Professional Documents
Culture Documents
D150e PDF
D150e PDF
TOTALIZER’S FUNCTION
(only in NET mode)
GROSS / NET
The totalizer function allows to add in memory the values
zero / tare /
of different weighed samples.
clear totalizer
This memory does not lose its value even if the D150E is
DEC button
turned off (or when batteries run down).
It is possible to visualize or zero at any moment, the total
configuration mode /
of the stored weights.
confirm zeroing function
INC button
To display the total weights value, press
one of the side buttons once
show totalizer /
shut off
The totalizer value will appear on the display (1234 kg in
ESC button
the example) alternating with the following caption
add to the totalizer
power on / ENTER button
The green led flashes once when the weight goes When the totalizer is displayed, it is possible to zero it.
through zero (see TOTALIZER FUNCTION)
To perform this operation, press one of the
The red led flashes repeatedly when the D150E is in side buttons
net weight mode (see GROSS/NET)
The following caption will
appear on the display
relative provisions of the following directives: EMC The tare function records the value of the actual weight as
89/336/EC and R&TTE 99/5/EC (only radio version) tare, therefore the net weight value is zero.
- it is designed and manufactured according to all This value remains stored also in case of D150E shutting
requirements set by “Essential Safety Requisites Annex 1” off.
of the EU Directive 98/37 CE named Machinery Directive To exit the HOLD function and to go back
To access the tare function to normal weighting, press the button again
press one of the side buttons
1076-MTUD1502 - Rev.3 Page 1 of 2
The configuration mode allows the displaying and USE SCOPE
modifying D150E's operating parameter values.
The hanging scale is a measuring instrument that is used
To enter in configuration mode, press exclusively to weigh loads.
one of the side buttons It must be used correctly, with care, gently and without
wrenching; when not in use, it must be stored in a
covered and dry place. • avoid rough impacts on the floor or against
The first of the following parameters structures
TIME Damage to the hanging scale, for improper use or
or functions will be visualized on DATe
• do not leave the load suspended to the
display, to go to the following ones, purposes not allowed, can create situations of dynamometer; once weighting is done, the load must
CONF
press the same button again. (function)
serious hazard for people exposed and/or damages be laid down gently
to the work environment. • do not use the dynamometer to drag loads
• lift only when the dynamometer is correctly
To enter one of the functions, press one Only qualified personnel are allowed to use the device. suspended and positioned above the load so that the
of the side buttons once. As regards to these instructions, the manufactures force goes though its carrying axle
declines any responsibility in case of: