Professional Documents
Culture Documents
SUBMITTED TO
DHOLERA.
PREPARED BY
NAVRANGPURA, AHMEDABAD-380009
EMAIL ID : Bhoomi080808@gmail.com.
1. Introduction. 2
6. Soil Srtatification 7
Gujarat Power Corporation Ltd.,Dholera proposes soil investigation work for construction
of a 5000 MW solar park at Bhangadh (Mingalpur) in Dholera, Tal : Dholera , Dist :
Ahmedabad , Gujarat State.
The purpose of the investigations was to determine the sub soil stratification of the soil,
geotechnical information & safe bearing capacity of the soil, so as to provide information
that will assist the structural engineers in the design of the foundations and the relevant
works.
The Job was carried out under the guidance and supervision of the soil personnels of
Bhoomi Consultancy Services,Ahmedabad, and client’s engineer.
[ 2 ] FIELD WORK :
1) Drilling Twenty numbers of 150mm dia borehole with casing whenever required up
to maximum depth of 10.0m from ground level.
Termination depth and Location details of boreholes are given in the following table.
Location/Plot Borehole Location of Co- RL Of Depth Of Termination
No.: No. ordinates (m.) GL Water Table depth
Easting Northing (m) Below EGL below EGL
(m.) (m.)
4 BH-1 217153.89 245072.21 5.0 1.5 10.0
BH-2 216897.29 2451558.98 6.7 1.5 10.0
Drilling of 150 mm dia borehole was carried out by shell and Auger/Rotary drilling
method above water table. Water was added while drilling but stopped at enough height
above the test level to avoid disturbance
Drilling below water table was made by percussion drilling method. Casing is required to be
lowered if holes do not retain its shape. Care is taken to maintain ground water table during
drilling and particularly before testing or sampling levels.In no case casing is allowed to
advance below the bottom of borehole. Chiselling is carried out if required while drilling.
The Location of borehole was decided with due consideration of Client/Consultant of the
project
Undisturbed soil samples in 38mm Ø shelby tubes were collected in the thin walled
sampling tubes in accordance with IS:2132-1981at regular interval for finding shear
parameters, field density, moisture content etc. of soil.The sampling tube was connected to
the rod by jarring link in case of 38mm Ø tubes.’A’ drill rods were connected by suitable
adaptor with ball check value. Before lowering the sampler ,the borehole was cleaned
properly and sampling tubes were lightly oiled from inner and outer side.
Sampling tube was pushed into the borehole by pressure hammering as per the soil stiffness.
The sampling tubes were waxed immediately after removal.
In case of medium to coarse grained ,non-cohesive sand samples,where sampling is
unsuccessful,Standard Penetration Tests was carried out after cleaning the borehole.
However, disturbed soil samples from shell or split spoon samplers were also collected in
polythene bags with proper levels during drilling for finding index properties of the soil.
Following laboratory tests were carried out on the samples collected from the site.
1. Water content on selected samples from SPT
2. Field density,Moisture content and dry density of undisturbed samples.
3. Grain size Analysis of SPT samples,.UD samples and disturbed samples
covering each soil strata.
4. Atterberg’s Limit for samples
5. Specific gravity Test for samples as per 3.
6. Shrinkage Limit / Free Swell / Differential Swell test for selected samples of
expansive soil
7. Test for shear properties of selected samples.
8. Unconfined compressive Strength on saturated cohesive soil
9. Triaxial Shear test under UU/CU condition with or without pore pressure
measurement as per in situ conditions.Normally soft cohesive saturated samples will be
consolidated at average overburden pressure.
The common practice adopted in the field and laboratory testing by & large are as
per I S code indicated . Results of the laboratory tests performed on various soil samples
are presented in the form of table at the end of report.
The moisture cans collected from SPT samplers from the field are weighed and placed in
oven for drying to determine natural moisture content(NMC). Results are tabulated in
table-3 UDS are extracted using screw type extractor and samples were prepared as per the
required size of the test. Weight and volume of the samples were noted before extracting
from tubes. Average bulk density is calculated and samples were placed in oven to get the
field moisture content for computing the dry density.Results are tabulated in table 4
Specific gravity with specific gravity bottle/pycnometer is calculated as per IS
2720.Results were tabulated in table4.Saturation of sample in % is also calculated which is a
useful data for deciding the condition of triaxial shear test.
1) Unconfined compressive strength as per IS 2720 part-10 for the saturated plastic soil
2) Triaxial shear test is tobe carried out on samples of size 38mm dia and 76 mm in
height on motorized 30 speed load frame .The confining pressure б3 is applied to the cell
by oil water constant pressure system. The tests are carried out for the three conditions
a) Unconsolidated Undrained (UU) test without pore water pressure measurement as per
IS 2720 part 1
b) Consolidated Undrained (CU) test without pore water pressure measurement as per
IS 2720 part 11
The condition decided on type of sample and water table condition or designers
specifications.
c) Direct/box shear test on noncohesive medium to coarse sandy soil as per IS 2720 part
13.
(6.1.1)Layer No. 1
This layer from 0.0m to 10.0 m depth (thickness 10.0m) is observed to consist of blackish to
yellowish brown coloured silty marine clay of medium plasticity. The grain size analysis
and consistency limits indicate the layer as CI. The grain size analysis shows variation in %
of silt and clay as 97 to 99% in sand as 03 to 01% and gravels as 00 %.The variation in liquid
limit is from 39 to 48 % and that in plasticity index varies from 19 to 26%.
(6.2.1)Layer No. 1
This layer from 0.0m to 10.0 m depth (thickness 10.0m) is observed to consist of blackish to
yellowish brown coloured silty marine clay of medium plasticity. The grain size analysis
and consistency limits indicate the layer as CI. The grain size analysis shows variation in %
of silt and clay as 98 to 99% in sand as 01 to 02% and gravels as 00 to 01 %.The variation in
liquid limit is from 42 to 48 % and that in plasticity index varies from 18 to 26%.
[ 6.3 ] BOREHOLE: BH-1 to BH – 5 (Plot no.: 6)
(6.3.1)Layer No. 1
This layer from 0.0m to 10.0 m depth (thickness 10.0m) is observed to consist of blackish to
yellowish brown coloured silty marine clay of medium plasticity. The grain size analysis
and consistency limits indicate the layer as CI. The grain size analysis shows variation in %
of silt and clay as 98 to 99% in sand as 01 to 02% and gravels as 00 %.The variation in liquid
limit is from 40 to 48 % and that in plasticity index varies from 15 to 25%.
(6.4.1)Layer No. 1
This layer from 0.0m to 10.0 m depth (thickness 10.0m) is observed to consist of blackish to
yellowish brown coloured silty marine clay of medium plasticity. The grain size analysis
and consistency limits indicate the layer as CI. The grain size analysis shows variation in %
of silt and clay as 98 to 99% in sand as 01 to 02% and gravels as 00 %.The variation in liquid
limit is from 40 to 48 % and that in plasticity index varies from 15 to 25%.
Ground water table was observed in the borehole at depth 1.50 m to 2.50 m depth below
GL at the time of investigation. (May, 2018)
(8.1) The site for proposed soil investigation work at Bhangadh (Mingalpur) in general is
observed to consist of silty clay of medium plasticity up to 10.00m depth of termination.
Ground water table was observed in the borehole at depth 1.50 m to 2.50 m depth below
GL at the time of investigation. (May, 2018)
(8.2) The load carrying capacity of single bulb concrete under reamed pile of 0.30 m diameter
and 3.0 m depth below cut off level of 1.0 m depth below GL is recommended with load
carring capacity as t in compression and t in up lift condition. However it is advisable to
verify this load by pile load test as per IS 2911-Part 5.
( 8.3) The top soil is having high swelling potential and hence is not suitable to be used for
back / Plinth filling purpose.
(8.4) Chemical analysis of water sample shows very high chlorides and sulphates making it
unsuitable for concrete mixing and curing .It is also recommended to provide large cover
over reinforcement with anti corrosive paint and dense concrete.
(8.5) The value of CBR test in soaked condition shows as 4.7 to 5%.
(8.5) The results of the laboratory tests are incorporated in the form of table at the later part
of the report.
For,
Bhoomi Consultancy services ,
Authorised Signatory.
Bulb Diameter : 0. 75 m
Cut-off-Level : 1 m
Ru = Ap Nc Cp + Aa Nc Cp
= 2.22 + 11.69
= 13.91 Tonnes
Rf = α C As
= 2.03 tonnes
Where,
Qu = Ru + Rf
= 13.91 + 2.03
= 15.94 Tonnes
Where
= Qu / {Factor of Safety}
= 16.8 / 3.0
= 5.6 Tonnes
= 14.57 / 3.0
=4.5 Tonnes
Authorised Signatory.
ML: Inorganic silt and very fine sands,silty or clayey fine sands or clayey silt with non to
low plasticity
MI: Inorganic silts, silty or clayey fine sands or clayey silts of medium plasticity
Pt.: Peat and other highly organic soil with very high compressibility
NP : Non Plastic
LL : Liquid Limit
PL : Plastic Limits
PI : Plasticity Index
* : Remolded Sample
Ref. : Refusal
1. The test are carried out under certain laboratory condition and parameter
2. Results given in this report refers only to the material supplied to the laboratory.
3. The test report do not indicate the quality of the product or usage of product or
4.This test report does not indicate the sampling criterion for testing the samples..
7. Reproduction of this report in whole or in part by any means except with written
permission of the testing agency shall be deemed to be an infringement.
For,
Bhoomi Consultancy Services ,
Authorised Signatory.
Note:(1) Figures on the Left shows R.L. and Type of Sample (D-DS, U-UDS, S-SPT, C-Core, V-Field Vane Shear)
(2) Figures on the Rigtht side shows: (a) for SPT samples: Nc-No. of Blows/300mm Penetration (N.M.C.)
(b) for UDS samples: Bulk Density, (N.M.C.), Dry Density
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate plot no.: 4/217153.89E,245072.21N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-1
( Table No.-3) RL of GL (m) 5
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Soil & Stratum
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 48 24 24 45 0.15
silty clay soil with
UDS 1.5 medium plasticity 0 1 99 47 22 25 1.70 1.38 23.5 34 TUU 0.3 2 2.7
SPT 3 4 0 1 99 45 21 24
SPT 6 5 0 1 99 40 23 17
SPT 9 3 0 1 99 40 20 20
SPT 10 4 0 2 98 39 23 16
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate plot no.: 4/216897.29E,2451558.98N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-2
( Table No.-3) RL of GL (m) 6.7
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test ( Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
laod increment)
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 48 22 26 48 0.28
silty clay soil with
UDS 1.5 medium plasticity 0 1 99 49 23 26 1.77 1.40 26.2 40 TUU 0.3 1 2.7
SPT 3 4 0 1 99 45 21 24
SPT 6 4 0 1 99 48 22 26
DS 7.5 0 3 97 46 22 24
SPT 9 4 0 1 99 44 21 23
SPT 10 5 0 1 99 40 23 17
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate plot no.: 4/218363.86E,2450949.83N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-3
( Table No.-3) RL of GL (m) 4.2
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test ( Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 44 21 23 36 0.2
silty clay soil with
UDS 1.5 medium plasticity 0 1 99 40 22 18 1.64 1.35 21.8 40 TUU 0.3 1 2.67
SPT 3 4 0 1 99 45 20 25
SPT 6 4 0 1 99 46 21 25
SPT 9 3 0 1 99 44 23 21
UDS 10 0 1 99 40 23 17 1.85 1.49 23.8
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate plot no.: 4/219239.72E,2449689.02N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-4
( Table No.-3) RL of GL (m) 5.7
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Soil & Stratum
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 44 24 20 32
silty clay soil with
SPT 1.5 2 medium plasticity 0 1 99 42 23 19 TUU 0.28 2 2.7
SPT 7.5 3 0 2 98 44 21 23
UDS 9 0 1 99 42 20 22 20.2
1.8 1.5
SPT 10 4 0 2 98 45 25 20
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate plot no.: 4/220542.09E,2450046.82N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH‐5
( Table No.‐3) RL of GL (m) 5.9
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidati
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) on Test
Properties
Angle of internal friction(Degree)
C.C.(Average of last two laod
Visual Description of
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Soil & Stratum
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Dre Density gm/cc
Clay ( < 0.002mm)
lS Classification
Specific Gravity
Plasticity index
Depth (m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 44 24 20 32
silty clay soil with
SPT 1.5 3 medium plasticity 0 1 99 42 23 19 TUU 0.28 2 2.7
SPT 7.5 4 0 2 98 44 21 23
UDS 9 0 1 99 42 20 22 20.2
1.8 1.5
SPT 10 4 0 2 98 45 25 20
5.0
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 SPT
Authorised Signatory
5.0
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 16-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 1, plot 4 BH Completed on : 16-05-18 R.L. of Ground Level : 5.0
Depth
in Visual Soil Description
meters
00.00 DS 0.15 0 1 99 48 24 24 45
03.00 SPT 04 0 1 99 45 21 24
06.00 SPT 05 0 1 99 40 23 17
09.00 SPT 03 0 1 99 40 20 20
10.00 SPT 04 0 2 98 39 23 16
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
6.7
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 SPT
Authorised Signatory
6.7
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 15-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 2, plot 4 BH Completed on : 15-05-18 R.L. of Ground Level : 6.7
Depth
in Visual Soil Description
meters
00.00 DS 0.28 0 1 99 48 22 26 48
03.00 SPT 04 0 1 99 45 21 24
06.00 SPT 04 0 1 99 48 22 26
07.50 UDS 0 3 97 46 22 24
09.00 SPT 04 0 1 99 44 21 23
10.00 SPT 05 0 1 99 40 23 17
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
4.2
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 UDS
Authorised Signatory
4.2
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 15-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 3, plot 4 BH Completed on : 15-05-18 R.L. of Ground Level : 4.2
Depth
in Visual Soil Description
meters
00.00 DS 0.2 0 1 99 48 22 26 36
03.00 SPT 04 0 1 99 45 21 24
06.00 SPT 04 0 1 99 48 22 26
09.00 SPT 03 0 1 99 44 21 23
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.7
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 UDS
07.50 SPT
09.00 UDS
10.00 SPT
Authorised Signatory
5.7
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 17-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 4, plot 4 BH Completed on : 17-05-18 R.L. of Ground Level : 5.7
Depth
in Visual Soil Description
meters
00.00 DS 0 1 99 44 24 20 32
07.50 SPT 03 0 2 98 44 21 23
10.00 SPT 04 0 2 98 45 25 20
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.9
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 UDS
07.50 SPT
09.00 UDS
10.00 SPT
Authorised Signatory
5.9
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
|
O
|
O
|
O
O
|
75.0 |
O
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 17-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 5, plot 4 BH Completed on : 17-05-18 R.L. of Ground Level : 5.9
Depth
in Visual Soil Description
meters
00.00 DS 0 1 99 45 24 21 32
07.50 SPT 04 0 2 98 44 21 23
10.00 SPT 04 0 2 98 45 22 23
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
Bore Hole : 1 Bore Hole : 2 Bore Hole : 3 Bore Hole : 4 Bore Hole : 5
RL :3.78 m RL :6.7 m RL : 4.2 m RL : 5.7 m RL : 4.2 m
0.00 0.00 0.00 0.00 0.00
Note:(1) Figures on the Left shows R.L. and Type of Sample (D-DS, U-UDS, S-SPT, C-Core, V-Field Vane Shear)
(2) Figures on the Rigtht side shows: (a) for SPT samples: Nc-No. of Blows/300mm Penetration (N.M.C.)
(b) for UDS samples: Bulk Density, (N.M.C.), Dry Density
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 5/215824.57E,2452502.19N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-1
( Table No.-3) RL of GL (m) 3.78
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Soil & Stratum
Sample No.& Type
Angle of internal
laod increment)
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 46 23 23 45
silty clay soil with
UDS 1.5 medium plasticity 0 1 99 44 24 20 1.68 1.39 20.5 44 0.22 TUU 0.21 2 2.66
SPT 3 5 0 2 98 42 22 20
SPT 6 6 0 1 99 40 22 18
SPT 7.5 5 0 3 97 40 21 19
SPT 9 7 0 3 97 39 23 16
SPT 10 5 0 4 96 41 22 19
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 5/215530.93E,2450922.53N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-2
( Table No.-3) RL of GL (m) 6.98
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 48 23 25 36 0.2
silty clay soil with
UDS 1.5 medium plasticity 0 2 98 43 20 23 1.65 1.32 24.9 TUU 0.3 2
SPT 3 3 0 1 99 45 21 24
SPT 6 6 0 1 99 42 23 19
SPT 7.5 5 0 1 99 41 21 20
SPT 9 6 0 2 98 40 22 18
SPT 10 8 0 2 98 41 23 19
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 5/217379.99E,2450283.0N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-3
( Table No.-3) RL of GL (m) 3
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 0 100 46 24 22 0.22
silty clay soil with
UDS 1.5 medium plasticity 0 2 98 43 23 20 1.71 1.38 23.8 40 TUU 0.25 0
SPT 3 3 0 1 99 41 21 20
SPT 6 5 0 1 99 40 20 20
SPT 7.5 5 0 1 99 43 22 21
SPT 9 4 0 1 99 44 23 21
SPT 10 3 0 3 97 42 21 21
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 5/217928.15E,2448935.63N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-4
( Table No.-3) RL of GL (m) 3.2
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidati
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) on Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 45 23 22 36 0.2
silty clay soil with
UDS 1.5 medium plasticity 0 1 99 44 22 22 1.68 1.34 25.2 TUU 0.3 2 2.66
SPT 3 5 0 1 99 43 21 19
SPT 6 6 0 1 99 42 20 22
UDS 7.5 0 1 99 44 22 22
SPT 9 5 0 2 98 40 23 17
UDS 10 0 2 98 38 23 16
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 5/219667.89E,2448646.18N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH‐5
( Table No.‐3) RL of GL (m) 4.2
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidati
Field Density test Swelling ( F.D.D. / F.M.C.)
For Rock
Analysis(%) Limit(%) on Test
Properties
C.C.(Average of last two laod increment)
Angle of internal friction(Degree)
Visual Description of
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Soil & Stratum
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Dre Density gm/cc
Clay ( < 0.002mm)
lS Classification
Specific Gravity
Plasticity index
Depth (m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
Porsity(%)
Silt factor
Hatching
N Value
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 45 23 22 36 0.2
silty clay soil with
UDS 1.5 medium plasticity 0 1 99 44 22 22 1.68 1.34 25.2 TUU 0.3 2 2.66
SPT 3 6 0 1 99 43 21 19
SPT 6 5 0 1 99 42 20 22
UDS 7.5 0 1 99 44 22 22
SPT 9 5 0 2 98 40 23 17
UDS 10 0 2 98 38 23 16
3.78
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 SPT
Authorised Signatory
3.78
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
| | |
O
|
O
|
O
|
O
|
O
|
O
|O |
O
| O O
| O
| O
O
| O
| O
75.0 |
O
O
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 16-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 1 - plot no 5 BH Completed on : 16-05-18 R.L. of Ground Level : 3.78
Depth
in Visual Soil Description
meters
00.00 DS 0.22 0 1 99 46 23 23 45
03.00 SPT 04 0 2 98 42 22 20
06.00 SPT 06 0 1 99 40 22 18
07.50 SPT 05 0 3 97 40 21 19
09.00 SPT 07 0 3 97 39 23 16
10.00 SPT 05 0 4 96 41 22 19
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
6.98
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 SPT
Authorised Signatory
6.98
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 14-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 2 BH Completed on : 14-05-18 R.L. of Ground Level : 6.98
Depth
in Visual Soil Description
meters
00.00 DS 0.2 0 1 99 48 23 25 36
03.00 SPT 04 0 1 99 45 21 24
06.00 SPT 04 0 1 99 42 23 19
07.50 UDS 0 1 99 41 21 20
09.00 SPT 04 0 2 98 40 22 18
10.00 SPT 05 0 2 98 41 23 19
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
3.0
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 UDS
Authorised Signatory
3.0
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 14-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 3 BH Completed on : 14-05-18 R.L. of Ground Level : 3.0
Depth
in Visual Soil Description
meters
03.00 SPT 03 0 1 99 41 21 20
06.00 SPT 05 0 1 99 40 20 20
07.50 UDS 05 0 1 99 43 22 21
09.00 SPT 04 0 1 99 44 23 21
10.00 UDS 03 0 3 97 42 21 21
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
3.2
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 UDS
07.50 SPT
09.00 UDS
10.00 SPT
Authorised Signatory
3.2
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
|
O
|
O
|
O
|
O |
O |
O |
O |
O O
| O
|
| O
| O
| O
| O
| O
O
75.0 |
O
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 14-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 4 BH Completed on : 14-05-18 R.L. of Ground Level : 3.2
Depth
in Visual Soil Description
meters
00.00 DS 0.2 0 1 99 45 23 22 36
03.00 SPT 05 0 1 99 43 21 19
06.00 SPT 06 0 1 99 42 20 22
07.50 UDS 0 1 99 44 22 22
09.00 SPT 05 0 2 98 40 23 17
10.00 UDS 0 2 98 38 23 16
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
4.2
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 UDS
07.50 SPT
09.00 UDS
10.00 SPT
Authorised Signatory
4.2
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
|
O
|
O
|
O
|O |
O |
O |
O |
O O
| O
|
| O
| O
| O
| O
| O
O
75.0 |
O
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 14-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 5 BH Completed on : 14-05-18 R.L. of Ground Level : 4.2
Depth
in Visual Soil Description
meters
00.00 DS 0.2 0 1 99 45 23 22 36
03.00 SPT 06 0 1 99 43 21 22
06.00 SPT 05 0 1 99 42 20 22
07.50 UDS 0 1 99 44 22 22
09.00 SPT 05 0 2 98 40 22 18
10.00 UDS 0 2 98 38 22 16
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
Bore Hole : 1 Bore Hole : 2 Bore Hole : 3 Bore Hole : 4 Bore Hole : 5
RL :6.2 m RL :6.1 m RL : 5.66 m RL : 5.66 m RL : 5.66 m
0.00 0.00 0.00 0.00 0.00
Note:(1) Figures on the Left shows R.L. and Type of Sample (D-DS, U-UDS, S-SPT, C-Core, V-Field Vane Shear)
(2) Figures on the Rigtht side shows: (a) for SPT samples: Nc-No. of Blows/300mm Penetration (N.M.C.)
(b) for UDS samples: Bulk Density, (N.M.C.), Dry Density
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 6/213799.49E,2450976.84N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-1
( Table No.-3) RL of GL (m) 6.2
CLIENT.: GPCL,DHOLERA Water Table (m) 2.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Water Absorption(5)
Natural Moisture(%)
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
laod increment)
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 45 23 22 44 0.29
silty clay soil with
SPT 1.5 3 medium plasticity 0 1 99 40 20 20
SPT 4.5 5 0 2 98 40 20 20
SPT 9 6 0 1 99 44 23 21
SPT 10 9 0 2 98 40 22 18
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 6/213799.49E,2450976.84N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-2
( Table No.-3) RL of GL (m) 6.01
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 48 23 25 46 0.25
silty clay soil with
SPT 1.5 5 medium plasticity 0 3 97 47 25 22
SPT 4.5 6 0 2 98 40 22 18
SPT 6 6 0 1 99 40 22 18
SPT 7.5 21 0 3 97 39 21 17
SPT 9 40 0 3 97 45 22 23
SPT 10 47 0 5 95 41 21 20
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 6/216686.32E,2449287.07N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-3
( Table No.-3) RL of GL (m) 5.66
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 45 23 22 46 0.25
silty clay soil with
UDS 1.5 medium plasticity 0 1 99 40 25 15
SPT 4.5 7 0 2 98 45 22 23
SPT 6 6 0 4 96 40 22 18
SPT 7.5 6 0 2 98 44 21 23
SPT 9 5 0 3 97 38 22 16
SPT 10 4 0 2 98 39 21 18
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 6/216686.32E,2449287.07N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-4
( Table No.-3) RL of GL (m) 5.66
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 44 24 20
silty clay soil with
UDS 1.5 medium plasticity 1 2 97 42 21 21 1.69 1.36 24.5 46 0.25 TUU 0.38 2 2.66 0.21
SPT 3 10 0 2 98 48 21 27
UDS 4.5 2 2 96 40 22 18
SPT 6 7 1 6 93 40 22 18
UDS 7.5 0 4 94 42 20 22
SPT 9 5 0 4 96 45 23 22
UDS 10
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 6/216686.32E,2449287.07N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-5
( Table No.-3) RL of GL (m) 5.66
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey colored CI 0 1 99 41 22 19
silty clay soil with
UDS 1.5 medium plasticity 1 2 97 42 21 21 1.69 1.35 25.2 46 0.25 TUU 0.22 1 2.66 0.2
SPT 3 5 0 2 98 40 20 20
UDS 4.5 2 2 96 39 21 18
SPT 6 6 1 6 93 42 22 20
UDS 7.5 0 4 94 42 22 20
SPT 9 5 0 4 96 45 23 22
UDS 10
6.2
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 UDS
07.50 SPT
09.00 SPT
10.00 SPT
Authorised Signatory
3.78
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 14-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 1 - plot no 6 BH Completed on : 14-05-18 R.L. of Ground Level : 6.2
Depth
in Visual Soil Description
meters
00.00 DS 0.29 0 1 99 45 23 22 44
07.50 SPT 06 0 2 98 41 21 20
09.00 SPT 06 0 1 99 44 23 21
10.00 SPT 09 0 2 98 40 22 18
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
6.01
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 SPT
07.50 SPT
09.00 SPT
10.00 SPT
Authorised Signatory
6.01
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |O |O |
O
|
O
|
O
|
O
|O |O
|
O
|
O
O
|
O
|
O
|
O
|
O
|
75.0 O
|
O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 12-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 2 plot no 6 BH Completed on : 12-05-18 R.L. of Ground Level : 6.01
Depth
in Visual Soil Description
meters
00.00 DS 0.25 0 1 99 48 23 25 46
01.50 SPT 05 0 3 97 47 25 22
04.50 SPT 06 0 2 98 40 22 18
Blackish grey colored silty
clay soil with medium
plasticity
06.00 SPT 06 0 1 99 40 22 18
07.50 SPT 21 0 3 97 39 21 17
09.00 SPT 40 0 3 97 45 22 23
10.00 SPT 47 0 5 95 41 21 20
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.66
00.00 DS
01.50 UDS
03.00 SPT
04.50 SPT
06.00 SPT
07.50 SPT
09.00 SPT
10.00 SPT
Authorised Signatory
5.66
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 O O O
|
O
|
O
|
O
|
O
|
O |
O |
O |
O |
O |
O |
O |
75.0 O
O
|
|
O |
|
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 11-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 3 plot no 6 BH Completed on : 11-05-18 R.L. of Ground Level : 5.66
Depth
in Visual Soil Description
meters
00.00 DS 0 1 99 44 24 20
03.00 SPT 08 0 2 98 48 21 27
04.50 SPT 07 2 2 96 40 22 18
Blackish grey colored silty
clay soil with medium
plasticity
06.00 SPT 06 1 6 93 40 22 18
07.50 SPT 06 0 4 96 42 20 22
09.00 SPT 05 0 4 96 45 23 22
10.00 SPT 04
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.66
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 UDS
Authorised Signatory
5.66
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 O O O O O O
|
O
|
O
|
O O | | | |
| |
O |
O |
O |
O |
O |
75.0 O
O
|
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 13-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 4 plot no 6 BH Completed on : 13-05-18 R.L. of Ground Level : 5.66
Depth
in Visual Soil Description
meters
00.00 DS 0.25 0 1 99 45 23 22 46
01.50 UDS 0 1 99 40 25 15
04.50 SPT 0 2 98 45 22 23
Blackish grey colored silty
clay soil with medium
plasticity
06.00 SPT 07 0 4 96 40 22 18
07.50 SPT 0 2 98 44 21 23
09.00 SPT 05 0 3 98 38 22 16
10.00 SPT 0 2 98 39 21 18
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.66
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 UDS
Authorised Signatory
5.66
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5
75.0
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 13-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 5 plot no 6 BH Completed on : 13-05-18 R.L. of Ground Level : 5.66
Depth
in Visual Soil Description
meters
00.00 DS 0.25 0 1 99 41 22 19 46
01.50 UDS 1 2 98 42 21 21
04.50 SPT 2 2 98 39 21 18
Blackish grey colored silty
clay soil with medium
plasticity
06.00 SPT 06 1 2 98 42 22 20
07.50 SPT 0 4 96 42 22 20
09.00 SPT 05 0 4 96 45 23 22
10.00 SPT
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
Bore Hole : 1 Bore Hole : 2 Bore Hole : 3 Bore Hole : 4 Bore Hole : 5
RL :3.97 m RL :5.35 m RL : 5.54 m RL : 4.3 m RL : 5.1 m
0.00 0.00 0.00 0.00 0.00
Note:(1) Figures on the Left shows R.L. and Type of Sample (D-DS, U-UDS, S-SPT, C-Core, V-Field Vane Shear)
(2) Figures on the Rigtht side shows: (a) for SPT samples: Nc-No. of Blows/300mm Penetration (N.M.C.)
(b) for UDS samples: Bulk Density, (N.M.C.), Dry Density
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 7/214509.73E, 2448040.76N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-1
( Table No.-3) RL of GL (m) 3.97
CLIENT.: GPCL,DHOLERA Water Table (m) 2
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey to CI 0 2 98 48 22 26 40 0.24
brownish colored
SPT 1.5 3 silty clay soil with 0 1 99 48 22 26 48
medium plasticity
UDS 3 0 1 99 42 21 21 1.74 1.40 23.8 TUU 0.21 2
SPT 4.5 7 0 1 99 45 22 23
SPT 9 6 0 2 98 40 20 20
SPT 10 7 0 1 99 42 21 21
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 7/216514.49E, 2447761.85N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-2
( Table No.-3) RL of GL (m) 5.35
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey to CI 0 1 99 46 24 22 51 0.4
brownish colored
SPT 1.5 5 silty clay soil with 0 1 99 45 21 24
medium plasticity
SPT 3 7 0 2 98 48 22 26
SPT 4.5 7 0 1 99 41 22 19
SPT 6 5 0 2 98 40 22 18
SPT 7.5 7 0 1 99 42 22 20
SPT 9 5 0 1 99 44 21 23
SPT 10 9 0 2 98 40 21 19
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 7/216748.50E, 2446169.89N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-3
( Table No.-3) RL of GL (m) 5.45
CLIENT.: GPCL,DHOLERA Water Table (m) 2
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey to CI 0 1 99 46 23 23 48 0.35
brownish colored
SPT 1.5 12 silty clay soil with 0 1 99 44 22 22
medium plasticity
UDS 3 0 2 98 45 21 24 1.71 1.38 23.8 TUU 0.2 2
SPT 4.5 8 0 1 99 42 22 20
UDS 9 1 1 98 41 19 22
SPT 10 8 1 2 97 42 21 21
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 7/218345.57E, 2444785.23N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-4
( Table No.-3) RL of GL (m) 4.3
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey to CI 0 1 99 46 23 23 42 0.29
brownish colored
UDS 1.5 silty clay soil with 0 1 99 45 23 22 1.68 1.36 23.5
medium plasticity
SPT 3 8 0 1 99 48 24 24 TUU 0.25 3
SPT 6 19 1 2 97 45 23 22 0.38 2
TUU
UDS 7.5 1 1 98 42 24 18
SPT 9 20 1 3 96 48 26 22
UDS 10 1 2 97 42 22 20
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate Plot no.: 7/216761.84E, 2444236.23N
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No. BH-5
( Table No.-3) RL of GL (m) 5.1
CLIENT.: GPCL,DHOLERA Water Table (m) 1.5
Depth Of B.H.(m) 10
Sieve/Hydrometer Atterberg's Shear Parameters Test Consolidatio
Field Density test Swelling For Rock
Analysis(%) Limit(%) ( F.D.D. / F.M.C.) n Test
Properties
Uniaxial Comp.Str(kg/cm2)
Swelling pressure(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Silt(0.002 to 0.075mm)
Water Absorption(5)
Natural Moisture(%)
Soil & Stratum
Cohesion kg/sq.cm.
Free swell Index(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
DS 0 Blackish grey to CI 0 1 99 48 25 23
brownish colored
SPT 1.5 5 silty clay soil with 0 1 99 45 23 22
medium plasticity
UDS 3 0 1 99 46 24 22 1.65 1.33 24.2 TUU 0.21 2 2.7
SPT 4.5 10 0 2 98 44 22 20
DS 9 0 1 99 45 23 22
SPT 10 10 0 1 99 45 23 22
3.97
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 UDS
07.50 SPT
09.00 SPT
10.00 SPT
Authorised Signatory
3.97
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
O
|
O
|
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 12-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 1 - plot no 7 BH Completed on : 12-05-18 R.L. of Ground Level : 3.97
Depth
in Visual Soil Description
meters
00.00 DS 0.24 0 2 98 48 22 26 40
07.50 SPT 06 0 2 98 48 24 24
09.00 SPT 06 0 2 98 40 20 20
10.00 SPT 07 0 1 99 42 21 21
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.35
00.00 DS
01.50 SPT
03.00 SPT
04.50 SPT
06.00 SPT
07.50 SPT
09.00 SPT
10.00 SPT
Authorised Signatory
5.35
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
O
|
O
|
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 11-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 2 plot no 7 BH Completed on : 11-05-18 R.L. of Ground Level : 5.35
Depth
in Visual Soil Description
meters
00.00 DS 0.4 0 1 99 46 24 22 51
01.50 SPT 05 0 1 99 45 21 24
03.00 SPT 07 0 2 98 48 22 26
04.50 SPT 07 0 1 99 41 22 19
Blackish grey colored silty
clay soil with medium
plasticity
06.00 SPT 05 0 2 98 40 22 18
07.50 SPT 07 0 1 99 42 22 20
09.00 SPT 05 0 1 99 44 21 23
10.00 SPT 09 0 2 98 40 21 19
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.45
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 DS
07.50 SPT
09.00 UDS
10.00 SPT
Authorised Signatory
5.45
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 O
|
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 10-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 3 plot no 7 BH Completed on : 10-05-18 R.L. of Ground Level : 5.45
Depth
in Visual Soil Description
meters
00.00 DS 0.35 0 1 99 46 23 23 48
01.50 SPT 12 0 1 99 44 22 22
04.50 SPT 08 0 1 99 42 22 20
Blackish grey colored silty
clay soil with medium
plasticity
07.50 SPT 09 1 1 98 44 23 21
09.00 UDS 1 1 98 41 19 22
10.00 SPT 08 1 2 97 42 21 21
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
4.3
00.00 DS
01.50 UDS
03.00 SPT
04.50 UDS
06.00 SPT
07.50 UDS
09.00 SPT
10.00 UDS
Authorised Signatory
4.3
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 |O |O |O |
O |
O O
| |O O
|
| |
O
| O
| O
| O
| O
| O
75.0 |
|
O
O
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 08-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 4 plot no 7 BH Completed on : 08-05-18 R.L. of Ground Level : 4.3
Depth
in Visual Soil Description
meters
00.00 DS 0.29 0 1 99 46 23 23 42
03.00 SPT 08 0 1 99 48 24 24
06.00 SPT 19 1 2 97 45 23 22
07.50 UDS 1 1 98 42 24 18
09.00 SPT 20 1 3 96 48 26 22
10.00 UDS 1 2 97 42 22 20
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
5.1
00.00 DS
01.50 SPT
03.00 UDS
04.50 SPT
06.00 UDS
07.50 SPT
09.00 UDS
10.00 SPT
Authorised Signatory
5.1
00.00
01.50
03.00
04.50
06.00
07.50
09.00
10.00
Authorised Signatory
| |
O O
97.5
90.0
82.5 O
|
|
O |
O |
O |
O |
O |
O |
O |
O |
O |
O
|
O
O
|
|
O
|
O
|
O
75.0 O
|
67.5
60.0
% PASSING
52.5
45.0
37.5
30.0
22.5
15.0
7.5
0.00
PARTICLE SIZE (mm)
Authorised Signatory
SUMMARY OF GEOTECHNICAL EXPLORATIONS
Project No. : 5000 MW Dholera Solar park at bhangadh BH Started on : 06-05-18 Depth of Water Table (m) :
Bore Hole No. : BH 5 plot no 7 BH Completed on : 06-05-18 R.L. of Ground Level : 5.1
Depth
in Visual Soil Description
meters
00.00 DS 0.25 0 1 99 48 25 23 46
01.50 SPT 05 0 1 99 45 23 22
04.50 SPT 10 0 2 98 44 22 20
Blackish grey colored silty
clay soil with medium
plasticity
07.50 SPT 16 0 1 99 42 24 18
09.00 UDS 0 1 99 45 23 22
10.00 SPT 10 0 1 99 45 23 22
SPT-Standard Penetration Test DS-Disturbed Sample Gr-Gravel LL-Liquid Limit Pi-Plasticity Index Cv-Coeff of Consolidation CR-Core Recovery
UDS-Undisturbed Sample VST-Vane Shear Test Sn-Sand PL-Plastic Limit C,
302, 3rd floor, Mangalmurti Complex, Opp. City Gold, Ashram Road, Navarangpura, Ahmedabad-380009
Bhoomi Consultancy Services
Authorised Signatory
Name of work 5000 MW Dholera solar park at Bhangadh
Consultant.: Bhoomi Consultancy Services
Location/Coordinate
Ahmedabad
SUMMARY OF EXPLORATION DATA Bore hole No.
( Table No.-3) RL of GL (m)
CLIENT.: GPCL,DHOLERA Water Table (m)
Depth Of B.H.(m)
Uniaxial Comp.Str(kg/cm2)
Sand(4.75mm & 0.075mm
Gravel(4.75 mm & above
Visual Description of
Water Absorption(5)
Soil & Stratum
Cohesion kg/sq.cm.
Unsoaked Value(%)
Bulk Density gm/cc
Sample No.& Type
Angle of internal
friction(Degree)
Specific Gravity
lS Classification
Plasticity index
(m)
Type of Test
Plastic Limit
Liquid Limit
P.C.kg/cm2
increment)
Porsity(%)
Silt factor
Hatching
N Value
Depth
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
1 0.5 Blackish grey colored CI 0 1 99 48 24 24 1.80 14.6 7.2 5.2
silty clay soil with
2 0.5 medium plasticity 0 1 99 47 22 25 1.79 15.8 8.8 4.7