The loader needed repairs to its hydraulic system, including replacing seals on the tilt and steering cylinders due to leakage, repairing the hydraulic pump that was working slowly, checking all hydraulic pipes, and repairing the bucket tilt pins that were damaged. Additionally, the steering valve was replaced due to leakage, the air intake system to the compressor was checked, and electrical faults were addressed by checking connections and components in the alternator and battery system.
The loader needed repairs to its hydraulic system, including replacing seals on the tilt and steering cylinders due to leakage, repairing the hydraulic pump that was working slowly, checking all hydraulic pipes, and repairing the bucket tilt pins that were damaged. Additionally, the steering valve was replaced due to leakage, the air intake system to the compressor was checked, and electrical faults were addressed by checking connections and components in the alternator and battery system.
The loader needed repairs to its hydraulic system, including replacing seals on the tilt and steering cylinders due to leakage, repairing the hydraulic pump that was working slowly, checking all hydraulic pipes, and repairing the bucket tilt pins that were damaged. Additionally, the steering valve was replaced due to leakage, the air intake system to the compressor was checked, and electrical faults were addressed by checking connections and components in the alternator and battery system.
The Hydraulic seal was more leakage so were seal change 02 Steering Cylinder jack Seal leakage Steering Jack Seal Damage 03 Hydraulic Pump Work Slow Repairing Hydraulic Pump Hydraulic pump it wasn’t working well so we had to repair it 04 All Hydraulic Pipe check We haven’t seen the pipe in a long time, so we’ll checking the pipe 05 bucket Tilt Position Central pin & lift and Right pin Damage Repairing Bucket Tilt pin anyone was in bad condition All Pin Could have caused a lot of damage Decided to repairing it 06 Steering valve (Steering Valve Orin Leakage New Change 07 Engine inlet air System the air enter the compressor checking Air pressure system fault for repairing & setting Electrical faults 1. Switch off the main power at the consumer unit/fuse box. ... It means your alternator is not charging the battery, this could be caused by a bad alternator, a bad battery, a loose belt, a loose connection between the alternator and battery, or other electrical checking