Professional Documents
Culture Documents
PO1TF 2016
Problem 1. A frame ABC is supported in part by cable DBE that passes through a frictionless ring at B.
Knowing that the tension in the cable is 385 N, determine the components of the force exerted by
the cable on (a) the support at D, (b) the support at E.
Problem 2. The ends of the three cables are attached to a ring at A and to the edge of a uniform 150-kg plate.
Determine the tension in each of the cables for equilibrium.
Problem 3. Collars A and B are connected by a 25 cm long wire and can slide freely on frictionless rods. If a
60 N force Q is applied to collar B as shown, determine (a) the tension in the wire when x = 9 cm,
(b) the corresponding magnitude of the force P required to maintain the equilibrium of the system.
PROBLEM 2.85
SOLUTION
DB = (480 mm)i − (510 mm) j + (320 mm)k
DB = (480 mm)2 + (510 mm 2 ) + (320 mm)2
= 770 mm
F = F λ DB
DB
=F
DB
385 N
= [(480 mm)i − (510 mm)j + (320 mm)k ]
770 mm
= (240 N)i − (255 N) j + (160 N)k
Fx =
+240 N, Fy =
−255 N, Fz =
+160.0 N
PROBLEM 2.86
SOLUTION
EB = (270 mm)i − (400 mm) j + (600 mm)k
EB = (270 mm)2 + (400 mm)2 + (600 mm)2
= 770 mm
F = F λ EB
EB
=F
EB
385 N
= [(270 mm)i − (400 mm)j + (600 mm)k ]
770 mm
F = (135 N)i − (200 N) j + (300 N)k
Fx =
+135.0 N, Fy =
−200 N, Fz =
+300 N
3 Solutions 44918 1/21/09 4:25 PM Page 170
© 2010 Pearson Education, Inc., Upper Saddle River, NJ. All rights reserved. This material is protected under all copyright laws as they currently
exist. No portion of this material may be reproduced, in any form or by any means, without permission in writing from the publisher.
2m
10 m
12 m
C 2m
D
4m
y
B 6m
2m
6m 6m
x
2m
10 m
12 m
C 2m
D
4m
y
B 6m
2m
6m 6m
x
170