Professional Documents
Culture Documents
1034290-H) MALA
JOB NO : EET/SI/21-399
1.0 INTRODUCTION
2.0 OBJECTIVE
APPENDIX:
CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT
8431 MUKIM PADANG SIDING, DAERAH CHUPING, PERLIS INDERA KAYANGAN.
1.0 INTRODUCTION
This report describes the results of the Soil Investigation Works for above-mentioned
project, carried out from 10th of August, 2021 until 20th of August, 2021
2.0 OBJECTIVE
The Soil Investigation Works were carried out to obtain geotechnical information
needed to assist in the design cost estimate and engineering control during the
construction of propose project in the future.
In order to complete the stated objectives, the following items of works were carried
out:-
a) Exploration of the subsoil condition at the proposed site– FOUR (04) numbers
of exploratory boreholes.
The field works for rotary wash boreholes were carried out in compliance and
accordance to the following guideline:
b) British Standard Code of Practice BS:1377-1990 “Method of Test for Soil for
Civil Engineering Purposes”.
EAGLE ENGINEERING & TRADING SDN BHD
The boreholes were advanced by using a multi-speed rotary boring machine and
mast. Method used to advance these bore holes was rotary wash boring and casings
were used to prevent bore holes wall from collapse. 88.9mm (outer diameter) 75mm
(inner diameter) casing (NW) was used during rotary wash boring. Water was used
as drilling fluid.
a. Boreholes were advanced using rotary wash boring in which a cutting tool was
rotated by a drilling machine, while water was pumped down the drill rods to
wash soil cuttings to ground level. It can also be advanced by a twisting action of
a casing shoe that is placed in the spindle of the drilling rig.
c. A wash boring was advanced partly by a twisting action of a drag or roller bit and
partly by jetting water, which is pump through the hollow drilled rod and bit.
d. Cuttings were removed from the hole by the circulating water from a piston pump.
The soil-laden water from the borehole is discharged into the same reservoir, where
the coarse material settled out. The collection reservoir was used to contain drill
cuttings, to allow settlement of sediments before water was discharged over board
considering environmental issues.
5.2 Sampling
Soil samples were collected in the form of disturbed and undisturbed samples. Upon
completing the SPT, disturbed soil samples were collected from the split spoon
sampler and stored in polythene bag for visual examination and transported to
laboratory for subsequent laboratory test.
For every borehole, undisturbed samples were taken at depth and interval accordance
to requirement by Client. Undisturbed samples were obtained by means of pushing
into the ground thin-walled stainless steel tube without impact or twisting. Minimum
outside diameter of the tube shall be 76mm and nominal length of the tube should be
at least 450mm for cohesion less soil and 600mm for cohesive soil.
EAGLE ENGINEERING & TRADING SDN BHD
When rock was encountered, rock coring was carried out as accordance with ASTM D
2113-83 or BS 5930: 1999 as follows:
a. Rotary core drilling was carried out using a triple tube NMLC core barrels with
76.0mm diameter.
c. The Core Run Recovery (CRR) will mean the ratio of the total length of the good
quality cores over the drilling, expressed to the nearest 5% and the Rock Quality
Designation (RQD) s the ratio of the length of good quality cores each exceeding
100mm in length, over the drilling run, correct to the nearest 5% was recorded in
the boring log and at the face of the core box.
d. When core was extracted from the core barrel, these was carried out as follows:
e. Core was transferred directly from the split inner tube to the core box (sheathed as
required). If it is necessary to break core to fit it into the core box, this fact will be
clearly marked on the core to distinguish such breaks from natural breaks or joints.
Borehole logs are presented in Appendix A, and photographs of soil and rock samples are
presented in Appendix C.
EAGLE ENGINEERING & TRADING SDN BHD
The following laboratory test was conducted on selected soil samples to determine the
physical properties of various soil types encountered in the borehole. The result is as
attached in Appendix B of this report.
Sieve analysis was carried out by preparing the samples by wet sieving to remove silt
and clay sized particles and followed by dry sieving of the remaining coarse material.
This method covers the quantitative determination of particle size distribution in an
essentially cohesionless soil, down to fine sand size. The combined silt clay can be
obtained by difference. If the soil does not contain particles retained on a 2 mm test
sieve in significant quantity, the hydrometer method shall be used.
Hydrometer method combined with wet or dry sieving enable a continuous particle size
distribution curve of a soil to be plotted from the size of the coarsest particles down to
clay sizes. The Hydrometer method covers the quantitative determination of the particle
size distribution in a soil from the coarse sand size to the clay size by means of
sedimentation. The test is normally not required if less than 10 % of the material passes
the 75 gm test sieve in a wet or dry sieving analysis. This type of analysis requires that
the particle density of the soil specimen is known or can be assumed.
APPENDIX A
BOREHOLE LOG
BH 1
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 1 OF 2 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 1 Type of Drill: Rotary Wash Boring Date Started: 16.08.2021
Project No: Water Level: 3.50m b.g.l Date End: 17.08.2021
Reduced Level: Not provided Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
0.00 - Top Soil 0 10 20 30 40 50
0.00
1.50
0.50
1.00
1.50 P1 Stiff, brownish dark red, sandy SILT with some gravel 3 2 2 3 2 3 10 22% 1.50
1.95 D1
x x x x 2.00
x x x x
x x x x 2.50
3
3.00 P2 Very stiff, reddish white, sandy SILT with some clay 3 5 5 7 5 5 22 67% 3.00
3.45 D2
x x x x 3.50
x x x x
x x x x 4.00
––––––
4.50 P3 Very stiff, greyish dark red, sandy SILT with some gravel 4 5 7 7 5 7 26 35% 4.50
4.95 D3
x x x x 5.00
x x x x
5.50
x x x x
6
6.00
–––––– 6.00 P4 Very stiff, whitish dark red, clayey SILT with some sand 3 5 5 4 5 7 21 55%
–––––– 6.45 D4
6.50
x x x x
x x x x
7.00
x x x x
7.50
–––––– 7.50 P5 Very stiff, whitish dark red, clayey SILT with some sand 4 4 5 4 3 5 17 67%
–––––– 7.95 D5 8.00
x x x x
x x x x 8.50
x x x x
9 9.00
9.00 P6 Very stiff, purplish dark red, sandy SILT with some gravel 5 7 7 5 8 7 27 55%
9.45 D6 9.50
x x x x
x x x x 10.00
x x x x
10.50
10.50 P7 Hard, brownish dark red, sandy SILT with some gravel 5 8 10 10 11 10 41 44%
11.00
10.95 D7
x x x x
11.50
x x x x
x x x x
12.00
12
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 2 OF 2 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 1 Type of Drill: Rotary Wash Boring Date Started: 16.08.2021
Project No: Water Level: 3.50m b.g.l Date End: 17.08.2021
Reduced Level: Not provided Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
12 12.00 P8 Hard, whitish dark red, sandy gravelly SILT 15 10 50 50 90% 0 10 20 30 40 50
12.00
12.20 D8 60mm65mm 65mm 200mm
x x x x
12.50
x x x x
x x x x
13.00
x x x x
13.50 P9 Hard, dark red, sandy SILT with some clay 25 50 50 70%
13.50
13.60 D9 70mm30mm 30mm 100mm
x x x x 14.00
x x x x
x x x x 14.50
15 ––––––
x x x x 15.00 P10 Very dense, dark red, silty gravelly SAND 25 50 50 86% 15.00
15.07 D10 20mm50mm 50mm 70mm
15.50
16.00
16.50 P11 Hard, whitish dark red, sandy silty CLAY with some gravel 25 50 50 78% 16.50
x x x x 16.59 D11 60mm30mm 30mm 90mm
–––––– 17.00
––––––
17.50
––––––
18
18.00
18.00 P12 Hard, dark red, gravelly SAND with some silt and clay 25 50 50 73%
18.11 D12 65mm45mm 45mm 110mm
18.50
19.00
x x x x
–––––– 19.50
x x x x 19.50 P13 Hard, whitish dark red, silty CLAY 25 50 50 100%
x x x x 19.62 D13 70mm50mm 50mm 120mm 20.00
––––––
–––––– 20.50
––––––
21 –––––– 21.00
x x x x 21.00 P14 Hard, dark red, silty CLAY 25 50 50 91%
–––––– 21.11 D14 60mm50mm 50mm 110mm 21.50
End of BH 1 at depth 21.11m b.g.l
22.00
22.50
23.00
23.50
24.00
24
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
BH 2
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 1 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 2 Type of Drill: Rotary Wash Boring Date Started: 13.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 14.08.2021
Reduced Level: Not provided Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
0.00 - Top Soil 0 10 20 30 40 50
0.00
1.50
0.50
1.00
x x x x 1.50 P1 Stiff, reddish brownish white, silty CLAY with some gravel 1 2 2 2 2 2 8 44% 1.50
x x x x 1.95 D1
–––––– 2.00
––––––
–––––– 2.50
3
x x x x 3.00 P2 Very stiff, reddish, white, silty CLAY 2 3 5 3 5 4 17 38% 3.00
x x x x 3.45 D2
–––––– 3.50
––––––
–––––– 4.00
––––––
x x x x 4.50 P3 Very stiff, reddish, white, silty CLAY 3 4 5 5 7 7 24 31% 4.50
x x x x 4.95 D3
–––––– 5.00
––––––
5.50
––––––
6 ––––––
6.00
6.00 P4 Very stiff, brownish white, sandy SILT with some clay 3 3 5 4 4 5 18 100%
6.45 D4
6.50
x x x x
x x x x
7.00
x x x x
–––––– 7.50
x x x x 7.50 P5 Stiff, brownish white, silty CLAY 1 3 2 3 3 4 12 78%
x x x x 7.95 D5 8.00
––––––
–––––– 8.50
––––––
9 –––––– 9.00
x x x x 9.00 P6 Very stiff, reddish white, silty CLAY 3 3 4 3 4 4 15 82%
x x x x 9.45 D6 9.50
––––––
–––––– 10.00
––––––
–––––– 10.50
x x x x 10.50 P7 Hard, brownish reddish white, silty CLAY with some sand 4 5 5 7 9 10 31 100%
11.00
x x x x 10.95 D7
––––––
11.50
––––––
––––––
12.00
12
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 2 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 2 Type of Drill: Rotary Wash Boring Date Started: 13.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 14.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
12 x x x x 12.00 P8 Very stiff, reddish brownish white, silty CLAY 4 3 5 5 7 5 22 100% 0 10 20 30 40 50
12.00
x x x x 12.45 D8
––––––
12.50
––––––
––––––
13.00
––––––
x x x x 13.50 P9 Hard, whitish dark red, silty CLAY 4 7 10 15 12 12 49 98%
13.50
x x x x 13.95 D9
–––––– 14.00
––––––
–––––– 14.50
15 ––––––
15.00 P10 Hard, whitish dark red, sandy SILT 4 5 10 10 11 15 46 51% 15.00
15.45 D10
x x x x 15.50
x x x x
x x x x 16.00
x x x x
–––––– 16.50 P11 Hard, whitish dark red, clayey SILT 5 5 9 10 15 15 49 73% 16.50
–––––– 16.95 D11
x x x x 17.00
x x x x
17.50
x x x x
18 x x x x
18.00
–––––– 18.00 P12 Hard, dark red, clayey SILT 25 50 50 86%
–––––– 18.14 D12 70mm70mm 70mm 140mm
18.50
x x x x
x x x x
19.00
x x x x
x x x x 19.50
–––––– 19.50 P13 Hard, whitish dark red, clayey SILT 5 9 10 9 12 15 46 75%
–––––– 19.95 D13 20.00
x x x x
x x x x 20.50
x x x x
21 x x x x 21.00
x x x x 21.00 P14 Hard, dark red, silty CLAY 5 5 7 8 8 10 33 100%
x x x x 21.45 D14 21.50
––––––
–––––– 22.00
––––––
–––––– 22.50
x x x x 22.50 P15 Hard, dark red, silty CLAY 5 6 7 10 10 9 36 98%
23.00
x x x x 22.95 D15
––––––
23.50
––––––
––––––
24.00
24 ––––––
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 3 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 2 Type of Drill: Rotary Wash Boring Date Started: 13.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 14.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
24 –––––– 24.00 P16 Hard, dark red, clayey SILT 5 6 8 8 10 8 34 55% 0 10 20 30 40 50
24.00
–––––– 24.45 D16
x x x x
24.50
x x x x
x x x x
25.00
x x x x
x x x x 25.50 P17 Very stiff, dark red, silty CLAY 4 4 5 8 7 8 28 80%
25.50
x x x x 25.95 D17
–––––– 26.00
––––––
–––––– 26.50
27 ––––––
x x x x 27.00 P18 Hard, dark red, silty CLAY 4 5 6 9 8 9 32 84% 27.00
x x x x 27.45 D18
–––––– 27.50
––––––
–––––– 28.00
––––––
28.50 P19 Hard, dark red, sandy SILT with some clay 5 7 10 10 12 10 42 64% 28.50
28.95 D19
x x x x 29.00
x x x x
29.50
x x x x
30 ––––––
30.00
–––––– 30.00 P20 Hard, dark red, clayey SILT 15 10 50 50 89%
–––––– 30.19 D20 70mm45mm 45mm 190mm
30.50
x x x x
x x x x
31.00
x x x x
x x x x 31.50
x x x x 31.50 P21 Hard, dark red, silty CLAY 25 50 50 71%
x x x x 31.64 D21 70mm70mm 70mm 140mm 32.00
––––––
–––––– 32.50
––––––
33 –––––– 33.00
x x x x 33.00 P22 Hard, dark red, silty CLAY 25 50 50 64%
x x x x 33.11 D22 65mm45mm 45mm 110mm 33.50
––––––
–––––– 34.00
––––––
–––––– 34.50
x x x x 34.50 P23 Hard, dark red, silty CLAY 20 5 50 50 97%
35.00
x x x x 34.665 D23 20mm70mm 70mm 165mm
––––––
35.50
––––––
––––––
36.00
36 ––––––
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 4 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 2 Type of Drill: Rotary Wash Boring Date Started: 13.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 14.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
36 x x x x 36.00 P24 Hard, dark red, silty CLAY 25 50 50 50% 0 10 20 30 40 50
36.00
x x x x 36.14 D24 70mm70mm 70mm 140mm
––––––
36.50
––––––
––––––
37.00
––––––
x x x x 37.50 P25 Hard, dark red, silty CLAY 15 10 50 50 89%
37.50
x x x x 37.69 D25 65mm50mm 50mm 190mm
–––––– 38.00
––––––
–––––– 38.50
39 ––––––
x x x x 39.00 P26 Hard, dark red, silty CLAY 20 5 50 50 100% 39.00
–––––– 39.17 D26 60mm35mm 35mm 170mm
End of BH 2 at depth 39.17m b.g.l 39.50
40.00
40.50
41.00
41.50
42
42.00
42.50
43.00
43.50
44.00
44.50
45 45.00
45.50
46.00
46.50
47.00
47.50
48.00
48
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
BH 3
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 1 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 3 Type of Drill: Rotary Wash Boring Date Started: 10.08.2021
Project No: Water Level: 5.98m b.g.l Date End: 12.08.2021
Reduced Level: Not provided Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
0.00 - Top Soil 0 10 20 30 40 50
0.00
1.50
0.50
1.00
–––––– 1.50 P1 Stiff, reddish brownish white, clayey SILT 2 3 3 2 3 3 11 100% 1.50
–––––– 1.95 D1
x x x x 2.00
x x x x
x x x x 2.50
3 x x x x
–––––– 3.00 P2 Stiff, whitish reddish brown, clayey SILT 3 2 2 2 2 2 8 100% 3.00
–––––– 3.45 D2
x x x x 3.50
x x x x
x x x x 4.00
x x x x
4.50 P3 Stiff, reddish greyish brown, sandy SILT 2 3 3 2 3 3 11 100% 4.50
4.95 D3
x x x x 5.00
x x x x
5.50
x x x x
6 x x x x
6.00
–––––– 6.00 P4 Stiff, whitish brown, clayey SILT 2 2 2 3 2 2 9 100%
–––––– 6.45 D4
6.50
x x x x
x x x x
7.00
x x x x
x x x x 7.50
–––––– 7.50 P5 Stiff, whitish reddish brown, clayey SILT 3 2 3 2 2 2 9 62%
–––––– 7.95 D5 8.00
x x x x
x x x x 8.50
x x x x
9 x x x x 9.00
–––––– 9.00 P6 Stiff, brownish white, clayey SILT 0 1 2 2 3 2 9 100%
–––––– 9.45 D6 9.50
x x x x
x x x x 10.00
x x x x
x x x x 10.50
–––––– 10.50 P7 Firm, brownish white, clayey SILT 0 0 1 2 2 2 7 100%
11.00
–––––– 10.95 D7
x x x x
11.50
x x x x
x x x x
12.00
12 x x x x
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 2 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 3 Type of Drill: Rotary Wash Boring Date Started: 10.08.2021
Project No: Water Level: 5.98m b.g.l Date End: 12.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
12 12.00 P8 Firm, greyish reddish brown, sandy SILT 0 0 2 2 1 2 7 100% 0 10 20 30 40 50
12.00
12.45 D8
x x x x
12.50
x x x x
x x x x
13.00
x x x x
–––––– 13.50 P9 Firm, reddish white, clayey SILT 0 1 1 2 1 2 6 69%
13.50
–––––– 13.95 D9
x x x x 14.00
x x x x
x x x x 14.50
15 x x x x
–––––– 15.00 P10 Stiff, reddish white, clayey SILT 0 4 2 3 3 3 11 100% 15.00
–––––– 15.45 D10
x x x x 15.50
x x x x
x x x x 16.00
x x x x
–––––– 16.50 P11 Very stiff, reddish white, clayey SILT with some gravel 1 3 3 5 5 6 19 100% 16.50
–––––– 16.95 D11
x x x x 17.00
x x x x
17.50
x x x x
18
18.00
–––––– 18.00 P12 Hard, reddish white, clayey SILT 3 5 10 7 7 8 32 91%
–––––– 18.45 D12
18.50
x x x x
x x x x
19.00
x x x x
x x x x 19.50
–––––– 19.50 P13 Hard, reddish white, clayey SILT 5 4 10 10 8 8 36 62%
–––––– 19.95 D13 20.00
x x x x
x x x x 20.50
x x x x
21 x x x x 21.00
21.00 P14 Very stiff, reddish white, sandy SILT 4 4 6 6 7 7 26 100%
21.45 D14 21.50
x x x x
x x x x 22.00
x x x x
x x x x 22.50
–––––– 22.50 P15 Hard, reddish white, clayey SILT 5 4 7 10 10 12 39 100%
23.00
–––––– 22.95 D15
x x x x
23.50
x x x x
x x x x
24.00
24 x x x x
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 3 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 3 Type of Drill: Rotary Wash Boring Date Started: 10.08.2021
Project No: Water Level: 5.98m b.g.l Date End: 12.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
24 –––––– 24.00 P16 Hard, reddish white, clayey SILT 3 5 7 9 10 10 36 78% 0 10 20 30 40 50
24.00
–––––– 24.45 D16
x x x x
24.50
x x x x
x x x x
25.00
x x x x
–––––– 25.50 P17 Hard, whitish dark red, clayey SILT 3 3 5 7 9 12 33 100%
25.50
–––––– 25.95 D17
x x x x 26.00
x x x x
x x x x 26.50
27 x x x x
x x x x 27.00 P18 Very stiff, whitish dark red, silty CLAY 4 5 5 8 8 8 29 100% 27.00
x x x x 27.45 D18
–––––– 27.50
––––––
–––––– 28.00
––––––
x x x x 28.50 P19 Hard, whitish dark red, silty CLAY 3 5 9 10 10 11 40 91% 28.50
x x x x 28.95 D19
–––––– 29.00
––––––
29.50
––––––
30 ––––––
30.00
–––––– 30.00 P20 Hard, whitish dark red, clayey SILT 2 8 10 9 10 10 39 67%
–––––– 30.45 D20
30.50
x x x x
x x x x
31.00
x x x x
x x x x 31.50
x x x x 31.50 P21 Hard, whitish dark red, silty CLAY 4 4 8 8 10 8 34 100%
x x x x 31.95 D21 32.00
––––––
–––––– 32.50
––––––
33 –––––– 33.00
x x x x 33.00 P22 Hard, whitish dark red, silty CLAY 5 5 9 9 10 10 38 100%
x x x x 33.45 D22 33.50
––––––
–––––– 34.00
––––––
–––––– 34.50
x x x x 34.50 P23 Hard, whitish dark red, silty CLAY 4 5 8 10 9 10 37 73%
35.00
x x x x 34.95 D23
––––––
35.50
––––––
––––––
36.00
36 ––––––
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 4 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 3 Type of Drill: Rotary Wash Boring Date Started: 10.08.2021
Project No: Water Level: 5.98m b.g.l Date End: 12.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
36 x x x x 36.00 P24 Hard, whitish dark red, silty CLAY 4 7 7 9 8 10 34 100% 0 10 20 30 40 50
36.00
x x x x 36.45 D24
––––––
36.50
––––––
––––––
37.00
––––––
x x x x 37.50 P25 Hard, whitish dark red, silty CLAY 25 50 50 86%
37.50
x x x x 37.64 D25 70mm70mm 70mm 140mm
–––––– 38.00
––––––
–––––– 38.50
39 ––––––
x x x x 39.00 P26 Hard, whitish dark red, silty CLAY 25 50 50 82% 39.00
x x x x 39.11 D26 50mm60mm 60mm 110mm
–––––– 39.50
––––––
–––––– 40.00
––––––
40.50 P27 NO RECOVERY 25 50 50 0% 40.50
40.55 D27 20mm30mm 30mm 50mm
41.00
41.50
42
42.00
–––––– 42.00 P28 Hard, dark red, clayey SILT with some gravel 25 50 50 50%
–––––– 42.10 D28 70mm30mm 30mm 100mm
42.50
x x x x
x x x x
43.00
x x x x
43.50
x x x x 43.50 P29 Hard, dark red, silty CLAY 20 5 50 50 61%
x x x x 43.665 D29 25mm65mm 65mm 165mm 44.00
––––––
–––––– 44.50
––––––
45 –––––– 45.00
–––––– 45.00 P30 Hard, reddish brownish white, clayey SILT 20 5 50 50 91%
–––––– 45.165 D30 35mm55mm 55mm 165mm 45.50
x x x x
x x x x 46.00
x x x x
x x x x 46.50
x x x x 46.50 P31 Hard, dark red, silty CLAY 25 50 50 71%
47.00
–––––– 46.64 D31 70mm70mm 70mm 140mm
End of BH 3 at depth 46.64m b.g.l
47.50
48.00
48
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
BH 4
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 1 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 4 Type of Drill: Rotary Wash Boring Date Started: 19.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 20.08.2021
Reduced Level: Not provided Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
0.00 - Top Soil 0 10 20 30 40 50
0.00
1.50
0.50
1.00
2.50
3
x x x x 3.00 P2 Very stiff, medium brown, silty CLAY 3 3 5 4 5 5 19 89% 3.00
–––––– 3.45 D2
3.50 MZ1 MAZIER SAMPLE 1 30% 3.50
4.50 1000mm
4.00
––––––
5.50
––––––
6 ––––––
6.00
x x x x 6.00 P4 Very stiff, medium brown, silty CLAY 3 3 3 4 5 5 17 44%
–––––– 6.45 D4
6.50
6.50 MZ2 MAZIER SAMPLE 2 100%
7.50 1000mm
7.00
7.50
7.50 P5 Stiff, whitish dark red, sandy SILT with some clay 3 4 3 3 4 3 13 44%
7.95 D5 8.00
x x x x
x x x x 8.50
x x x x
9 –––––– 9.00
–––––– 9.00 P6 Stiff, reddish white, clayey SILT 2 3 2 3 3 4 12 20%
–––––– 9.45 D6 9.50
x x x x
x x x x 10.00
x x x x
x x x x 10.50
x x x x 10.50 P7 Stiff, dark red, silty CLAY 3 2 3 3 4 4 14 51%
11.00
x x x x 10.95 D7
––––––
11.50
––––––
––––––
12.00
12 ––––––
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 2 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 4 Type of Drill: Rotary Wash Boring Date Started: 19.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 20.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
12 12.00 P8 Stiff, dark red, sandy SILT 2 3 3 2 2 2 9 42% 0 10 20 30 40 50
12.00
x x x x 12.45 D8
12.50 MZ3 MAZIER SAMPLE 100%
12.50
13.50 1000mm
13.00
––––––
17.50
––––––
18 ––––––
18.00
x x x x 18.00 P12 Very stiff, whitish dark red, silty CLAY 3 5 5 5 7 7 24 75%
x x x x 18.14 D12
18.50
––––––
––––––
19.00
––––––
–––––– 19.50
19.50 P13 NO RECOVERY 2 3 6 6 7 6 25 0%
19.95 D13 20.00
20.50
21 21.00
21.00 P14 Very stiff, dark red, sandy SILT 3 3 5 8 7 8 28 35%
21.45 D14 21.50
x x x x
x x x x 22.00
x x x x
x x x x 22.50
x x x x 22.50 P15 Hard, dark red, silty CLAY with some gravel 4 3 7 7 7 9 30 29%
23.00
x x x x 22.95 D15
––––––
23.50
––––––
––––––
24.00
24
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 3 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 4 Type of Drill: Rotary Wash Boring Date Started: 19.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 20.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
24 x x x x 24.00 P16 Hard, dark red, silty CLAY 5 4 8 8 7 8 31 29% 0 10 20 30 40 50
24.00
x x x x 24.45 D16
––––––
24.50
––––––
––––––
25.00
––––––
x x x x 25.50 P17 Hard, dark red, silty CLAY 25 50 50 93%
25.50
x x x x 25.64 D17 70mm70mm 70mm 140mm
–––––– 26.00
––––––
–––––– 26.50
27 ––––––
x x x x 27.00 P18 Hard, dark red, silty CLAY 25 50 50 83% 27.00
x x x x 27.12 D18 70mm50mm 50mm 120mm
–––––– 27.50
––––––
–––––– 28.00
––––––
x x x x 28.50 P19 Hard, dark red, silty CLAY 25 50 50 83% 28.50
x x x x 28.62 D19 65mm55mm 55mm 120mm
–––––– 29.00
––––––
29.50
––––––
30 ––––––
30.00
x x x x 30.00 P20 Hard, dark red, silty CLAY 25 50 50 71%
x x x x 30.07 D20 20mm50mm 50mm 70mm
30.50
––––––
––––––
31.00
––––––
–––––– 31.50
31.50 P21 NO RECOVERY 25 50 50 0%
31.55 D21 20mm30mm 30mm 50mm 32.00
32.50
33 33.00
x x x x 33.00 P22 Hard, dark red, silty CLAY 25 50 50 89%
x x x x 33.09 D22 35mm55mm 55mm 90mm 33.50
––––––
–––––– 34.00
––––––
–––––– 34.50
x x x x 34.50 P23 Hard, dark red, silty CLAY 25 50 50 59%
35.00
x x x x 34.635 D23 60mm75mm 75mm 135mm
––––––
35.50
––––––
––––––
36.00
36 ––––––
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
EAGLE ENGINEERING & TRADING SDN BHD SHEET: 4 OF 4 RECORD OF BORING
PROJECT: CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING,
DAERAH CHUPING, PERLIS INDERA KAYANGAN.
Client: CLASSIC SOLAR FARM SOLAR SDN BHD Supervisor: Khairul
Borehole No: BH 4 Type of Drill: Rotary Wash Boring Date Started: 19.08.2021
Project No: Water Level: 3.80m b.g.l Date End: 20.08.2021
Reduced Level: Coordinate: E: N:
SAMPLE SPT Plot
Recovery
SCALE (m)
LEGEND
DEPTH No. DESCRIPTION Standard Penetration Test SPT No. Of Blows (N)
(m) 75 75 75 75 75 75 (N) (%)
36 x x x x 36.00 P24 Hard, dark red, silty CLAY 25 50 50 93% 0 10 20 30 40 50
36.00
–––––– 36.14 D24 65mm75mm 75mm 140mm
End of BH 4 at depth 36.14m b.g.l
36.50
37.00
37.50
38.00
38.50
39
39.00
39.50
40.00
40.50
41.00
41.50
42
42.00
42.50
43.00
43.50
44.00
44.50
45 45.00
45.50
46.00
46.50
47.00
47.50
48.00
48
Notes:
REMARKS -
P = Standard Penetration Test (SPT)
D = Disturbed Sample Consistency / Relative Density Legend:
N = SPT Result Cohesive Soil (N) Non Cohesive Soil (N) –– –– CLAY
VS = Vane Shear Test 0-2 Very Soft 0-4 Very Loose
UD = 50mm dia. Undisturbed Sample 2-4 Soft 4 - 10 Loose x x x x SILT
M = Mazier Sample 4-8 Firm 10 - 30 Medium Dense
W = Water Sample 8 - 15 Stiff 30 - 50 Dense SAND
C = Rock Coring 15 - 30 Very Stiff 50 > Very Dense
RQD = Rock Quality Designation (%) 30 > Hard GRAVEL
.
APPENDIX B
NP = NON PLASTICITY
PRECISE TEST ENTERPRISE
PARTICLE SIZE DISTRIBUTION
Date : 01-09-2021
PROJEK : CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431
MUKIM PADANG SIDING, DAERAH CHUPING, PERLIS INDERA KAYANGAN.
SAMPLE NO: D D D
1 Clay 0.002mm % 10 7
2 Silt 0.002-0.063mm % 47 53 16
3 Sand 0.063-2mm % 40 37 60
4 Gravel % 3 3 24
63 mm
50 mm
37.5 mm
Particle Size 28 mm
Distribution for 20 mm
Sieve Analysis Test 14 mm
(% Passing) 10 mm 100
6.3 mm 94
5 mm 90
3.35 mm 100 100 82
2 mm 97 97 76
1.18 mm 91 93 67
0.6 mm 87 89 58
0.425 mm 81 83 50
0.3 mm 73 75 42
0.212 mm 67 70 31
0.15 mm 61 65 25
0.063 mm 57 60 16
Particle Diameter (mm) for Hydrometer Test Particle Size Distribution for Hydrometer Test (% Passing)
SAMPLE NO: SAMPLE NO:
D D D D D D
0.0478 0.0471 53 56
0.0348 0.0343 47 50
Particle 0.0223 0.0226 44 41
Size 0.0093 0.0096 38 32
(mm) 0.0069 0.0069 29 26
0.0050 0.0050 23 20
0.0036 0.0036 17 14
0.0015 0.0015 8 5
100%
90%
80%
70%
Percentage Passing
60%
50%
40%
30%
20%
D
D
10%
D
0%
0.001 0.01 0.1 1 10 100 0.001 0.01 0.1 1 10 100
Particle size (mm) Particle size (mm)
SAMPLE NO: D D D
1 Clay 0.002mm % 12 4 11
2 Silt 0.002-0.063mm % 62 59 54
3 Sand 0.063-2mm % 26 37 35
4 Gravel % 0 0 0
63 mm
50 mm
37.5 mm
Particle Size 28 mm
Distribution 20 mm
(% Passing) 14 mm
10 mm
6.3 mm
5 mm
3.35 mm
2 mm 100 100
1.18 mm 100 98 98
0.6 mm 95 94 93
0.425 mm 90 86 87
0.3 mm 86 80 81
0.212 mm 82 74 77
0.15 mm 78 70 71
0.063 mm 74 63 65
Particle Diameter (mm) for Hydrometer Test Particle Size Distribution for Hydrometer Test (% Passing)
SAMPLE NO: SAMPLE NO:
D D D D D D
0.0441 0.0463 0.0463 73 58 60
0.0322 0.0338 0.0338 67 52 54
Particle 0.0214 0.0223 0.0220 57 44 48
Size 0.0091 0.0095 0.0092 47 35 41
(mm) 0.0067 0.0069 0.0068 38 26 32
0.0049 0.0050 0.0049 28 20 26
0.0036 0.0037 0.0036 19 11 17
0.0015 0.0015 0.0015 9 2 8
100%
90%
80%
70%
Percentage Passing
60%
50%
40%
30%
20%
D
D
10%
D
0%
0.001 0.01 0.1 1 10 100 0.001 0.01 0.1 1 10 100
Particle size (mm) Particle size (mm)
SAMPLE NO: D D D
1 Clay 0.002mm % 4 8 2
2 Silt 0.002-0.063mm % 48 49 52
3 Sand 0.063-2mm % 45 40 43
4 Gravel % 3 3 3
63 mm
50 mm
37.5 mm
Particle Size 28 mm
Distribution 20 mm
(% Passing) 14 mm
10 mm
6.3 mm
5 mm
3.35 mm 100 100 100
2 mm 97 97 97
1.18 mm 93 91 92
0.6 mm 87 85 86
0.425 mm 79 77 78
0.3 mm 72 73 71
0.212 mm 64 67 63
0.15 mm 58 63 59
0.063 mm 52 57 54
Particle Diameter (mm) for Hydrometer Test Particle Size Distribution for Hydrometer Test (% Passing)
SAMPLE NO: SAMPLE NO:
D D D D D D
0.0492 0.0478 0.0485 48 55 50
0.0357 0.0348 0.0352 42 49 44
Particle 0.0235 0.0226 0.0232 33 42 35
Size 0.0098 0.0096 0.0098 26 33 26
(mm) 0.0071 0.0069 0.0071 20 27 20
0.0051 0.0050 0.0051 14 21 14
0.0037 0.0036 0.0037 8 15 5
0.0015 0.0015 0.0016 2 6 0
100%
90%
80%
70%
Percentage Passing
60%
50%
40%
30%
20%
D
D
10%
D
0%
0.001 0.01 0.1 1 10 100 0.001 0.01 0.1 1 10 100
Particle size (mm) Particle size (mm)
SAMPLE NO: D D D
1 Clay 0.002mm % 12 8 7
2 Silt 0.002-0.063mm % 60 62 47
3 Sand 0.063-2mm % 28 30 43
4 Gravel % 0 0 3
63 mm
50 mm
37.5 mm
Particle Size 28 mm
Distribution 20 mm
(% Passing) 14 mm
10 mm
6.3 mm
5 mm
3.35 mm 100
2 mm 97
1.18 mm 100 100 92
0.6 mm 98 96 85
0.425 mm 93 89 77
0.3 mm 87 84 70
0.212 mm 81 79 63
0.15 mm 77 75 60
0.063 mm 72 70 54
Particle Diameter (mm) for Hydrometer Test Particle Size Distribution for Hydrometer Test (% Passing)
SAMPLE NO: SAMPLE NO:
D D D D D D
0.0448 0.0448 0.0456 70 67 52
0.0328 0.0327 0.0336 63 60 46
Particle 0.0212 0.0212 0.0222 57 51 37
Size 0.0089 0.0089 0.0094 47 44 29
(mm) 0.0065 0.0065 0.0069 38 35 23
0.0046 0.0047 0.0050 28 28 17
0.0034 0.0034 0.0037 19 15 11
0.0014 0.0014 0.0015 9 6 5
100%
90%
80%
70%
Percentage Passing
60%
50%
40%
30%
20%
D
D
D 10%
0%
0.001 0.01 0.1 1 10 100
0.001 0.01 0.1 1 10 100
Particle size (mm)
Particle size (mm)
(21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING, DAERAH CHUPING, Sample No : MZ
Date : 06/09/2021
Specimen Size (mm) : 50.00 50.00 Specific Gravity of Soil, Gs : 2.590 2.590
Wt.of Ring+Wet Soil : 143.68 139.80 Ht. of Solid, ho (mm) : 10.152 10.152 D, Total Deflection
INITIAL FINAL Ht. of Soil Sample, h (mm) : 20.000 16.879 e, void Ratio (H-ho)/ho
Weight of Ring (g) : 75.00 75.00 INITIAL FINAL de, change in Void Ratio
Weight of Wet Soil (g) : 68.68 64.80 Void Ratio, eo : 0.970 0.663 Cv, coeff. Of Consolidation
Weight of Dry Soil (g) : 51.64 51.64 Bulk Density (Mg/m3) : 1.749 1.955 Mv, Coeff. Of Compressibility
Weight of Water (g) : 17.04 13.16 Dry Density (Mg/m3) : 1.315 1.558 k, Coeff. Of Permeability
Applied Pressure Total Sample % Sample Height of Voids Ratio Mean Ht. k=
(kN/m2) dp(kN/m2) D, (mm) H, (mm) H/h * 100 H-ho (mm) e=(H-ho)/ho de hm, (mm) (m2/MN) (min) (m2/yr) (m/s)
1.000
eo = 0.970
0.950 Pc = 50 kPa
Cc = 0.332
0.900
0.850
Void Ratio , e
0.800
0.750
0.700
0.650
0.600
0.1 1 10 100 1000 10000
Pressure (kPa)
Pressure Versus Cv
4.00
3.50
3.00
Cv (m2/year)
2.50
2.00
1.50
1.00
0.50
0.00
0 1 10 100 1000 10000
Pressure (kPa)
Pressure Versus Mv
0.90
0.80
0.70
Mv (m2/MN)
0.60
0.50
0.40
0.30
0.20
0.10
0.00
0 1 10 100 1000 10000
Pressure (kPa)
PRECISE TEST ENTERPRISE
ONE DIMENSIONAL CONSOLIDATION TEST (BS1377, PART 5:1990)
(21 TAHUN) DI ATAS LOT 8431 MUKIM PADANG SIDING, DAERAH CHUPING, Sample No : MZ
Date : 06/09/2021
Specimen Size (mm) : 50.00 50.00 Specific Gravity of Soil, Gs : 2.600 2.600
Wt.of Ring+Wet Soil : 145.06 142.00 Ht. of Solid, ho (mm) : 10.473 10.473 D, Total Deflection
INITIAL FINAL Ht. of Soil Sample, h (mm) : 20.000 17.383 e, void Ratio (H-ho)/ho
Weight of Ring (g) : 75.00 75.00 INITIAL FINAL de, change in Void Ratio
Weight of Wet Soil (g) : 70.06 67.00 Void Ratio, e : 0.910 0.660 Cv, coeff. Of Consolidation
Weight of Dry Soil (g) : 53.48 53.48 Bulk Density (Mg/m3) : 1.784 1.963 Mv, Coeff. Of Compressibility
Weight of Water (g) : 16.58 13.52 Dry Density (Mg/m3) : 1.362 1.567 k, Coeff. Of Permeability
Applied Pressure Total Sample % Sample Height of Voids Ratio Mean Ht. k=
(kN/m2) dp(kN/m2) D, (mm) H, (mm) H/h * 100 H-ho (mm) e=(H-ho)/ho de hm, (mm) (m2/MN) (min) (m2/yr) (m/s)
0.950
eo = 0.910
Pc = 60 kPa
0.900
Cc = 0.311
0.850
Void Ratio , e
0.800
0.750
0.700
0.650
0.600
0.1 1 10 100 1000 10000
Pressure (kPa)
Pressure Versus Cv
5.00
4.00
Cv (m2/year)
3.00
2.00
1.00
0.00
0 1 10 100 1000 10000
Pressure (kPa)
Pressure Versus Mv
0.70
0.60
0.50
Mv (m2/MN)
0.40
0.30
0.20
0.10
0.00
0 1 10 100 1000 10000
Pressure (kPa)
PRECISE TEST ENTERPRISE
UNCONFINED COMPRESSION TEST (BS 1377 : PART 7 : 1990)
Project : CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM
PADANG SIDING, DAERAH CHUPING, PERLIS INDERA KAYANGAN.
SAMPLE : BH4 / MZ / 6.50m Date Tested : 01-09-2021
45
40
35
30
Stress (kN/m2)
25
20
15
10
0
0 1 2 3 4 5 6 7 8 9
Strain (%)
PRECISE TEST ENTERPRISE
UNCONFINED COMPRESSION TEST (BS 1377 : PART 7 : 1990)
Project : CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM
PADANG SIDING, DAERAH CHUPING, PERLIS INDERA KAYANGAN.
SAMPLE : BH4 / MZ / 12.50m Date Tested : 01-09-2021
Deflect. Axial Correct. Proving Axial Deviator
Reading Strain Area Ring Load Stress TEST ON ONE SPECIMEN
X0.01mm (%) (sq.cm) Reading (kN) (kPa)
0 0.00 11.35 0 0.000 0.000
25 0.33 11.38 3 0.004 3.454 Sample Height, mm : 76
50 0.66 11.42 6 0.008 6.885 Sample Diameter, mm: 38
75 0.99 11.46 9 0.012 10.293 Strain Rate, mm/min : 1.200
100 1.32 11.50 12 0.016 13.678 Ring Factor, kN/div : 0.001311
125 1.64 11.54 15 0.020 17.041
150 1.97 11.57 18 0.024 20.380
175 2.30 11.61 21 0.028 23.697
200 2.63 11.65 24 0.031 26.991
225 2.96 11.69 27 0.035 30.263 SAMPLE
250 3.29 11.73 30 0.039 33.511 AT
275 3.62 11.77 33 0.043 36.737 FAILURE
300 3.95 11.81 36 0.047 39.940 SKETCH
325 4.28 11.85 38 0.050 42.014
350 4.61 11.89 40 0.052 44.074
375 4.93 11.93 42 0.055 46.118
400 5.26 11.98 43 0.056 47.052
425 5.59 12.02 44 0.058 47.979
450 5.92 12.06 45 0.059 48.899
475 6.25 12.10 46 0.060 49.811
500 6.58 12.15 46 0.060 49.636 Moisture Content (%) 88.24
550 7.24 12.23 46 0.060 49.286 Bulk Density, Mg/m3 1.482
600 7.89 12.32 45 0.059 47.873 Dry Density, Mg/m3 0.787
650 8.55 12.41
700 9.21 12.50 Failure Strain (%) 6.25
750 9.87 12.59 Maximum Deviator Stress (kN/m2) 50
800 10.53 12.68
850 11.18 12.77
900 11.84 12.87
950 12.50 12.97
1000 13.16 13.07 Mode Of Failure : INTERMEDIATE
1050 13.82 13.16
1100 14.47 13.27
60
50
40
Stress (kN/m2)
30
20
10
0
0 1 2 3 4 5 6 7 8 9
Strain (%)
PRECISE TEST ENTERPRISE
UNCONSOLIDATED UNDRAINED COMPRESSION TEST (BS 1377 : PART 7 : 1990)
Project : CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM
PADANG SIDING, DAERAH CHUPING, PERLIS INDERA KAYANGAN.
SPECIMEN LAT. PRESSURE A SPECIMEN, kPa = 60 B SPECIMEN, kPa = 120 C SPECIMEN, kPa = 240
Deflect. Axial Correct. Proving Axial Deviator Proving Axial Deviator Proving Axial Deviator
Reading Strain Area Ring Load Stress Ring Load Stress Ring Load Stress
X0.01mm (%) (sq.cm) Reading (kN) (kPa) Reading (kN) (kPa) Reading (kN) (kPa)
0 0.00 11.35 0 0.000 0.000 0 0.000 0.000 0 0.000 0.000
25 0.33 11.38 3 0.004 3.454 4 0.005 4.605 5 0.007 5.756
50 0.66 11.42 6 0.008 6.885 7 0.009 8.032 8 0.010 9.179
75 0.99 11.46 9 0.012 10.293 10 0.013 11.436 11 0.014 12.580
100 1.32 11.50 11 0.014 12.538 13 0.017 14.818 14 0.018 15.958
125 1.64 11.54 13 0.017 14.768 16 0.021 18.177 17 0.022 19.313
150 1.97 11.57 15 0.020 16.984 19 0.025 21.512 20 0.026 22.645
175 2.30 11.61 17 0.022 19.183 22 0.029 24.826 23 0.030 25.954
200 2.63 11.65 19 0.025 21.368 25 0.033 28.116 26 0.034 29.241
225 2.96 11.69 21 0.028 23.538 27 0.035 30.263 29 0.038 32.504
250 3.29 11.73 23 0.030 25.692 29 0.038 32.394 31 0.041 34.628
275 3.62 11.77 25 0.033 27.831 31 0.041 34.510 33 0.043 36.737
300 3.95 11.81 27 0.035 29.955 33 0.043 36.611 35 0.046 38.830
325 4.28 11.85 29 0.038 32.064 35 0.046 38.697 37 0.048 40.909
350 4.61 11.89 31 0.041 34.157 36 0.047 39.666 39 0.051 42.972
375 4.93 11.93 33 0.043 36.235 37 0.048 40.628 41 0.054 45.020
400 5.26 11.98 35 0.046 38.298 38 0.050 41.581 43 0.056 47.052
425 5.59 12.02 36 0.047 39.256 39 0.051 42.527 44 0.058 47.979
450 5.92 12.06 37 0.048 40.206 40 0.052 43.466 45 0.059 48.899
475 6.25 12.10 38 0.050 41.148 41 0.054 44.397 46 0.060 49.811
500 6.58 12.15 39 0.051 42.083 42 0.055 45.320 47 0.062 50.715
550 7.24 12.23 39 0.051 41.786 43 0.056 46.072 48 0.063 51.429
600 7.89 12.32 39 0.051 41.490 43 0.056 45.745 49 0.064 52.128
650 8.55 12.41 38 0.050 40.137 43 0.056 45.419 50 0.066 52.812
700 9.21 12.50 42 0.055 44.043 50 0.066 52.432
750 9.87 12.59 50 0.066 52.052
800 10.53 12.68 49 0.064 50.639
850 11.18 12.77
900 11.84 12.87
950 12.50 12.97
1000 13.16 13.07
1050 13.82 13.16
1100 14.47 13.27
1150 15.13 13.37
1200 15.79 13.47
1250 16.45 13.58
1300 17.11 13.69
1350 17.76 13.80
1400 18.42 13.91
1450 19.08 14.02
1500 19.74 14.14
1550 20.39 14.25
1600 21.05 14.37
Specimen A B C
Moisture Content (%) 33.21 33.58 34.18 Sample Height, mm : 76
Bulk Density, Mg/m3 1.737 1.742 1.759 Sample Diameter, mm: 38
Dry Density, Mg/m3 1.304 1.304 1.311 Strain Rate, mm/min : 1.200
Normal Load At Failure, (kN) 0.051 0.056 0.066 Ring Factor, kN/div : 0.001311
Normal Stress, (kPa) 42.08 46.07 52.81
Lateral Stress, (kPa) 60 120 240 FAILURE TYPE : INTERMEDIATE
Total Normal Stress, (kPa) 102.08 166.07 292.81
FAILURE ENVELOPE OF MOHR CIRCLES
SAMPLE NO : BH4 / MZ / 6.50m
150
Partially Saturated Total Stress (Dot Line)
C = 18 kN/m2 φ = 2 deg
120
Shear Stress (kN/m2)
60
30
0
0 30 60 90 120 150 180 210 240 270 300
Total Normal Stress (kN/m2)
PRECISE TEST ENTERPRISE
UNCONSOLIDATED UNDRAINED COMPRESSION TEST (BS 1377 : PART 7 : 1990)
Project : CADANGAN 1 TAPAK LADANG SOLAR FOTOVOTAIK SEMENTARA (21 TAHUN) DI ATAS LOT 8431 MUKIM
PADANG SIDING, DAERAH CHUPING, PERLIS INDERA KAYANGAN.
SPECIMEN LAT. PRESSURE A SPECIMEN, kPa = 120 B SPECIMEN, kPa = 240 C SPECIMEN, kPa = 480
Deflect. Axial Correct. Proving Axial Deviator Proving Axial Deviator Proving Axial Deviator
Reading Strain Area Ring Load Stress Ring Load Stress Ring Load Stress
X0.01mm (%) (sq.cm) Reading (kN) (kPa) Reading (kN) (kPa) Reading (kN) (kPa)
0 0.00 11.35 0 0.000 0.000 0 0.000 0.000 0 0.000 0.000
25 0.33 11.38 4 0.005 4.605 5 0.007 5.756 6 0.008 6.907
50 0.66 11.42 7 0.009 8.032 8 0.010 9.179 10 0.013 11.474
75 0.99 11.46 11 0.014 12.580 11 0.014 12.580 13 0.017 14.867
100 1.32 11.50 14 0.018 15.958 14 0.018 15.958 16 0.021 18.237
125 1.64 11.54 17 0.022 19.313 17 0.022 19.313 19 0.025 21.585
150 1.97 11.57 20 0.026 22.645 20 0.026 22.645 22 0.029 24.909
175 2.30 11.61 23 0.030 25.954 23 0.030 25.954 25 0.033 28.211
200 2.63 11.65 26 0.034 29.241 26 0.034 29.241 28 0.037 31.490
225 2.96 11.69 29 0.038 32.504 29 0.038 32.504 31 0.041 34.746
250 3.29 11.73 31 0.041 34.628 31 0.041 34.628 34 0.045 37.979
275 3.62 11.77 33 0.043 36.737 33 0.043 36.737 36 0.047 40.077
300 3.95 11.81 35 0.046 38.830 35 0.046 38.830 38 0.050 42.159
325 4.28 11.85 37 0.048 40.909 37 0.048 40.909 40 0.052 44.226
350 4.61 11.89 39 0.051 42.972 39 0.051 42.972 42 0.055 46.277
375 4.93 11.93 41 0.054 45.020 41 0.054 45.020 44 0.058 48.314
400 5.26 11.98 43 0.056 47.052 43 0.056 47.052 46 0.060 50.335
425 5.59 12.02 44 0.058 47.979 44 0.058 47.979 48 0.063 52.341
450 5.92 12.06 45 0.059 48.899 45 0.059 48.899 50 0.066 54.332
475 6.25 12.10 46 0.060 49.811 46 0.060 49.811 52 0.068 56.308
500 6.58 12.15 47 0.062 50.715 47 0.062 50.715 53 0.069 57.189
550 7.24 12.23 48 0.063 51.429 48 0.063 51.429 54 0.071 57.858
600 7.89 12.32 48 0.063 51.065 49 0.064 52.128 55 0.072 58.512
650 8.55 12.41 48 0.063 50.700 50 0.066 52.812 56 0.073 59.150
700 9.21 12.50 47 0.062 49.286 51 0.067 53.481 57 0.075 59.773
750 9.87 12.59 52 0.068 54.135 58 0.076 60.381
800 10.53 12.68 52 0.068 53.739 58 0.076 59.940
850 11.18 12.77 51 0.067 52.318 58 0.076 59.499
900 11.84 12.87 57 0.075 58.040
950 12.50 12.97
1000 13.16 13.07
1050 13.82 13.16
1100 14.47 13.27
1150 15.13 13.37
1200 15.79 13.47
1250 16.45 13.58
1300 17.11 13.69
1350 17.76 13.80
1400 18.42 13.91
1450 19.08 14.02
1500 19.74 14.14
1550 20.39 14.25
1600 21.05 14.37
Specimen A B C
Moisture Content (%) 27.85 27.11 27.49 Sample Height, mm : 76
Bulk Density, Mg/m3 1.748 1.751 1.768 Sample Diameter, mm: 38
Dry Density, Mg/m3 1.367 1.378 1.387 Strain Rate, mm/min : 1.200
Normal Load At Failure, (kN) 0.063 0.068 0.076 Ring Factor, kN/div : 0.001311
Normal Stress, (kPa) 51.43 54.13 60.38
Lateral Stress, (kPa) 120 240 480 FAILURE TYPE : INTERMEDIATE
Total Normal Stress, (kPa) 171.43 294.13 540.38
FAILURE ENVELOPE OF MOHR CIRCLES
SAMPLE NO : BH4 / MZ / 12.50m
300
Partially Saturated Total Stress (Dot Line)
C = 22 kN/m2 φ = 1 deg
240
Shear Stress (kN/m2)
120
60
0
0 60 120 180 240 300 360 420 480 540 600
Total Normal Stress (kN/m2)
.
APPENDIX C
SITE PHOTOGRAPHS
LADANG
CADANGAN SOLAR
MEMBINA FOTOVOTAIK
JAMBATAN DI KG. DESASEMENTARA , PERLIS
MAKMUR JALAN GOMBAK-BENTONG
SEWERAGE LINE
E01-18 TO E01-19
N 2 , IPOH
SEWERAGE LINE
E01-18 TO E01-19
N 2 , IPOH
, MELAKA
, MELAKA
SEWERAGE LINE
LOCATION PLAN
BH1:
6.488466191148773,
BH2: 100.29408053581287
6.486019663386902,
100.29059352823955
BH4:
6°29'8.99"N,
100°17'27.12"E
BH3:
6.481981, 100.290085