Professional Documents
Culture Documents
Sonajero Mono
Sonajero Mono
Work in a continuous spiral, do not join rounds or turn your work, unless
instructed otherwise in the pattern.
Use a stitch marker or a piece of yarn to mark the end or the beginning of a
round. Move the marker up after completing each round.
All stitches are worked into both loops, unless instructed otherwise in the
pattern.
Make sure to crochet tightly enough to achieve a tight gauge that will not
allow the stuffing to show through the fabric. You can use the same pattern
to make larger or smaller toys by using finer or bulkier yarn. Make sure to pick
a crochet hook at least a size smaller than suggested on the yarn label and
crochet tightly enough to achieve a tight gauge that will not allow the
stuffing to show through the fabric. You may also need to adjust the size of
the eyes.
Contact Info
Pattern includes unlimited support from me over email, FB or Etsy message
Svetochka19999@mail.ru
https://www.etsy.com/shop/ToysByKnitFriends
https://www.facebook.com/svetlana.altunina.5
My Instagram @knit.friends
Size: When using these materials monkey teether turns 10.5 cm or 4.13 inches tall.
ABBREVIATIONS (US)
• st(s) = stitch(es).
• Sl st = slip stitch.
• ch = chain stitch.
• sc = single crochet stitch.
• hdc = half double crochet stitch.
• dc = double crochet stitch.
• inc = increase – crochet two single crochet stitches in the same stitch.
• dec = decrease – crochet two stitches together.
• (sc 4, inc) * n = repeat the pattern between parentheses n times.
• (36) = number of stitches in a round after finishing round.
Eye circles.
10 hdc in a magic ring. In this case, don’t tighten the ring immediately: first crochet
10 hdc, insert the eye into the magic ring, then pull it around the eye. Connect the
row with sl st, fasten the thread and leave a long end for sewing.
Tail.
1 row: 6 sc in a magic ring (6)
Crochet to the desired length. Approximately 15-17
rows. Fasten the thread and leave a long end for
sewing.
Muzzle.
1 row: Crochet 6 ch. Crochet in the chains starting into the second loop from the
hook: 4 sc, 3 sc in last st, continue on the other side of chain 3 sc, 1 inc (12). ↓ The
first row is shown in the photo ↓
Leaves.
Crochet the first leaf (oval, similar to the muzzle): Crochet 8 ch. Crochet in the
chains starting into the second loop from the hook 1 sl st, 1 sc, 1 hdc, 2 dc, 1 hdc,
2 sc in last st, continue on the other side of chain 1 sc, 1 hdc, 2 dc, 1 hdc, 1 sc, 1 sl
st, do not cut the thread.
Crochet the part of this detail that will wrap around the ring.
Crochet 10 ch, crochet in the chains starting into the second loop from the hook 9
sc. Do not cut the thread.
Next, crochet a second leaf: crochet 8 ch, crochet in the chains starting into the
second loop from the hook 1 sl st, 1 sc, 1 hdc, 2 dc, 1 hdc, 1 sc, 2 sc in last st,
continue on the other side of chain 1 hdc, 2 dc, 1 hdc, 1 sc, 1 sl st.
Fasten the thread and leave a long end for sewing parts around the ring.
Then with the same thread continue to embroider a smiling mouth. Pull the needle
in the upper corner of the mouth and make a stitch to the lower corner of the
mouth, while pulling the needle in the middle of the mouth in front of thread. Make
a small stitch, but do not tighten the thread so that the mouth does not turn out
angular. Fasten the thread and cut it off.
8. Sew a leaf around
the ring.