Professional Documents
Culture Documents
SERVICE BULLETIN
BULLETIN NO: TSB00040
RELEASE DATE: 6/23/11
EFFECTIVITY
1. Bendi B40i4 Lift Trucks between the s/n's of 6409 and 6604.
REASON
DESCRIPTION
REQUIRED EQUIPMENT
1. 166446 Kit, B40i4 Drive Filter Plumbing. Kit contains parts shown in figure 1.
2. A clean drain pan/container to contain up to 10 gallons of hydraulic fluid. Oil can be saved and
reused if a clean drain pan is used and the oil is kept clean during this repair.
3. Various hand tools, including a 7/32 hex wrench and 1-3/8 wrench.
COMPLIANCE
At the next available service event (preventative or unplanned downtime) the filter bracket must
be reversed and new hose installed.
LABOR
A properly completed warranty claim must be submitted, on which 1.0 hour will be approved to perform
this modification. Contact Landoll Service for a call number prior to beginning any work.
MODIFICATION PROCEDURE
1. Drain hydraulic fluid to a level that is below the upper return tee in the hydraulic reservoir.
2. Remove existing drive filter, p/n: 146356, discard, see Figure 2.
3. Remove bypass tube,p/n:161902, that connects the drive filter mount to the upper return tee and
the adapter, p/n:104382, that is in the bypass port of the filter bracket, discard. See Figures 3 and
4.
4. Disconnect filter status indicator wiring connector and cut nylon tie that is holding the wire to
filter mount. See Figure 4.
5. Install new adapter, 0018104, into bypass port with #8 port facing down.
LANDOLL CORP. WARRANTY DEPARTMENT
PHONE: 1-800-446-5175
6. Remove 4 mounting screws, (7/32 Hex) See Figure 4.
7. Rotate filter mount 180 degrees, bypass port is towards the center of the truck with the filter
sensor on the right side of installed filter mount. Re-attach using exiting screws and tighten.
8. Connect drive fluid hoses and tighten.
9. Attach new bypass hose between upper return tee and the new adapter; tighten. See Figure 5.
10. Lubricate element o-ring and threads, Install new filter element on mount; tighten.
11. Add hydraulic fluid to reservoir, fill to a level that is between the two marks in the sight glass. Use
Mobil 424 or equivalent to top off fluid level.
12. Start truck, check for leaks.
13. Repair leaks as necessary, return truck to service.
0018104, ADAPTER
166447, HOSE
105-0214, TY-WRAP
104382, Adapter
Connector
166447, Hose