Professional Documents
Culture Documents
BATHINDA
Mechanical Engineering
MMM Lab
LIST OF EXPERIMENTS
1. Measurement of an angle with the help of sine bar.
2. Measurement of surface roughness of a machined Plate, Rod and Pipe.
3. Measurement of gear elements using profile projector.
4. Measurement of thread element by Tool maker microscope.
5. Use of stroboscope for measurement of speed of shaft.
6. Calibration of Micrometer using slip gauges.
Thermal Lab
LIST OF EXPERIMENTS
1. Determination of the calorific value of a given fuel and its flash & fire points
2. Study the construction and operation of 2 stroke and 4 stroke Petrol and Diesel engines; and
draw the valve timing diagram.
3. Determine the brake power, indicated power, friction power and mechanical efficiency of a
multi-cylinder petrol engine running at constant speed (Morse Test).
4. Performance testing of a petrol engine from no load to full load (at constant speed) for a single
cylinder/ multi- cylinder engine in terms of brake power, indicated power, mechanical
efficiency and specific fuel consumption and to measure the smoke density. Also make the heat
balance sheet.
5. Performance testing of a diesel engine from no load to full load (at constant speed) for a single
cylinder/…
HT Lab
LIST OF EXPERIMENTS
1 To study and compare temperature distribution, heat transfer rate, overall heat transfer in
parallel flow and counter flow heat exchanger.
2. To find out total thermal resistance and total thermal conductivity of composite wall.
3. . To study the temperature distribution along the length of fin in Forced convection and
Natural Convection
4. To determine heat transfer coefficient in drop wise and film wise condensation.
5. . To study the phenomenon of the boiling heat transfer and to plot the graph of heat flux
versus temperature difference.
6. . To determine the emissivity of given test plate surface
9. To analyze the motion of a motorized gyroscope when the couple is applied along its spin
axis.
10. Velocity ratios of simple, compound, Epicyclic and differential gear trains.
11. Kinematics of four bar, slider crank, crank rocker, double crank, double rocker and
Oscillating cylinder mechanisms.
12. Cam & follower and motion studies.
LIST OF EXPERIMENTS
1. Modeling of machine parts and components using any 3D modeling software.
2. Assembling of any two machine parts with proper mating conditions and checking of tolerances and fits using CAD
software.
10. Study of reciprocating movement of double acting cylinder using pneumatic direction control valves.
11. Use of direction control valve and pressure control valves clamping devices for jig and fixture.
LIST OF EXPERIMENTS
1. Study of various elements of a vapour compression refrigeration system through cut section models / actual
apparatus.
6. Visit to a central Air conditioning plant for study of processes for winter and summer air conditioning.