Professional Documents
Culture Documents
INTERLEAVED MID
PV
BOOST POINT SRM
PANNEL
CONVERTER CONVERTER
MPPT
PROPOSED CONVERTER CIRCUIT
MODES OF OPERATION
• MODE 1:
• (Switch on period t2-t1): The flow of current during turn on period in
both SEPIC and Cuk converter is shown
• The input inductor starts charging with a slope of ()mi VtL, whereas
selection of Li is made such that current always remains continuous
through the inductor.
• The capacitors C1 and C2 of Cuk and SEPIC converters configuration
start discharging across output side inductors Lo1 and Lo2.
• As diodes D1 and D2 do not conduct during this mode, the load current
requirement is fulfilled by output capacitor.
MODE 1:
• MODE 2:
• (Switch off period t3-t2): This mode explains the
switch off period of the switching cycle.
• In this mode, the capacitors C1 and C2 of both Cuk
and SEPIC converters start charging through
common input side inductor Li and the load
current requirement is fulfilled by the two output
side inductors Lo1 and Lo2 as shown
• In this mode, both the ultrafast diodes, D1 and D2
are forward biased, thus capacitor charging
current and output inductor discharging current
are found in their path through these two diodes.
MODE 2:
• MODE 3:
• (DCM mode t3-t4): During this mode, the
currents through inductors Lo1 and Lo2 enter
discontinuous conduction mode as shown in
Figure.
• The diodes D1 and D2 provide the path for
constant freewheeling current, as constant
current flows through Li, Lo1 and Lo2.
• The constant charging of capacitors C1 and C2
take place through an input inductor.
• This mode lasts for until the next switching
period.
MODE 3:
REFERENCES