Professional Documents
Culture Documents
Panasonic Car Stereo System CQ-CP134U PDF
Panasonic Car Stereo System CQ-CP134U PDF
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
FO
CQ-CP134U DISP
FO
TUNE / TRACK
P US
TUNE / TRACK
P US
APM
switches the information
H SEL
H SEL
[SRC] (Source) REPEAT AUX
on the display.
REPEAT AUX S C R OL L RANDOM SCAN
SCAN
The 12-hour system is used for the clock. 1
S C R OL L RANDOM
6 selects a source. SQ
1
22 5 6
Display off [SQ] (Sound Quality) [SRC] (Source) *[AUX] (AUX IN)
2 Hold down [DISP] (CLOCK) for more than selects a sound type (SQ). selects a source. Caution to a line output of an external
Preset buttons [1] to [6]
selects a preset station in the radio source,
2 seconds. [PWR] (Power) Set the volume level to sound/audio device. and presets the current station. (Hold it down
toggles power on/off. low enough before the (ex. Silicon audio player, HDD audio for more than 2 seconds.) Up to 6 stations can be preset in AM, FM1, FM2, and FM3
Hour blinks. AUX connection is com- Manual station preset
Clock display player, etc) respectively.
pleted.
3 Adjust the hour. (for details Installation Instructions) Preset stations can be simply called up by pressing [1] to [6].
1 Tune into a station.
Hour entered. Power On/Off SQ (Sound Quality) Auto Preset Memory (APM) 2 Hold down one of the preset buttons from
Clock Setting
Set your car's ignition switch to the ACC or ON position. SQ is a function that can call up various sound types [1] to [6] for more than 2 seconds.
[[]: sets the hour ahead. With this operation, stations with good receiving conditions
[]]: sets the hour back. Power on: Press [SRC] (PWR). at the touch of button in accordance with your listen- can be automatically stored in the preset memory.
ing music type.
4 Press [DISP] (CLOCK). Power off: Hold down [SRC] (PWR) for
more than 1 second.
Press [SQ] to select the sound type as follows: 1 Select a band.
Minute blinks. (FLAT) flat frequency response: 1 Press [SRC] to select the radio source. 3 Select a station. 2 Hold down [BAND] (APM) for more than 2 (blinks once)
does not emphasize any part. (Default) seconds.
Source Selection 2 Press [BAND] to select a band.
5 Adjust the minute. Frequency adjustment The preset stations under best receiving conditions are
Note: New stations overwrite existing saved stations.
Station Preset
Press [SRC] to change the source. (ROCK) speedy and heavy sound:
Minute entered. * received for 5 seconds each after presetting the stations
General Operations
exaggerates bass and treble. [TUNE]]: Lower
Radio Disc Player AUX IN (SCAN). To stop scanning, press one of the buttons
[[]: sets the minute ahead. [TUNE[]: Higher from [1] to [6].
[]]: sets the minute back. (POP) wide-ranged and deep sound: Note: New stations overwrite existing saved stations.
Operation Flow
slightly emphasizes bass and treble. Note: Hold down either of them for more than 0.5 seconds
FO
¡ A disc which has both CD-DA data and MP3 Normal Normal DISP
TUNE / TRACK
nel. Please refer the checking and the repair to professionals.
P US
Printed side up consult your dealer.
H SEL
data on it may not be reproduced normally. Panasonic shall not be liable for any accidents arising out of neglect
[u] (Eject) Disc title Play time REPEAT AUX ¡ Never try to repair the unit by yourself because it is dangerous
Repeat indicator
S C R OL L RANDOM SCAN
of checking the unit or your own repair after your checking.
ejects the disc. SQ
1 2 3 SRC / PWR 4 5 6 to do so.
Never take measures especially for those other than indicated by
Player Source Display
DISP
TUNE / TRACK
Album*
P US
English
WMA MP3 CD Player/Receiver with CD Changer Control
■ Read the operating instructions for the unit and all other compo- ■ This manual uses pictographs to show you how to use the product
General FM Stereo Radio
Power supply : DC 12 V (11 V – 16 V DC), test voltage
14.4 V, negative ground
Frequency range
Usable sensitivity
: 87.9 MHz – 107.9 MHz
: 11.0 dBf. (75 Ω)
CQ-C1401U nents of your car audio system carefully before using the system.
They contain instructions about how to use the system in a safe and
effective manner. Panasonic assumes no responsibility for any prob-
safely and to alert you to potential dangers resulting from improper
connections and operations. The meanings of the pictographs are
explained below. It is important that you fully understand the mean-
Caution
Observe the following cautions when using this ❑ Use the designated parts and tools for installation.
Current consumption : Less than 2.2 A (CD mode; 0.5 W x 4 50 dB quieting sensitivity : 15.2 dBf. (75 Ω) lems resulting from failure to observe the instructions given in this ings of the pictographs in order to use this manual and the system Use the supplied or designated parts and appropriate tools to
channels) Frequency response : 30 Hz – 15 kHz (±3 dB) manual. properly. unit. install the product. The use of parts other than those supplied or
Maximum power output : 50 W x 4 channels (at 1 kHz), volume MP3 CD Player/Receiver
control maximum
Alternate channel selectivity : 75 dB ❑ Keep the sound volume at an appropriate level. designated may result in internal damage to the unit. Faulty
Tone adjustment range
Speaker impedance
: Bass: ±12 dB at 100 Hz,
Treble: ±12 dB at 10 kHz
:4 – 8 Ω
Stereo separation
Image rejection ratio
IF rejection ratio
: 35 dB (1 kHz)
: 55 dB
: 100 dB
Model: CQ-CP134U This pictograph intends to alert you to the presence of
important operating instructions and installation
This pictograph intends to alert you to the presence of
important operating instructions and installation instruc-
Keep the volume level low enough to be aware of road and traffic
conditions while driving.
❑ This unit is designed for use exclusively in automo-
installation may lead to an accident, a malfunction or fire.
❑ Do not block the air vent or the cooling plate of the unit.
Blocking these parts will cause the interior of the unit to over-
Pre-amp output voltage : 2.5 V (CD mode, 1 kHz, 0 dB) Signal/noise ratio : 62 dB
instructions. Failure to heed the instructions may tions. Failure to heed the instructions may result in biles. heat and will result in fire or other damage.
Pre-amp output impedance : 200 Ω AM Radio Warning Caution
❑ Do not operate the unit for a prolonged period with the
VO
result in severe injury or death. injury or material damage. ❑ Do not install the product where it is exposed to strong
L ER
LD
Operating Instructions
CQ-CP134U
FO
TUNE / TRACK
Dimensions (W x H x D) : 178 x 50 x 155 mm
P US
H SEL
{7” x 1 15/16” x 6 2/16”} Frequency range : 530 kHz – 1 710 kHz SQ
1 2
S C R OL L
3 SRC / PWR
RANDOM
4
SCAN
5
REPEAT
6
AUX
engine turned off. vibrations or is unstable.
Weight : 1.3 kg {2 lbs. 14 oz} Usable sensitivity : 28 dB/µV (S/N 20 dB) Operating the audio system for a long period of time with the Avoid slanted or strongly curved surfaces for installation. If the
engine turned off will drain the battery. installation is not stable, the unit may fall down while driving and
Front AUX input Above specifications comply with EIA standards. ❑ Do not expose the unit to direct sunlight or excessive this can lead to an accident or injury.
Input impedance : 10 kΩ Observe the following warnings when installing. ❑ Installation Angle
Allowable external input : 2.0 V Power Output: Warning ❑ Disconnect the lead from the negative (–) battery termi-
heat.
18 W RMS x 4 Channels at 4 Ω and ≤ 1% Otherwise these will raise the interior temperature of the unit, The product should be installed in a horizontal position with the
Connector : 3.5 mm ø stereo mini-pin Observe the following warnings when using this
THD+N nal before installation. and it may lead to smoke, fire, or other damage to the unit. front end up at a convenient angle, but not more than 30˚.
Disc Player Signal to Noise Ratio: unit. Wiring and installation with the negative (–) battery terminal con- ❑ Do not use the product where it is exposed to water, The user should bear in mind that in some areas there may be
85 dBA (reference: 1 W into 4 Ω) nected may cause electrical shock and injury due to a short circuit. moisture, or dust. restrictions on how and where this unit must be installed.
Sampling frequency : 8 times oversampling ❑ The driver should neither watch the display nor operate Some cars equipped with the electrical safety system have specific Consult your dealer for further details.
DA converter : 1 bit DAC System Exposure of the unit to water, moisture, or dust may lead to
Notes: the system while driving. procedures of battery terminal disconnection. smoke, fire, or other damage to the unit. Make especially sure ❑ Wear gloves for safety. Make sure that wiring is com-
Pick-up type : Astigma 3-beam Watching the display or operating the system will distract the driv-
Light source : Semiconductor laser ¡ Specifications and design are subject to modification without FAILURE TO FOLLOW THE PROCEDURE MAY LEAD TO THE that the unit does not get wet in car washes or on rainy days. pleted before installation.
notice due to improvements. er from looking ahead of the vehicle and can cause accidents. UNINTENDED ACTIVATION OF THE ELECTRICAL SAFETY SYSTEM
Wave length : 790 nm
¡ Some figures and illustrations in this manual may be different Always stop the vehicle in a safe location and use the parking ❑ Set the volume level to low enough before the AUX con- ❑ To prevent damage to the unit, do not connect the
Frequency response : 20 Hz – 20 kHz (±1 dB) RESULTING IN DAMAGE TO THE VEHICLE AND PERSONAL
from your product. brake before watching the display or operating the system. nection is completed. power connector until the whole wiring is completed.
Signal to noise ratio : 96 dB INJURY OR DEATH.
Total harmonic distortion : 0.01 % (1 kHz) ❑ Use the proper power supply. ❑ Never use safety-related components for installation,
Failure to observe this, the loud noise may come out and dam- ❑ Do not connect more than one speaker to one set of
Wow and flutter : Below measurable limits age your speakers and your hearing. Direct connection of the speaker leads. (except for connecting to a tweeter)
This product is designed for operation with a negative grounded grounding, and other such functions.
Channel separation : 75 dB speaker/headphone output of an external device without any
12 V DC battery system. Never operate this product with other bat- Do not use safety-related vehicle components (fuel tank, brake, attenuator may distort sound or damage the connected external
tery systems, especially a 24 V DC battery system. suspension, steering wheel, pedals, airbag, etc.) for wiring or fix-
Accessories ❑ Protect the Deck Mechanism. ing the product or its accessories.
device.
Do not insert any foreign objects into the slot of this unit. ❑ Installing the product on the air bag cover or in a location
Observe the following cautions when installing.
Instruction kit Installation kit (ZZBISC1101U-J) Mounting Collar
Operating Instructions (FX0214C384ZB) ❑ Do not disassemble or modify the unit. where it interferes with airbag operation is prohibited. ❑ Refer wiring and installation to qualified service per-
Lock Cancel Plate
(English: YFM284C698CA) (FX0214C385ZA) Q'ty: 1 Do not disassemble, modify the unit or attempt to repair the prod- ❑ Check for piping, gasoline tank, electric wiring, and other sonnel.
(Français: YFM284C699CA) Trim Plate uct yourself. If the product needs to be repaired, consult your items before installing the product. Installation of this unit requires special skills and experience. For
(Español: YFM264C001CA) Q'ty: 2 dealer or an authorized Panasonic Servicenter. maximum safety, have it installed by your dealer. Panasonic is
(YFC054C079YA) If you need to open a hole in the vehicle chassis to attach or wire
Q'ty: 1 set Mounting Bolt ❑ Do not use the unit when it is out of order. not liable for any problems resulting from your own installation
(YEJV014C002N) Q'ty: 1 the product, first check where the wire harness, gasoline tank, and
Installation Instructions If the unit is out of order (no power, no sound) or in an abnormal electric wiring are located. Then open the hole from outside if pos- of the unit.
Power Connector
(YFM294C111CA) Q'ty: 1 state (has foreign objects in it, is exposed to water, is smoking, or sible. ❑ Follow the instructions to install and wire the product.
Rubber Bushing (YEAJ02874)
Q'ty: 1 smells), turn it off immediately and consult your dealer. ❑ Never install the product in a location where it interferes Not following the instructions to properly install and wire the
(YFS014C095ZA) Q'ty: 1 ❑ Refer fuse replacement to qualified service personnel. product could cause an accident or fire.
Owners Information with your field of vision.
Card
Q'ty: 1 When the fuse blows out, eliminate the cause and have it replaced ❑ Never have the power cord branched to supply other ❑ Take care not to damage the leads.
with the fuse prescribed for this unit by a qualified service engi- When wiring, take care not to damage the leads. Prevent them
Q'ty: 1 equipment with power.
neer. Incorrect replacement of the fuse may lead to smoke, fire, from getting caught in the vehicle chassis, screws, and moving
and damage to the product. ❑ After installation and wiring, you should check the nor- parts such as seat rails. Do not scratch, pull, bend or twist the
Notes: mal operation of other electrical equipment. leads. Do not run them near heat sources or place heavy objects
¡ The number in parentheses underneath each accessory part name is the part number for maintenance and service. The continuation of their using in abnormal conditions may cause on them. If leads must be run over sharp metal edges, protect
¡ Accessories and their part numbers are subject to modification without prior notice due to improvements. fire, electrical shock or a traffic accident. the leads by winding them with vinyl tape or similar protection.
¡ Mounting Collar and Trim Plate are mounted on the main unit at shipment. ❑ In the case of installation to an airbag equipped car, con-
firm warnings and cautions of the vehicle manufacturer
© 2006 Matsushita Electric Industrial Co., Ltd. All Rights Reserved. before installation.
❑ Make sure the leads do not interfere with driving or get-
ting in and out of the vehicle. The following applies only in the U.S.A.
Panasonic Consumer TEXT ❑ Insulate all exposed wires to prevent short circuiting. Caution
Electronics Company, THIS PRODUCT UTILIZES A CLASS I LASER. Part 15 of the FCC Rules
Division of Panasonic USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF FCC Warning:
Corporation of North America PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY Any unauthorized changes or modifications to this equipment
One Panasonic Way, Secaucus, RESULT IN HAZARDOUS RADIATION EXPOSURE. would void the user's authority to operate this device.
New Jersey 07094 DO NOT OPEN COVERS AND DO NOT REPAIR BY YOURSELF.
http://www.panasonic.com ¡Please read these instructions (including “Limited Warranty” and “Customer Services Directory”) carefully before using this product REFER SERVICING TO QUALIFIED PERSONNEL.
and keep this manual for future reference.
YFM284C698CA PTW1206-0 Printed in China
Notes on MP3
¡ If the selected folder does not contain any MP3 files, the
During the “Labor” warranty period, there will be no charge for labor. recorded using CD recorders (CD-R/RW drives), either due depending on the file format.
U.S.A. Service in Puerto Rico During the “Parts” warranty period, there will be no charge for parts. You
nearest MP3 files in the order of playback will be played.
Panasonic Puerto Rico, Inc. must carry-in or mail-in your product prepaid during the warranty period.
to their recording characteristics or dirt, fingerprints, ¡ This unit does not have the play list function. ¡ Playback order may be different from other MP3 players
Obtain Product Information and Operating Assistance; locate Panasonic Sales Company If non-rechargeable batteries are included, they are not warranted. This scratches, etc. on the disc surface. ¡ Although Multi-session recording is supported, the use of even if the same disc is used.
your nearest Dealer or Servicenter; purchase Parts and warranty only applies to products purchased and serviced in the United ¡ CD-R/RW discs are less resistant to high temperatures and Disc-at-Once is recommended.
Factory Servicenter: States or Puerto Rico. This warranty is extended only to the original pur- Display Information ¡ “ROOT” appears when displaying the root folder name.
Accessories; or make Customer Service and Literature Ave. 65 de Infantería, Km. 9.5, San Gabriel Industrial Park, chaser of a new product which was not sold “as is”. A purchase receipt or high humidity than ordinary music CDs. Leaving them
Supported file systems
requests by visiting our Web Site at: Carolina, Puerto Rico 00985 other proof of the original purchase date is required for warranty service. inside a car for extended periods may damage them and Displayed items
ISO 9660 Level 1/Level 2, Apple Extension to ISO 9660, Joliet,
http://www.panasonic.com/support Phone (787) 750-4300, Fax (787) 768-2910 make playback impossible.
CARRY-IN OR MAIL-IN SERVICE Romeo ¡ CD-TEXT ¡ MP3 (ID3 tag)
or, contact us via the web at: For Carry-In or Mail-In Service in the United States, call 1-800-211-PANA ¡ Some CD-R/RWs cannot be played back successfully due
(7262) or visit
Disc title Album name
http://www.panasonic.com/contactinfo to incompatibility among writing software, a CD recorder Note: Apple HFS, UDF 1.50, MIX mode CD, CD Extra is not
Panasonic Web Site: http://www.panasonic.com Track title Title name/Artist name
Customer Services Directory
You may also contact us directly at: For assistance in Puerto Rico, call Panasonic Sales Company (787)-750-
(CD-R/RW drive) and the discs. supported. Copyright
1-800-211-PANA (7262), 4300 or fax (787)-768-2910. ¡ This player cannot play the CD-R/RW discs if the session is ¡ MP3
Monday-Friday 9 am-9 pm; Saturday-Sunday 10 am-7 pm, not closed. Compression formats Folder name It is prohibited by copyright laws to copy, distribute and
LIMITED WARRANTY LIMITS AND EXCLUSIONS (Recommendation: “Points to remember when making deliver copyrighted materials such as music without the
EST. ¡ This player cannot play the CD-R/RW discs which contain File name
CD-Rs/RWs
For hearing or speech impaired TTY users, TTY : 1-877-833- workmanship, and DOES NOT COVER normal wear and tear or cosmetic
8855 damage. The warranty ALSO DOES NOT COVER damages which occurred ¡ Be sure to observe the instructions of the CD-R/RW disc sonally.
during shipment, failures which are caused by products not supplied by Displayable characters
Accessory Purchases: the warrantor, failures which result from accident, misuse, abuse, neg- for handling it. ¡ Displayable length of file name/folder name: within 32 No warranty
lect, bug infestation, mishandling, misapplication, alteration, faulty instal-
Purchase Parts, Accessories and Instruction Books online for lation, set-up adjustment, maladjustment of consumer control, improper Recording MP3 files on a CD-media characters. (Unicoded file and folder names are reduced
Above description complies with our investigations as of
all Panasonic Products by visiting our Web Site at: maintenance, improper antenna, inadequate signal reception or pickup, ¡ MPEG 1 audio layer 3 by half in the number of displayable characters.)
power line surge, improper voltage supply, lightning, modification, com- ¡ You are recommended to minimize the chances of mak- December 2006. It has no warranty for reproducibility and
http://www.pasc.panasonic.com Bit rate: 32 k-320 kbps ¡ Name files and folders in accordance with the standard of
mercial use (such as use in hotels, offices, restaurants, or other business ing a disc that contains both CD-DA files and MP3 files. displayability of MP3.
or, send your request by E-mail to: uses) or rental use of the product, or service by anyone other than the each file system. Refer to the instructions of writing soft-
¡ If CD-DA files are on the same disc as MP3 or files, the VBR: Yes
npcparts@panasonic.com technician from Factory Servicenter or other authorized service centers, ware for details.
or damage that is attributable to acts of God. songs may not play in the intended order, or some songs Sampling frequency:
You may also contact us directly at: ¡ ASCII character set and special characters in each lan- MPEG Layer-3 audio coding technology licensed from
may not play at all. 32, 44.1, 48 kHz
1-800-332-5368 (Phone) 1-800-237-9080 (Fax Only) THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED UNDER guage can be displayed. Fraunhofer IIS and Thomson.
“LIMITED WARRANTY COVERAGE”. THE WARRANTOR IS NOT LIABLE ¡ Do not record files other than MP3 files and unnecessary ¡ MPEG 2 audio layer 3
(Monday-Friday 9 am to 8 pm, EST.)
FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES RESULTING FROM folder on a disc. Bit rate: 8 k-160 kbps Notes:
Panasonic Services Company THE USE OF THIS PRODUCT, OR ARISING OUT OF ANY BREACH OF
¡ The name of MP3 file should be added by rules as shown in VBR: Yes ¡ With some software in which MP3 format files have been
20421 84th Avenue South, Kent, WA 98032 THIS WARRANTY. (As examples, this excludes damages for lost time,
cost of having someone remove or re-install an installed unit if applica- the following descriptions and also comply with the rules of Sampling frequency: encoded, the character information may not be displayed
(We accept Visa, MasterCard, Discover Card, American ble, travel to and from the sevicer, and loss of media, data or other mem- each file system. 16, 22.05, 24 kHz properly.
Express, and Personal Checks) ory contents. The items listed are not exclusive, but are for illustration
only.) ALL EXPRESS AND IMPLIED WARRANTIES, INCLUDING THE ¡ You may encounter trouble in playing MP3 files or display- ¡ Undisplayable characters and symbols will be converted
For hearing or speech impaired TTY users, TTY : 1-866-605-
WARRANTY OF MERCHANTABILITY, ARE LIMITED TO THE PERIOD OF ing the information of MP3 files recorded with certain writ- into an asterisk ( ).
1277 THE LIMITED WARRANTY. ing software or CD recorders.