This document provides instructions for a welding test involving carbon steel plates. Participants will deposit a fillet weld on the front side of a butt joint between two 12mm thick plates, with the weld having a leg length of 10mm +/- 0.5mm. The weld must be completed in 2 to 3 runs without any gap between the plates. It will be evaluated through visual inspection and a break test to check the weld strength.
This document provides instructions for a welding test involving carbon steel plates. Participants will deposit a fillet weld on the front side of a butt joint between two 12mm thick plates, with the weld having a leg length of 10mm +/- 0.5mm. The weld must be completed in 2 to 3 runs without any gap between the plates. It will be evaluated through visual inspection and a break test to check the weld strength.
This document provides instructions for a welding test involving carbon steel plates. Participants will deposit a fillet weld on the front side of a butt joint between two 12mm thick plates, with the weld having a leg length of 10mm +/- 0.5mm. The weld must be completed in 2 to 3 runs without any gap between the plates. It will be evaluated through visual inspection and a break test to check the weld strength.
TRADE TASK WELDING PAGE 1 of 1 SCALE E DRAWN DATE N.T.S. Fizan CHECKED DESIGNED 7 MAY,2012 1. Dawot Hussin 2. Charles Gobi 3. Aziz Dawam 4. Hafizan 21st Malaysian Skill Competition Committee NUMBER REFERENCE TD1 B A C K SID E X X X X 10 TEST D MATERIAL : CARBON STEEL PLATE ( 12MM ) t WELDING POSITION : WELDING PROCESS : NOTES : 1. DEPOSIT A FILLET WELD ON THE FRONT SIDE OF THE JOINT WITH 10mm O/2 mm LEG LENGTH 2. WELD DEPOSITED WITH A MINIMUM OF 2 RUNS AND MAXIMUM 3 RUNS. 3. EDGE PREPARATON MUST REMAN AT 90 TO THE PLATE FACE. 4. NO GAP ALLOWED EVALUATION: 1. VISUAL INSPECTION 2. BREAK TEST