Professional Documents
Culture Documents
NEWS
Q. Question Status
No
Ask an Expert
Q.1
a. μ
b. μ0.5
c. μ–1
d. μ–0.5
Q.2
For uniform laminar flow over a flat plate, the thickness of the boundary
layer (δ) at a distance x from the loading edge of the plate follows the
relation:
a.
b.
c.
d.
Q.3
Losses for flow through valves and fitting are expressed in terms of
a. drag coefficient
b. equivalent length of a straight pipe
c. shape factor
d. roughness factor
Q.4
a.
b.
c.
d.
Q.5
a. Decreases 2 times
b. Decreases 16 times
c. Increases 2 times
d. Increases 16 times
Q.6
a. Pitot tube
b. Venturimeter
c. Rotameter
d. Orificemeter
Q.7
Two and a half cumecs of water flows through a 50 cm diameter pipe. If the
diameter is reduced 25 cm at constant discharge, what would be the mean
velocity ?
a. 12.73 m/s
b. 10 m/s
c. 50.95 m/s
d. 40.72 m/s
Q.8
Match List-I with List-II and select the correct answer using the codes given
below the lists:
List-I List-II
A. Viscosity 1. Pyrometer
C. Velocity 3. Rheometer
a. a
b. b
c. c
d. d
Q.9
a.
b.
c.
d.
Q.10
Q.11
to satisfy the mass conservation, the value of the constant P (in s–1) is
___________.
Q.12
Q.13
Q.15
If the pressure of a liquid is increased from 850 N/cm2 to 1500 N/cm2, the
volume of liquid is decreased by 0.18%. The bulk modulus of elasticity of
liquid is ___________ GPa.
Q.16
___________ kg/m3.
Q.17
Q.18
3.2 m3 of a certain oil has weight 27.5 kN. The kinematic viscosity of the oil
is 7 × 10–3 stoke. What would be specific weight (w), specific volume (v),
Specific gravity(S) and dynamic viscosity(μ) of the fluid ?
a. a
b. b
c. c
d. d
Q.19
A pump draws oil (specific gravity 0.8) from a storage tank and discharges it
to an overhead tank. The mechanical energy delivered by the pump to the
fluid is 50 J/kg. The velocities at the suction and the discharge points of the
pump are 1 m/s and 7 m/s, respectively. Neglecting friction losses and
assuming kinetic energy correction factor to be unity, the pressure
a. 19.2
b. 20.8
c. 40
d. 80
Q.20
Match List-I with List-II and select the correct answer using the codes given
below the lists:
List-I List-II
a. a
b. b
c. c
d. d
Q.21
For flow of oil [μ = 0.1 kg/m-s, SG = 0.9] through a long, striaght smooth 5
a. 2200 Pa
b. 2535 Pa
c. 10000 Pa
d. 160 Pa
Q.22
a. 1, 2 and 4
b. 2, 3 and 4
c. 1, 3 and 4
d. 1, 2, 3 and 4
Q.23
A flat plate is exposed to a steady, constant density fluid flow with a free
stream parallel to the axis of the plate (case 1). In another case, this plate is
replaced by a plate which is half the length of the previous plate (case 2), all
other conditions remaining unaltered. In both the cases, flow over the entire
length of the plate is laminar. What is the ratio of the drag coefficients for
these two cases (Given: the local boundary layer thickness δ scales as
coordinate x)?
a.
b.
c.
d.
Q.24
a. 2.3 m
b. 5.3 m
c. 6.3 m
d. 8.3 m
Q.25
Q.26
Q.27
An unsteady flow velocity distribution is given below and assume the flow is
irrotaional, then the value of ‘C’ will be ___________.
Q.28
Q.29
A liquid is flowing through the following piping network. The length of pipe
sections P, Q, R and S shown in the schematic are equal. The diameters of
the sections P and R are equal and the diameter of the sections Q is twice
that of S. The flow is steady and laminar. Neglecting curvature and entrance
effects, the ratio of the volumetric flow rate in the pipe section Q to that in S
is ___________.
Q.30
Q.31
Q.32
Q.33
[Take g = 10 m/s2]