Professional Documents
Culture Documents
Cat 3516B-2250 en
Cat 3516B-2250 en
Energy Systems
Hasenmattstrasse 2
CH 4901 Langenthal / BE
www.avesco.ch
info@avesco.ch
Tel:
Fax:
Ref:
Date:
DIN/ISO 3046
Low Emission, 60 C ACT
Prime
Standby
2000 kVA
2250 kVA
1600 kW
1800 kW
516DE90
DM8358
DM8355
Diesel Engine
Brand
Type
No. of Cylinders / Alignment
Cycle
Cooling Method
Fuel
Speed
Bore
Stroke
Displacement
Compression Ratio
Aspiration
Fuel System
Base Tank Capacity
Jacket Water heaters
Starting Motor
Battery Type
Quantity
Capacity per Battery / total
Caterpillar
3516B TA
16 / V
4-Stroke
Water-cooled
Diesel
1500 rpm
170.00 mm
190.00 mm
69.00 L
14.0:1
Turbo after cooler
Electronic unit injection
n. a.
220 V / 9 kW
24 V / 7 kW
153-5700
4
145 Ah - 12 V / 290 Ah - 24 V
Generator
Brand
Type / Frame
Excitation
Pitch
Number of Poles
Number of Bearings
Number of Leads
Insulation
IP Rating
Nominal Speed
Over Speed capability
Wave form Deviation (Line to Line)
Voltage Regulator
Voltage regulation
Telephone Influence Factor (TIF)
Total Harmonic Distortion (THD)
CBK 3pol manual, fixed mount rear
Typical Cabeling; TN-C (Prime)
Typical Cabeling; TN-C (Standby)
Package Dimensions
Engine:
Length x Width x Height
Weight
Generator: Length x Width x Height
Weight
Radiator:
Length x Width x Height
Dry Weight
Complete: Length x Width x Height
Weight
Caterpillar
1647
Permanent Magnet or AREP
0.6667
4
Single Bearing
6
Class H
IP23
1500 rpm
150 %
2%
3 Phase sensing with selectible
volts/Hz
Less than % (steady state)
Less than 1% (no load to full load)
Less than 50
Less than 5%
4000 A / 50 kA
8 x 4 x 240 mm + 4 x 1 x 240 mm
8 x 4 x 240 mm + 4 x 1 x 240 mm
CAT 3516B-2250_EN
11 November 2013
CAT 3516B-2250
Illustration
Technical Data
Prime
Standby
Fuel Consumption
100% load with Fan
412.2 L/hr
469.8 L/hr
75% load with Fan
311.4 L/hr
348.5 L/hr
50% load with Fan
218.0 L/hr
240.8 L/hr
Oil consumption 75% load
0.247 L/hr
0.277 L/hr
Cooling System
Engine coolant Capacity with
382.0 L
Radiator / expansion Tank
Engine coolant Capacity
233.0 L
Inlet Air
Combustion Air inlet flow rate
122.9 m/min
135.2 m/min
Exhaust System
Exhaust stack gas Temperature
517.0 C
538.5 C
Exhaust gas flow rate
339.4 m/min
383.9 m/min
Exhaust System backpressure max.
6.7 kPa
Heat Rejection
Heat Rejection to coolant (total)
674 kW
742 kW
Heat Rejection to exhaust (total)
1580 kW
1819 kW
Heat Rejection to after cooler
262 kW
341 kW
Heat Rejection to Atmosphere from
158 kW
166 kW
Engine
Heat Rejection to Atmosphere from
68.4 kW
80.9 kW
Generator
Lube System
Sump refill with Filter
401.3 L
Exhaust Emission (Nominal Data); Potential Site Variation possible
NOx mg/nm
CO mg/nm
HC mg/nm
Part Matter mg/nm
Generator
Motor starting capability @30%
Voltage Dip
Rated Current
Short-Circuit Current
2000
125
75
18
2000
145
60
17
5865 skVA
2886.4 A
3247.6 A
3 x INOM
Radiator
Radiator Type
Design Temperature
Radiator coolant Capacity
Air Flow @ 120 Pa
Air Flow @ 180 Pa
44.0 CTD
38 C
149.0 L
1543 m/min
1459 m/min
Hz
Mechanical [Stby]
Exhaust [Stby]
Mechanical [Prim]
Exhaust [Prim]
63
125
250
500
1000
2000
4000
8000
Overall
dBA
101
110
101
92
88
87
85
89
98
96
107
101
92
92
93
93
89
100
101
110
101
92
88
87
85
89
98
96
106
100
91
91
92
93
88
99
All data in this document is for information only and is subject to change.