Professional Documents
Culture Documents
Gasturbine sgt6 2000e Brochure PDF
Gasturbine sgt6 2000e Brochure PDF
SGT-2000E Series
Reliable, robust, flexible
2
By July 2011, more than 400 SGT5-2000E
and SGT6-2000E Siemens Gas Turbines
were in operation worldwide.
SGT5-2000E SGT6-2000E
3
Proven design features –
derived from decades of experience
■■ Variable-pitch inlet guide vanes allow operation down to half ■■ The light, highly rigid rotor of disk design allows rapid startups.
load while maintaining a constant e xhaust temperature.
■■ Internal air-circulation paths in the rotor minimize thermal
■■ All stationary and moving blades in the compressor and stresses.
turbine can be replaced individually without removing
■■ Hirth facial serrations at the outer perimeter of the disks ensure
the rotor from the lower casing.
self-centering of all the rotor components under steady- and
non-steady-state operating conditions.
2 Turbine blades
4
Operational flexibility and service-
friendliness – for challenging operating
conditions
Large combustion chambers The SGT-2000E series can be fired with Off-board combustion eliminates
ensure low emissions, fuel a wide variety of fuels, from low- to high- any direct flame radiation on the
flexibility, and ease calorific gaseous and/or liquid fuels, turbine blading, and the long dilution
in maintenance. including treated heavy oils. path allows for long service intervals
and high availability of the hot gas
casings.
4
Emissions
(in dry exhaust gas with 15% O2)
ppm
175
NOx
150
CO
125
100
75
50
25
0
0 20 40 60 80 100 %
Output at ISO conditions
5
Fuel flexibility –
a broad range to meet different needs
With a fuel range from heavy Siemens has broad experience with Thanks to the robust design, the
fuel oils to low c alorific different types of fuels, including non- SGT-2000E series operates at high levels
gases, the SGT-2000E series standard fuels like crude oil and low of reliability – even under challenging
delivers high calorific gases. fuel conditions.
application flexibility Depending on the fuel composition,
Siemens provides standard combustors
or project-specific solutions.
Gas turbines in the SGT-2000E series are capable of firing the following fuels:
SynGas/IGCC/naptha
Crude oil
6
The SGT5-PAC 2000E and
SGT6-PAC 2000E – Pre-engineered
modules for faster commissioning
The Siemens Gas Turbine We deliver our Siemens Gas Turbine Pre-engineered options are available
Package (SGT-PAC) comprises Packages largely pre-assembled, includ- to meet project- and site-specific
the gas turbine and generator, ing piping and wiring to a major extent. requirements or to increase operating
and all major mechanical, The auxiliary systems are combined in flexibility and performance of the power
control, and electrical equipment groups and installed as pre-fabricated generating system.
required for safe and reliable packages. This reduces installation and
operation of these components. commissioning time and expenditures.
7
Oil and gas business applications:
one engine – many possibilities
In addition to applications The compressor drive design, derived Due to the robust engine design, the
in power plants, the from proven standards, can be used, for SGT-2000E series is capable of operating
SGT-2000E series can also example, in the production of liquified with low calorific gases and syngas.
be used for diverse natural gas – either as a direct mechani- Typical applications are gas-to-liquid
applications in the oil and cal drive compressor or as an all-electric plants and IGCC power plants.
gas industry. generator version.
Air Syngas
8
More than 350 engines
working hard – worldwide
The SGT5-2000E has been in service since 1981, and the SGT6-2000E since 1989.
We have sold more than 400 SGT5-2000E and SGT6-2000E gas turbines and accumulated
about nine million operating hours, with fleet reliability exceeding 99 percent.
1 2 3 4
Nuon Power Buggenum operates its power station as an The Ministry of Electricity and Water operates the
integral part of a fully integrated, coal-based IGCC plant 960-MWe Az Zour power plant, which consists of eight
with a net output of 290 MW. The Buggenum power station SGT5-2000E Siemens Gas Turbines in simple cycle operation
consists of one single-shaft combined cycle unit with one with more than 170,000 operating hours. The gas turbines
SGT5-2000E gas turbine with approximately 80,000 operat- are equipped with Siemens hybrid burners, which permit the
ing hours. The gas turbine is equipped with Siemens s yngas use of both gas and oil.
burners that permit operation using both syngas and natural
gas, which is used as backup fuel. 4 Hsinta, Taiwan
9
Published by and copyright © 2011:
Siemens AG
Energy Sector
Freyeslebenstrasse 1
91058 Erlangen, Germany
Printed on elementary chlorine-free bleached paper. Subject to change without prior notice.
All rights reserved. The information in this document contains general
Trademarks mentioned in this document descriptions of the technical options available, which
are the property of Siemens AG, its affiliates, may not apply in all cases. The required technical
or their respective owners. options should therefore be specified in the contract.