The entablature is the cylinder block that houses the cylinder liners and incorporates spaces for scavenge air and cooling water. It is made of cast iron and can be cast individually per cylinder or in multi-cylinder units that are then bolted together. The underside of the entablature is machined and aligned on A-frames before being fastened with fitted bolts for alignment purposes only, as tie bolts are needed to resist firing forces.
The entablature is the cylinder block that houses the cylinder liners and incorporates spaces for scavenge air and cooling water. It is made of cast iron and can be cast individually per cylinder or in multi-cylinder units that are then bolted together. The underside of the entablature is machined and aligned on A-frames before being fastened with fitted bolts for alignment purposes only, as tie bolts are needed to resist firing forces.
The entablature is the cylinder block that houses the cylinder liners and incorporates spaces for scavenge air and cooling water. It is made of cast iron and can be cast individually per cylinder or in multi-cylinder units that are then bolted together. The underside of the entablature is machined and aligned on A-frames before being fastened with fitted bolts for alignment purposes only, as tie bolts are needed to resist firing forces.
The Entablature • The entablature is the name given to the cylinder block which incorporates the scavenge air space and the cooling water spaces. • It forms the housing to take the cylinder liner and is made of cast iron. • castings are either for individual cylinders which after machining on the mating surfaces are bolted together to form the cylinder beam, or they may be cast in multi - cylinder units, which are then bolted together. • The underside of the cylinder beam is machined and then it is aligned on the A frames and fastened in position using fitted bolts
• It is important to remember that the fitted bolts used to
bolt the entablature, A frames and Bedplate together are for alignment and location purposes only. • They are not designed to resist the firing forces which will tend to separate the three components. This is the job of the tie bolts. • In the photograph opposite, the liners can be seen in place in the entablature. Note also the diaphragm plate and the stuffing box housing. Entablature Mounted On A Frame With Liners In Place
Bearings And Bearing Metals: A Treatise Dealing with Various Types of Plain Bearings, the Compositions and Properties of Bearing Metals, Methods of Insuring Proper Lubrication, and Important Factors Governing the Design of Plain Bearings