Professional Documents
Culture Documents
Q.1 what is earth resistance? Explain how earth resistance in substation is measured? [June-14,
Sept-13]
Q.2 What is diff. between system earthing and structure earthing ? Explain with diagram,
measurement of earth resistance in substation. [Dec-14, June-14,July-12,Sept-13]
1. What are different types of tests performed on electrical equipment? Explain them briefly
2. Explain the procedure of alignment of shaft of electrical machines. [May-16,May-
12]
Q.1 Explain drying out method of oil cooled transformer? [ Oct ‘12]
Q.2 What is the method for purification of transformer oil? How can we [Oct ’12 ,Dec’14]
measure Dielectric strength of oil?
Q3 Explain the following test regarding transformer (1) Polarity test (2) Loss [Oct ’12, Dec’14]
measurement (3) Power frequency with stand test.
Q4 Explain the Phase group of Power Transformer with necessary vector and Sept’13
winding diagram.
Q5 Explain the properties of Transformer oil. Explain Dielectric test of [Sept’13, Dec’14]
transformer oil.
Q6 Explain the significance of Polarization Index Number. Explain drying [Sept’13, Oct ‘12]
out procedure of Power Transformer.
Q7 Explain with setup sketch, Impulse testing for power transformer. [Dec’14]
Q8 List out the various tests on transformer. Explain temp. Rise test for same. [Dec’14]
Q9 Explain power frequency and impulse voltage withstand test on three phase [ Dec’14]
distribution transformer.
Unit-4: Installation & commissioning of Rotating Machine:
Q1 what is polarization index? How can you measure the slip of induction [May’12, Dec’14]
motor?
Q2 Explain the causes and remedies of unbalance input current in 3- phase [May’12Sep’13
Induction motor. Dec’14]
Q3 In an industry main motor of 300 KW slip ring induction motor was burnt. An [May’12]
other motor of same size and rating was tested in workshop and found its
meggar value of 0.5 M Ohm. To prevent heavy loss of production it becomes
compulsory to install this within minimum possible time motors. As a
engineer what will be your decision.
Q4 Explain variation of voltage and frequency on performance of Induction [sept’13]
motor
Q5 Define Degree of Protection of Induction Motor. Explain I.P. and I.C. codes [Dec’14]
for same.
Q6 Explain purposes for performing No-load and Blocked rotor tests on 3-ф [ June’14]
induction motor.
Q7 Explain drying out procedure of a 3-ф induction motor. [ June’14]
DC Machine
Q. 1 State the various troubles with commutator and brush gear, their causes and [Dec-14 May-12]
remedies. Explain the choice of selection of materials used for the brushes
of various rotating machine
Q. 2 How voltage drop & bar-to-bar test is performed on DC machine? State [June-14 Sept-13]
importance of this test
Q. 3 Why the Hopkinson’s test performed on D.C. machine? Explain it. [July-12 Sept-13]
Q. 4 Explain the procedure of alignment of shaft of electrical machines. [May-12]
Q1 Explain Murray test for earth fault location in underground cable. [Dec-14, June-14 July-
12,Sept-13]
Q.2 State the types of cable fault locators and their applicatons. [June-12, July-2]
Q.3 Explain Line charging, loading & Dropping in cable [June-12, July-2]
Q4 Explain insulation resistance measurement for cable. [June-14, July-12]