point Hitch

Attach Tipping Trailer


Hydraulic power can be extended to tipping trailer through
auxiliary port (B). When preselector (A) is fully screwed-in,
hydraulic oil will move to tipping trailer. Use draft control
lever for lowering or raising of trailer.

PY5281 —UN—24NOV05
CAUTION: Carefully check the tipping trailer pipe
connection for any leakage. For checking that
leakage do not use bare hands as oil may be hot
and coming out of the system with full force.
Use hand gloves and follow safety rules.

NOTE: When tipping trailer is not attached to tractor, JD Rockshaft


fully screw-out preselector knob, otherwise
rockshaft will not function.

A— Preselector Knob B— Auxiliary Port

PY5282 —UN—24NOV05
JD Rockshaft
DP97633,000021C -19-30JUL18-1/1

Prepare Implement
Category II implements should have the top hole of the
implement mast located 610 mm (24 in.) above the lower
pins. Drill another hole in top mast or extend top mast
if necessary.

PY2274 —UN—07JUN06
Category Mast Width Pin Size
Height Between
Lower Pins
Lower Upper
II 610 mm 824 mm 28.7 mm 25.5 mm
(24 in.) (32-7/16 in.) (1-1/8 in.) (1 in.)

SA61034,00002E6 -19-18MAR08-1/1

Preparation for Wet Land Cultivation 4. Check the tractor for leakages. Take corrective action
to avoid water entry from these leakage points.
1. Before and after wet land operations grease all 5. Ensure that oil filler plugs on Engine and Transmission
assemblies. are tightly closed.
2. Grease assemblies everyday or every 10 hours of 6. Ensure that the engine oil dipstick is fully tightened.
working.
3. Check all joints seal.
SS27023,00001A0 -19-23AUG11-1/1

55-6 071321

PN=73
Rockshaft and 3-Point Hitch

Position Center Link


The draft sensing rockshaft center link attaching bracket
has holes which allow three different positions for
attaching the center link. The position effects the draft
sensing sensitivity.
Move the center link attachment to holes (B) if:

PY12211 —UN—09JUN11
• Excessive hitch activity or hunting occurs in draft control
operation.
• The rear of the implement raises too much when lifted.
The implement weight which can be lifted is reduced
slightly with the center link attachment in the lower holes.
• The draft control lever range is too small.
Move the center link attachment to holes (C) if:
• The hitch seems unresponsive in draft control operation
and allows the engine speed to drop too far before
raising the rockshaft.
• The rear of the implement droops and drags the ground
as the implement is lifted.
Upper hole (A) eliminates nearly all draft sensing.
NOTE: Implements with Category II mast height 610
mm (24 in.) will use the upper two holes.

PY12223 —UN—22JUN11
A— Upper Hole C— Lower Hole
B— Middle Hole

SV86979,00004E1 -19-24JUL13-1/1

55-7 071321

PN=74
Rockshaft and 3-Point Hitch

Attach Implements to 3-Point Hitch


1. Be sure drawbar will not interfere. If necessary, move
drawbar ahead, or remove it. Check for any other
potential interference.

PY5374 —UN—09DEC05
CAUTION: Prevent unexpected movement of
rockshaft by placing draft sensing lever in
the forward or OFF position before attaching
implement to hitch.

2. Back tractor up to implement (A) so hitch points (B)


align. Place transmission in neutral (N), stop the
engine and engage brakes BEFORE leaving the
tractor seat.
3. Slip draft links over implement hitch pins (B), and
retain with quick-lock pins.
NOTE: Locking pins can be stored on draft links (through
holes in sway chain ears) when not in use.

4. To remove center-link from transport hook, lift center


link locking clip (C), and rotate tab (D) to rear of center
link clip.

PY12224 —UN—22JUN11
5. Attach center link to implement top mast.
6. Adjust center link and lift links as necessary. (See
Level the Hitch in this section.)

CAUTION: To avoid bodily injury or machine


damage whenever an implement, implement quick
coupler, or other attachment is connected to the
tractor 3-Point Hitch, check full range of operation
for interference, binding or PTO separation.

7. Using rockshaft position control lever (E), lower and


raise implement slowly and check for any point of

PY9949 —UN—24AUG10
interference.

A— Implement D— Tab
B— Implement Hitch Pins E— Rockshaft Position Control
C— Center Link Locking Clip Lever
F— Rockshaft Draft Control
Lever

AK50421,0000104 -19-22JUN11-1/1

55-8 071321

PN=75
Rockshaft and 3-Point Hitch

Adjust Hitch Side Sway


NOTE: Check implement operator's manual for instruction
on whether to allow side sway.

NOTE: Use spring or rubber strap to keep draft


links out of rear tyres when draft links are
not attached to implement.

Implement side sway should be adjusted when the


rockshaft is raised for transport by loosening the jam nut
on the threaded link (A) and turning the center rod to

PY4970 —UN—10DEC05
increase or decrease the length of chain. Tighten jam nut
again when adjusted.

A— Threaded Link

DP79986,000009B -19-23AUG10-1/1

55-9 071321

PN=76
Rockshaft and 3-Point Hitch

Level the Hitch


1. Lower implement to take weight off hitch.
IMPORTANT: DO NOT attempt to overextend center
link beyond limits of locking clip or lift links past
the stops. Link body threads could be damaged.

NOTE: Maximum adjustment range of the center link can


only be obtained if the ends are positioned equally
within the body when attached to an implement.

2. Adjust center link to level implement front-to-rear.


Unlatch locking clip (A). Rotate center link body

PY12225 —UN—22JUN11
clockwise to lengthen center link or counterclockwise
to shorten it. Be sure to latch the locking clip.
3. Adjust right-hand link to level implement side-to-side.
Lift locking handle (C) and turn 1/4 turn to engage slot
(D) onto roll-pin in the center portion of the lift link.
Turn crank handle (C) clockwise to raise draft link. JD Rockshaft
Turn crank handle (C) counterclockwise to lower draft
link.
After adjustment, lift handle (C) and turn to engage
slot (D) onto the lower body to prevent change of
adjustment during operation.

PY5914 —UN—20NOV18
4. The left-hand lift link is also adjustable in length to
accommodate different tyre sizes.
To change the left-hand lift link length, remove the
upper lift link pin and rotate the upper end assembly
clockwise to shorten or counterclockwise to lengthen,
and then reinstall the upper pin and locking pin.
Adjust left and right lift links to accommodate various
tyre sizes. Set the lift links to have fully-lowered draft A—Locking Clip C—Locking Handle
link balls approximately seven inches off the ground B—Center Link Body D—Slot
for greatest range of usable hitch motion.
VP27597,0000015 -19-08FEB16-1/1

Adjust Lateral Float


To allow the draft link to raise slightly as implement follows
ground contour, place head of float pin and the rectangular
washer on the inside end of the pin in a vertical position (A).
To hold implement rigid, place head of float pin and the
rectangular washer in the horizontal position (B).
PY5381 —UN—10DEC05

PY5380 —UN—10DEC05

Use lift link pins in the float position for hitch-mounted


implements such as a cultivator or mower, which have
ground gauging skids or wheels which may cause the
implement to twist relative to the tractor.
Use the rigid position for implements such as plows and
ground engaging implements that should not twist relative
to the tractor.
A—Pin in Vertical Position B—Pin in Horizontal Position

SA61034,00002E9 -19-18MAR08-1/1

55-10 071321

PN=77
Rockshaft and 3-Point Hitch

Adjust Rockshaft Control Lever Friction- JD


Rockshaft
REASON:
To keep the rockshaft position and draft-sensing levers
in their set positions.
PROCEDURE:
NOTE: SCV levers, right-hand fender and console
removed for clarity.

PY5210 —UN—17SEP05
1. Loosen jam nuts (A).
2. Turn adjusting cap screws (B) clockwise to increase
friction, counterclockwise to decrease friction. Turn
cap screws equal number of times.
3. Retighten jam nuts (A) when adjustment is complete.
A—Jam Nut B—Cap Screw

AK50421,00000FE -19-19DEC11-1/1

Warm Hydraulic System Oil


Hydraulic system may be slow to function when tractor is
started in cold weather. This is because cold oil will not
flow as easily through the hydraulic system filter (A).
Steering may be slow until system warms up.

PY6097 —UN—22NOV18
Hydraulic system will function normally when oil warms up.

A— Hydraulic Oil Filter

Right Side of Transmission


SV86979,00005E7 -19-03OCT13-1/2

IMPORTANT: To prevent damaging hydraulic pump


or relief valve, DO NOT exceed two—three

PY15876 —UN—03OCT13
minutes warm-up time with steering wheel held
in full left or full right turn position.

1. Depress clutch pedal, start engine and idle at about


1000 rpm.
2. Turn and hold steering wheel in full left or right turn.

SV86979,00005E7 -19-03OCT13-2/2

55-11 071321

PN=78
Remote Hydraulic Cylinders (If Equipped)
Use Correct Hose Tips tip as recommended by ISO1 and SAE2. Adapters are
available to allow connecting the older John Deere hose
If your tractor is equipped with a selective control valve tips to the ISO couplers on your tractor.
(SCV), the couplers receptacles accept a standard hose
1
International Standards Organization
2
Society of Automotive Engineers
PG57337,0000199 -19-16DEC11-1/1

Control Lever and Coupler Identification


A—SCV I Lever B—SCV I Receptacles

PY13082 —UN—19DEC11
PY13079 —UN—19DEC11
PG57337,000019A -19-19DEC11-1/1

Rear SCV Dust Plug Identification


A—Red Dust Plug B—Blue Dust Plug

PY13080 —UN—19DEC11

PG57337,000019C -19-19DEC11-1/1

60-1 071321

PN=79
Remote Hydraulic Cylinders (If Equipped)

Connect Cylinder Hoses

CAUTION: Escaping fluid under pressure can


penetrate the skin causing serious injury.
Avoid the hazard by relieving pressure before
disconnecting hydraulic or other lines. Tighten

X9811 —UN—23AUG88
all connections before applying pressure. Search
for leaks with a piece of cardboard. Protect hands
and body from high pressure fluids.
If an accident occurs, see a doctor immediately.
Any fluid injected into the skin must be surgically
removed within a few hours or gangrene
may result. Doctors unfamiliar with this type
of injury should reference a knowledgeable
medical source. Such information is available 1. Remove dust caps from hose end.
from Deere & Company Medical Department
in Moline, Illinois, U.S.A.
PG57337,000019D -19-19DEC11-1/3

2. Pull dust plug (A) from couplers.


3. Make sure hose end and coupler receptacles are clean.
4. Check hoses to see which is used for extending
cylinder. This hose must be connected to a coupler
receptacle (B) in order for cylinder to extend when

PY13081 —UN—19DEC11
SCV levers are moved rearward or inward.

A—Coupler I Receptacle B—Dust Plug (Red)

PG57337,000019D -19-19DEC11-2/3

CAUTION: Hydraulic hoses can fail due to


physical damage, kinks, age and exposure.
Check hoses regularly. Replace damaged
hoses. See your John Deere dealer.

5. To connect each hose, push hose tip firmly into coupler


PY6441 —UN—22NOV18
receptacle. Pull lightly on hose to make sure positive
connection was made.

Connect SCV

PG57337,000019D -19-19DEC11-3/3

60-2 071321

PN=80
Remote Hydraulic Cylinders (If Equipped)

Connect Single-Acting Cylinder


In order for lever (B) to work properly, a single-acting
cylinder should be connected only to SCV I Outlet in the
extend position (top coupler) (A).
IMPORTANT: Volume of oil required to extend

PY6442 —UN—29JUN07
cylinder must not lower transmission-hydraulic
oil level below lower sight glass. Check oil
level with cylinder fully extended. (See Check
Transmission-Hydraulic System Oil Level in
Service - 50 Hours section.)

Push SCV I control lever full forward to use “float” position


to lower single-acting cylinder.
“Float” position allows a cylinder to extend and retract
freely and uses no engine power.

A—SCV I Outlet B—SCV I Control Lever

PY13083 —UN—19DEC11
PG57337,000019F -19-19DEC11-1/1

Correct Reversed Cylinder Response

CAUTION: If cylinder response is reversed,


extending when it should retract, reverse cylinder
hose connections at coupler.
PG57337,00001A0 -19-16DEC11-1/1

Neutral Lever Position


SCV I lever (A), spring pressure returns lever (A) to a
centered position (except when lever is fully forward in
the “Float” position). When the control levers are in the
centered position, the remote cylinder is hydraulically
locked in position.
PY13082 —UN—19DEC11

A—SCV I Lever

PG57337,00001A1 -19-19DEC11-1/1

60-3 071321

PN=81
Remote Hydraulic Cylinders (If Equipped)

Extend/Retract Cylinder—SCV I
Extend Cylinder
Pull lever (A) to the rear of neutral and hold it against
spring pressure. This extends cylinder (B) (up arrow)
connected to couplers I and in most cases raises
implement. Lever returns to neutral when released.

PY13082 —UN—19DEC11
Retract Cylinder
Push lever (A) forward and hold it against spring pressure.
This retracts cylinder (B) connected to SCV I couplers and
in most cases lowers implement. Lever returns to neutral
when released.
Float Position
Push lever full forward into detent to operate Float feature.
Float operation allows cylinder to extend and retract freely,
such as when an implement follows ground contour.
IMPORTANT: When FLOAT is not needed, manually
move lever back to neutral position to prevent

PY6487 —UN—20NOV18
accidental use of “Float”.

A—Control Lever B—Extend and Retract


Cylinder

PG57337,00001A2 -19-19DEC11-1/1

60-4 071321

PN=82
Drawbar and PTO
Use Swinging Drawbar
Drawbar cap screws (A) can be removed to let drawbar
swing free. This is helpful when turning under load.
Drawbar cap screws should be installed and tightened at
all other times.
IMPORTANT: Install drawbar cap screws to
prevent drawbar from swinging free during

PY4410 —UN—31DEC04
transport of towed loads.

A—Drawbar Cap Screws

DP97633,000021D -19-30JUL18-1/1

65-1 071321

PN=83
Drawbar and PTO

Adjustable Drawbar
The drawbar is used to pull drawn equipment of all types,
mostly for PTO-driven implements.
The drawbar hitch is located to increase the rear axle load
and at the same time slightly reduce load on the front axle.
Besides having a variable swinging range, the drawbar
can also be adjusted lengthwise.

PY22111 —UN—30OCT14
Maximum permissible static vertical loads and towable
drawbar loads are stated in the "Specifications" section.
NOTE: Towing on public roads with the swinging drawbar
set to one side is not permitted!

DP97633,000021E -19-30JUL18-1/1

Proper Use of Drawbar


IMPORTANT: Comply with local traffic regulations
when using the drawbar. Use suitable,
approved hitch pins only. Combine
drawbars as shown only.

LX1036188 —UN—02MAY05
DP97633,000021F -19-30JUL18-1/1

Observe Drawbar Load Limitations


NOTE: FIK Option is available on the fixed type drawbar.

IMPORTANT: Certain heavy equipment, such as a


loaded single-axle trailer, can place excessive
PY13090 —UN—21DEC11

strain on drawbar. Strain is greatly increased


by speed and rough ground.
Static vertical load on drawbar should not
exceed 556 kg (1225 lb).
Drive slowly with heavy loads.
Specification
Drawbar
Drawbar Static Vertical
Load—Capacity..............................................556 kg (1225 lb) Maximum
A—Drawbar

DP79986,00000DA -19-21DEC11-1/1

65-2 071321

PN=84
Drawbar and PTO

Stay Clear of Rotating Drivelines


Entanglement in rotating driveline can cause serious
injury or death.
Keep tractor master shield and driveline shields in place
at all times. Make sure rotating shields turn freely.

TS1644 —UN—22AUG95
Wear close fitting clothing. Stop the engine and be sure
PTO driveline is stopped before making adjustments,
connections, or cleaning out PTO driven equipment.

PY80265,05GO862 -19-10SEP05-1/1

Attach PTO-Driven Implement

CAUTION: Stop engine before attaching


implement or working in area of implement hitch.

1. Attach implement to tractor before connecting PTO

PY13090 —UN—21DEC11
drive line. Raise hitch to upward position if it is not
to be used.
2. Range shift lever in neutral (N), key to OFF position to
stop engine and set brakes.
3. If PTO driven implement will be attached to drawbar
(A), the drawbar must be positioned so there is 355
mm (14 in.) between end of PTO shaft and center of
drawbar pin hole. Make sure drawbar locking pins A—Drawbar
and spring pins are in place. If implement will be
connected to 3-Point Hitch, be sure drawbar will not
interfere. Remove it if necessary. 5. Be sure all shields are in place and in good condition.
NOTE: There are two holes at the front of the drawbar. Never operate PTO unless master shield is properly
Place the drawbar pin in the second hole for the installed. WITH ENGINE STOPPED, check integral
proper 355 mm (14 in.) length. shields on drive line by making sure they rotate freely
on shaft. Lubricate or repair as necessary.
4. Rotate PTO shield upward for clearance. With engine 6. Check carefully for any interference, make sure hitch
off, turn shaft slightly by hand if necessary to line up is raised to the upper position if it is not used.
splines. Connect drive line to PTO shaft. Pull out
on shaft to be sure drive line is locked to PTO shaft.
Place PTO shield in downward position.
DP79986,00000DB -19-21DEC11-1/1

65-3 071321

PN=85
Drawbar and PTO

Operate Tractor PTO

C B

PY15878 —UN—08OCT13
PY4485 —UN—16FEB06
Without PTO Indicator

Hand Throttle Lever


1. Depress clutch pedal, start engine, and push hand
throttle lever (A) forward until engine speed is sufficient
to start PTO implement. Engine speed must be less
than 2050 rpm (B) for standard PTO, for economic
PTO operation engine speed must be 1600 rpm (C).
2. Move control lever (D) forward to engage PTO.

PY15882 —UN—08OCT13
3. For standard PTO operation increase engine speed
to 2050 rpm.
4. Economic PTO operation place EPTO lever (E) on
540E position.

CAUTION: Turn key OFF and pull Fuel Shut-off PTO & EPTO Lever
Knob to stop engine, set brakes and make
sure that all mechanisms have stopped before
cleaning out machine or making any adjustments A— Hand Throttle Lever D— PTO Engage Lever
to PTO driven implement. B— Standard PTO Operation E— Economic PTO Lever (If
Speed Equipped)
C— Economic PTO Operation
5. Pull control lever back to disengage PTO. Speed

SV86979,00005E8 -19-08OCT13-1/1

65-4 071321

PN=86
Drawbar and PTO

Adjust PTO Clutch Operating Rod

PY5912 —UN—22NOV18

LV4082 —UN—02NOV99
1. Move PTO lever (A) to rearward (disengaged) position.
2. Remove clip pin (B) from forward end of PTO clutch
rod.
3. Check for equal thread engagement at turnbuckle
(G). Loosen jam nuts (F) and (C). Turn rod (D) until
threads on each side of turnbuckle are equal. Tighten
jam nut (F).
4. Loosen jam nut (C) from rear of front clevis (E).
5. Adjust length of arm (D) so the clip pin (B) can be
inserted with the rod pulled forward and the arm pulled
rearward to eliminate free play. Lengthen rod by turn
of the clevis to provide PTO clutch lever free play
and PTO clutch rod travel in fully engaged position

PY5019 —UN—21MAY05
to specification.
Specification
PTO Clutch Lever—Free
Play............................................................................................... 15 mm
PTO Clutch Rod
(In Fully Engaged
Position)—Travel.............................................................. 14 mm -16 mm

NOTE: Adjust turnbuckle (G) if you cannot make A—PTO Clutch Lever E—Clevis
proper adjustment with clevis. B—Clip Pin F— Jam Nut
C—Jam Nut G—Turnbuckle
D—Arm
6. Reinstall clip pin (B) in clevis (E) and arm (D).
7. Tighten jam nut (C) at clevis.
SA61034,00002EE -19-18MAR08-1/1

65-5 071321

PN=87
Ballast
Plan for Maximum Productivity
Proper ballasting is an important factor in tractor tractor weight and ballast selection. FMO-Machinery
performance. maximum productivity can be achieved only Management includes information on tractor and
if tractor weight is appropriate for the job. implement matching and increasing productivity. .
John Deere FMO (Fundamentals of Machine Operations) Your John Deere dealer can assist you with information
Tractors, discusses methods of determining correct on these subjects.
SA61034,00002EF -19-18MAR08-1/1

Use Proper Ballast


3. Provide proper fore/aft balance to minimize occurrence
The amount of ballast required and especially the locations of a power hop in MFWD tractors.
of ballast weights depend very much on type of implement
being used and operating speed. Ballasting is required to: 4. Assure rear axle carries sufficient weight for traction,
braking, and stability when a loader or other front
1. Assure front axle carries sufficient weight for steering implement is attached to front of tractor.
security and stability with the field draft loads as well
as transport in field and on road. 5. When changing from one implement or attachment to
another it is necessary to reconfigure ballast on tractor.
2. Provide sufficient traction to pull efficiently high draft
loads.
SD74272,0000215 -19-17MAR20-1/1

Select Ballast Carefully


Match amount of ballast needed for each job. What is but with hydraulic oil and lubricants, a full fuel
right for one job may be wrong for another job. Ballast for tank and an operator weighing 75 kg.
traction and stability.
CAUTION: Use suitable lifting tackle/hoists when
CAUTION: When determining front and rear axle handling weights. Safety and performance of
ballast, ensure that permissible axle loads and your tractor depend on correct ballasting of front
maximum permissible machine weight (including axle (front weights) and rear axle (wheel weights,
mounted implements) are not exceeded (see filling tires with liquid ballast, pick-up weight).
Specifications Section in Operator’s Manual).
Comply with local regulations regarding Factors determining amount of ballast:
installation and maximum permissible number
of weights. In order to maintain steerability, at
• Soil surface-loose or firm
least 20% of unladen mass must be on front
• Type of implement-integral/semi-integral or towed
axle. Unladen mass is mass of tractor without
• Travel speed-slow or fast
special equipment, attachments, trailer, or ballast,
• Tractor power output-partial or full load
• Tires-single, oversize, or dual
SD74272,0000216 -19-23APR15-1/1

Match Ballast to Load Work


Use no more ballast than necessary, and remove ballast Rather than weighing tractor down to pull heavy loads, try
when it is no longer needed. to reduce load. Pulling a lighter load at a higher speed is
more economical and more efficient.
SA61034,00002F1 -19-18MAR08-1/1

70-1 071321

PN=88
Ballast

Check for Correct Ballast to Little Ballast Too Much Ballast


1 Excessive wheel slip 1 Increased load
The best way to check for correct ballast is to measure
amount of travel reduction (% slip) of the drive wheels. 2 Power loss due to churning 2 Power loss due to carrying
Under normal field conditions, travel reduction should be soil extra weight
10—15 percent. 3 tire wear 3 Tire strain

Add more weight to drive wheels if slip is excessive. If there 4 Fuel waste 4 Soil compaction
is less than 10 percent slip, weight should be removed 5 Lower productivity 5 Fuel waste
6 Lower productivity
SV86979,00004D8 -19-23JUL13-1/1

70-2 071321

PN=89
Ballast

Measure Wheel Slip—Manually

LV733 —UN—25JUN94
1. Place a mark (A) on a rear tyre which is easily 7. Adjust ballast or load to give correct slippage.
observed (a chalk mark is recommended).
NOTE: Available horsepower is greatly reduced when
2. With tractor working and implement lowered, mark a wheel slip drops below 10 percent.
starting point (B) on the ground at the place where the
tyre mark (A) meets the ground. WHEEL SLIPPAGE CHART
3. Mark the ground again where the tyre mark (A) Non-Loaded Wheel Estimated % Recommended Action
completes 10 full revolutions (C). Revolutions (Step 5) Slip

4. With implement raised return in the opposite direction. 10 0 Remove Ballast


At the second mark on the ground (C) remark the tyre 9-1/2 5 Remove Ballast
(D). 9 10 Proper Ballast
5. While driving the tractor along the same path 8-1/2 15 Proper Ballast
(implement raised), count the tyre revolutions required 8 20 Add Ballast
to reach the starting point (B).
7-1/2 25 Add Ballast
6. Use the return tyre revolutions count and “Wheel
7 30 Add Ballast
Slippage Chart” to determine slippage. 10—15
percent is ideal.
SA61034,00002F3 -19-18MAR08-1/1

Ballast Limitations
Ballast should be limited by either tyre capacity or tractor Treads section.) If a greater amount of weight is needed
capacity. Each tyre has a recommended carrying capacity for traction, a larger tyre should be considered.
which should not be exceeded. (See Wheels, Tires and
Ballast can be added as either liquid or cast iron.
SA61034,00002FD -19-18MAR08-1/1

70-3 071321

PN=90
Ballast

Ballast Front End for Transport

CAUTION: Additional front ballast may be needed


for transporting rear-mounted implements. When
implement is raised, drive slowly over rough
ground, regardless of how much ballast is used.

CAUTION: Weights are heavy. Use proper lifting

APY02464 —UN—06FEB18
equipment. Approximate weight of starter weight
(C) is : 49 kg (109 lb). Approximate weight of
QUIK-TATCH™ weights (D) are 45 kg (99 lb).
Specification
Starter Weight
(Ballast)—Weight...................................................... 50 kg (110 lb) Each
QUIK-TATCH™ Weight
(Ballast)—Weight........................................................ 45 kg (99 lb) Each

A—Ballast Center C—Starter Weight


B—Ballast Retaining Bolts (2 D—QUIK-TATCH Weights
NOTE: For Tractors with TSS transmission, an option used)
of weights with six sets is available.

Installing QUIK-TATCH™ Weights: QUIK-TATCH™ 2. To hold weights in place, run retaining bolts (B) through
weights can be installed on the front of the tractor. holes from side-to-side. Tighten to specification.
One starter weight and up to 8 QUIK-TATCH™ weights Specification
can be installed. Ballast Weights Retaining
Bolts—Torque............................................................ 230 N·m (170 lb-ft)
1. Install weights in pairs, one on each side of center (A).

QUIK-TATCH is a trademark of Deere & Company


DP97633,0000226 -19-30JUL18-1/1

Ballast Tractor
Add weight to front end if needed for stability. Heavy
Refer to the implement operator's manual, along with
pulling and heavy rear-mounted implements tend to lift “Using Implement Codes” in this section, to determine
front wheels. Add enough ballast to maintain steering the minimum number of front weights that are required
control and prevent tip-over. for your tractor model.
SA61034,00002F6 -19-18MAR08-1/1

Ballast MFWD Equipped Tractors the implement code in ur implement operator’s


manual along with “using Implement Codes” in this
Ideal tire slippage for MFWD equipped tractors is 8—12 section.To determine the minimum number of front
percent. To reduce wheel slip to this level more weights are weights that are required for your tractor model.In
needed on the front than with the two wheel drive tractors. some cases additional front ballast is required for
Ideal weight split is 40 percent at front and 60 percent at optimum field performance. If more assistance is
rear of total tractor weight. In some cases liquid ballast needed then contact your John Deere Dealer
will be needed in front tyres to obtain its weight splits
NOTE: Implement codes are used to determine proper
ballast for stability and steering control. Refer to
AK50421,0000133 -19-26JUL11-1/1

70-4 PN=91
071321
Ballast

Determine Maximum Rear Ballast


IMPORTANT: DO NOT overload tires. If maximum Chart shows carrying capacity per tyre.
weight shown in chart is not enough for safety,
reduce load or install heavier ply tires. MAXIMUM LOAD PER WHEEL

To extend drive train life, avoid excessive Tyre Size Capacity


Bias Ply tires Ply Rating kg (lb)
soil compaction and rolling resistance, avoid
adding too much ballast. Ballast should never 14.9-28 12 1545 (3406)
exceed the weight required to provide traction 13.6-28 12 1329 (2930)
for continuous full power loads in 3rd gear.
Remove ballast if tractor engine labors when 12.4-28 12 1211 (2670)
pulling heavy loads in the first three gears.
SA61034,00002F7 -19-18MAR08-1/1

Determine Maximum Front Ballast


Use appropriate front ballast for a particular operating MAXIMUM LOAD PER WHEEL
condition. Two-wheel drive tractors should only have 2-WD
enough ballast to maintain safe steering control MFWD
equipped tractors should have adequate ballast to Capacity
Tyre Size Ply Rating kg (lb)
properly load front wheels. Remove ballast when it is no
longer needed. 6.00-16 8 534 (1177)
7.50-16 8 750(1650)
Chart shows carrying capacity per tyre.
8-18 6 800(1763)
IMPORTANT: DO NOT overload tires. If maximum
weight shown in chart is not enough for
safety, reduce load or install tires with
a higher load rating.
AK50421,000016A -19-19OCT11-1/1

Use Cast Iron Weights


Cast iron weights are available in a 48 kg (106 lb) size.
Weights can be installed on the inside or outside of wheel.
See your John Deere dealer for more information and
recommendations on weight use and placement.

M47215 —UN—29JAN92
Specification
Cast Iron
Weights—Weight................................................................ 48 kg (106 lb)

SA61034,00002F9 -19-18MAR08-1/1

70-5 071321

PN=92
Ballast

Install Rear Cast Iron Weights

PY1635 —UN—17FEB06
A—Additional Weight B—Weight
C—Weight Holes

CAUTION: Optional cast iron weight weighs 2. To install additional weights (A), install bolts in previous
48 kg (106 lb). Handle with care! Use weight (B). Rotate the added weight to align bolts with
appropriate equipment or have the job done weight holes (C).
by your John Deere dealer.
3. Tighten attaching bolts securely. Tighten again after a
few hours service. Check tightness regularly.
1. Attach first weight to wheel disks.
SA61034,00002FA -19-18MAR08-1/1

70-6 071321

PN=93
Ballast

Use Liquid Weight

CAUTION: Installing liquid ballast requires special


equipment and training. Have the job done by
your John Deere dealer or a tyre service store.

IMPORTANT: NEVER fill tyre to more than 75% full.


More solution would leave too little air space to
absorb shocks. Damage to tyre could occur.

A solution of water and calcium chloride provides safe,


economical ballast. Used properly, it will not damage
tires, tubes, or rims.
Use calcium chloride to prevent water from freezing. A
mixture of 0.6 kg per liter (5.0 lb of calcium chloride per
gal) will not freeze solid above —45°C (—53°F).

RW25003 —UN—07JUL93
Charts on this page show how much each tyre size holds
if filled to 75 percent full.
LIQUID WEIGHT FOR FRONT TYRES
With 0.6 kg/L (5 lb/gal) Calcium Chloride Solution
Liquid Weight per tyre
Tyre Size kg (lb)—75% Full
6.00-16 30 (67)
7.5-16 40 (107) LIQUID WEIGHT FOR REAR TYRES
8-18 30 (67) With 0.6 kg/L (5 lb/gal) Calcium Chloride Solution
Liquid weight per Tyre
Tyre Size kg (lb)—75% Full
12.4-28 216 (478)
13.6-28 237 (524)
14.9-28 339 (747)
BS13987,0000266 -19-24JAN13-1/1

Use Implement Codes

CAUTION: DO NOT attempt to transport an With maximum front ballast, do not attempt to transport
implement without adequate front ballast which an implement whose code exceeds:
may result into lack of steering control. (For 2-WD)
• 115 for 2-WD Tractor
John Deere engineers have developed a code to NUMBER OF QUIK-TATCHä WEIGHTS NEEDED
determine how much front ballast is needed for stability
2-WD
and steering control.
Implement Code Without Liquid in With Liquid in Front
1. Find implement code in implement operator’s manual Front Tires Tires
0—65 0 -
2. Use the following chart to determine how many
QUIK-TATCHä front weights are required on your 66—75 2 0
tractor model. 76—85 4 2
To use chart, find the implement code range in the left 86—95 6 4
column into which your implement code fits. Then 96—105 8 6
move to the right until you are beneath the column
106—115 - 8
which identifies your tractor configuration. The number
you find at this point in the chart is the number of
QUIK-TATCHä weights needed.
SA61034,00002FC -19-02AUG18-1/1

70-7 071321

PN=94
Wheels, Tires, and Treads
Service Tires Safely
Explosive separation of at tire and rim parts can cause
serious injury or death.
Do not attempt to mount a tire unless you have the proper
equipment and experience to perform the job.
Always maintain the correct tire pressure. Do not inflate
the tires above the recommended pressure. Never weld
or heat a wheel and tire assembly. The heat can cause
an increase in air pressure resulting in a tire explosion.
Welding can structurally weaken or deform the wheel.
When inflating tires, use a clip-on chuck and extension
hose long enough to allow you to stand to one side and
NOT in front of or over the tire assembly. Use a safety
cage if available.
Check wheels for low pressure, cuts, bubbles, damaged
rims or missing lug bolts and nuts.

TS211 —UN—15APR13
SA61034,0000302 -19-18MAR08-1/1

Check Implement-to-Tire Clearance


IMPORTANT: Check for adequate clearance (A)
between outside diameter of the tire and
implement with hitch in raised position.
When large diameter rear tires are installed on

M47177 —UN—31JAN92
a tractor with a 3-Point Hitch, a quick coupler
or similar device may be required to provide
adequate implement-to-tire clearance.

A—Clearance

SA61034,0000303 -19-18MAR08-1/1

75-1 071321

PN=95
Wheels, Tires, and Treads

Check Tire Inflation Pressure


Check tires daily for damage or noticeably low pressure. /vehicle system. Correctly inflated radial tires will show
a large deflection of the sidewall or “cheeks”. This is
At least every 100 hours of operation, check inflation normal and will not hurt the if the inflation pressure
pressure with a gauge. Use an accurate gauge having 10 is maintained.
kPa (0.1 bar) (1 psi) graduations.
3. Inflation pressures less than 80 kPa (12 psi) should
If tires contain liquid ballast, use a special air-water gauge be monitored regularly because of the increased risk
and measure with valve stem at bottom. of low pressure air leaks (especially due to leaking
NOTE: When furrow plowing or during hillside operation, valve cores).
pressure can be increased 28 kPa (0.28 bar) (4 psi) 4. Tractors operating on steep side slopes should
ABOVE maximum to prevent wrinkling or buckling. increase inflation pressures 28 kPa (4 psi) above the
values listed to compensate for lateral weight transfer.
IMPORTANT: Always check inflation pressure with
an accurate gauge to prevent over-inflation. 5. Tires run as singles in high traction conditions
Over-inflation reduces performance and sometimes experience bead slip if the bead was not
increases strain of both and rim. fully seated or if too much lubricant was used to mount
the . Increasing the inflation pressure will compensate
NOTE: Following inflation information applies to both front for this condition but will not cause reduced traction.
and rear tires and Tire Inflation Pressure Chart. Consult your dealer if this problem occurs.

1. All inflation pressures are calculated for 29 km/h (18 6. If higher load capacities are needed, contact your
mph) travel speeds for both diagonal (bias) ply and John Deere dealer for manufacturers load and inflation
radial ply tires. table information.

2. Operation of tires at the inflation pressures listed on


chart will result in optimum tractive performance of the
SA61034,0000304 -19-18MAR08-1/1

Tire Inflation Pressure Chart


With Maximum Ballast or Heavy
Front Tires With Little or No Added Weight Mounted Implement
Tire Size Ply Rating Tread kPa (bar) (psi) kPa (bar) (psi)
6.00-16 8 F2 160 (1.6) (23) 280 (2.8) (40)
7.50-16 8 F2 170 (1.7) (24) 303 (3.0) (44)
8-18 8 R1 190 (1.9) (27)
With Maximum Ballast or Heavy
Rear Tires With Little or No Added Weight Mounted Implement
Tire Size Ply Rating Tread kPa (bar) (psi) kPa (bar) (psi)
12.4-28 12 R1 80 (0.8) (12) 140 (1.4) (20)
13.6-28 12 R1, R3, R4 90 (0.9) (13) 120 (1.2) (18)
14.9-28 8a/12 R1 80 (0.8) (12) 140 (1.4) (20)
a
8 ply rating applicable for MFWD HLD tires
SV86979,00006DD -19-01JAN14-1/1

75-2 071321

PN=96
Wheels, Tires, and Treads

Tighten Wheel/Axle Hardware Correctly

CAUTION: NEVER operate tractor with a loose 1. After driving tractor about 100 m (109 yd), and before
rim, wheel, hub, or axle. placing it under load, tighten hardware to specified
torque.
Any time hardware is loosened, tighten to specified torque.
2. Check hardware after working three hours and again
NOTE: Follow checking procedure when a new tractor after 10 hours.
is first used, or wheels have been off.
3. Check all hardware frequently and keep it tight.
PY80265,05GO883 -19-10SEP05-1/1

Tighten Bolts— Front Axle


Tighten bolts in the following locations to specifications:
Specification
Front Axle—Axle-to-Knee
Bolts—Torque.............................................................. 480 Nm (350 lb-ft)
Front Axle—Disk-to-
Flange Bolts—Torque.................................................. 210 Nm (130 lb-ft)

B—Disk-to-Flange

PY4526 —UN—21JAN05
PY80265,05GO884 -19-10SEP05-1/1

Tighten Bolt Adjustable Front Axle––If


Equipped
Tighten bolts in the following locations to specifications:
Specification
Adjustable Front

PY5021 —UN—21MAY05
Axle-to-Knee
Bolts—Torque............................................................................. 480 N•m
Adjustable Front
Axle Disk-to-Flange
Bolts—Torque............................................................................. 210 N•m

A—Axle-to-Knee B—Disk-to-Flange

PY5844 —UN—26NOV18

NR25796,0000683 -19-15JAN07-1/1

75-3 071321

PN=97
Wheels, Tires, and Treads

Tighten Bolts—Rear Axle (M-20 Stud)


Tighten bolts in the following locations to specifications:
Specification
Rear Axle Rim-to-Disk
(Steel Disk)—Torque................................................... 245 Nm (180 lb-ft)
Rear Axle Disk-to-Flange
(Steel Disk)—Torque................................................... 550 Nm (406 lb-ft)

PY4282 —UN—06DEC04
A—Rim-to-Disk Bolts C—Stud
B—Disk-to-Flange Bolts D—Nut

PY1956 —UN—12JAN04
New Arrangement with M-20 Stud and Nut

PY80265,05GO886 -19-10SEP05-1/1

Observe Rear Wheel Tread Width Limitations


IMPORTANT: Tires must have at least 25 mm (1 in.)
clearance with fenders (A) and fuel tank. When
large diameter rear tires are installed, check
clearance between and fenders and fuel tank.

M47179 —UN—31JAN92

SA61034,0000306 -19-18MAR08-1/1

75-4 071321

PN=98
Wheels, Tires, and Treads

Tread Settings—Multi-Position Rear Wheels


Wheel tread on rear axle with multi-position wheels can Multi-Position Rear
be adjusted by repositioning or exchanging the rims or by Wheels Disk-to-Flange
reversing the wheel disks. (Steel Disk)—Torque................................................... 175 Nm (130 lb-ft)

Wheel tread can also be adjusted by exchanging the NOTE: Tread settings are measured at bottom
complete wheel to the opposite side of the tractor (This of centerline.
maneuver permits the change from disk-dished-in to
disk-dished-out operations without disassembling the STEEL DISKS
wheel). When changing rear wheels from one side to the REAR TREAD WIDTH
other, the arrow on side wall of points in the direction of Centerline-to-Centerline
forward rotation. Diagram Tire Sizes
The relationship of the wheel disk and rim in obtaining 14.9-28
the different tread settings is shown in the diagrams on 13.6-28
the facing page. 12.4-28
A 1417 mm (55.8 in.)
A study of these diagrams, before attempting to change
tread settings, will save unnecessary labor. B 1513 mm (59.6 in.)
C 1617 mm (63.7 in.)
IMPORTANT: After setting wheel spacing, tighten
rim-to-disk and disk-to-flange bolts. Drive D 1716 mm (67.6 in.)
tractor 100 m (109 yd) and tighten again. E 1820 mm (71.7 in.)
Specification
Multi-Position Rear
Wheels Rim-to-Disk
(Steel Disk)—Torque................................................... 245 Nm (180 lb-ft)

IN227 —UN—24MAY00
DP79986,00000A4 -19-24AUG10-1/1

75-5 PN=99
071321
Wheels, Tires, and Treads

Tread Settings—Adjustable Front Axle––If Equipped

LV1515 —UN—05MAR96
PY5021 —UN—21MAY05
Front rims are offset. With some tires, this provides two
tread spacings, at each axle setting.
ADJUSTABLE FRONT AXLE TREAD SETTINGS
Diagram C
Centerline-to-centerline
Tread Positionª For 2 WD
Tire 1 2 3 4 5 6
7.5-16 1449 mm 1549 1649 1749 1849 1949
(57.0 in.) (61.0 in.) (64.9 in.) (68.9 in) (72.8 in.) (76.7 in.)
6.0-16 1435 mm (56.5 in.) 1535 mm (60.4 in.) 1635 mm (64.4 in.) 1735 mm (68.3 in.) 1835 mm (72.2 in.) 1935 mm (76.2 in.)
ªTread position 1 is with axle adjustment at its most inward location. See adjust Front Axle Tread Width in this section.

ADJUSTABLE FRONT AXLE TREAD SETTINGS


Diagram D
Centerline-to-centerline
Tread Positionª
Tire 1 2 3 4 5 6
7.5-16 1583 1683 mm 1783 mm 1883 mm 1983 mm 2083 mm
(62.3 in.) (66.3 in.) (70.2 in.) (74.1 in.) (78.1 in.) (82.0 in.)
ªTread position 1 is with axle adjustment at its most inward location. See adjust Front Axle Tread Width in this section.

NR25796,0000684 -19-15JAN07-1/1

75-6 071321

PN=100
Wheels, Tires, and Treads

Adjust Front Axle Tread Width


IMPORTANT: DO NOT place jack under engine oil pan.

1. Jack up front end of tractor.


2. When making large tread adjustments, loosen cap

PY5529 —UN—21FEB06
screws (E) and adjust the tie rod (A) length with axle
length.
3. Remove two nuts (B), sleeves (D), and cap screws (C)
from front axle (2 on each side).
4. Slide axle knees to desired position. Both sides should
be adjusted to same spacing.
5. Install sleeves (if equipped), cap screws and nuts on A—Tie Rod D—Sleeve (4 used)
each side. Tighten cap screws to specification. B—Axle Nuts (4 used) E—Tie Rod Cap Screw
C—Cap Screws (4 used)
Specification
Adjustable Front
Axle-to-Knee
Bolts—Torque............................................................. 400 N·m (295 lb-ft) 6. Set toe-in. See Check and Adjust Toe-In for your axle
type.
SA61034,00002C0 -19-17MAR08-1/1

Check Toe-In
1. Park machine on level surface.
2. Turn steering wheel so front wheels are in the
straight-ahead position. Stop engine.
3. Measure distance (A) between tires at hub level in
front of axle. Record measurement and mark the tires.
4. Move tractor back about 1 m (3 ft), so mark is
at hub level behind the axle. Again, measure
distance between tires at same point on tire. Record
measurement.
5. Determine the difference between front and rear
measurements. If the front measurement is smaller,
toe is “in”. If the rear is smaller, toe is “out”.
6. Distance (A) at front of tires should be 0—2 mm for
DANA front axle. Adjust toe-in if necessary. (See
procedure in this section.)

PY9953 —UN—24AUG10
Toe-In Value Chart
Make Toe-In Value
DANA FRONT AXLE 0-2 mm

A— Front Axle Toe-In Distance

DP79986,00000A5 -19-24AUG10-1/1

75-7 071321

PN=101
Wheels, Tires, and Treads

Adjust Toe-In
1. Loosen lock nut (A) on tie rod.
2. Adjust tie rod equally by rotating tube (B) to lengthen
or shorten tie rod. Adjust toe-in to 0—2 mm for DANA
front axle.
3. Tighten bolt to specification. Do not overtighten as
damage to the tube may occur.

PY4882 —UN—22NOV18
Specification
Tie Rod Jam
Nut—Torque................................................................. 90 N·m (66 lb.-ft.)

Toe-In Value Chart


Powered Axle
Make Toe-In Value
DANA FRONT AXLE 0-2 mm

A—Tie Rod Lock Nut B—Tie Rod Tube

PY4148 —UN—26AUG04
Non-Powered Axle

SA61034,00002FF -19-17DEC13-1/1

Check Toe-in (MFWD Tractor)


1. Disengage MFWD and park tractor on smooth, level
surface. Steer front wheels straight ahead. Stop
engine
2. Measure distance (A) between centerline of tires at
hub level in front of axle, using an outside bar of each

PY6522 —UN—06NOV06
tire or an inside bar of each tire. Record measurement
and mark the tires.
3. Move tractor back about 1 m (3 ft), so mark is
at hub level behind the axle. Again, measure
distance between tires at same point on tire. Record
measurement
4. Determine the difference between front and rear A-MFWD Axle Toe-In Distance
measurements. If the front measurement is smaller,toe
is IN. If the rear is smaller, toe is OUT. The difference
may be in either direction (toe-in or toe-out but should
be less than 3 mm (1/8 in.). Adjust toe-in necessary.
(See procedure in this section.)
AK50421,0000130 -19-26JUL11-1/1

75-8 071321

PN=102
Wheels, Tires, and Treads

Adjust Toe-in (MFWD Tractor)


NOTE: This procedure is for toe-in adjustment off
the vehicle. The toe-in adjustment must be
performed again on the vehicle.

1. Jack up front axle so tires are off floor


2. Rotate tire by hand and scribe a line near the center
of each of the front tires.

PY12247 —UN—26JUL11
NOTE: One of the tie rod ends and jam nut
has left-hand threads

3. Measure and record the distance between the lines at


the front and the rear of the tire at about axle height.
The front measurement should be less than the rear
measurement.
4. If measurement is not correct, loosen jam nuts (A) on .
both ends of tie rod and turn the tie rod (B) using a
wrench to increase or decrease the amount of toe until
the measured dimension is 0–0.125 in.[0–3 mm].
5. Apply Loctite 262 and tighten the jam nuts (A) to
173–192 lbs. ft. [235–260 N•m].
Item Measurement Specification

MFWD Tie Rod Jam Nuts— Torque 173–192 lbs. ft. [235–260 N•m]
AK50421,0000131 -19-26JUL11-1/1

Adjust Toe-In - Adjustable Front Axle––IF


Equipped
1. Loosen locker nuts (A) on locker (B).
2. Loose ball joint lock nut (E).
3. Adjust tie rods on both sides of the tractor equally by
the extensioner to lengthen or shorten. Adjust toe-in

PY5025 —UN—25MAY05
to 3 to 6 mm (1/8 to 1/4 in.)
4. Tighten nut on locker (A) to specification.
Specification
Locker Nut—Torque......................................................................40 N·m

5. Tighten the ball joint lock nuts (E) to specification.


Specification
Extensioner Lock A—Locker Nut D—Extensioner
Nut—Torque................................................................................160 N·m B—Locker E—Lock Nut
C—Tie Rod

SA61034,0000300 -19-18MAR08-1/1

75-9 071321

PN=103
Wheels, Tires, and Treads

Use Correct Tire Combinations


IMPORTANT: When replacing tires, consult your
In order to achieve maximum drawbar pull, maintain tire dealer. Mixing worn and new tires, bias
proper steerability, and reduce tire wear and fuel and radial, or tires of different diameters
consumption, comply with the correct tire combinations or loaded radii can reduce tire life and
shown on TIRE COMPATIBILITY CHART. overall tractor performance.
Should mechanical front wheel drive front tires show Using any tire combination, other than those
excessive wear in comparison with rear tire, the front tires listed on the TIRE COMPATIBILITY CHART,
must be replaced in order to maintain the predetermined could result in premature tire and driveline wear
tire ratio. due to excessive underspeed or overspeed.
AH98466,00000B8 -19-31MAY07-1/1

Tire Compatibility Chart


NOTE: The following chart details which front tires are
Underneath each rear tire is the compatible front tires,
compatible with an available rear tire.
either 2-WD or MFWD, along with the compatible tractor
model.
5045D 5045D
Rear Tire 2WD 4WD
13.6-28, 6 PR X X
14.9-28, 12PR X
Front Tire
7.5- 16, 10 PR X
8.0-18, 6 PR X

RP32883,0000B81 -19-26MAY20-1/1

75-10 071321

PN=104
Transporting
Use Safety Lights and Devices
Prevent collisions between other road users, slow moving
tractors with attachments or towed equipment, and
self-propelled machines on public roads. Frequently
check for traffic from the rear, especially in turns, and use
turn signal lights.
Use headlights, flashing warning lights, and turn signals
day and night. Follow local regulations for equipment
lighting and marking. Keep lighting and marking visible,
clean, and in good working order. Replace or repair
lighting and marking that has been damaged or lost. An
implement safety lighting kit is available from your John

TS951 —UN—12APR90
Deere dealer.

DX,FLASH -19-07JUL99-1/1

Driving Tractor on Roads

CAUTION: Observe the following precautions


when operating on a road.

1. Before operating tractor on highway be sure tail lights

PY15895 —UN—01JAN14
(A) and flashing turning lights (B) work properly. Install
and use auxiliary lighting to equipment as required for
safety and by local regulations.

A— Tail light C— Reflex Reflector


B— Turning Lights

DP97633,0000221 -19-30JUL18-1/5

CAUTION: NEVER operate flood light when


transporting tractor. Clear bright light at the rear
of the tractor could confuse drivers of other
vehicles as they approach from the rear.

IMPORTANT: Refer to Lights section for detailed


PY15837 —UN—09JUL13
descriptions of lighting operations
and functions.

2. Turn light switch to high beam headlights or low beam


headlights position. Never use bright lights which are
visible from the rear. Always dim headlights before
meeting another vehicle. Keep headlights properly
adjusted.
A— Lights OFF D— Full-Beam, Tail Lights and
B— Parking Light Position Warning Lights Position
C— Low-Beam, Tail Lights and E— Flood Light Position
Warning Lights Position

Continued on next page DP97633,0000221 -19-30JUL18-2/5

80-1 071321

PN=105
Transporting

3. Use turn signals when turning. Be sure to return turn


signal lever (A) to center position after turning.

A—Turn Signal Lever

PY25225 —UN—21AUG15
DP97633,0000221 -19-30JUL18-3/5

4. Couple brake pedals (A) together before driving on a


road. Avoid hard applications of brakes.
5. Drive slowly enough to maintain safe control at all
times. Slow down for hillsides, rough ground, and
sharp turns, especially when transporting heavy,
rear-mounted equipment.

PY6098 —UN—06AUG06
6. Before going down a hill, shift to a gear low enough
to control speed without using brakes. Never coast
down hill.
7. When transporting downhill on icy or graveled grades,
be alert for skids which could result in loss of steering
control. To decrease chance of skids, reduce speed Brake Pedals
and be sure that tractor has proper ballast.
A—Brake Pedals

Continued on next page DP97633,0000221 -19-30JUL18-4/5

80-2 071321

PN=106
Transporting

CAUTION: Stopping distance increases with


speed and weight of towed loads, and on slopes.
Towed loads with or without brakes that are
too heavy for the tractor or are towed too fast
can cause loss of control. Consider the total
weight of the equipment and its load.

LV4042 —UN—09JUL99
Observe these recommended maximum road
speeds, or local speed limits which may be lower:
If towed equipment does not have brakes, do not
travel more than 32 km/h (20 mph) and do not tow
loads more than 1.5 times the tractor weight.
If towed equipment has brakes, do not travel
more than 40 km/h (25 mph) and do not tow loads
9. Use additional caution when transporting towed loads
more than 4.5 times the tractor weight.
under adverse surface conditions, when turning and
Ensure that the load does not exceed the on inclines.
recommended weight ratio. Add ballast to
10. Heavy towed or rear mounted implement may start
recommended maximum for tractor, lighten the
swaying in transport. Excessive swaying will result
load, or get a heavier towing unit. The tractor must
in loss of steering control. Drive slowly and avoid
be heavy and powerful enough with adequate
quick turns of steering wheel. Refer to your implement
braking power for the towed load. Use additional
operator's manual regarding maximum travel speed
caution when towing loads under adverse surface
limitations.
conditions, when turning, and on inclines.
11. Hitch height for trailer should not exceed 630 mm from
8. Use caution when operating tractor at transport ground.
speeds. Reduce speed if towed load weighs more than
tractor and is not equipped with brakes. (See Towed
Equipment operator's manual for recommended
transport speeds.)
DP97633,0000221 -19-30JUL18-5/5

Transport on Carrier

CAUTION: Chain tractor to carrier securely.


Drive carrier slowly.

The best method of transporting a disabled tractor is to


haul it on a flatbed carrier.

LV610 —UN—22APR94
IMPORTANT: Seal exhaust to prevent dirt from
entering and damaging engine and/or
turbocharger (If Equipped).

SV86979,00004D9 -19-23JUL13-1/1

80-3 071321

PN=107
Transporting

Tow Tractor
CAUTION: NEVER tow tractor faster than
16 km/h (10 mph). Have an operator steer
and brake tractor.

PY15833 —UN—09JUL13
IMPORTANT: To avoid damaging transmission-
hydraulic system, observe the following
precautions:

1. Be sure that transmission-hydraulic system oil is to the


full level line on sight gauge (A). If the tractor is to be
towed with the front wheels raised, add 1 liter of oil to
hydraulic fill port (C) for each 90 mm (3-1/2 in.) the
wheels are raised. DO NOT raise front wheels more
C— Hydraulic Oil Filler Port
than 305 mm (12 in.) above ground.
NOTE: After transporting tractor, drain oil that
was added for towing. 4. Make sure that range lever is in neutral and gear lever
is in 4th gear.
2. Make sure that the differential lock is disengaged.
3. Make sure the MFWD is disengaged.
SV86979,000048A -19-17DEC13-1/1

80-4 071321

PN=108
Fuels, Lubricants and Coolant
Handle Fuel Safely—Avoid Fires
Use only diesel fuel.
Handle fuel with care, it is highly flammable.
DO NOT refuel machine:
• While you smoke.

M73115 —UN—09MAR90
• When machine is near open flame or sparks.
• When engine is running. STOP engine.
Fill fuel tank outdoors.
Help prevent fires:
• Clean oil, grease and dirt from machine.
• Clean up spilled fuel immediately.
Do not store machine with fuel in tank in a building where
fumes may reach an open flame or spark.
MX,FIRE,5A1 -19-22JUL94-1/1

Handle Fluids Safely—Avoid Fires


When you work around fuel, do not smoke or work near
heaters or other fire hazards.
Store flammable fluids away from fire hazards. Do not
incinerate or puncture pressurized containers.

TS227 —UN—15APR13
Make sure machine is clean of trash, grease, and debris.
Do not store oily rags; they can ignite and burn
spontaneously.

DX,FLAME -19-29SEP98-1/1

Fuel Storage
Buy good quality, clean fuel from a reputable supplier.
Avoid storing fuel over long periods of time.
Proper fuel storage is critically important. Use clean
storage and transfer tanks. Periodically drain water and Store fuel in a convenient place away from buildings.
sediment from bottom.
PY80265,05GO897 -19-10SEP05-1/1

Fuel Saving Tips • Engine will not achieve optimum working temperature
if the thermostat valve is removed and will consume
The consumption of fuel and lubricating oil can be reduced more fuel.
by the following practices— • Less or no clutch pedal free play will result in slipping
• Do not allow fuel leak. Ensure that the connections are or premature failure of clutch and will result in wastage
adequately tight. of fuel.
• Excessive inflation pressure in tyres and worn out tyres • Use matching trailer for transportation. Ensure proper
cause wheel slippage resulting in wastage of fuel. hitch application. Never overload the trailer.
• Get your tractor regularly serviced by Authorized John
Deere Dealer.
SS27023,000019F -19-23AUG11-1/1

85-1 071321

PN=109
Fuels, Lubricants and Coolant

Diesel Fuel
Consult your local fuel distributor for properties of the
Sulfur Content for Interim Tier 4, Final Tier 4, Stage III
diesel fuel available in your area.
A and B, Stage IV, and Stage V Engines Above 560 kW
In general, diesel fuels are blended to satisfy the low
temperature requirements of the geographical area in • Use ONLY diesel fuel with a maximum of 500 mg/kg
which they are marketed. (500 ppm) sulfur content.

Diesel fuels specified to EN 590 or ASTM D975 are Sulfur Content for Interim Tier 4, Final Tier 4, Stage
recommended. Renewable diesel fuel produced by III B, Stage IV Engines, and Stage V Engines
hydrotreating animal fats and vegetable oils is basically
identical to petroleum diesel fuel. Renewable diesel that
• Use ONLY ultra low sulfur diesel (ULSD) fuel with a
maximum of 15 mg/kg (15 ppm) sulfur content.
meets EN 590, ASTM D975, or EN 15940 is acceptable
for use at all percentage mixture levels. Sulfur Content for Tier 3 and Stage III A Engines
Required Fuel Properties • Use of diesel fuel with sulfur content less than 1000
mg/kg (1000 ppm) is RECOMMENDED.
In all cases, the fuel shall meet the following properties:
• Use of diesel fuel with sulfur content 1000—2000 mg/kg
Cetane number of 40 minimum. Cetane number greater (1000—2000 ppm) REDUCES the oil and filter change
than 47 is preferred, especially for temperatures below interval.
–20 °C (–4 °F) or elevations above 1675 m (5500 ft.).
• BEFORE using diesel fuel with sulfur content greater
Cloud Point should be below the expected lowest ambient than 2000 mg/kg (2000 ppm), contact your John Deere
temperature or Cold Filter Plugging Point (CFPP) should dealer.
be a maximum 10°C (18°F) below the fuel cloud point.
Sulfur Content for Tier 2 and Stage II Engines
Fuel lubricity should pass a maximum scar diameter of
0.52 mm as measured by ASTM D6079 or ISO 12156-1. • Use of diesel fuel with sulfur content less than 2000
A maximum scar diameter of 0.45 mm is preferred. mg/kg (2000 ppm) is RECOMMENDED.
• Use of diesel fuel with sulfur content 2000—5000 mg/kg
Diesel fuel quality and sulfur content must comply with (2000—5000 ppm) REDUCES the oil and filter change
all existing emissions regulations for the area in which interval.1
the engine operates. DO NOT use diesel fuel with sulfur • BEFORE using diesel fuel with sulfur content greater
content greater than 10 000 mg/kg (10 000 ppm). than 5000 mg/kg (5000 ppm), contact your John Deere
dealer.
Materials such as copper, lead, zinc, tin, brass and
bronze should be avoided in fuel handling, distribution Sulfur Content for Other Engines
and storage equipment as these metals can catalyze fuel
oxidation reactions which can lead to fuel system deposits • Use of diesel fuel with sulfur content less than 5000
and plugged fuel filters. mg/kg (5000 ppm) is RECOMMENDED.
• Use of diesel fuel with sulfur content greater than 5000
E-Diesel fuel mg/kg (5000 ppm) REDUCES the oil and filter change
interval.
DO NOT use E-Diesel (Diesel fuel and ethanol blend).
Use of E-Diesel fuel in any John Deere machine may void IMPORTANT: Do not mix used diesel engine oil or any
the machine warranty. other type of lubricating oil with diesel fuel.
Improper fuel additive usage may cause damage
CAUTION: Avoid severe injury or death due to the on fuel injection equipment of diesel engines.
fire and explosion risk from using E-Diesel fuel.
1
See DX,ENOIL12,OEM, DX,ENOIL12,T2,STD, or DX,ENOIL12,T2,EXT
for more information on Engine Oil and Filter Service Intervals.
DX,FUEL1 -19-13JUL20-1/1

85-2 071321

PN=110
Fuels, Lubricants and Coolant

Fuel Saving Tips • Engine will not achieve optimum working temperature
if the thermostat valve is removed and will consume
The consumption of fuel and lubricating oil can be reduced more fuel.
by the following practices— • Less or no clutch pedal free play will result in slipping
• Do not allow fuel leak. Ensure that the connections are or premature failure of clutch and will result in wastage
adequately tight. of fuel.
• Excessive inflation pressure in tyres and worn out tyres • Use matching trailer for transportation. Ensure proper
cause wheel slippage resulting in wastage of fuel. hitch application. Never overload the trailer.
• Get your tractor regularly serviced by Authorized John
Deere Dealer.
SS27023,000019F -19-23AUG11-1/1

Diesel Fuel Filters


Filtration of fuel is critical for proper operation of engine.
Use genuine MICO fuel filters. Always change fuel filter
inserts (primary and secondary) at given interval.

A—Fuel Filters (Primary and


Secondary)

PY25263 —UN—04NOV15
.

NM61126,0000130 -19-10DEC15-1/1

Fill Fuel Tank


CAUTION: Handle fuel with care: It is highly
flammable. DO NOT refuel the machine while
smoking or when near open flame or sparks.
Always stop engine before refueling machine.

TS202 —UN—23AUG88
Fill fuel tank outdoors.
Prevent fires by keeping machine clean
of accumulated trash, grease and debris.
Always clean up spilled fuel.

Fuel tank can be filled through either fill cap (A). Fill
fuel tank at end of each days operation. This prevents
condensation in tank as moist air cools.
Specification
Fuel Tank —Capacity........................................................................60 lit
PY9955 —UN—24AUG10

A— Fuel Tank Filler Cap

DP79986,00000A9 -19-24AUG10-1/1

85-3 071321

PN=111
Fuels, Lubricants and Coolant

Lubricant Storage
Your equipment can operate at top efficiency only when
clean lubricants are used. Make certain that all containers are properly marked to
identify their contents.
Use clean containers to handle all lubricants.
Properly dispose of all old containers and any residual
Whenever possible, store lubricants and containers lubricant they may contain.
in an area protected from dust, moisture, and other
contamination. Store containers on their side to avoid
water and dirt accumulation.
PY80265,05GO902 -19-10SEP05-1/1

Diesel Engine Oil — Tier 3 and Stage IIIA


Failure to follow applicable oil standards and drain
intervals can result in severe engine damage that might 50oC 122oF
not be covered under warranty. Warranties, including the
emissions warranty, are not conditioned on the use of 40oC 104oF
John Deere oils, parts, or service.

SAE 40
30oC 86oF
Use oil viscosity based on the expected air temperature

SAE 15W-40

SAE 30
range during the period between oil changes.

SAE 10W-40
20oC 68oF

SAE 10W-30
John Deere Plus-50™ II oil is preferred.

SAE 5W-30
SAE 5W-40
SAE 0W-40
10oC 50oF
John Deere Plus-50™ is also recommended.
0oC 32oF

SAE 10W
John Deere Torq-Gard™ is also allowed.
Other oils may be used if they meet one or more of the -10oC 14oF
following standards:
-20oC -4oF

TS1743 —UN—25APR19
• API Service Category CK-4
• API Service Category CJ-4 -30oC -22oF
• API Service Category CI-4 PLUS
• API Service Category CI-4 -40oC -40oF
• ACEA Oil Sequence E9
• ACEA Oil Sequence E7
• ACEA Oil Sequence E6 Oil Viscosities for Air Temperature Ranges
• ACEA Oil Sequence E5
• ACEA Oil Sequence E4
DO NOT use diesel fuel with sulfur content greater than
Multi-viscosity diesel engine oils are preferred. 10 000 mg/kg (10 000 ppm).
Diesel fuel quality and fuel sulfur content must comply
with all existing emissions regulations for the area in
which the engine operates.
Plus-50 is a trademark of Deere & Company
Torq-Gard is a trademark of Deere & Company
DX,ENOIL11 -19-23APR19-1/1

85-4 071321

PN=112
Fuels, Lubricants and Coolant

Diesel Engine Break-In Oil — Non-Emissions Certified and Certified Tier 1, Tier 2, Tier
3, Stage I, Stage II, and Stage III
New engines are filled at the factory with either John • ACEA Oil Sequence E1
Deere Break-In™ or John Deere Break-In Plus™
Engine Oil. During the break-in period, add John Deere IMPORTANT: Do not use Plus-50™ II, Plus-50™, or
Break-In™ or Break-In Plus™ Engine Oil, respectively, as engine oils meeting any of the following for the
needed to maintain the specified oil level. initial break-in of a new or rebuilt engine:
API CK-4 ACEA E9
Operate the engine under various conditions, particularly
heavy loads with minimal idling, to help seat engine API CJ-4 ACEA E7
components properly. API CI-4 PLUS ACEA E6
If John Deere Break-In™ Engine Oil is used during the API CI-4 ACEA E5
initial operation of a new or rebuilt engine, change the oil API CH-4 ACEA E4
and filter at a maximum of 100 hours.
API CG-4 ACEA E3
If John Deere Break-In Plus™ Engine Oil is used, change API CF-4
the oil and filter at a minimum of 100 hours and a
maximum equal to the interval specified for John Deere API CF-2
Plus-50™ II or Plus-50™ oil. API CF

After engine overhaul, fill the engine with either John


These oils do not allow the engine to
Deere Break-In™ or Break-In Plus™ Engine Oil.
break in properly.
If John Deere Break-In™ or Break-In Plus™ Engine Oil is
not available, use an SAE 10W-30 viscosity grade diesel John Deere Break-In Plus™ Engine Oil can be used for
engine oil meeting one of the following and change the oil all John Deere diesel engines at all emission certification
and filter at a maximum of 100 hours of operation: levels.

• API Service Classification CE After the break-in period, use John Deere Plus-50™
• API Service Classification CD II, John Deere Plus-50™, or other diesel engine oil as
• API Service Classification CC recommended in this manual.
• ACEA Oil Sequence E2
Break-In is a trademark of Deere & Company.
Break-In Plus is a trademark of Deere & Company
Plus-50 is a trademark of Deere & Company.
DX,ENOIL4 -19-02NOV16-1/1

Tractor Engine Coolant


The engine cooling system is filled to provide year-round
protection against corrosion and cylinder liner pitting, and Water Quality
winter freeze protection to -37°C (-34°F). If protection at Water quality is important to the performance of the
lower temperatures is required, consult your John Deere cooling system. Distilled, deionized, or demineralized
dealer for recommendations. water is recommended for mixing with ethylene glycol and
John Deere COOL-GARD™ II Premix Coolant propylene glycol base engine coolant concentrate.
is preferred. IMPORTANT: Do not use cooling system sealing
John Deere COOL-GARD II Premix is available in a additives or antifreeze that contains
concentration of 50% ethylene glycol. sealing additives.

NOTE: Consult your John deere dealer for additional Do not mix ethylene glycol and propylene
recommended coolant concentrations. glycol base coolants.
Do not use coolants that contain nitrites.

COOL-GARD is a trademark of Deere & Company


DP79986,00000DC -19-15DEC11-1/1

85-5 071321

PN=113
Fuels, Lubricants and Coolant

Use Correct Transmission-Hydraulic Filter John Deere filters. Other filters may be used if they meet
Element these performance specifications.

To protect systems, replace transmission-hydraulic oil See Lubrication and Maintenance section for
filter with a John Deere service filter element. Minimum recommended filter change intervals.
and maximum performance specifications are printed on
PY80265,05GO905 -19-10SEP05-1/1

Transmission and Hydraulic Oil


Use oil viscosity based on the expected air temperature
range during the period between oil changes.
The following oils are preferred:
• John Deere Hy-Gard™
• John Deere Low Viscosity Hy-Gard™
Other oils may be used if they meet one of the following:
• John Deere Standard JDM J20C
• John Deere Standard JDM J20D
Use John Deere Bio Hy-Gard™ II oil when a biodegradable
fluid is required.1

RG30204 —UN—08MAR18
Oils for Air Temperature Ranges

Hy-Gard is a trademark of Deere & Company


Bio Hy-Gard is a trademark of Deere & Company
1
Bio Hy-Gard II meets or exceeds the minimum biodegradability of 80%
within 21 days according to CEC-L-33-T-82 test method. Bio Hy-Gard
II should not be mixed with mineral oils, because this reduces the
biodegradability and makes proper oil recycling impossible.
DX,ANTI -19-01JAN18-1/1

85-6 071321

PN=114
Fuels, Lubricants and Coolant

Multipurpose Extreme Pressure (EP) Grease


IMPORTANT: For automated lubrication systems
different ambient air temperatures need
to be considered.

Use grease based on NLGI consistency numbers and the


expected air temperature range during the service interval.
John Deere SD Polyurea Grease is preferred.
The following greases are also recommended:
• John Deere HD Lithium Complex Grease
• John Deere Grease-Gard™ Premium Plus
Other greases may be used if they meet the following:

RG30199 —UN—08MAR18
• NLGI Performance Classification GC-LB
• ISO-L-X-BDHB 2 or DIN KP 2 N-10 Lithium Complex,
Non-Synthetic Base Oil (100 to 220 mm2/s @ 40°C)
IMPORTANT: Some types of thickeners, base
oils, and additives used in greases are not
compatible with others. Mixing greases should Greases for Air Temperature Ranges
be avoided. Consult your grease supplier before
mixing different types of grease.
Grease-Gard is a trademark of Deere & Company
DX,GREA1 -19-13JAN18-1/1

85-7 071321

PN=115
Service and Maintenance
Observe Service Intervals
Using hour meter (A) as a guide, perform all services at
the hourly intervals indicated on the following pages. Keep

PY15879 —UN—03OCT13
a service record on charts provided in the Lubrication and
Maintenance Record Charts section.
IMPORTANT:
Recommended service intervals are for average
conditions. Service MORE OFTEN if tractor is A
operated under adverse conditions.

A— Hour Meter

SV86979,00005E9 -19-03OCT13-1/1

Break-In Service
IMPORTANT: Keep wheel hardware tight to avoid Check alternator/fan belt tension and tighten air intake
tractor damage. Check wheel hardware torque and cooling system hose clamps
before operating, twice during first ten hours
of operation, after fifty hours of operation, Perform 50 Hours Service
and periodically thereafter.
After the First 100 Hours of Operation:
During the First 10 Hours of Operation: Replace transmission-hydraulic filter element
Perform daily or 10 hours service. (See Service Intervals Change engine oil and filter1
in Lubrication and Maintenance section.)
After the First 1100 Hours of Operation
Tighten wheel hardware. (See Wheels, Tyres, and Treads
section.) Change transmission-hydraulic oil and filter
After the First 50 Hours of Operation:
Tighten wheel hardware. (See Wheels, Tyres, and Treads
section.)
1
See Engine Break-In Oil in Service section for additional information.
NR25796,0000236 -19-21JUN06-1/1

90-1 071321

PN=116
Service and Maintenance

Service Intervals
Filter Overview With Service Intervals

PY15896 —UN—21OCT14
A— Transmission and Hydraulic B— Engine Oil Filter C— Air Filter
Oil Filter (Replace first 100 hours, (Service every 250 hours,
(Replace First 100 hours, Replace every 250 hours, Service annually elements
Replace every 500 hours) Replace annually) and as required)
D— Fuel Filter
(Replace Primary and
Secondary filter elements
every 250 hours alternatively)

Every 10 hours • Greasing front & rear trunnion 3


• Tighten wheel nuts
• Check engine oil level
• Check coolant level Every 50 hours
• Drain water and sediment from fuel filter
• Lubricate tie rod ends1 1 • Check transmission-hydraulic system oil level
• Lubricate steering spindles 1 • Check MFWD axle oil level
• Lubricate front axle pivot pin(s) • Clean and check battery
• Lubricate rear axle bearings1 • Inspect all tires
• Lubricate clutch pedal and right2 hand brake pedal. 2 • Lubricate front axle pivot pin(s)
• Lubricate cluch / brake shaft. • Lubricate steering spindles
• Inspect tractor for loose nuts and bolts
IMPORTANT: External lubrication is not required • Lubricate clutch pedal and right hand brake pedal.
for oil type rear axle • Lubricate clutch / brake shaft. 4
• Greasing front & rear trunnion VP52664,00003BC -19-10MAY17-1/2
Continued on next page

90-2 071321

PN=117
Service and Maintenance

First 100 hours • Check and tighten all hoses and hose clamps
• Check cooling system for leaks
• Change engine oil and filter • Lubricate rear axle bearings
• Replace transmission-hydraulic filter • Check engine idle speeds
• Change MFWD axle oil • Check the water separator trap
Every 250 hours
• Have your John Deere dealer:
-Check front axle pivot pin
• Service air cleaner IMPORTANT: External lubrication is not required
• Change engine oil and filter for oil type rear axle
• Clean and check battery
• Inspect and adjust alternator/fan belt First 1100 hours
• Lubricate 3-point hitch
• Check neutral start system • Change transmission-hydraulic oil and filter
• Check clutch pedal free travel Every 1250 hours
• Check brake pedal adjustment
• Replace filter inserts (primary and secondary • Change transmission-hydraulic oil and filter
alternatively) • Clean transmission-hydraulic pickup screen
• Tighten wheel nuts
Annually
IMPORTANT: Never replace primary and secondary
inserts simultaneously • Change engine oil and filter
• Replace air cleaner elements
Every 500 hours
Every 2 Years or 2000 hours (Whichever Comes First)
• Replace transmission-hydraulic filter • Flush cooling system
Every 600 hours
Service As Required
• Change MFWD axle oil • Service air cleaner
• Tighten MFWD axle front trunnion bolt • Adjust throttle friction
• Clean engine crankcase vent tube • Drain water and sediment from fuel tank and fuel filter
• Repack front wheel bearings
1
Only necessary when operating in extremely wet and muddy conditions.
2
Only necessary when operating in extremely wet and muddy conditions
3
For wet land applications
4
For dry land applications
VP52664,00003BC -19-10MAY17-2/2

90-3 071321

PN=118
Service—Every 10 Hours
Check Engine Oil Level
1. Park tractor on level ground, put range shift lever in
neutral (N), set brakes and turn engine “OFF”.
2. Pull out dipstick . Oil level should be between two
marks on dipstick. DO NOT operate engine when oil

PY15823 —UN—03JUL13
level is below “LOW” mark on dipstick.
3. If level is low, add oil through oil filler port (A) until
even with upper mark. DO NOT overfill. (See fuels,
Lubricants, Coolants and filters section.)

A—Engine Oil Filler Port

SV86979,0000476 -19-04JUL13-1/1

Check Coolant Level


CAUTION: . Only remove radiator cap (A) when
engine is cold. Slowly loosen cap to first stop to
relieve pressure before removing completely.

IMPORTANT: Check the coolant level when

TS281 —UN—15APR13
engine is cold.

NOTE: Clean radiator in most dusty conditions.


Failure of cleaning leads to improper flow of
coolants through radiator which leads to a
temperature increase of coolants.

1. Check coolant level in coolant recovery tank (B).


2. Coolant level shall be up to the “Cold Mark”. If it is
below “Cold Mark”, add coolant to that mark only. (See
Fuels, Lubricants and Coolant section.)

PY15847 —UN—05AUG13
A— Radiator Cap B— Coolant Recovery Tank

SV86979,00004DA -19-24JUL13-1/1

95-1 071321

PN=119
Service—Every 10 Hours

Drain Water and Sediment From Fuel Filter


NOTE: Place a small container under drain fitting to catch
draining fuel. Dispose of waste properly.

1. Put range shift lever in neutral (N), set brakes and turn
engine OFF.
2. Open fuel filter drain Plug (A) to bleed accumulated
moisture and sediment from filter into container.

PY25265 —UN—04NOV15
Tighten drain plug when clear fuel runs from drain.

A—Fuel Filter Drains

NM61126,0000132 -19-10DEC15-1/1

Lubricate as Necessary
Lubrication required only when operating in wet and muddy IMPORTANT: External lubrication is not required
conditions. Lubricate with several shots of multipurpose for the oil type rear axle.
grease specified in Fuels, Lubricants, and Coolant section.
• Tie rod ends • Lubricate clutch pedal and right handbrake pedal (See
• Steering spindles (Front Axle) (See Service—50 Hours) Service—50 Hours)
• Front axle pivot pin(s) (See Service—50 Hours) • Lubricate clutch / brake shaft. (See Service—50 Hours)
• Rear axle bearings (See Service—600 Hours)
NR25796,00002C6 -19-25JUL06-1/1

95-2 071321

PN=120
Service—Every 50 Hours
Check Transmission-Hydraulic System Oil
Level
1. Park on level ground. Put range shift lever in neutral
(N), set brakes and turn engine OFF.
2. Wait a minimum of five minutes for oil to settle.

PY16778 —UN—07JAN13
3. Check level at sight glass. Make sure that the oil level
should be full in level mark (B) as shown.
NOTE: As long as Lower window is full, there is no
requirement of oil top up. Upper window is the full
level, beyond that oil is not required to be filled.

4. Add oil to filler port (C) if lower glass window


(B) shows an empty space. (See Anti-Chatter
Transmission/Hydraulic Oil in Fuels, Lubricants and
Coolant section.)

A—Hydraulic Oil Full Level C—Hydraulic Oil Filler Port

PY15833 —UN—09JUL13
Mark
B—Hydraulic Oil Low Level
Mark

SV86979,000048B -19-09JUL13-1/1

Check MFWD Axle Oil Level


1. Park tractor on level surface.
2. Remove plug (A) to check oil level in axle housing with
help of dipstick attached to the plug(A).
3. If level is low, add John Deere HYGARD® Gear

PY12252 —UN—01SEP11
Lubricant or its equivalent. (See Fuels, Lubricants and
Coolant section.)
NOTE: HYGARD is a registered trademark of
Deere & Company

A—MFWD Oil Filler


Cap/Dipstick
Oil Fill Plug DANA

PG57337,00000FA -19-01SEP11-1/1

Clean and Check Battery


To access battery, see procedure in Service section.
Put range shift lever in neutral (N), set brakes and turn
engine OFF. Wipe battery with a damp cloth. Clean and
tighten connections if needed. Check fluid level in each
PY8021 —UN—13FEB19

cell, fill to bottom of filler neck with clean mineral-free


water. (See Servicing Battery in Service section.)

A— Negative Terminal B— Positive Terminal

DP79986,00000BB -19-25AUG10-1/1

100-1 071321

PN=121
Service—Every 50 Hours

Lubricate Front Axle Pivot Pin


Front axle pivot pin (C) requires lubrication of the front
and rear pivot bushing jerks with multipurpose grease.
(See Fuels, Lubricants and Coolant section).

C— Front Axle Pivot Pin

PY4496 —UN—23FEB06
DP79986,00000BD -19-25AUG10-1/1

Lubricate Steering Spindles


On front axle, apply several shots of general purpose
grease to steering spindle fitting (A). (See Fuels,
Lubricants and Coolant section) As Dana make front axle
comes with self lubricating bearings, there is no need of
spindle lubrication.

PY4144 —UN—26AUG04
A—Greasing point

NR25796,0000261 -19-12JUL06-1/1

Lubricate Steering Spindles (Adjustable


Front Axle—If Equipped)
On tractors equipped with adjustable front axle, apply
several shots of general-purpose grease (See Fuels,
Lubricants and Coolant section) to steering spindle fitting
(A).

PY4068 —UN—20NOV18
A— Spindle Fitting

Adjustable Front Axle Shown

SV86979,0000475 -19-04JUL13-1/1

100-2 PN=122
071321
Service—Every 50 Hours

Lubricate Clutch Pedal and Brake Pedal


Lubricate clutch pedal with multipurpose grease at
greasing point (A).
Lubricate brake pedals with multipurpose grease at
greasing point (B).

PY5993 —UN—22NOV18
Also lubricate clutch and brake shaft at the same time.

A—Clutch Pedal Greasing B—Brake Pedal Greasing


Points Points

Clutch Pedal Lubrication

PY5992 —UN—22NOV18
Brake Pedal Lubrication

NR25796,00002C9 -19-25JUL06-1/1

100-3 071321

PN=123
Service—Every 50 Hours

Inspect Tires and Loose Hardware

APY41946 —UN—02JUL21
NOTE: Tractor shown may have optional equipment. Inspect all tires and check inflation pressure. Also check
tractor for any loose hardware
Item Measurement Specification

Ballast Weights Retaining Bolts Torque 230 N·m (170 lb.-ft.)


Front Axle Disk-to-Flange Bolts Torque 210 N·m (155 lb.-ft.)
Rear Axle Rim-to-Disk Bolts Torque 245 N·m (180 lb.-ft.)
Rear Axle Disk-to-Flange Bolts Torque 550 N·m (406 lb.-ft.)
(5036D, 5039D & 5045D)
ROPS Mounting Bolts Torque 420 (+/- 10) N·m (310 lb.-ft.)
WKJQUWJ,0000B6D -19-05JUL21-1/1

100-4 071321

PN=124
Service—Every 250 Hours
Change Engine Oil and Filter
1. Run engine to heat oil. Turn engine off.
2. Remove oil drain plug (A) and drain oil.
3. Replace engine oil filter (B) while changing oil. Apply
a film of oil on the new oil filter gasket and install new

PY4147 —UN—26AUG04
filter. Hand tighten plus 1/2 turn.
4. Install drain plug.
5. Add seasonal viscosity grade oil. (See Fuels,
Lubricants and Coolant section.)
Specification
Engine Crankcase
Oil—Capacity................................................................................... 8.5 L A—Engine Oil Drain Plug B—Engine Oil Filter

NOTE: In Break-in-period, change the oil in first 100 hours.

PY80265,05GO920 -19-10SEP05-1/1

Service Air Cleaner


A dual element air cleaner is standard. A dirty primary
element is indicated when the air restriction indicator on
instrument panel illuminates. A dirty element can result
in loss of power or excessive smoke.
IMPORTANT: Check unloader valve (B) frequently.

PY12202 —UN—02JUN11
Empty as often as needed to keep it from filling
with dust. If valve is allowed to fill with dust,
air cleaner element will plug rapidly.

Service air cleaner (A) when indicator light illuminates,


every 250 hours or at least once a year.
Replace primary element at least one a year.
The secondary element should be removed only when A—Air cleaner B—Dust unloader valve
being replaced, normally once a year.
See procedure in Removing Air Cleaner Elements in
Service section.
AK50421,00000E9 -19-06JUN11-1/1

110-1 071321

PN=125
Service—Every 250 Hours

Replace Fuel Filter Inserts


1. Remove cap screw (A) and filter element bowl (B).
2. Take out filter insert (C).
3. Drain the fuel and clean the bowl.
4. Install new filter insert.
5. Reinstall the bowl (B) and tighten screw (A) and
washer (D).
6. Bleed the system from bleed screw (E).
IMPORTANT: Change primary and secondary filter
inserts alternatively. Never change both filter
inserts simultaneously. Always use new

PY4917 —UN—18APR05
O-ring which comes filter inserts.

A—Cap Screw D—Washer


B—Filter Element Bowl E—Bleed Screw
C—Filter Insert

PY80265,05GO922 -19-17DEC13-1/1

Inspect and Adjust Alternator/Fan Belt


Replace if worn or damaged. (See procedure in Service
section.)
NOTE: Run engine for five minutes to warm a cold belt.
Let a hot belt cool for 15 minutes before adjustment.

PY15831 —UN—04JUL13
Check tension by pressing belt midway between pulleys.
Belt should deflect about 19 mm (3/4 in.) at 89 N (20
lb.-force).
Adjust tension by loosening cap screw (A) and mounting
bolt (B). Apply force to alternator frame (C) until belt
tension is correct. Tighten cap screw and bolt.
A—Alternator Frame C—Alternator Mounting Bolts
B—Tension Adjustment Cap
Screw

SV86979,0000474 -19-04JUL13-1/1

Lubricate 3-Point Hitch


Lubricate right lift link (A) and left lift link (B) with several
shots of multipurpose grease. (See Fuels, Lubricants and
Coolant section.)
PY27534 —UN—09FEB16

A— Right Lift Link Grease B— Left Lift Link Grease Fitting


Fittings (2 used)

VP52664,00002F0 -19-09FEB16-1/1

110-2 071321

PN=126
Service—Every 250 Hours

Check Neutral Start System


Your John Deere tractor is equipped with interlocks to
prevent inadvertent movement when the engine is started.
Turning the key switch with the clutch pedal depressed
should crank the engine if all of the following conditions
exist:

PY5390 —UN—10DEC05

PY5391 —UN—10DEC05
• Range shift lever (A) in NEUTRAL
• PTO lever (B) in disengaged position
CAUTION: If starter turns engine in any of the
following steps, have the neutral start system
repaired by your John Deere dealer.
Dual Clutch Tractor Single Clutch Tractor
Turning the key switch to the start position should NOT
start the engine, if either of the following exist:
A—Range Shift Lever B—PTO Control Lever
• Range shift lever (A) in gear (not in NEUTRAL)
• PTO lever (B) in engaged position
PY80265,05GO925 -19-10SEP05-1/1

Check and Adjust Clutch Pedal Free Play


Measure free play (A) at top of pedal stroke. Adjust
linkage to obtain 20 to 25 mm free play.
To adjust linkage, loosen lock nut (B), remove cotter pin
(C), washer (D) and retaining pin (E) and return spring

PY6100 —UN—22NOV18
(F). Rotate clevis. After making adjustment, replace clip,
pin and washer and check free play. When free play is
correct, tighten lock nut.

A—Clutch Pedal Free Play D—Washer


B—Lock Nut E—Retaining Pin
C—Cotter Pin F— Return Spring
Clutch Pedal Free Play

PY4976 —UN—18JUN07

AH98466,00000BC -19-18JUN07-1/1

110-3 071321

PN=127
Service—Every 250 Hours

Check and Adjust Brake Pedal Free Play

PY5828 —UN—20JUN06
1. Park on level surface. Chock wheels to prevent
machine movement.
2. Unlock brake pedals.
3. Check free play (A) of each brake pedal at top of stroke.
4. Linkage must be to specification.

PY6100 —UN—22NOV18
Specification
Brake Pedal—Free Play........................................................... 35-45 mm

5. To adjust linkage, loosen jam nut (C).


6. Remove clip pin (B) from yoke (E) on either end of Brake Pedal Adjustment
linkage.
A—Brake Pedal Free Play D—Arm
7. Turn arm (D) until free play is to specification. B—Clip Pin E—Yoke
C—Jam Nut
8. Tighten jam nut.
9. Install clip pin.
SV86979,00005ED -19-12DEC13-1/1

110-4 071321

PN=128
Service—Every 500 Hours
Replace Transmission-Hydraulic Filter
1. Remove filter (A). Apply a film of oil to new gasket and
install new filter. Hand tighten plus 1/2 turn.
2. Run engine several seconds and recheck
transmission-hydraulic oil level.

PY7252 —UN—18JUN07
3. Add transmission-hydraulic oil if required (See Fuels,
Lubricants and Coolant section).

A—Transmission - Hydraulic
Oil Filter

AH98466,00000BD -19-18JUN07-1/1

112-1 071321

PN=129
Service—Every 600 Hours
Change Oil in MFWD Axle (If Equipped)

PY12255 —UN—01SEP11

PY12254 —UN—01SEP11
Wheel Hub

Oil Fill Plug DANA

1. Tractor should be positioned on level ground to assure


correct oil levels when filling.
NOTE: Each front wheel hub has a drain (C)

2. Remove drain plugs (B and C).Drain oil.


3. Install drain plugs (B & C).

PY12252 —UN—01SEP11
4. Fill differential housing at fill location (A) with John
Deere HYGARD® Gear Lubricant. (See Fuels,
Lubricants and Coolant section.) Fill oil to level mark
on dipstick attached to filler cap.

Oil Drain Plug DANA

A—Mfwd fill port plug C—Wheel Hub Drain Port Plug


B—Differential Housing Drain
Plug

Item Measurement Specification

MFWD Assembly Axle Oil - DANA— Capacity 5.9 L (1.55 Gal)


IMPORTANT: Check oil level after 30 minutes. Oil flows NOTE: HYGARD is a registered trademark of
very slowly through bearings and axle housings. Deere & Company
Fill through hub fill port (A). Add oil as needed.
VP52664,00001F8 -19-10MAY17-1/1

115-1 071321

PN=130
Service—Every 600 Hours

Clean Engine Crankcase Vent Tube

CAUTION: Reduce compressed air to less than


210 kPa (2 bar) (30 psi) when using for cleaning
purposes. Clear area of bystanders, guard
against flying chips, and wear personal protection

PY15830 —UN—04JUL13
equipment including eye protection.

Remove crankcase vent tube (A) from engine. Wash in


solvent or blow clean with compressed air. Reassemble
vent tube breather cap to engine. Be sure that vent tube
is not kinked or pinched.

A—Crankcase Vent Tube

SV86979,0000473 -19-04JUL13-1/1

Check Hoses and Hose Clamps for Tightness

PY4156 —UN—28AUG04
PY4115 —UN—21AUG04

Radiator Lower Hose

PY4154 —UN—27AUG04
PY4155 —UN—28AUG04

Radiator Upper Hose

A—Hose Clip

Check the following systems hose clamps for tightness: • Fuel


• Air Cleaner to engine intake Check all hoses for cracks which could cause leaks or
• Engine Cooling possible failure. Replace as necessary.
• Hydraulics
SV86979,0000472 -19-09JUL13-1/1

115-2 PN=131
071321
Service—Every 600 Hours

Lubricate Rear Axle Bearings


Lubricate rear axle fittings (A), both sides, with several
shots of multi-purpose grease. (See Fuels, Lubricants
and Coolant section.)

PY4025 —UN—16JUL04
IMPORTANT: External lubrication is not required
for oil type rear axle.

Rear Axle Fitting ( Dry Land)

AK50421,00000E7 -19-02JUN11-1/1

Check Engine Idle Speeds

PY15876 —UN—03OCT13
Slow idle speed is 850±50 rpm.
With no load, fast idle speed is 2300±50 rpm.
If idle speeds are not correct, see your John Deere dealer.
Specification
Engine—Slow
Idle—Speed........................................................................... 850±50 rpm
Engine—Fast Idle (with
No Load)—Speed................................................................ 2300±50 rpm
SV86979,00005EA -19-03OCT13-1/1

Check Front Axle Pivot Pin


Ask your John Deere dealer to check the front axle pivot
pin (C) for correct end play.

C— Front Axle Pivot Pin

PY4496 —UN—23FEB06
DP79986,00000D0 -19-01JAN14-1/1

115-3 071321

PN=132
Service—Every 600 Hours

Check Water Separator Trap


After 650 hours of operation, check the visibility of the
water separator trap in every service interval of 250 hours.
If the trap turns yellow/brown, open the trap and clean
it with compressed water. If the yellow/brown color still
persists, replace the trap.
NOTE: Every time when the trap is opened for cleaning
replace with the new ‘O’ ring.

PY12206 —UN—07JUN11
NOTE: Replace the water separator after 2000
hours of operation.

AK50421,00000F1 -19-15DEC11-1/1

Tighten MFWD Axle Front Trunnion Bolt


Tighten thrust bolt (A) and jam nut (B) at specified torque
values.

PY31178 —UN—10MAY17
A—Thrust Bolt B—Jam Nut

Item Measurement Specification

Thrust Bolt Torque 15-30 Nm (11-22 lb-ft)


Jam Nut Torque 175-200 Nm (129-147 lb-ft)
VP52664,00003BB -19-10MAY17-1/1

115-4 071321

PN=133
Service—Every 1250 Hours
Change Transmission-Hydraulic Oil and
Filter
1. Lower rockshaft to remove trapped oil.
2. Remove drain plug (C) from transmission case and
drain oil. Dispose of waste oil properly.
3. Replace filter (B) while changing oil. Apply a film of oil
to new filter gasket and install new filter. Hand tighten
only.

PY4417 —UN—31DEC04
A—Axle Housing C—Transmission Case Drain
B—Transmission Oil Filter Plug

SV86979,00005D6 -19-26SEP13-1/2

4. Fill system with transmission-hydraulic oil. (See


Fuels, Lubricants and Coolant section.)
Specification
Transmission Oil (Oil
Axle)—Capacity................................................................................. 32 L
Transmission Oil (Grease

PY4143 —UN—22NOV18
Axle)—Capacity................................................................................. 30 L

5. Check oil level at sight glass after filling. Make sure


that oil level is to full level mark (A). Check again after
operating for five minutes. Add oil if necessary.

A—Full Level Mark B—Add Level Mark

SV86979,00005D6 -19-26SEP13-2/2

120-1 071321

PN=134
Service—Every 1250 Hours

Clean Transmission-Hydraulic Pickup Screen


1. Drain transmission-hydraulic oil. (See Change
Transmission-Hydraulic Oil and Filter in this section.)
2. Remove two cap screws (A) and remove screen cover
(B).
3. Remove screen and examine it for damage. Replace
if necessary. Clean screen in solvent and blow dry

APY10153 —UN—07AUG18
with compressed air.
4. Carefully install the screen so the front of screen is
inserted in the hole at the front of differential case.
5. Fill system with transmission-hydraulic oil. (See
Changing Transmission-Hydraulic Oil and Filter in this
section.)
Hydraulic Pickup Screen
6. Check oil level at sight glass (C) after filling and again
after operating for five minutes.

A—Cap Screw (2 used) C—Sight Glass


B—Screen Cover

APY10154 —UN—07AUG18
Sight Glass

SA61034,0000453 -19-11JUN08-1/1

120-2 071321

PN=135
Service—Annually
Replace Air Cleaner Elements
1. Open hood and remove side screen. (See Removing
Side Screen in Service chapter.)
2. Release clips (A).
3. Remove cover (B).

PY7251 —UN—07JUN07
4. Remove primary element (C).
5. Clean out any dirt in canister taking care not to
damage the secondary filter element.
IMPORTANT: Remove secondary element (inner
element) ONLY if it is to be replaced. DO NOT
attempt to clean secondary element.
If secondary element is replaced, install new
element immediately to prevent dust from
entering air intake system.

6. Removal of the secondary element (D) is similar to


removal of the primary element.
NOTE: When installing the air cleaner canister, make sure
that the dust unloader valve is facing down.

PY4271 —UN—06DEC04
7. Install secondary element, primary element and cover.
8. Install side screens.

A—Clips D—Secondary Element


B—Cover E—Dust Unloader Valve
C—Primary Element

PY4294 —UN—06DEC04

AH98466,00000C0 -19-18JUN07-1/1

125-1 071321

PN=136
Service—2 Years/2000 Hours
Flush Cooling System

APY10157 —UN—07AUG18

APY10158 —UN—07AUG18
APY10160 —UN—07AUG18
APY10159 —UN—07AUG18

A—Radiator Cap C—Coolant Drain Plug D—Thermostat Cover


B—Drain Plug

For efficient operation, drain old coolant, flush the entire


system, and fill with clean antifreeze solution at least once
every 2 years. 3. Flush system with water - Close all drain valves/plugs
and fill system with clean water. Run engine about
10 minutes to stir up possible rust or sediment. Stop
CAUTION: DO NOT remove radiator cap or drain engine and drain water from system before rust and
coolant until coolant is cold. Always loosen sediment settle.
radiator cap slowly to relieve any excess pressure.
4. Flush system with radiator cleaner - Close all drain
NOTE: Clean radiator in most dusty conditions. valve/plugs and fill the cooling system with a good
Failure of cleaning leads to improper flow of commercial radiator cleaner and water. Follow
coolants through radiator which leads to a instructions provided with cleaner. Stop engine and
temperature increase of coolants. immediately drain system.

1. Drain coolant - Remove radiator cap (A). Open drain 5. Flush system with water - Close all drain valves/plugs
plug (B) on radiator and attach a drain hose. Route and fill with clean water to flush the system. Run the
hose to container and drain coolant from radiator. Drain engine about 10 minutes, then drain out flushing water.
coolant from the engine block by removing plug (C). 6. Remove thermostat cover and clean off the gasket
IMPORTANT: Thermostat must be removed to material. Apply gasket sealant to the new gasket and
ensure a thorough flush. install the thermostat and cover. Tighten cap screws
to specification.
2. Remove thermostat cover (D), remove thermostat and Specification
install cover (without thermostat). Tighten cap screws Thermostat Cover Cap
to specification. Screws—Torque............................................................. 47 N·m (35 lb·ft)
Specification
Thermostat Cover Cap
Screws—Torque............................................................. 47 N·m (35 lb·ft)
Continued on next page SV86979,00004DB -19-23JUL13-1/2

130-1 PN=137
071321
Service—2 Years/2000 Hours

reached. Let the engine cool (preferably overnight)


7. Fill with fresh coolant - Close all drain valves/plugs and
and recheck the coolant level. Coolant level with a
fill with a mixture of antifreeze, soft water, and coolant
cold engine must be at the bottom of the filler neck.
conditioner as specified in the Fuels, Lubricants, and
When filling the cooling system it is required several
Coolant section.
operating/cooling periods to stabilize the coolant level
8. Check coolant level - Fill radiator to the top of the filler in the system. Add make-up coolant to the radiator as
neck. Run the engine until operating temperature is needed and bring the coolant level to the correct level.
SV86979,00004DB -19-23JUL13-2/2

130-2 071321

PN=138
Service—As Required
Service Air Cleaner
Under dusty conditions, it is necessary to service air
cleaner more often than every 250 hours.
Loss of power, excessive smoke, or air filter restriction

APY10161 —UN—07AUG18
indicator light indicates dirty primary element.
Replace primary element (A). (See Replace Air Cleaner in
Service—250 Hours section.)

A—Primary Element

PY80265,05GO939 -19-10SEP05-1/1

Adjust Throttle Friction


When throttle linkage becomes loose and does not stay in
set position, adjust as follows:
NOTE: Instrument and side panels removed for illustration
purposes. Throttle lever lock nut can be accessed

APY10162 —UN—07AUG18
by lowering key switch cover.

1. Adjust spring tension by loosening or tightening


lock nut (A) until throttle lever movement is smooth
throughout range of travel with only slight drag.

A—Throttle Lever Lock Nut

PY80265,05GO940 -19-10SEP05-1/1

135-1 071321

PN=139
Service
Additional Service Information If you want more detailed service information, refer to Parts
Catalog and/or a Technical Manual available at Dealership
This is not a detailed service manual. It contains only
information needed for operation and routine maintenance.
PY80265,05GO941 -19-10SEP05-1/1

Service Tractor Safely

APY41946 —UN—02JUL21
NOTE: Tractor shown may have optional equipment. Before you work on any part of the engine, stop the engine,
and let it cool. Hot engine parts can burn skin on contact.
Disengage power to attachments and stop engine before
making any repairs or adjustments. Never run engine unless range shift lever is in neutral
position.
Do not change engine governor setting or overspeed
engine. Be careful to prevent clothing, jewelry, or long hair from
getting caught in the fan blades, drive belts, or any other
Keep the vehicle and attachments in good operating moving engine parts.
condition.
Unauthorized modifications to the machine may impair the
Keep safety devices in place and in working condition. function and/or safety and affect machine life.
Keep all nuts, bolts, and screws tight to be sure the
equipment is in safe working condition.
WKJQUWJ,0000B6E -19-05JUL21-1/1

140-1 071321

PN=140
Service

Engine Break-In Oil


New engines are filled at the factory with John Deere to maintain the specified oil level. Change
ENGINE BREAK-IN OIL. During the break-in period, the filter and oil at the first opportunity and
add John Deere ENGINE BREAK-IN OIL as needed to refill with John Deere ENGINE BREAK-IN OIL
maintain the specified oil level. to continue the break-in period.
Change the oil and filter after the first 100 hours of • API Service Classification CG-4
operation of a new or rebuilt engine. If the engine has not • API Service Classification CF-4
reached 100 hours after 12 months of use, change the oil • ACEA Specification E3
and filter and refill with John Deere ENGINE BREAK-IN • ACEA Specification E2
OIL. Continue to use ENGINE BREAK-IN OIL until 100
hours is reached. After the break-in period, use John Deere PLUS-50â oil or
other diesel engine oil as recommended in this manual.
If engine has been under light load during the first 100
hours of operation, continue to use ENGINE BREAK-IN IMPORTANT: Do not use John Deere PLUS-50â oil
OIL for the first 2—3 oil changes. or engine oils meeting API CG4 or API CF4
during the first 100 hours of operation of a
If John Deere ENGINE BREAK-IN OIL is not available, use new or rebuilt engine. These oils will not allow
a diesel engine oil with oil viscosity based on the expected the engine to break-in properly.
air temperature range, and meeting one of the following:
IMPORTANT: These oils are not ENGINE BREAK-IN
OIL’s and should only be used as a last resort
AH98466,00000C1 -19-01JUN07-1/1

Work In Ventilated Area


Engine exhaust fumes can cause sickness or death. If
it is necessary to run an engine in an enclosed area,
remove the exhaust fumes from the area with an exhaust
pipe extension.
If you do not have an exhaust pipe extension, open the

TS220 —UN—15APR13
doors and get outside air into the area

PY80265,05GO944 -19-10SEP05-1/1

Use High-Pressure Washers


IMPORTANT: Directing pressurized water at
electronic/electrical components or connectors,
bearings and hydraulic seals, fuel injection
pumps or other sensitive parts and components
may cause product malfunctions. Reduce
T6642EJ —UN—18OCT88

pressure, and spray at a 45 to 90 degree angle.

SA61034,0000309 -19-18MAR08-1/1

140-2 071321

PN=141
Service

Raise Hood

PY27245 —UN—10DEC15

PY27535 —UN—09FEB16
Left-Hand Side

A—Hood Release

1. Stop tractor, engage park brake park (If Applicable) 2. Unlock the key (A) and raise hood.
and remove key.
NM61126,0000134 -19-09FEB16-1/1

Air Intake System Components (With


Turbocharger)
Air enters the intake system through the open end of
the air cleaner canister. A major portion of the dust is B
separated out by air turbulence action of the primary

APY10090 —UN—07AUG18
A
air cleaner element (A) and passed out into the radiator
inlet air flow through the dust unloader valve (C). If the C
primary element becomes plugged, dust is filtered out by
the secondary element (B).

A—Primary Air Cleaner C—Dust Unloader Valve


Element
B—Secondary Air Cleaner
Element

SV86979,000046F -19-23JUL13-1/1

Air Intake System Components(Without


Turbocharger)
Air enters the intake system through the open end of
the air cleaner canister. A major portion of the dust is
separated out by air turbulence action of the primary
air cleaner element (A) and passed out into the radiator
LV4089 —UN—20JUL99

inlet air flow through the dust unloader valve (C). If the
primary element becomes plugged, dust is filtered out by
the secondary element (B).

A—Primary Air Cleaner C—Dust Unloader Valve


Element
B—Secondary Air Cleaner
Element

SV86979,00004DC -19-23JUL13-1/1

140-3 071321

PN=142
Service

Service Air Cleaner at Regular Intervals


Service air cleaner if air filter restriction indicator (A)
illuminates or at least every 250 hours. Replace air

PY15873 —UN—03OCT13
cleaner elements at least once a year.
The smaller “secondary” element should be removed only
when being replaced, normally once a year. (See Replace
Air Cleaner in Service—250 hours section.)

A— Air Restriction Indicator A

SV86979,00005EB -19-03OCT13-1/1

Check Air Intake System(With Turbocharger)

PY15836 —UN—09JUL13

PY15835 —UN—09JUL13
A— Air Intake System Clamps

Check all air intake system clamps (A) for tightness.


SV86979,0000480 -19-23JUL13-1/1

Check Air Intake System (Without


Turbocharger)
Check all air intake system clamps (A) for tightness.

A— Air Intake System Clamps

APY10163 —UN—13FEB19

SV86979,00004DD -19-25JUL13-1/1

140-4 PN=143
071321
Service

Remove Primary Air Cleaner Element


1. Disconnect rubber strap (A) at the front of the canister.
2. Lift clip (B) and pull canister cover.
3. Clean out any dirt in canister taking care not to

APY10164 —UN—07AUG18
damage the secondary filter element.
4. Removal of the secondary element is similar to
removal of the primary element.
IMPORTANT: Remove secondary element (inner
element) ONLY if it is to be replaced. DO
NOT attempt to clean secondary element. If
secondary element is replaced, install new
element immediately to prevent dust from
entering air intake system. When replacing the
air cleaner canister, make sure that the dust
cup/ejector hose is facing downward.

APY10165 —UN—07AUG18
A—Rubber Strap C—Primary Element
B—Clip

SA61034,000030D -19-18MAR08-1/1

Clean Primary Element


1. Pat sides of element gently to loosen dirt. DO NOT
tap element against a hard surface.
2. clean element with compressed air (below 690 kPa or
100 psi). Hold nozzle next to inner surface, and move

APY03714 —UN—01JUN18
up and down pleats.
IMPORTANT: DO NOT direct air against outside of
element, as it might force dirt through to inside.

3. Inspect element before reinstalling.

SA61034,000030E -19-18MAR08-1/1

140-5 071321

PN=144
Service

Wash Primary Element


IMPORTANT: Never wash element in gasoline or
any solvent. Never use compressed air on a
wet element. Do not oil element.

APY03715 —UN—01JUN18
1. If element is coated with oil or soot, wash in a solution
of warm water . Let element soak at least 15 minutes,
then agitate gently to flush out dirt.
2. Rinse element thoroughly from inside with clean water.
Use element cleaning gun or a free-running hose.
Keep water pressure low (below 280 kPa or 40 psi) to
avoid damaging element.
3. Allow element to dry completely before using. This
usually takes from one to three days. DO NOT oven 4. Inspect element before installing.
dry or use drying agents. Protect element from
freezing until dry.
SA61034,000030F -19-18MAR08-1/1

Inspect Element
1. Hold a bright light (A) inside element (B) and check
carefully for holes. Discard any element which shows
the slightest hole.
2. Be sure outer screen is not dented. Vibration would

APY03704 —UN—01JUN18
quickly wear a hole in filter.
3. Be sure rubber sealing surfaces (C) are in good
condition on both ends. If damaged, replace element.

A—Light Source C—Rubber Sealing Surface


B—Element

SA61034,0000310 -19-18MAR08-1/1

Store Element
If element is not installed on tractor, seal element in a
plastic bag and store in its original shipping container to
protect against dust and damage.

APY03705 —UN—01JUN18

SA61034,0000311 -19-18MAR08-1/1

140-6 071321

PN=145
Service

Replace Alternator/Fan Belt


1. Loosen cap screw (A) and bolt (B) and rotate the
alternator (C) to free the belt.
2. Remove belt from drive pulley.
3. Belt can be pulled around fan to remove.

PY1652 —UN—27OCT03
4. Install new belt in reverse order of removal.
5. Adjust belt tension. (See Inspect and Adjust
Alternator/Fan Belt in Service—250 Hours section.)

A— Alternator Cap Screw C— Alternator


B— Alternator Bolt

DP79986,00000C2 -19-25AUG10-1/1

Fuel System Components

PY4887 —UN—19APR05
PY25141 —UN—08JUL15

A—Mico Fuel filter Assembly D—Bleeding Screws-2 nos G—Fuel Line to Pump K—Acclerator
B—Primary Filter E—Sediment Drain Screws-2 nos H—Fuel return line L— Fuel Shut Off Lever
C—Secondary filter F— Fuel Injection Lines I— Hand Priming Pump
J— Lubrication

NM61126,0000137 -19-10DEC15-1/1

Do Not Modify Fuel System


IMPORTANT: Modification or alteration of the injection DO NOT attempt to service injection pump or fuel
pump, the injection pump timing, or the fuel injectors yourself. Special training and special
injectors in ways not recommended by the tools are required. (See your John Deere dealer.)
manufacturer will terminate the warranty
obligation to the purchaser. (See warranty
information inside front cover.)
PY80265,05GO960 -19-10SEP05-1/1

140-7 071321

PN=146
Service

Bleed Fuel System


1. Loosen fuel return line (A).
2. Unscrew hand primer (B) on fuel supply pump until
it can be pulled by hand.

PY4117 —UN—21AUG04
3. Operate the hand primer until fuel flow is free from
air bubbles.
4. Simultaneously stroke the hand primer down and
close the fuel return port. This prevents air from
entering the system. Tighten securely.
5. Lock hand primer in position.

A—Fuel Return Line B—Hand Primer

SA61034,0000313 -19-17DEC13-1/1

Bleed Fuel System At Fuel Injection Nozzles


If engine will not start after the bleeding procedures
described above, continue as follows:
1. Place throttle lever in fast idle position.
2. Using two open-end wrenches, loosen fuel line on at

PY1743 —UN—06NOV03
least three nozzles.
3. Turn over engine with starter motor until fuel flows free
from bubbles out of loosened fuel nozzle connections.
Retighten connections.

PY80265,05GO962 -19-10SEP05-1/1

140-8 071321

PN=147
Service

Engine Cooling System

APY10168 —UN—07AUG18
PY15825 —UN—23DEC13
Coolant is added in coolant recovery tank and not in
radiator directly. For efficient operation, drain old coolant,
flush entire cooling system at least once in two years (See
procedure in Service-2 years / 2000 hours section)
IMPORTANT: Never pour cold water into the cooling

APY10167 —UN—07AUG18
system of a hot engine, as it might crack
cylinder block or head. DO NOT operate engine
without coolant for even a few minutes.

NOTE: Clean radiator in most dusty conditions.


Failure of cleaning leads to improper flow of
coolants through radiator which leads to a
temperature increase of coolants.

A—Radiator Cap D—Upper Radiator Hose


B—Radiator E—Thermostat Valve
C—Coolant Recovery Tank F— Radiator Drain Plug

SV86979,000046E -19-23JUL13-1/1

140-9 071321

PN=148
Service

Clean Grille, Screens and Radiator

TS266 —UN—23AUG88

PY27536 —UN—09FEB16
1. Whenever trash builds up on front grille (A), stop
engine and brush clean.

CAUTION: Reduce compressed air to less than


210 kPa (2 bar) (30 psi) when using for cleaning
purposes. Clear area of bystanders, guard

PY8206 —UN—22NOV18
against flying chips, and wear personal protection
equipment including eye protection.

NOTE: Clean radiator in most dusty conditions.


Failure of cleaning leads to improper flow of
coolants through radiator which leads to a
temperature increase of coolants.

2. Raise hood and see if trash has built up on radiator


A—Grille B—Radiator
(B). If so, remove it using a brush or compressed air.
3. If a more thorough cleaning is necessary, clean
radiator from behind with compressed air or water.
Straighten any bent fins.
NM61126,0000139 -19-09FEB16-1/1

Prevent Battery Explosions


Keep sparks, lighted matches, and open flame away from
the top of battery. Battery gas can explode.
Never check battery charge by placing a metal object
across the posts. Use a volt-meter or hydrometer.
TS204 —UN—15APR13

Do not charge a frozen battery; it may explode. Warm


battery to 16°C (60°F).

PY80265,05GO965 -19-10SEP05-1/1

140-10 071321

PN=149
Service

Observe Electrical Service Precautions


CAUTION: Keep all sparks and flames away
from batteries, as gas given off by electrolyte is
explosive. To avoid sparks, connect negative
(ground) cable (B) last and disconnect it first.
When using a booster battery, follow instructions

TS204 —UN—15APR13
in “Operating the Engine” section.
To avoid shocks and burns, disconnect battery
negative (ground) cable (B) before servicing
any part of the electrical system, then remove
positive cable (A) if removing battery.
Keep all electrical shields in place.

A— Negative (—) Battery Cable B— Positive (+) Battery Cable

APY10134 —UN—11SEP18
DP79986,00000C3 -19-25AUG10-1/1

Battery Access
Battery is located in front of the radiator. Raise hood to
gain access.

APY10170 —UN—12SEP18
DP79986,00000BE -19-25AUG10-1/1

140-11 071321

PN=150
Service

Remove Battery

CAUTION: To avoid sparks, disconnect negative


(ground) cable first and connect it last.

1. Remove negative (ground) battery cable (A) and

APY10134 —UN—11SEP18
remove the cable connection. Then remove positive
cable (B) and connection.
Loosen nuts securing battery hold-down and rotate
the holder down, freeing the battery.
2. Lift and slide the battery from the battery tray.

A— Negative (—) Cable Nut B— Positive (+) Cable Nut

DP79986,00000BF -19-25AUG10-1/1

Check Battery Condition

CAUTION: Battery gas can explode. Keep sparks


and flames away from batteries. Use a flashlight
to check battery electrolyte level.
Never check battery charge by placing
a metal object across the posts. Use a
voltmeter or hydrometer.

TS204 —UN—15APR13
Always remove grounded (—) battery clamp
first and replace it last.

1. Use a battery hydrometer to check specific gravity of


electrolyte in each cell. Charge battery if reading is
below 1.215. Replace battery if difference between
cells is more than 0.050 or if battery will not charge
above 1.225. below 80°F (27°C). Corrected specific gravity of a fully
charged battery is from 1.265 to 1.280.
2. Always correct specific gravity reading for electrolyte
temperature variation. Add 0.004 to the reading 3. A battery is considered fully charged when three
obtained in step one for every 10°F above 80°F (add consecutive hydrometer readings, taken at hourly
0.007 to the reading for every 10° above 27°C). intervals, show no rise in specific gravity.
Subtract at same rate if electrolyte temperature is
SA61034,0000316 -19-18MAR08-1/1

140-12 071321

PN=151
Service

Service Battery
1. Keep battery clean by wiping with a damp cloth. Keep
all connections (A and B) clean and tight. To remove
any corrosion, wash terminals with a solution of four
parts water to one part baking soda.

APY10134 —UN—11SEP18
CAUTION: To avoid sparks, connect negative
(ground) (—) cable last and disconnect it first.

2. Keep battery fully charged, especially during cold


weather. If a battery charger is connected, attach
a positive cable to the positive battery terminal (A).
Connect the negative battery charger lead to a good
ground on tractor frame.
A— Negative (—) Battery B— Positive (+) Battery
Terminal Terminal

Continued on next page DP79986,00000C4 -19-25AUG10-1/2

140-13 071321

PN=152
Service

CAUTION: Sulfuric acid in battery electrolyte is


poisonous. It is strong enough to burn skin,
eat holes in clothing, and cause blindness
if splashed into eyes.
Avoid the hazard by:
1. Filling batteries in a well-ventilated area.
2. Wearing eye protection and rubber gloves.
3. Avoiding breathing fumes when
electrolyte is added.
4. Avoiding spilling or dripping electrolyte.
5. Use proper jump start procedure.
If you spill acid on yourself:
1. Flush your skin with water.
2. Apply baking soda or lime to help
neutralize the acid.
3. Flush your eyes with water for 15—30 minutes.
Get medical attention immediately.
If acid is swallowed:
1. Do not induce vomiting.
2. Drink large amounts of water or milk, but

TS203 —UN—23AUG88
do not exceed 2 L (2 quarts).
3. Get medical attention immediately.

IMPORTANT: DO NOT add water in freezing weather


unless tractor will be run at least 30 minutes
to assure thorough mixing.

3. Check level of electrolyte in each cell (A) at least every


250 hours. If low, fill to bottom of filler necks with
CLEAN, SOFT water. DO NOT OVERFILL.
4. Coat terminals with a small amount of grease.

A— Battery Cells

APY03716 —UN—01JUN18
DP79986,00000C4 -19-25AUG10-2/2

140-14 071321

PN=153
Service

Charge Battery
Keep battery fully charged, especially during cold weather.

CAUTION: Gas given off by battery is explosive.


Keep sparks and flames away from battery.
Before connecting or disconnecting a battery

TS204 —UN—15APR13
charger, turn charger off. Make last connection
and disconnection at a point away from battery.

1. With charger off, attach positive battery charger lead


to positive (+) battery terminal (A). Attach negative
charger lead to tractor frame away from the battery.
2. Turn charger on and recharge the battery following
battery manufacturer's instructions for using charger.
Check battery condition as described below.
3. To disconnect battery charger, turn charger off.
Remove negative charger lead first, follow by positive

APY10134 —UN—11SEP18
charger lead.

A— Negative (—) Battery B— Positive (+) Battery


Terminal Terminal

DP79986,00000C5 -19-25AUG10-1/1

Battery Replacement Specifications Specification


When replacing battery, use recommended battery. See Battery—Volts.............................................................................. 12 Volts
your John Deere dealer. Ampere Rating................................................................................88 Ah
SV86979,00005CE -19-08OCT13-1/1

Connect Starter Wiring


IMPORTANT: Disconnect battery negative (ground)
cable before servicing any part of electrical
system. Make all other connections before
connecting ground cable.

Connect large battery cable (A) and alternator cable to


large solenoid post (B). Connect the small white wire (C)
to solenoid terminal (D). PY27249 —UN—10DEC15

A—Large Battery Cable C—Small White Wire


B—Large Solenoid Post D—Solenoid Terminal

NM61126,000013A -19-10DEC15-1/1

140-15 PN=154
071321
Service

Connect Alternator Wiring


IMPORTANT: Disconnect battery negative (ground)
cable before servicing any part of electrical
system. Make all other connections before
connecting ground cable.

PY1658 —UN—15DEC05
To prevent damage to electrical system,
disconnect alternator before making any
electrical weld repairs. If an attached
implement needs weld repair, disconnect it
from tractor before welding, to prevent damage
to tractor electrical system.

If alternator is disconnected for any reason, connect wires


(A) and (B) as shown at right. A— Alternator Wire B— Alternator-Battery
Charging Indicator Wire

DP79986,00000C6 -19-25AUG10-1/1

Locate Fuses
Fuse box is located under hood on right-hand side of
tractor.
All electrical circuits are protected by fuses. Amperage
rating is marked on each fuse, plus fuses are color coded
to ensure proper replacement.
IMPORTANT: DO NOT replace original fuse with

PY25224 —UN—21AUG15
higher rated fuse or machine damage may occur.
If original size fuse will not carry electrical
load and continues to blow, have the electrical
system checked by your John Deere dealer.

DP97633,0000222 -19-30JUL18-1/1

Fuse Size and Function

JOHN DEERE
MADE IN INDIA
FLOOD LAMP
HEAD MOBILE CHRG
LAMP
15A LO-BEAM
AUXILIARY
25A
HEAD CLUSTER
LAMP
15A HI BEAM 15A
BR LAMP
PY27537 —UN—09FEB16

FLASHR
PARK
20A HAZARD
TURN
10A

USE THE DESIGNATED FUSE ONLY

Fuse Location
DP97633,0000223 -19-30JUL18-1/1

140-16 071321

PN=155
Service

Aim Headlights
1. Park tractor on level ground, with lights 8 m (25 ft)
from a wall.
2. Measure from top of hood to the ground (A). Place a
strip of masking tape (B) on the wall at the same height.

PY9959 —UN—25AUG10
3. Place a piece of tape, folded in the middle to make a
point, on the top front center of the hood.
4. Using the hood tape as a guide, sight across steering
wheel and hood to locate tractor centerline. Mark
tractor centerline (C) on wall.
5. From tractor centerline (C), mark a point 130 mm (5
in.) out in each direction (D). This mark locates a point
directly in front of center of each headlight.
6. Turn light switch to dim position.
7. Locate small zone of bright light projected by each
lamp. Cover other lamps if necessary. Top of zone (E)
should be 130 mm (5 in.) below the tape. Left edge of
zone (F) should be 130 mm (5 in.) left of lamp location
marked (D).
8. To adjust headlights. (See Adjust Headlights in this
section.)

A— Hood-to-Ground Distance D— Center of Headlight


B— Masking Tape E— Top of Zone
C— Tractor Centerline F— Left Edge of Zone

LV3020 —UN—10JUN99
DP79986,00000C1 -19-25AUG10-1/1

Adjust Headlights
1. Turn screws (A and B) counterclockwise to lower
beam or clockwise to raise beam.
2. Turn screw (A) counterclockwise and screws (B and
C) clockwise an equal number of turns on each screw.
PY7324 —UN—20NOV18

3. Turn screw (B and C) counterclockwise and screws


(A) clockwise an equal number of turns on each screw.

A—Headlight Mounting Screw C—Headlight Mounting Screw


B—Headlight Mounting Screw

SA61034,000027F -19-05MAR08-1/1

140-17 071321

PN=156
Service

Replace Headlight Bulb


1. Remove headlight connector (A).
2. Remove dust boot (B).

A—Headlight Connector B—Dust Boot

PY25146 —UN—09JUL15
Hood - Upside Down
NM61126,000013B -19-10DEC15-1/2

3. Twist collar (C).


4. Remove bulb (D).

CAUTION: A halogen bulb is pressurized


and may shatter. Protect bulb against
abrasions and scratches.

PY5817 —UN—16JUN06
To guard against personal injury, wear protective
eyeglasses and clothing when handling bulb.
Turn power off when installing and before
removing bulb. Dispose of bulb with care.
Allow bulb to cool before removing.
Read and follow all bulb manufacturers
installation instructions.

5. Install bulb, collar, seal, and connector in reverse order.

C—Collar D—Bulb

PY5818 —UN—20NOV18

NM61126,000013B -19-10DEC15-2/2

140-18 071321

PN=157
Service

Replace Tail Light and Warning Light Bulbs


1. Remove screws (A).
2. Remove lens.
3. Push and twist to release bulb from socket.

PY15891 —UN—01JAN14
4. Reverse this procedure to reassemble light.

A— Cap Screws (2 used)

SV86979,00006E4 -19-02JAN14-1/1

Replace Flood Lamp Bulb


1. Loosen mounting hardware (A) and rotate flood lamp
up to access cover fastening screw.
2. Remove screw, lamp cover and lamp from housing.

PY4167 —UN—28AUG04
3. Disconnect wiring leads from bulb.
4. Rotate bulb counterclockwise and remove.
5. Reverse the procedure to reassemble the flood lamp.

PY80265,05GO984 -19-29DEC06-1/1

Check Tires no added weight. If you install ballast or


mounted implements, or if you pull heavy
1. Check tires daily for damage or noticeably low loads, increase pressure.
pressure.
2. Have any cuts or breaks repaired as soon as possible. 5. At least every 100 hours of operation, check tires
with an accurate gauge having 10 kPa (0.1 bar) (1
3. Protect tires from exposure to sunlight, petroleum psi) graduations. If tires contain liquid ballast, use a
products and chemicals. special air-water gauge and measure with valve stem
at bottom.
4. Drive carefully. Try to avoid rocks and sharp objects.
Refer to Tire Inflation Pressure Chart in Wheels, Tires
IMPORTANT: Minimum pressures may be used and Treads section.
only for light loads and only if tractor has
SA61034,0000280 -19-05MAR08-1/1

140-19 071321

PN=158
Service

Keep ROPS Installed Properly

APY41940 —UN—25JUN21

PY4441 —UN—03JAN05
CAUTION: Make certain all parts are installed
correctly if roll-over protective structure (ROPS)
is loosened or removed for any reason. Tighten
mounting bolts to proper torque.
The protection offered by ROPS will be impaired
if ROPS is subjected to structural damage,
as in an overturn incident, or is in anyway
altered by welding, bending, drilling, or cutting.

APY41939 —UN—25JUN21
A damaged ROPS should be replaced, not
reused. Any alteration to the ROPS must be
approved by the manufacturer.

When installation of equipment on a machine necessitates


loosening or removing Roll-Over Protective Structure
(ROPS) (A), mounting bolts (B) should be tightened to
specification.
Specification
A—ROPS Crossbar C—Headed Pins
ROPS Mounting B—Mounting Bolts (8 used) D—Quick-lock Pin
Bolts—Torque.................................................420 (+/- 10) N·m (310 lb-ft)

Inspect ROPS mounting hardware every 250 hours for


proper torque or replacement.
Continued on next page WKJQUWJ,0000B6F -19-05JUL21-1/2

140-20 071321

PN=159
Service

TO LOWER ROPS CROSSBAR (A):


1. Remove quick-lock pins (D) and headed pins (C).
2. Lower crossbar (A) of ROPS onto stops.
3. Reinstall pins (C and D) into holes in ROPS to lock
crossbar down.

PY1421 —UN—20MAY03
CAUTION: Always keep upper part of ROPS
pinned in vertical position (as pictured) when
operating tractor. If tractor is operated with ROPS
folded (e.g. to enter a low building) drive with
extreme caution and DO NOT use seat belt.
Fold the ROPS up again as soon as the tractor
is operated under normal conditions.
Lift crossbar (A) of ROPS to position shown. Install pins
TO PUT ROPS IN OPERATING POSITION: (C) and quick-lock pins (D).
WKJQUWJ,0000B6F -19-05JUL21-2/2

140-21 071321

PN=160
Troubleshooting
Engine Troubleshooting
Symptom Problem Solution

Engine hard to start or will not start Improper starting procedure. Reviewing starting procedure.

No fuel. Check fuel tank.

Air in fuel tank. Bleed fuel tank.

Hand primer left raised. Push primer down.

Slow starter speed. See “Starter Cranks Slowly”.

Crankcase oil too heavy. Use oil of proper viscosity.

Improper type of fuel. Consult fuel supplier; use proper type


fuel for operating conditions.

Water, dirt, or air in fuel system. Drain, flush, fill and bleed system.

Clogged fuel filter. Replace filter element.

Dirty or faulty injectors. Have John Deere dealer check


injectors.

Fuel shutoff valve closed. Open fuel shutoff valve.

Engine knocks Insufficient oil. Add oil.

Injection pump out of time. See your John Deere dealer.

Low coolant temperature. See your John Deere dealer.

Engine overheating. See “Engine Overheats”.

Engine runs irregularly or stalls Low coolant temperature. See your John Deere dealer.
frequently
Clogged fuel filter. Replace filter element.

Water, dirt, or air in fuel system. Drain, flush, fill, and bleed system.

Dirty or faulty injectors. Have John Deere dealer check


injectors.

Improper type of fuel. Use proper fuel.

Below normal engine temperature Defective temperature gauge or Check gauge, sender, and conditions.
sender.
Lack of power Engine overloaded. Reduce load or shift to lower gear.

Continued on next page SV86979,000048C -19-10JUL13-1/4

145-1 PN=161
071321
Troubleshooting

Symptom Problem Solution

Low fast idle speed. See your John Deere dealer.

Intake air restriction. Service air cleaner.

Clogged fuel filter. Replace filter element.

Improper type of fuel. Use proper fuel.

Overheated engine. See “Engine Overheats”.

Below normal engine temperature. See your John Deere dealer.

Improper valve clearance. See your John Deere dealer.

Dirty or faulty injectors. Have John Deere dealer check


injectors.

Injection pump out of time. See your John Deere dealer.

Turbocharger not functioning See your John Deere dealer.

Leaking exhaust manifold gasket See your John Deere dealer.

Implement improperly adjusted. See implement operator's manual.

Restricted fuel line. See your John Deere dealer.

Restricted return line. See your John Deere dealer.

Improper ballast. Adjust ballast to load.

Low oil pressure Low oil level. Add oil.

Improper type of oil. Drain, fill crankcase with oil of proper


viscosity and quality.

High oil consumption Crankcase oil too light. Use proper viscosity oil.

Oil leaks. Check for leaks in lines, around


gaskets and drain plugs.

Restricted crankcase vent tube. Clean vent tube.

Engine emits white smoke Improper type fuel. Use proper fuel.

Low engine temperature. Warm up engine to normal operating


temperature.

Continued on next page SV86979,000048C -19-10JUL13-2/4

145-2 PN=162
071321
Troubleshooting

Symptom Problem Solution

Defective thermostat. See your John Deere dealer.

Defective injection nozzles. See your John Deere dealer.

Engine out of time. See your John Deere dealer.

Cold start advance or light load See your John Deere dealer.
advance not functioning.
Engine emits black or gray exhaust Improper type of fuel. Use proper fuel.
smoke
Clogged or dirty air cleaner. Service air cleaner.

Engine overloaded. Reduce load or shift to a low gear.

Injection nozzles dirty. See your John Deere dealer.

Engine out of time. See your John Deere dealer.

Turbocharger not functioning. See your John Deere dealer.

Engine overheats Dirty radiator core, or grille screens. Remove all trash.

Engine overloaded. Shift to lower gear or reduce load.

Low engine oil level. Check oil level. Add oil as required.

Low coolant level. Fill radiator to proper level, check


radiator, and hoses for loose
connection or leaks.

Faulty radiator cap. Replace cap.

Loose or defective fan belt(s). Adjust belt tension(s).

Cooling system needs flushing. Flush cooling system.

Defective thermostat. See your John Deere dealer.

Defective temperature gauge or See your John Deere dealer.


sender.
Incorrect grade of fuel. Use proper fuel.

High fuel consumption. Improper type of fuel. Use proper fuel.

Clogged or dirty air cleaner. Service air cleaner.

Engine overloaded. Reduce load or shift to a lower gear.

Continued on next page SV86979,000048C -19-10JUL13-3/4

145-3 PN=163
071321
Troubleshooting

Symptom Problem Solution

Improper valve clearance. See your John Deere dealer.

Injection nozzles dirty. See your John Deere dealer.

Engine out of time. See your John Deere dealer.

Implement improperly adjusted. See implement operator's manual.

Low engine temperature. See your John Deere dealer.

Excessive ballast. Adjust ballast to load.

Defective turbocharger . See your John Deere dealer.

Restricted air intake system. Check system.

Plugged crankcase vent tube. Clean vent tube.

SV86979,000048C -19-10JUL13-4/4

Transmission Troubleshooting
Symptom Problem Solution

Transmission oil overheats Low oil supply. Fill system with correct oil.

Clogged transmission-hydraulic oil Replace filter.


filter.
Internal hydraulic leak. See your John Deere dealer.

Hitch feedback linkage improperly Reset linkage. See your John Deere
adjusted. dealer.

Hydraulic motor not plumbed See your John Deere dealer.


correctly.
Low transmission pressure. Low oil supply. Fill system with correct oil.

Clogged transmission-hydraulic oil Replace filter.


filter.
PY80265,05GO987 -19-10SEP05-1/1

145-4 071321

PN=164
Troubleshooting

Hydraulic System Troubleshooting


Symptom Problem Solution

Entire hydraulic system fails to Low oil supply. Fill system with correct oil.
function
Clogged transmission-hydraulic filter. Replace filter.

Clogged transmission-hydraulic Clean pickup screen.


pickup screen.
High-pressure internal leak. See your John Deere dealer.

Hydraulic oil overheats Low oil supply. Fill system with correct oil.

Clogged transmission-hydraulic oil Replace filter.


filter.
Internal hydraulic leak. See your John Deere dealer.

Hitch feedback linkage improperly Reset linkage. See your John Deere
adjusted. dealer.

Hydraulic motor not plumbed See your John Deere dealer.


correctly.
PY80265,05GO988 -19-10SEP05-1/1

Brakes Troubleshooting
Symptom Problem Solution

No solid pedal feel Pedals adjusted incorrectly. See your John Deere dealer.

Pedal settles Rear brake piston seal leaking. See your John Deere dealer.

Excessive pedal travel Pedals adjusted incorrectly. See your John Deere dealer.

Brakes drag during transport Brakes out of adjustment. See your John Deere dealer.

SV86979,000048D -19-11JUL13-1/1

145-5 071321

PN=165
Troubleshooting

Rockshaft and 3-Point Hitch Troubleshooting


Symptom Problem Solution

Insufficient transport clearance Center link too long. Adjust center link.

Lift links to long. Adjust lift links.

Implement not level. Level implement.

Implement not properly adjusted. See implement operator's manual.

Front of center link in upper holes. Move center link to lower holes.

Sway chains adjusted to short. Lengthen sway chains.

Hitch drops slowly Rockshaft rate-of-drop control not Adjust rate-of-drop knob.
properly set.
Hitch fails to lift or lifts slowly Excessive load on hitch. Reduce load.

Low oil level. Fill system with proper oil.

Hydraulic oil too cold. Allow oil to warm.

Transmission-hydraulic oil filter Replace filter.


clogged.
Transmission-hydraulic pickup screen Clean or replace pickup screen.
clogged.
Implement will not operate at Lift links too short. Adjust lift links.
desired depth
Lack of penetration. See implement operator's manual.

Improper setting of limit stop. Reset position limit.

Improper setting of draft lever. See Rockshaft and 3-Point Hitch


section.

Insufficient or no hitch response Front attachment of center link in Move center link attachment to lower
to draft load upper holes. bracket holes.

Draft control lever in “Off” position. Move lever rearward.

Lift links too short. Adjust lift links.

Lack of penetration. See implement operator's manual.

Rate-of-drop too slow. Adjust rate-of-drop valve.

Hitch too responsive Front attachment on center link in Move center link attachment to upper
lower bracket holes. bracket holes.

Continued on next page PY80265,05GO990 -19-10SEP05-1/2

145-6 071321

PN=166
Troubleshooting

Symptom Problem Solution

Improper draft sensing adjustment. Move lever forward.

Hitch drops too fast Rate-of-drop set too fast. Adjust rate-of-drop.

Rockshaft control levers “drift”. Friction disks are loose. Adjust rockshaft control lever friction.
Levers too loose. See procedures in “Rockshaft and
3-Point Hitch” section or see your
John Deere dealer.

PY80265,05GO990 -19-10SEP05-2/2

Remote Hydraulic Cylinders Troubleshooting


Symptom Problem Solution

Direction of remote cylinder travel Improper hose connections. Reverse hose connections
is reversed
Hoses will not couple Improper hose male tips. Replace tip with ISO standard tips.

Remote cylinder will not lift load Excessive load. Reduce load.

Hoses not completely installed. Attach hoses correctly.

Incorrect remote cylinder size. Use correct size cylinder.

Direction of travel reverses on II SCV lever moved to regenerate Reverse hose couplings.
SCV. position.
PG57337,00001A9 -19-19DEC11-1/1

145-7 071321

PN=167
Troubleshooting

Electrical System Troubleshooting


Symptom Problem Solution

Battery will not charge Loose or corroded connections. Clean and tighten connections.

Sulfated or worn-out battery. Check electrolyte level and specific


gravity.

Loose or defective alternator/fan belt. Adjust belt tension or replace belt.

Charging system indicator glows Low engine speed. Increase speed.


with engine running
Defective battery. Check electrolyte level and specific
gravity.

Defective alternator. See your John Deere dealer.

Slipping alternator/fan belt. Adjust belt tension.

Starter inoperative Range shift lever in gear. Move lever to neutral.

PTO lever in engaged position. Move PTO lever to disengaged


position.

Low battery output. See your John Deere dealer.

Blown fuse. Replace fuse.

Starter cranks slowly Low battery output. Check electrolyte level and specific
gravity.

Crankcase oil too heavy. Use proper viscosity oil.

Loose or corroded connections. Clean and tighten loose connections.

Light system does not function; Blown fuse. Replace fuse.


rest of electrical system functions
Entire electrical system does not Faulty battery connections. Clean and tighten connections.
function
Sulfated or worn-out battery. Check electrolyte level and specific
gravity.

Blown fuse. Replace fuse.

Relay(s) sticking or nonfunctional; Diode to protect circuit from arcing See your John Deere dealer.
repeated failures has failed.
PY80265,05GO991 -19-10SEP05-1/1

145-8 071321

PN=168
Tractor Storage
Tractor Storage
IMPORTANT: Any time tractor will not be used for
several months, use this procedure to minimize
corrosion and deterioration.

1. Service air cleaner (A). (See Servicing Air Cleaner in


Service section.)

PY15824 —UN—04JUL13
2. If coolant has been in tractor for two years, flush cooling
system (B). (See Flush Cooling System in Service
section.) Add 50 percent antifreeze water mixture.
Test coolant for adequate cold-weather protection.
3. Change engine oil and filter (D). (See Change Engine
Oil and Filter in Service—250 hours section.)
4. Drain fuel and add back 4 L of fuel. Then add 0.4 L
of corrosion inhibitor.
5. Add 0.25 L of corrosion inhibitor to transmission-
hydraulic system fill port (E).
6. Depress clutch and start engine. Run engine until it

PY4168 —UN—12DEC05
reaches operating temperature. Also raise and lower
rockshaft several times. Shut off engine.

A— Air Cleaner D— Engine Oil Filter


B— Cooling System E— Transmission-Hydraulic
C— Engine Oil Drain Plug Oil Filler Cap

PY4169 —UN—12DEC05
PY15834 —UN—09JUL13

Continued on next page WKJQUWJ,0000B70 -19-05JUL21-1/3

150-1 071321

PN=169
Tractor Storage

7. Add 0.5 L more inhibitor to fuel tank at either filler cap


(A).
8. Add 0.5 L inhibitor to engine crankcase at filler (B).
9. Remove air intake hose at manifold. Pour 0.1 L
inhibitor into manifold and replace hose. Pull hand
throttle back to slow idle position. Crank engine only a
few revolutions.

APY41857 —UN—26MAR21
10. Loosen alternator/fan belt after they have cooled.
11. Remove and clean battery. Store in a cool, dry place.
Keep it charged.1
12. Tie or block clutch pedal in the disengaged position.
13. Coat exposed metal surfaces, such as adjustable front
axles, if extended, with grease or a corrosion inhibitor.

A— Fuel Tank Filler Cap B— Engine Oil Filler Cap

PY15832 —UN—04JUL13
1
Disconnect battery ground cable for short-term storage pe-
riods (20 to 90 days).
Continued on next page WKJQUWJ,0000B70 -19-05JUL21-2/3

150-2 071321

PN=170
Tractor Storage

PY15832 —UN—04JUL13
PY5004 —UN—21MAY05
14. Use tape to seal air inlet hole (A), dust unloader valve
(E), exhaust pipe, crankcase filler (B), fuel caps, and
transmission-hydraulic system filler cap (C).
15. Cover dash with opaque material to prevent gauges
from fading.

PY15833 —UN—09JUL13
16. Raise tires off ground. Protect them from heat and
sunlight.
17. Thoroughly clean tractor. Touch up any painted
surfaces that are scratched or chipped.
18. If tractor must be stored outside, cover it with a
waterproof material.

A—Air Cleaner Inlet Hole C—Transmission-Hydraulic Oil


B—Engine Oil Filler Cap Filler Cap
E—Dust Unloader Valve

WKJQUWJ,0000B70 -19-05JUL21-3/3

150-3 071321

PN=171
Tractor Storage

Remove Tractor From Storage


1. Check tire inflation pressure. (See Wheels, Tires and
Treads section.) Lower tires to ground.
2. Unseal all openings sealed in “Tractor Storage”.
3. Install battery.
4. Remove ties or block which secured clutch pedal down.

PY4485 —UN—16FEB06
5. Check levels of engine oil, transmission-hydraulic oil,
and engine coolant, Add if necessary.
6. Drain a small amount of fuel from fuel tank to purge
any moisture condensation that has collected.
7. Fill fuel tank.
8. Perform all appropriate 10-hour, 50-hour, 250-hour, A—Hand Throttle
and 600-hour services as instructed in Lubrication and
Maintenance section.
9. Check all instruments and indicators by turning key 11. Connect wiring lead to fuel injection pump shut-off
switch to ON position. solenoid.
IMPORTANT: DO NOT operate starter more than 20 12. Depress clutch pedal and start engine. Operate engine
seconds at a time, and wait at least two minutes at slow idle for several minutes. Warm up carefully and
for starter to cool before trying again. check all systems before placing tractor under load.

10. Pull hand throttle (A) all the way down, depress clutch
pedal, and crank engine until oil pressure rises.
SA61034,0000308 -19-18MAR08-1/1

150-4 071321

PN=172
Specifications
John Deere 5045D Tractor
5045D—3029D Naturally Aspirated Engine (At Rated Hydraulics
Engine rpm 2100)
Total flow (with 90% Efficiency) 36.1 L/min
Declared PTO Power 27.8 kW (37.2 hp)
Lifting Capacity 1400 kgf
Maximum Engine Torque 175 N·m @ 1300 rpm
Max. hydraulic power 6.8 kW
Cylinders 3
Bore 106.5 mm Drawbar

Stroke 110 mm Max. drawbar pull without ballast 14.4 kN

Displacement 2.9 L Max. drawbar power 22.48 kW

Compression Ratio 18.5:1


Wheels and Tires
Firing Order 1-2-3
Front Tire 7.5 x 16, 10 PR/ 8.0 x 18, 6
Low Idle 850±50 rpm PR
Fast Idle 2300±50 rpm Rear Tire 13.6 x 28, 6 PR/ 14.9 x 28,
12 PR
Operating Range 1400—2100 rpm
Working Range 800—2350 rpm Dimensions and Weight
Injection Pump Timing 13° BTDC 2WD MFWD
Total Weight 1825 kg 1975 kg
Electrical
Wheel Base 1950 mm 1950 mm
Battery 12 V, 88 Ah
Overall Length 3350 mm 3350 mm
Alternator 42 A
Overall Height (with 2220 mm 2220 mm
Starter 12 V, 2.5 kW Exhaust Pipe)
Overall Width 1775 mm 1775 mm
Transmission
Ground Clearance 460 mm 365 mm
Clutch Type Single/Dual (Option)
Turning Radius with Brake 2.9 m 3m
Gearbox Type Collar Shift
Turning Radius without 3.2 m 3.2 m
Forward Gears 8
Brake
Reverse Gears 4
Standard PTO Speed 540 @ 2050 Erpm Filling capacities

Economy PTO Speed 540 @ 1600 Erpm Fuel Tank 60L


Engine Sump 8.5L (2WD)
Brakes 6.5L (MFWD)

Type Wet Disc Brakes Transmission 32 L (Oil Axle)


30 L (Grease Axle)
Actuation Mechanical
MFWD Housing Axle Oil 5.9 L
Hydraulics Common to transmission

RP32883,0000B82 -19-26MAY20-1/1

155-1 071321

PN=173
Specifications

Ground Speeds
NOTE: Ground speeds are at rated engine
speed, 2100 rpm.

Tire Compatibility Chart


5045D 5045D
Rear Tire 2WD 4WD
13.6-28, 6 PR X X
14.9-28, 12 PR X
Front Tire
7.5-16, 10 PR X
8.0-18, 6 PR X

Speed Chart
Speed Chart
Rear tire size: Rear tire size: Rear tire size:
12.4 x 28 13.6 x 28 14.9 x 28
Rolling Radius- Rolling Radius- Rolling Radius-
590 mm 610 mm 640 mm
Gear Speed (km/h) Speed (km/h) Speed (km/h)
A1 3.13 2.83 2.97
A2 4.6 4.16 4.36
A3 7.18 6.5 6.82
A4 11.32 10.24 10.74
B1 9.44 8.54 8.96
B2 13.88 12.56 13.18
B3 21.69 19.62 20.59
B4 34.18 30.92 32.44
R1 4.1 3.71 3.89
R2 6.03 5.45 5.72
R3 9.42 8.52 8.94
R4 14.84 13.43 14.1

RP32883,0000B83 -19-26MAY20-1/1

155-2 071321

PN=174
Specifications

Metric Bolt and Screw Torque Values


TS1742 —UN—31MAY18

4.8 8.8 9.8 10.9 12.9

4.8 8.8 9.8 10.9 12.9

Class 4.8 Class 8.8 or 9.8 Class 10.9 Class 12.9


a a a
Bolt or Screw Hex Head Flange Hex Head Flange Hex Head Flange Hex Heada Flange
Size Headb Headb Headb Headb
N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in
M6 3.6 31.9 3.9 34.5 6.7 59.3 7.3 64.6 9.8 86.7 10.8 95.6 11.5 102 12.6 112
N·m lb·ft N·m lb·ft N·m lb·ft N·m lb·ft
M8 8.6 76.1 9.4 83.2 16.2 143 17.6 156 23.8 17.6 25.9 19.1 27.8 20.5 30.3 22.3
N·m lb·ft N·m lb·ft N·m lb·ft
M10 16.9 150 18.4 13.6 31.9 23.5 34.7 25.6 46.8 34.5 51 37.6 55 40.6 60 44.3
N·m lb·ft
M12 — — — — 55 40.6 61 45 81 59.7 89 65.6 95 70.1 105 77.4
M14 — — — — 87 64.2 96 70.8 128 94.4 141 104 150 111 165 122
M16 — — — — 135 99.6 149 110 198 146 219 162 232 171 257 190
M18 — — — — 193 142 214 158 275 203 304 224 322 245 356 263
M20 — — — — 272 201 301 222 387 285 428 316 453 334 501 370
M22 — — — — 365 263 405 299 520 384 576 425 608 448 674 497
M24 — — — — 468 345 518 382 666 491 738 544 780 575 864 637
M27 — — — — 683 504 758 559 973 718 1080 797 1139 840 1263 932
M30 — — — — 932 687 1029 759 1327 979 1466 1081 1553 1145 1715 1265
M33 — — — — 1258 928 1398 1031 1788 1319 1986 1465 2092 1543 2324 1714
M36 — — — — 1617 1193 1789 1319 2303 1699 2548 1879 2695 1988 2982 2199
The nominal torque values listed are for general use only with the assumed Replace fasteners with the same or higher property class. If
wrenching accuracy of 20%, such as a manual torque wrench. higher property class fasteners are used, tighten these to the
DO NOT use these values if a different torque value or tightening procedure is strength of the original.
given for a specific application.
For lock nuts, for stainless steel fasteners, or for nuts on U-bolts, see the
tightening instructions for the specific application.

• Make sure that fastener threads are clean.


• Apply a thin coat of Hy-Gard™ or equivalent oil under the head and on the threads of the fastener, as shown in the following image.
• Be conservative with the amount of oil to reduce the potential for hydraulic lockup in blind holes due to excessive oil.
• Properly start thread engagement.
TS1741 —UN—22MAY18

a
Hex head column values are valid for ISO 4014 and ISO 4017 hex head, ISO 4162 hex socket head, and ISO 4032 hex nuts.
b
Hex flange column values are valid for ASME B18.2.3.9M, ISO 4161, or EN 1665 hex flange products.
DX,TORQ2 -19-30MAY18-1/1

155-3 PN=175
071321
Specifications

Unified Inch Bolt and Screw Torque Values


TS1671 —UN—01MAY03

SAE Grade 1a SAE Grade 2b SAE Grade 5, 5.1 or 5.2 SAE Grade 8 or 8.2
c c c
Bolt or Screw Hex Head Flange Hex Head Flange Hex Head Flange Hex Headc Flange
Size Headd Headd Headd Headd
N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in N·m lb·in
1/4 3.1 27.3 3.2 28.4 5.1 45.5 5.3 47.3 7.9 70.2 8.3 73.1 11.2 99.2 11.6 103
N·m lb·ft N·m lb·ft
5/16 6.1 54.1 6.5 57.7 10.2 90.2 10.9 96.2 15.7 139 16.8 149 22.2 16.4 23.7 17.5
N·m lb·ft N·m lb·ft
3/8 10.5 93.6 11.5 102 17.6 156 19.2 170 27.3 20.1 29.7 21.9 38.5 28.4 41.9 30.9
N·m lb·ft N·m lb·ft
7/16 16.7 148 18.4 163 27.8 20.5 30.6 22.6 43 31.7 47.3 34.9 60.6 44.7 66.8 49.3
N·m lb·ft N·m lb·ft
1/2 25.9 19.1 28.2 20.8 43.1 31.8 47 34.7 66.6 49.1 72.8 53.7 94 69.3 103 75.8
9/16 36.7 27.1 40.5 29.9 61.1 45.1 67.5 49.8 94.6 69.8 104 77 134 98.5 148 109
5/8 51 37.6 55.9 41.2 85 62.7 93.1 68.7 131 96.9 144 106 186 137 203 150
3/4 89.5 66 98 72.3 149 110 164 121 230 170 252 186 325 240 357 263
7/8 144 106 157 116 144 106 157 116 370 273 405 299 522 385 572 422
1 216 159 236 174 216 159 236 174 556 410 609 449 785 579 860 634
1-1/8 305 225 335 247 305 225 335 247 685 505 751 554 1110 819 1218 898
1-1/4 427 315 469 346 427 315 469 346 957 706 1051 775 1552 1145 1703 1256
1-3/8 564 416 618 456 564 416 618 456 1264 932 1386 1022 2050 1512 2248 1658
1-1/2 743 548 815 601 743 548 815 601 1665 1228 1826 1347 2699 1991 2962 2185
The nominal torque values listed are for general use only with the assumed Replace fasteners with the same or higher property class. If
wrenching accuracy of 20%, such as a manual torque wrench. higher property class fasteners are used, tighten these to the
DO NOT use these values if a different torque value or tightening procedure is strength of the original.
given for a specific application.
For lock nuts, for stainless steel fasteners, or for nuts on U-bolts, see the
tightening instructions for the specific application.

• Make sure that fastener threads are clean.


• Apply a thin coat of Hy-Gard™ or equivalent oil under the head and on the threads of the fastener, as shown in the following image.
• Be conservative with the amount of oil to reduce the potential for hydraulic lockup in blind holes due to excessive oil.
• Properly start thread engagement.
TS1741 —UN—22MAY18

a
Grade 1 applies for hex cap screws over 6 in (152 mm) long, and for all other types of bolts and screws of any length.
b
Grade 2 applies for hex cap screws (not hex bolts) up to 6 in (152 mm) long.
c
Hex head column values are valid for ISO 4014 and ISO 4017 hex head, ISO 4162 hex socket head, and ISO 4032 hex nuts.
d
Hex flange column values are valid for ASME B18.2.3.9M, ISO 4161, or EN 1665 hex flange products.
DX,TORQ1 -19-30MAY18-1/1

155-4 PN=176
071321
Identification Numbers
Identification Plates component for any John Deere product support program.
Also, they are needed for law enforcement to trace your
Each tractor has the identification plates shown on these tractor if it is ever stolen. ACCURATELY record these
pages. The letters and numbers stamped on the plates characters in the spaces provided in each of the following
identify a component or assembly. ALL these characters photographs.
are needed when ordering parts or identifying a tractor or
PY80265,05G1102 -19-10SEP05-1/1

Record Tractor Serial (Chassis) Number


Serial number plate (A) is located on the right front support
member of the tractor.
Tractor Serial Number

A—Serial Number Plate

APY07684 —UN—30JUL18
DP97633,0000225 -19-30JUL18-1/1

Record Front Axle Serial Number


The front-axle serial number plate (A) is located on the
right rear side of the axle housing.
Front Axle Serial Number

PY1722 —UN—21NOV18
DANA Front Axle
DP79986,0000092 -19-23AUG10-1/1

160-1 071321

PN=177
Identification Numbers

Record Engine Serial Number


Serial number plate (A) is located on the right-hand side
of the engine block between the starter solenoid and the
hydraulic pump.
Engine Serial Number

PY5154 —UN—21AUG05
PY80265,05G1105 -19-10SEP05-1/1

ROPS Serial Number


ROPS serial number plate (A) is located on left - hand
side of the ROPS (inner side).
Record serial number below.
ROPS Serial Number ________________________

A—ROPS Serial Number Plate

APY41720 —UN—11SEP20
WKJQUWJ,0000B71 -19-05JUL21-1/1

Record Transmission Serial Number


Transmission serial number is stamped into the lower
left-hand corner of rear housing (A).
Transmission shield is removed for better quality of picture

PY4178 —UN—03SEP04
Transmission Serial Number

Transmission Serial number


NR25796,0000358 -19-04AUG06-1/1

160-2 071321

PN=178
Lubrication Maintenance Record Charts
50, 250 Hour Service Chart
Every 50 Hours • Service air cleaner
• Inspect and adjust alternator/fan belt
• Check transmission-hydraulic system oil level • Lubricate 3-point hitch
• Check MFWD axle hub oil level • Check neutral start system
• Clean and check battery • Check clutch pedal free play
• Inspect all tyres • Check brake pedal adjustment
• Lubricate front axle pivot pin • Change primary and secondary filter inserts alternatively
• Lubricate steering spindles
• Inspect tractor for loose nuts and bolts
Every 250 Hours

• Change engine oil and filter


Hours Hours
Date Date
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
BS13987,0000269 -19-24JAN13-1/1

165-1 071321

PN=179
Lubrication Maintenance Record Charts

500,600 Hour Service Chart


Every 500 Hours • Tighten engine air intake hose clamps
• Check cooling system for leaks
• Replace transmission-hydraulic filter • Lubricate rear axle bearings
Every 600 Hours • Check engine idle speeds
• Have your John Deere dealer:
• Change oil in MFWD axle housing - Check front axle pivot pin
• Adjust engine valve clearance IMPORTANT: External lubrication is not required
• Clean crankcase vent tube for oil type rear axle
• Repack front wheel bearings
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
SV86979,00005FF -19-07NOV13-1/1

165-2 071321

PN=180
Lubrication Maintenance Record Charts

1250 Hour Service Chart


Every 1250 Hours • Clean transmission-hydraulic pickup screen
• Change transmission-hydraulic oil and filter
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
AH98466,00000C5 -19-01JUN07-1/1

165-3 071321

PN=181
Lubrication Maintenance Record Charts

Annual Service Chart


Annually • Replace air cleaner elements
• Change engine oil and filter
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
PY80265,05G1110 -19-10SEP05-1/1

165-4 071321

PN=182
Lubrication Maintenance Record Charts

2000 Hour Service Chart


Every 2 Years or 2000 Hours (Whichever Comes First)
• Flush cooling system
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
PY80265,05G1111 -19-10SEP05-1/1

165-5 071321

PN=183
Lubrication Maintenance Record Charts

As Required Service Chart


Service as Required • Service air cleaner
• Adjust throttle friction
• Replace fuel filter
• Drain water and sediment from fuel tank
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
Hours Hours
Date Date
PY80265,05G1112 -19-10SEP05-1/1

165-6 071321

PN=184
John Deere Service
John Deere Parts
We help minimize downtime by putting genuine John
Deere parts in your hands in a hurry. That’s why we
maintain a large and varied inventory to meet your spare
parts needs.

TS100 —UN—23AUG88
PY00013,0000003 -19-14JUN01-1/1

The Right Tools


Precision tools and testing equipment enable our Service
Department to locate and correct troubles quickly. They
save your time and money.

TS101 —UN—23AUG88
PY00013,0000004 -19-14JUN01-1/1

Well Trained Technician


School is never out for John Deere service technicians.
Training schools are held regularly to be sure our
personnel know your equipment and how to maintain it.
Result?

TS102 —UN—23AUG88
Experience you can count on!

PY00013,0000005 -19-14JUN01-1/1

170-1 071321

PN=185
John Deere Service

Prompt Service
Our goal is to provide prompt, efficient care when you
want it and where you want it. We can make repairs at
your place or at ours, depending on the circumstances.
see us, depend on us.We'll be around when you need us.

TS103 —UN—23AUG88
PY00013,0000006 -19-14JUN01-1/1

170-2 071321

PN=186
Index
Page
Page
A
Booster battery ........................................................... 45-7
Acid burns, battery.................................................. 140-13 Brake pedal free play
Adjust rockshaft speed-of-drop Check and adjust ...................................................110-4
Implement lock........................................................ 55-5 Brakes
Adjustments Use.......................................................................... 50-6
Rockshaft sensing lever friction .............................55-11 Brakes troubleshooting............................................. 145-5
Air cleaner Break-in ...................................................................... 35-1
Inspect primary element........................................ 140-6 Break-in engine oil
Replace elements ................................................. 125-1 Non-Emissions certified and certified tier
Service ....................................................... 110-1, 135-1 1, tier 2, tier 3, stage I, stage II, and stage III........ 85-5
Service/regular intervals ....................................... 140-4 Break-in service................................................. 35-1, 90-1
Store primary element........................................... 140-6
Air intake system C
Check.................................................................... 140-4
Components.......................................................... 140-3 Cast iron weights ........................................................ 70-5
Air restriction indicator ................................................ 45-3 Install rear ............................................................... 70-6
Alternator wiring Center link
Connect............................................................... 140-16 Position ................................................................... 55-7
Alternator/fan belt Charge system indicator............................................. 45-3
Inspect and adjust..................................................110-2 Check Toe-In .............................................................. 75-7
Alternator/fan belt, replace ....................................... 140-7 Clutch pedal free play
Attach implements to three point hitch ....................... 55-8 Check and adjust ...................................................110-3
Attach PTO-driven implement .................................... 65-3 Connect single acting cylinder.................................... 60-3
Attach tipping trailer.................................................... 55-6 Control lever and coupler identification ...................... 60-1
Avoid static electricity risk when fueling ..................... 05-4 Coolant
Check level ............................................................. 95-1
B Diesel engine .......................................................... 85-5
Coolant temperature gauge........................................ 45-4
Ballast................................................................ 70-1, 70-4 Cooling system
Front end for transport ............................................ 70-4 Components.......................................................... 140-9
Limitations............................................................... 70-3 Flush every two years ........................................... 130-1
Liquid weight ........................................................... 70-7 Correct hose tips ........................................................ 60-1
Match to load work.................................................. 70-1 Cylinder, extend/retract
Maximum front ........................................................ 70-5 No. 1 SCV............................................................... 60-4
Maximum rear ......................................................... 70-5
Select ...................................................................... 70-1 D
Battery
Access .................................................................140-11 Dash panel ................................................................. 15-5
Acid burn treatment............................................. 140-13 Diesel engine oil
Booster.................................................................... 45-7 Tier 3 and stage IIIA................................................ 85-4
Charge ................................................................ 140-15 Diesel fuel................................................................... 85-2
Check condition .................................................. 140-12 Differential lock
Clean and check ................................................... 100-1 Use.......................................................................... 50-7
Removing............................................................ 140-12 Draft control, use ........................................................ 55-4
Replacement specifications ................................ 140-15 Drawbar ...................................................................... 65-2
Service ................................................................ 140-13 Load limitations ....................................................... 65-2
Battery explosion .................................................... 140-12 Swinging ................................................................. 65-1
Battery Handling, Safety Driving on public roads ...................................... 50-3, 80-1
Safety, Battery Handling ....................................... 05-15
Before starting the engine .......................................... 45-1 E
Bolt and screw torque values
Metric .................................................................... 155-3 Electrical service precautions ..................................140-11
Unified inch ........................................................... 155-4 Electrical system troubleshooting ............................. 145-8
Bolts Engine
Front axle, tighten ................................................... 75-3 Avoid idling.............................................................. 45-5
Rear axle, tighten.................................................... 75-4 Break-in oil ............................................................ 140-2

Continued on next page

Index-1 071321

PN=1
Index

Page Page

Change oil and filter ...............................................110-1


Change speeds....................................................... 45-4 H
Check idle speeds..................................................115-3
Check oil level......................................................... 95-1 Hardware
Observe work and idle speeds................................ 45-5 Wheel/axle, tighten ................................................. 75-3
Stalled ..................................................................... 45-5 Hardware torque values
Stop......................................................................... 45-6 Metric .................................................................... 155-3
Troubleshooting .................................................... 145-1 Unified inch ........................................................... 155-4
Warm up ................................................................. 45-5 Headlights................................................................... 20-1
Engine crankcase vent tube Adjust .................................................................. 140-17
Clean......................................................................115-2 Aim...................................................................... 140-17
Engine oil Replace bulb ....................................................... 140-18
Break-In High beam indicator.................................................... 20-2
Non-Emissions certified and certified Hitch
tier 1, tier 2, tier 3, stage I, stage II, Adjust side sway ..................................................... 55-9
and stage III....................................................... 85-5 Components............................................................ 55-1
Diesel Level ..................................................................... 55-10
Tier 3 and stage IIIA ............................................ 85-4 Lubricate three-point ..............................................110-2
Exhaust Filter, Safety Hood, raise ............................................................... 140-3
Safety, Exhaust Filter ............................................ 05-18 Hoses and hose clamps, check.................................115-2
Hydraulic cylinder hoses, connect .............................. 60-2
F Hydraulic oil ................................................................ 85-6
Hydraulic system troubleshooting............................. 145-5
Fan/alternator belt, replace....................................... 140-7 Hydraulic-transmission filter element.......................... 85-6
Flood lamp.................................................................. 20-5
Front axle pivot pin I
Check.....................................................................115-3
Lubricate ............................................................... 100-2 Identification numbers .............................................. 160-1
Fuel Idle speeds, check.....................................................115-3
Diesel ...................................................................... 85-2 Implement to tire clearance ........................................ 75-1
Fill tank.................................................................... 85-3 Implement, prepare .................................................... 55-6
Storage ................................................................... 85-1 Indicator
Watch level ............................................................. 45-4 Air restriction ........................................................... 45-3
Fuel consumption, reducing ....................................... 50-1 Charge system........................................................ 45-3
Fuel filter Oil pressure............................................................. 45-3
Drain ....................................................................... 95-2 Instrument panel......................................................... 15-5
filter ........................................................................110-2
Fuel system L
Bleed (MICO injection pump)................................ 140-8
Bleeding fuel injection nozzles.............................. 140-8 Lateral float, adjusting .............................................. 55-10
Components.......................................................... 140-7 Light
Fuels and lubricants ................................................... 85-1 Hazard .................................................................... 20-4
Fuses Light switch
Locate ................................................................. 140-16 Operation ................................................................ 20-1
Size and function ................................................ 140-16 Lighting and signals.................................................... 20-1
Lubricant
G Storage ................................................................... 85-4
Lubrication and maintenance record charts ............. 165-1
Gauge
Coolant temperature ............................................... 45-4 M
Grease
Multipurpose Extreme Pressure (EP) ..................... 85-7 Metric bolt and screw torque values ......................... 155-3
Grille screens, cleaning .......................................... 140-10 Multipurpose Extreme Pressure (EP) grease ............. 85-7
Ground speeds ......................................................... 155-2
N
Neutral lever position.................................................. 60-3

Continued on next page

Index-2 071321

PN=2
Index

Page Page

Neutral start system, check .......................................110-3 Tires, service safely .............................................. 05-21
Towed equipment, transport at safe speeds ..........05-11
O Tractor, operating safely ......................................... 05-8
Use caution on slopes, uneven terrain,
Oil and rough ground................................................ 05-12
Engine Safety, Avoid High-Pressure Fluids
Tier 3 and stage IIIA ............................................ 85-4 Avoid High-Pressure Fluids .................................. 05-22
Engine break-in..................................................... 140-2 Safety, Fire Prevention
Hydraulic ................................................................. 85-6 Fire Prevention........................................................ 05-3
Transmission........................................................... 85-6 Safety, Forestry Operations
Warm hydraulic system..........................................55-11 Limited Use in Forestry Operation .......................... 05-9
Oil cooler, cleaning ................................................. 140-10 Safety, Handle Fuel Safely, Avoid Fires
Oil pressure indicator.................................................. 45-3 Avoid Fires, Handle Fuel Safely.............................. 05-3
Operate Park Brake Lever.......................................... 25-3 Safety, ROPS
Operate transmission ................................................. 50-5 ROPS, Keep Installed Properly............................... 05-5
Operator training......................................................... 50-3 Safety, Steps and Handholds
Operator’s Manual...................................................... 10-1 Use Steps and Handholds Correctly....................... 05-6
Safety, Tightening Wheel Retaining
P Bolts/Nuts
Tightening Wheel Retaining Bolts/Nuts ................ 05-22
Pictorial Safety Signs.................................................. 10-1 Seat
Position center link ..................................................... 55-7 Select position......................................................... 25-2
Position control lever stop, set.................................... 55-2 Select a gear .............................................................. 50-6
Prepare implement ..................................................... 55-6 Service
Prestart checks........................................................... 40-1 10 hours .................................................................. 95-1
PTO 100 hours ...............................................................110-1
Adjust clutch rod ..................................................... 65-5 1200 hours ............................................................ 120-1
Attach driven implement ......................................... 65-3 250 hours ...............................................................110-1
Operate ................................................................... 65-4 50 hours ................................................................ 100-1
As required............................................................ 135-1
Service intervals ......................................................... 90-2
R Service intervals, observe .......................................... 90-1
Seven-terminal outlet.................................................. 20-6
Radiator, cleaning................................................... 140-10 Signal words, understand ........................................... 05-1
Rear axle bearings, lubricate.....................................115-3 Signals........................................................................ 20-1
Refueling, avoid static electricity risk.......................... 05-4 Speed/hour meter....................................................... 45-6
Remote hydraulic cylinders troubleshooting............. 145-7 Start the engine .......................................................... 45-2
Remove tractor from storage.................................... 150-4 Starter wiring, connect............................................ 140-15
Reversed cylinder response, correct .......................... 60-3 Steering spindles, Adjustable front axle, lubricate.... 100-2
Ride comfort, adjust.................................................... 25-2 Steering spindles, lubricate ...................................... 100-2
Riders ......................................................................... 10-2 Stopping tractor .......................................................... 50-8
Rockshaft Storing lubricants........................................................ 85-4
Postion control ........................................................ 55-3 Storing tractor ........................................................... 150-1
Rate-of-drop adjustment ......................................... 55-5
Rockshaft and quick-coupler 3-point hitch
troubleshooting ..................................................... 145-6 T
Rockshaft control levers ............................................. 55-2
Rockshaft sensing lever friction Tail light....................................................................... 20-2
Adjustment .............................................................55-11 Replace bulb ....................................................... 140-19
ROPS ............................................................ 10-4, 140-20 Three-point hitch, lubricate ........................................110-2
ROPS - OOS .............................................................. 25-1 Throttle friction, adjust .............................................. 135-1
Tipping trailer, attach .................................................. 55-6
Tires
S Check.................................................................. 140-19
Compatibility chart ................................................ 75-10
Safety Inflation pressure .................................................... 75-2
Protect against noise .............................................. 05-2 Inflation pressure chart ........................................... 75-2
Rotating drivelines, stay clear ................................. 05-6 Tires, service safely.................................................. 05-21
Safe maintenance, practice .................................. 05-17

Continued on next page

Index-3 071321

PN=3
Index

Page Page

Toe-in Electrical system ................................................... 145-8


Adjust ...................................................................... 75-8 Engine................................................................... 145-1
Toe-in, 2-WD tractor Hydraulic system................................................... 145-5
Adjust ...................................................................... 75-9 Quick-coupler 3-point hitch ................................... 145-6
Torque charts Remote hydraulic cylinders................................... 145-7
Metric .................................................................... 155-3 Rockshaft .............................................................. 145-6
Unified inch ........................................................... 155-4 Transmission......................................................... 145-4
Torque values Turn signals ................................................................ 20-3
Adjustable front axle ............................................... 75-3
Rear axle................................................................. 75-4 U
Wheels/axles........................................................... 75-3
Tow tractor .................................................................. 80-4 Unified inch bolt and screw torque values ................ 155-4
Towed equipment, transport at safe speeds..............05-11 Use
Tractor controls........................................................... 15-1 Brakes..................................................................... 50-6
Tractor PTO, operate.................................................. 65-4 Cast iron weights .................................................... 70-5
Tractor, operating safely ............................................. 05-8 Differential lock ....................................................... 50-7
Transmission oil.......................................................... 85-6 Draft control ............................................................ 55-4
Transmission troubleshooting................................... 145-4 Flood lamp .............................................................. 20-5
Transmission, operate ................................................ 50-5 Tail lights ................................................................. 20-2
Transmission, shifting................................................. 50-5 Turn signals ............................................................ 20-3
Transmission-hydraulic system Using
Change oil and filter .............................................. 120-1 Headlights ............................................................... 20-1
Check oil level....................................................... 100-1
Clean pickup screen ............................................. 120-2 W
Replace filter ..........................................................112-1
Transport .................................................................... 80-3 Warm hydraulic system oil.........................................55-11
Tread settings Warning light
Adjustable front axle ............................................... 75-6 Replace bulb ....................................................... 140-19
Multi-position rear wheels ....................................... 75-5 Weights
Tread width Cast iron.................................................................. 70-5
Adjusting front axle, late model tractor.................... 75-7 Install rear cast iron................................................. 70-6
Rear wheel limitations............................................. 75-4 Wheel slip
Troubleshooting Measure manually................................................... 70-3
Brakes................................................................... 145-5

Index-4 071321

PN=4
Index

Index-5 071321

PN=5
Index

Index-6 071321

PN=6

You might also like