Professional Documents
Culture Documents
l Free From Corrosion & Scale Formation at Inner and Outer sides
Market Acceptance
3
l Excellent Performance
2 l High Reliability
1. Pre-filter 4. Desiccant tower l Require Less Service Time
2. Inlet shuttle valve 5. After filter
3. Exhaust valve 6. Outlet shuttle valve l Very Reasonable Cost
l Low moving components
Principle of Operation l Low Maintenance
l Very Safe Operation
Drying Cycle : Moist air from the compressor is sent through
the coalescing filter. Here water & oilcoalesces, gets purged l Global Support
through the auto drain valve. The relatively clean air with water
vaporpasses through the aluminum drying tower filled with Specifications
desiccant gets completely dried (up to -400CPDP) and then Flow : 20 scfm
passes through a built in after filter. The desiccant fines from the Maximum Operating Pressure : 16 kg/cm2(g)
towers arecompletely removed and clean dry air is let out through
Air Inlet Temperature : 380C Max
the outlet port for use.
Operating Pressure : 7 kg/cm2(g)
Regeneration Cycle: During the regeneration cycle, the sudden Pre-Filter Rating : 5 Microns
depressurization brings out water moleculestrapped in the
Cycle Time : 4 Minutes
Desiccant pores to the surface of the beads. A small portion dry
compressed airfrom the drying tower then passes over the Operating Voltage : 100-240 VAC 50/60 Hz 1 Ph
desiccant through the regeneration orifice built inthe Top Block. Outlet Conditions : Dry air at -400C PDP
This results in complete regeneration of the Desiccant. Purge Loss : 15±1%
Sales & Ahmedabad Bangalore Chennai Delhi Hyderabad Kolkatta Mumbai & Pune
Service Outlets 98673 67726 98450 93322 97894 80564 93113 10726 98854 45321 82200 19925 98673 67726