Professional Documents
Culture Documents
Zid Anexa 1
Zid Anexa 1
outside
3 6
100 5
228,5
15 4
100 www.ubakus.de
3
10 1 2
inside
1 OSB/3 (10 mm) 3 ISOVER Topdec Loft (100 mm) 5 Cellulose (100 mm)
Commercial use only with Plus-, PDF- or Profi-Option (from 2.99 € / month plus VAT).
2 Vapor retarder sd=2,3m 4 OSB (15 mm) 6 weber.pas 430 AquaBalance (3 mm)
0 20 40 60 80 100 120 140 160 180 200 220 240 260 280 300 320 mm
08 Ti au ,25 ,1
41 5 i ge ub =0 nd U =0
N r e U ta s
DI O 9 nied 4N s au
t zV nd E V1 Be nd au sivh
u a n V ta
ch st E E
En Bes Neu u
b
P as
es V Be 0 a =0,2
r m E 2 1 6 b ,15
ä En 20 EV Neu V U .
W G n n U =0
GE E 20 nM aß 40
20 ESa elm 5 us
G z 5 r- Ha KfW
GE e
Ein fW BW -Lit bau
f W u K eG 3 u
K a Ne
e ub ärm
N EW
*Vergleich mit dem Höchstwert gemäß GEG 2020 für erstmaligen Einbau, Ersatz oder Erneuerung von Außenwänden (Anlage 7, Zeile 1a,1b). Page 1
All statements without guarantee
Temperature profile
Temperature profile
20 Temperature
18 Dew point
1
16
2 3 4 5 6
14
12 1 OSB/3 (10 mm)
Temperature [°C]
Commercial use only with Plus-, PDF- or Profi-Option (from 2.99 € / month plus VAT).
www.ubakus.de Outside
Temperature and dew-point temperature in the component. The dew-point indicates the temperature, at which water vapour
condensates. As long as the temperature of the component is everywhere above the dew-point temperature, no
condensation occurs. If the curves have contact, condensation occurs at the corresponding position.
Page 2
All statements without guarantee
Moisture proofing
For the calculation of the amount of condensation water, the component was exposed to the following constant climate for
90 days: inside: 20°C und 50% Humidity; outside: -5°C und 80% Humidity. This climate complies with DIN 4108-3.
This component is free of condensate under the given climate conditions.
Humidity
Commercial use only with Plus-, PDF- or Profi-Option (from 2.99 € / month plus VAT).
The temperature of the inside surface is 18,9 °C leading to a relative humidity on the surface of 54%.Mould formation is not
expected under these conditions.
The following figure shows the relative humidity inside the component.
Page 3
All statements without guarantee
Heat protection
The following results are properties of the tested component alone and do not make any statement about the heat protection
of the entire room:
Temperature profile
This document has been generated by the U-value calculator on www.ubakus.de. If you are harmed by the free use of these contents, the service provider is only liable in case of
32 2 3 4 5 6
30 1 OSB/3 (10 mm)
Temperature [°C]
Commercial use only with Plus-, PDF- or Profi-Option (from 2.99 € / month plus VAT).
16
14
0 50 100 150 200 250
Inside [mm]
www.ubakus.de Outside
Page 4