You are on page 1of 2

Republic of the Philippines

Department of Education
Division Office of Taguig City and Pateros
PRESIDENT DIOSDADO MACAPAGAL HIGH SCHOOL

T.L.E. - Electrical Installation and Maintenance


Grade 7 JEREMIAH, LEVITICUS AND ISAIAH
A. Y. 2019 -2020
Name: ______________________________________________________ Score: ______________________
Grade & Section: ___________________________________________ Date: ______________________

I. Directions: Read each item carefully and choose the letter of the best answer from the choices below. Write your answer on the
space provided.

_______1. This is used for griping, holding, cutting electrical wires and cables and even small nails.
a. Combination Pliers b. Hammer c. Electrician’s Knife d. Cutter pliers
_______2. This can reach tight space or small opening where other pliers cannot reach.
a. Long Nose Pliers b. Hammer c. Electrician’s Knife d. Cutter pliers
_______3. This has a cross tip resembling a positive (+) sign. It is used to drive screws with cross slot heads.
a. Long Nose Pliers b. Hammer c. Philip Screw Driver d. Cutter plier
_______4. This is tools used in driving or pounding and pulling out nails.
a. Long Nose Pliers b. Hammer c. Philip Screw Driver d. Cutter plier
_______5. A tool used for removing insulation of medium sized wires ranging from gauge #10 to gauge #16.
a. Junction Box b. Wire Stripper c. Conduit d. Male Plug
_______6. A small drilling machine with a chuck capacity of ¼‖ to 3/8‖.
a. Stubby Screw Driver b. Portable Electrical Drill c. Fuse d. Male Plug
_______7. Comes in either Standard or Philips screw driver with short shank or blade and shorted handle used to
turn screws in tight space where standard screw drive cannot be used.
a. Junction Box b. Portable Electrical Drill c. Fuse d. Male Plug
_______8. Used by linemen to remove insulation of wire and cables in low and high voltage transmission lines.
a. Long Nose Pliers b. Hammer c. Electrician’s Knife d. Cutter pliers
_______9. Is a device inserted to a convenience outlet to conduct electric current.
a. Clamp b. Switch c. Male Plug d. Connectors
_______10. This is a circuit protective device that automatically blows and cut the current when an over load or
short circuit happens.
a. Circuit Breaker b. Switch c. Buzzer d. Male Plug
_______11. This is a rectangular shaped metallic or plastic (PVC) material in which flush type
convenience outlet and switch are attached.
a. Conduits b. Utility Box c. Junction Box d. Connectors
_______12. Are electrical materials used as the passage of wires for protection and Insulation.
a. Conduits b. Utility Box c. Junction Box d. Connectors
_______13. Are used to attach metallic or non-metallic conduit to the junction or utility boxes.
a. Conduits b. Utility Box c. Junction Box d. Connectors
_______14. This is a protective device used to cut off the current when trouble in the circuit such as short circuit or
over load occurs.
a. Fuse b. Switch c. Buzzer d. Male Plug
_______15. Is an octagonal shaped electrical material where the connections or
joints of wires are being done. It is also where the flush type lamp holder is attached.
a. Conduits b. Utility Box c. Junction Box d. Connectors

________16 a. Knotted Top b. Y- Splice c. Rat Tail d. Plain Tap Joint

________17. a. Knotted Top b. Y- Splice c. Rat Tail d. Plain Tap Joint

_______18. a. Knotted Top b. Y- Splice c. Rat Tail d. Plain Tap Joint

_______19. a. Knotted Top b. Y- Splice c. Rat Tail d. Plain Tap Joint

_______20. a. Aerial Tap b. Cross Duplex


c. Western union Short Tie Splice d. Western Union Long Tie

_______21. a. Aerial Tap b. Cross Duplex


c. Western union Short Tie Splice d. Western Union Long

_______22. a. Aerial Tap b. Cross Duplex


c. Western Union Short Tie Splice d. Western Union Long

_______23. a. Aerial Tap b. Cross Duplex


c. Western Union Short Tie Splice d. Western Union Long
_______24. a. Switch b. Fuse c. Cell d. battery

_______25. a. Switch b. Fuse c. Cell d. battery

_______26 a. Terminal b. Conductor c. Range Outlet d. Diode

_______27. a. Antenna b. battery c. Floor Outlet d. Incandescent Lamp

_______28. a. Antenna b. battery c. Floor Outlet d. Incandescent Lamp

_______29. a. Antenna b. battery c. Floor Outlet d. Male Plug

_______30. a. Antenna b. battery c. Floor Outlet d. Male Plug

_______31. a. Antenna b. battery c. Floor Outlet d. Male Plug

________32. a. Wires Connected b. Terminal c. Conductor d. Floor Outlet

______33. a. Wires Connected b. Terminal c. Conductor d. Ground


______34. The unit of electrical current (coulombs per second)
a. Volts b. Ampere c. Watts d. Ohm
______35. It specifies hazardous situation which, if not avoided, will result to a serious injury or even death
a. Warning b. High Voltage c. Danger d. Caution
______36. The unit of electrical resistance (volts/ampere)
a. Ohm b. Volts c. Watts d. Current
______37. The unit of electric pressure or electromotive force which will produce a current.
a. Ohm b. Volts c. Watts d. Current
______38. An instrument used to measure the amount of electrical current intensity in a circuit.
a. Voltmeter b. Ammeter c. Micrometer d. Ohmmeter
______39. A pocket sized tool used to test the line wire or circuit if there is current in it.
a. Test light b. Wire gauge c. Ruler d. Pull-push rule
______40. A measuring tool used to measure the length of an object in centimeter and inches.
a. Test light b. Wire gauge c. Ruler d. Pull-push rule
______41. It is used to measure the diameter of wires/conductors in circular mils.
a. Voltmeter b. Ammeter c. Micrometer d. Ohmmeter

______42. a. Conduit b. Junction Box c. Utility Box d. Circuit Breaker

______43. a. Conduit b. Junction Box c. Utility Box d. Circuit Breaker

______44. a. Conduit b. Junction Box c. Utility Box d. Long Nose Pliers

______45. a. Connector b. Fuse c. Conduit d. Lamp Holder

______46. a. Clamp b. Fuse c. Conduit d. Lamp Holder

______47. a. Clamp b. Swtich c. Conduit d. Outlet

_______48. a. Male Plug b. Convenience Outlet C. Extension Wire d. Flat Cord

_______49. a. Conduit b. Junction Box c. Utility Box d. Pliers

_______50. a. Conduit b. Junction Box c. Utility Box d. Pliers

Prepared by: Mr. Dominic Hawang __________________________________


Subject Teacher Parent’s/Guardian’s Signature

You might also like