Professional Documents
Culture Documents
Disusun Oleh:
Nama : Muhammad Irfan Najmudin
NRP : 0817040039
Kelas : TP6B
PROGRAM STUDI D4 TEKNIK PERPIPAAN
JURUSAN TEKNIK PERMESINAN KAPAL
POLITEKNIK PERKAPALAN NEGERI SURABAYA
2020
Deskripsi Analisa Kasus
The following figure shows a simple bracket made of structural steel with Young’s
modulus E = 200 GPa and Poisson’s ratio ν = 0.3. The bracket has a cross-section profile shown
below and an extrusion depth of 12 cm. A through-hole of diameter 1.5 cm is centered on the
bracket’s flat ends, one on each side, as shown in the figure. Suppose that the bracket is fixed on
the bottom, and lifted by a pressure load of 1000 N/cm2 from the inside surface of the top flat
portion. Compute the deformation and stresses in the bracket using the FEA
Mesh:
Number Of Nodes 2469
Number Of element 1181
Total Deformation :
Minimum (m) 0
Maximum (m) 1,0285e-004
Average (m) 1,6086e-005
Equivalent Stress :
Minimum (Pa) 1,3872e+005
Maximum (Pa) 1,451e+008
Average (Pa) 2,9712e+007