Professional Documents
Culture Documents
2. . Introduction
In this module, the history of the structural code of the Philippines will be taken up, the reasons for
updating the structural code, the bases for updating the code and
some updates in comparison to previous provisions.
3. Learning Outcomes
products and services for all concerned with the safety and
NSCP 2015, 7 TH
EDITION
RELEASE OF
NSCP 7TH EDITION
NSCP 2010 NSCP 2015
SIGNIFICANT
REVISION TO
NSCP 2015
PROVISION MINOR CHANGES MAJOR CHANGES
CHAPTER 1 – SECTION 103 – Classification SECTION 103 – Classification
GENERAL of Structures of Structures
REQUIREMENTS Churches, Mosque and other related
-The provision for deflection of religious structures are under the
any structural member under special occupancy category.
the serviceability requirement
is deleted.
The revisions made in this chapter are following: c.6 The figure for cut slopes has been amended for clarity;
c. 1 Provisions pertaining to the conduct and interpretation of c.7 The figure for fill slopes has been amended for clarity and some
foundation investigation for cases involving liquefiable, provisions have been modified;
expansive or questionable soils are adopted;
c.8 A table on the minimum required number of boreholes has been
c. 2 The section on footings is amended to incorporate added to the section on foundation investigation;
provisions for differential settlement, design load and vibratory
loads. c. 9 Provisions pertaining to minimum dimension of ditches have
been modified;
c. 3 The section on the foundations is amended to incorporate
new provisions in splicing of concrete piles; and c.10 The section on excavations and fills has been amended to
incorporate provisions for scouring and erosion protection as well as
c. 4 The section on special foundations, slope stabilization and support of excavation and open cuts;
materials of construction are added.
c.11 Provisions pertaining to general pile requirements have been
c. 5 Provisions on construction in Zone 4 pertaining to expand to include design of piles and pile groups subjected to lateral
reinforcement of Precast Prestressed Piles have been revised to loads.
ensure consistency with ACI 318.
c.12 A section on MSE Structures and Similar Reinforced
Embankments and Fills has been added.