Professional Documents
Culture Documents
Please (X) Mark in The Answer Sheet For Marking The Correct Answer
Please (X) Mark in The Answer Sheet For Marking The Correct Answer
Note: There are 50 Questions. Each question has ONE correct answer. One mark for
Each question. Please ( X ) mark in the answer sheet for marking the correct answer
a. Shift Superintendent
b. Plant HOD
c. HSE Chief
d. SSM
a. Increases
b. Decreases
c. Remains unchanged
d. Data insufficient
De-Engg-2004-Shift Engineer-1 1
7. Effective way for handling pyro-phoric material is
a. SL header
b. SH header
c. OWS header
d. Storm water
a. Fail Open
b. Fail Close
c. Fail in Position
d. None
a. Foam
b. FM 200
c. CO2 extinguisher
d. Fire water
a. 3413 Btu
b. 3.2 cal
c. 420 J
d. 746 horse power
a. Density
b. Pressure
c. Viscosity
d. Fluid specific volume
a. 1/3 r3h
b. 1/3 r2 h
c. (/3) r2 h
d. /6 r3 h
De-Engg-2004-Shift Engineer-1 2
14. The temperature at which vapor above the substance will explode in presence of flame is called
17. If pA is a partial pressure of component A over a solution in which the mole fraction of A is x and
PA is vapor pressure of A at given temperature then, Raoult’s law can be written as:
a. pA = x * PA
b. PA = x* pA
c. PA * pA * x =1
d. None of above
a. Chlorine
b. Bromine
c. Fluorine
d. Iron
a. increases
b. decreases
c. does not change
d. none of the above
a. 9.8 m/sec2
b. 9.8 m/sec
c. 980 m/sec
d. 981 m/sec2
De-Engg-2004-Shift Engineer-1 3
21. Distillation is an operation, which involves the following.
a. Mass transfer
b. Heat transfer
c. Both a and b
d. Adsorption
22. The liquid with fouling / corrosive nature should be kept in which side of the exchanger?
a. Shell side
b. Tube side
c. None of the above
23. In case of fired heaters, the heat input is given to the coils by
a. Radiation
b. Conduction
c. Convection
d. Radiation and convection
a. Selective Adsorption
b. Crystallization of gases
c. Condensation of gases
d. Absorption of gases
26. The properties that change with respect to temperature in a fluid are
a. density
b. viscosity
c. mass
d. both a & b
27. A pump, when used for another heavier liquid service, which one of the following is wrong?
De-Engg-2004-Shift Engineer-1 4
29. Efficiency of distillation column improves when
a. When certain combination of metallic junctions, kept at different temperatures, potential difference is
generated.
b. When certain combination of metallic junctions, kept at different temperatures, electric light is
generated.
c. Conductivity increases with temperature which is measured
32. The number that indicates the nature of turbulence in case of flow is
a. Reynold’s number
b. Reagan’s number
c. Nusselt’s number
d. Reinforcement number
33. The most optimal cracking that can result in better yield in a refinery is
a. Thermal cracking
b. Vis-breaking
c. Catalytic cracking
a. Date of Birth
b. Boil over Design.
c. Biological Oxygen demand.
d. Burn out duration.
De-Engg-2004-Shift Engineer-1 5
37. Cavitation occurs in a centrifugal pump when
a) the suction pressure < vapour pressure of the liquid at that temperature
b) the suction pressure > vapour pressure of the liquid at that temperature
c) the suction pressure = vapour pressure
d) the suction pressure = developed head
a) speed
b) impeller diameter
c) both ''a'' and "b"
d) neither á' nor 'b
40. which of the following factor contributing to the pressure drop in a pipe line
a) velocity of fluid
b) size of pipe
c) length of pipe and no of bends
d) all of above a, b, and c
41. Which of the following valve incur maximum pressure drop for the same discharge of water
a) globe valve
b) gate valve
c) butterfly valve
d) check valve
42. A centrifugal pump used to pump water is used to an oil with specific gravity .8 at the same
rate , the power consumption will be now
a) increase
b) decrease
c) remain same
d) not related with specific gravity
a) 200 opening/cm2
b) 200 opening/ cm
c) 200 opening/inch
d) 200 opening /inch2
De-Engg-2004-Shift Engineer-1 6
44. Kerosene should have
a) kcal/hr. m2 .deg C
b) kcal/hr. m .deg C
c) kcal/hr. m
d) kcal/hr. .deg C
XXXX
De-Engg-2004-Shift Engineer-1 7