Professional Documents
Culture Documents
3) In a cylinder splitting test, the member 11) Assume straight line instead of parabola for
yielded/cracked at a load of 100 kN. If the length stress strain curve of concrete as given below
and diameter of the member are 500 mm, 100 mm and partial FOS as 1.25.
then the splitting tensile strength is _______ MPa.
[1.27]
a) 86.58 kN b) 108.89 kN
just prior to failure. What is the flexure bond stress
c) 195.47 kN d) 100 kN
at that section. Take M20 concrete & Fe415 steel.
B = 400 mm _______ [0.74 N/mm2]
26) The critical sections for shear at left and right
support of the beam respectively are 30) Consider the following statements:
(Where d = effective depth of beam) 1. Reinforcement that is no longer required for
flexure beyond a certain section, shall
however be extended by ‘d’ or 12Ф,
whichever is greater, before being curtailed
2. Atleast half of the total bars should be bent
up at the cut off point
Which of these statement(s) is/are correct?
a) 1 only b) 2 only
c) 1 & 2 d) none of above
46) A rectangular column has dimension 600 mm x 52) In post tensioned system
300 mm. the unsupported length is 3 m. what is a) Wires are first tensioned followed by
the difference between the minimum concreting
eccentricities (in mm) the perpendicular planes b) Tensioning of wires and concreting is
________. [6 mm] simultaneously done
c) The wires are tensioned against the
RINCHTAR _RCC –PS -06
49) A square footing of dimension 2 m x 2m supports Common data question for Q 54 & 55
a square column of section 400 mm. the A simply supported prestressed concrete beam
minimum overall depth required to support this of span 6 m, 300 mm wide and 600 mm total
column load of 700 kN will be? Use M20 concrete depth. It is prestressed by 1200 kN, linear cable
and Fe415 steel. of zero eccentricity at supports and 100 mm
a) 225 mm b) 250 mm eccentricity at mid span
c) 275 mm d) 300 mm 54) Maximum and minimum prestress developed at
mid span are equal to (in MPa)
50) The plan of the stairs supported at each end by a) Zero & 13.33 b) 23.33 & 15.22
RINCHTAR _RCC –PS -06
landing spanning parallel with risers is shown in c) 13.33 & zero d) 15.33 & 23.33
figure. The effective span of staircase slab is
55) Neglecting the self weight, the magnitude of
central load that can sustain will be _______.
a) 60 kN b) 80 kN
c) 90 kN d) 100 kN
dip is 0.9 m. effective prestressing force is 40 kN eccentricity of 20 mm. The cross sectional area
and length of the beam is 10 m. the equivalent of the prestressing steel is 87.5 mm2. Take
upward acting uniform load is ______ kN/m. modulus of elasticity of steel and concrete as 2.1
[2.88] x 105 MPa and 3.0 x 104 MPa respectively. The
% loss of stress in the prestressing steel due to
59) A prestressed concrete beam is 250 mm x 500 elastic deformation of concrete is
mm deep has a span of 9 m. it carries two point a) 8.75 b) 6.125
loads 20 kN each placed at 3 m and 6 m from c) 4.81 d) 2.19
one end. A load balancing cable is provided with
an eccentricities of 100 mm for the middle third 64) Which of the following is categorized as a long
of the beam. The prestressing force required so term loss of prestress in a pre stressed concrete
that under the action of the prestressing force, member?
the imposed loads and dead load of the beam a) Loss due to elastic shortening
the stress at the soffit at the mid section is zero b) Loss due to friction
is _______. [dead load of the beam is 24 kN/m3] c) Loss due to relaxation of strands
a) 492.95 kN b) 208.33 kN d) Loss due to anchorage slip
c) 625.23 kN d) 333.23 kN
65) Consider a prestressed concrete beam of 12 m
Losses in prestressed concrete span as shown in figure