Professional Documents
Culture Documents
LCA - Mesh & Nodal Analysis Problems
LCA - Mesh & Nodal Analysis Problems
Page 1 of 5
6. For the beginners, before you rush out to your archery set for an arrow, the symbol in the circuit below is a DC current source (hard to find at Radio Shack). In Multisim/EWB look under Place, Component, Sources, Signal_current sources, DC CURRENT. As you can guess the current goes in the direction of the arrow. The other 'funny symbol' is a battery (easily found at Radio Shack, under the hood of your car, etc.) Look around in EWB and you will find it! :) Back
Figure 1 - Problem 1 # 1. Find the voltage across R2. Answer Nodal Equations Mesh Equations
3/15/2008
Page 2 of 5
Figure 2 - Problem 2 # 2. Find the node voltages V1 and V2. Answer Nodal Equations Mesh Equations
Figure 3 - Problem 3 # 3. Find the current through R2 and R3 Answer Nodal Equations Mesh Equations
3/15/2008
Page 3 of 5
Figure 4 - Problem 4 # 4. Find the voltage across R3 Answer Nodal Equations Mesh Equations
Figure 5 - Problem 5 # 5. Find the current through R3 Answer Nodal Equations Mesh Equations
3/15/2008
Page 4 of 5
Figure 6 - Problem 6 # 6. Find the voltage across the 1A current source Answer Nodal Equations Mesh Equations
Figure 7 - Problem 7 # 7. Find the current labeled "I" Answer Nodal Equations Mesh Equations
3/15/2008
Page 5 of 5
Figure 8 - Problem 8 # 8. Find the voltage across R1, R2 and R3. Answer Nodal Equations Mesh Equations
Figure 9 - Problem 9 # 9. Find the current labeled "I" Answer Nodal Equations Mesh Equations
3/15/2008