ID Command System Description 102 SET_GAS_IO_FROM_PS Manual gas system This command will allow the user to turn on or off each output Auto gas system of the processor. After sending this command, the SYSTEM_ RESET command must be issued to restore the processor state. The I/O are in the following order: Note: Use caution when selecting gas valves to make sure fuel and oxidizers are not mixed together resulting in a combustible mixture. Data: 1 = On, 0 = Off for each I/O point Return value: 1 = accepted, 0 = not accepted Manual Gas Console Shield cutflow (SV16) Calibrate bypass (SV13) Plasma cutflow 1 (SV14) Ramp-down valve (SV20) Shield preflow (SV17) Plasma preflow (SV18) Plasma cutflow 2 (SV19) H35 plasma cutflow 2 (SV12) Spare valve (SV15) O2 shield cutflow (SV4) Air shield cutflow (SV5) N2 shield cutflow (SV6) Air preflow (SV7) N2 preflow (SV8) Air plasma cutflow 2 (SV9) Air plasma cutflow 1 (SV1) O2 plasma cutflow 1 (SV2) H35 plasma cutflow 1 (SV3) O2 plasma cutflow 2 (SV10) N2 plasma cutflow (SV11) Auto Gas Console O2 inlet (SV1) Air inlet (SV2) Air inlet 2 (SV3) H5 inlet (SV4) H35 inlet (SV5) F5 inlet (SV6) Spare out 1 (Spare) Ramp-down valve (SV16) Non-XD = Spare out 2, XD = Ar inlet2 (SV15) Gas 2 no mix (SV14) Gas 2 mix (SV13) N2 mix (SV12) N2 inlet 2 (SV11) Air inlet 3 (SV10) N2 inlet (SV9) O2 air inlet (SV8) Non-XD = CH4 inlet, XD = Ar inlet1 (SV7) Sample: >1021111111111111111111167< >1021C4<
It Is Vital To Good Project Management To Be Meticulously Honest in Estimat Ing The Time Required To Complete Each of The Various Tasks Included in The Project. Note That