The document provides instructions for inspecting the cooling fan system components in 3 steps:
1. Check the continuity of the cooling fan relay by applying voltage and measuring resistance across terminals. Replace if continuity is incorrect.
2. Inspect a second cooling fan relay in the same manner, checking continuity between terminals and replacing if necessary.
3. Measure the resistance of the cooling fan resistor and ensure it reads within the specified range of 1.17-1.43 ohms.
The document provides instructions for inspecting the cooling fan system components in 3 steps:
1. Check the continuity of the cooling fan relay by applying voltage and measuring resistance across terminals. Replace if continuity is incorrect.
2. Inspect a second cooling fan relay in the same manner, checking continuity between terminals and replacing if necessary.
3. Measure the resistance of the cooling fan resistor and ensure it reads within the specified range of 1.17-1.43 ohms.
The document provides instructions for inspecting the cooling fan system components in 3 steps:
1. Check the continuity of the cooling fan relay by applying voltage and measuring resistance across terminals. Replace if continuity is incorrect.
2. Inspect a second cooling fan relay in the same manner, checking continuity between terminals and replacing if necessary.
3. Measure the resistance of the cooling fan resistor and ensure it reads within the specified range of 1.17-1.43 ohms.
Inspect the cooling fan relay continuity. (1) Using an ohmmeter, check that there is continuity between terminals 1 and 2. If there is no continuity, replace the relay. (2) Check that there is no continuity between terminals 3 and 5. If there is continuity, replace the relay. (3) Apply battery voltage across terminals 1 and 2. (4) Using an ohmmeter, check that there is continuity between terminals 3 and 5. If there is no continuity, replace the relay.
2. (a)
If
If A30519
If
If
3. (a)
COOLING FAN RELAY NO.2
Inspect the cooling fan relay continuity. (1) Using an ohmmeter, check that there is continuity between terminals 1 and 2. there is no continuity, replace the relay. (2) Using an ohmmeter, check that there is continuity between terminals 3 and 4. there is no continuity, replace the relay. (3) Check that there is no continuity between terminals 3 and 5. there is continuity, replace the relay. (4) Apply battery voltage across terminals 1 and 2. (5) Using an ohmmeter, check that there is continuity between terminals 3 and 5. there is no continuity, replace the relay.
COOLING FAN RESISTOR
Using an ohmmeter, measure the resistance between the terminals. Resistance: 1.17 1.43 at 20 C (68 F)