Professional Documents
Culture Documents
Most Important Ans Question Bank of Network Analysis and Synthesis UNIT 1 and UNIT 2
Most Important Ans Question Bank of Network Analysis and Synthesis UNIT 1 and UNIT 2
UNIT-1
SYLLABUS: signal analysis, complex frequency, network analysis, network synthesis, general
characteristics and description of signals, step function and associated waveforms, unit impulse,
introduction to network analysis: network elements, initial and final conditions, step and impulse
responses, solution of network equation
2. Consider a series R-L circuit. The switch S is closed at time t=0, find the current i(t) through
and voltage across the resister and inductor using classical method of solution of differential
equation.
3. In the circuit shown fig.(b) switch is closed at t=0. Obtain the expression for the current in
circuit and find i(t) & t = 0.25 sec .
4. For the circuit shown in fig (c) find the current equation for t>0,when the switch k is moved
at t=0 from position ‘a’ to ‘b’. Assume that circuit is in steady state before t=0 instant.
6. Consider a series R-C circuit. The switch S is closed at time t=0, find the current i(t) through
and voltage across the resister and capacitor using classical method of solution of differential
equation.
7. In the network shown in fig(e), switch k is kept open for very long time. On closing switch, after
10msec, capacitors voltage attains a value of 80V.Then the switch is kept closed for a very long
time. When switch is again opened, capacitor voltage becomes 90V.after half second. Calculate
values R and C for given circuit .
8. Consider a series R-C circuit. Find the value of Vc (t) for t>0 in the circuit shown in fig
(f).assume initial Condition Vc(0-) = 9 volt.
Fig(f)
9. Consider RLC series circuit of fig (g) with R=2Ω ,L=0.5H,C=0.1F.The circuit is initially
relaxed. When the switch is closed at t=0.calculatethe transient current and voltage across
capacitor.
10. Using classical method, find current i(t) for t=0 from fig (h).
11. Derive homogeneous and non- homogeneous equation for the first and second order of
differential equation of such network. (classical method).
12. Derive expression for the instantaneous current through series R-L-C circuit fort=0
UNIT-2
Syllabus: Review Of Laplace Transform, Poles And Zeros, Initial Value Theorems,
Thetransform Circuit, Thevenin’s And Norton’s Theorem, The System Function ,Step And
Impulses Responses,The Convolution Integral.
(b) f(t)=t3+3t-6t+4
(c) f(t) =
(d) for
(a) f(t)=
(b) F(S) = 3
(c) F(S) =
4. Find Laplace transform of the following wave form shown in(3marks each part)
i.
ii.
(iii)
5. Find the final value theorem for the function f(t)= (3mark)
6. Find the initial and final value theorem for the following function(3marks each parts)
a)
b)
7. Finds the response of a continuous –time LTI system described by the differential eqn
with initial conditions i+(0) =3 and (0+)
= -4. : (5mark)
[ans i(t)= A]
8. Solve differential equation : (5marks )
9. , where x(0-) =1 and = x’ (0-) = -1.
[ans i(t)= ]
10. Finds the response of a continuous –time LTI system described by the differential eqn
with initial conditions y (0) =2 and = y’ (0) =1.
Also given input f(t)=2u(t). : (5marks )
11. Define and explain the characteristics of : (15mark)
(i) Unit step function
(ii) unit ramp function
(iii) Unit impulse function.
12. Explain the procedure to find the solution of s differential equation using Laplace transform
method. (10mark)
13. Consider a series R-L circuit, the switch is closed at t=0.calculate of the resulting current
using Laplace transform. (10mark)
14. Determine current i(t) in the RL circuit shown in fig (a).the input voltage applied is
v(t)=10sin25t V using Laplace transform(5mark)
Fig(a)
15. Consider a series R-C circuit, the switch is closed at t=0.calculate of the resulting current
using Laplace transform. (10mark)
16. Find the particular solution for the current i(t) after switch is closed for the circuit shown in
fig(b) . , the switch is closed at t=0.calculate of the resulting current assuming there is no
charge in the capacitor C before switching using Laplace transform. (5mark)
Fig(b)
14. Consider a series R-L-C circuit, the switch is closed at t=0.calculate of the resulting current
using Laplace transform. (10mark)
15.A series RLC circuit shown in fig(c) the values of varies components are V=10 V , R=5Ω,
L=1H,C=0.25F.The switch ‘k’ is closed at t=0.find the i(t) through series circuit. Assume that
there is zero current through inductor L and zero charge across the capacitor C before switching.
(5mark)
19. Determine the Norton’s equivalent of network shown in fig(e).between terminal a and b.
20. For the circuit shown in fig (f) determine the I(B-D) through the 10Ω resistance by using
thevenin’s and Norton theorem.
Fig(f)
21. Determine driving point admittance function and transform function admittance Y(S) for the
network fig (i) and fig (ii)
22. find the expression of the voltage, current ,impedance and admittance transfer function for
the network given below
a) ; decaying exponential
b) F(t)= cos ; a sinusoid
c)
d) use partial fraction also find h(t).
24. Determine stability of the system using Routh Hurwitz stability method whose
characteristics equation are as following:
a) s4+8s3+18s2+16s+5=0
b) s4+2s3+13s2+16s+5=0
c) s5 +4s4+8s3+8s2+7s+4=0
d) s3+3Ks2+(K+2)s+4=0