Professional Documents
Culture Documents
Test Information
Description The mid-term quiz covers all examinable materials from lectures 1 - 6.
Instructions You have 75 minutes to complete questions 1 - 20. You may start any time between 9:30 and 10:30 AM on Friday 25 September 2020.
Timed Test This test has a time limit of 1 hour and 15 minutes.This test will save and submit automatically when the time expires.
Warnings appear when half the time, 5 minutes, 1 minute, and 30 seconds remain.
Multiple Attempts Not allowed. This test can only be taken once.
Force Completion Once started, this test must be completed in one sitting. Do not leave the test before clicking Save and Submit.
Your answers are saved automatically.
For reaction in a catalyst pellet, if the rate is proportional to (particle diameter)0.33. What is the most likely value of
the Thiele Modulus?
0.1
10
From a heat management point of view, which of the following reactor con guration is best for a highly exothermic
gas-phase reaction?
PFR
CSTR
CSTRs in series
Which of the following reaction types favour two CSTR in series over a simple PFR?
Exothermic reactions
Click Save and Submit to save and submit. Click Save All Answers to save all answers. Save All Answe
QUESTION 4 5 points Saved
Which of the following statement about Langmuir isotherm is NOT true?
Remaining Time: 14 minutes, 31 seconds.
Surface coverage is a function of temperature
Question Completion Status:
Surface coverage is a ected by the presence of a species competing for adsorption sites.
Reaction A (g) + B (g) → C (g) over a catalysts surface is described by the following elementary steps:
A + S ⇌ AS
B + S ⇌ BS
AS + BS ⇌ CS
CS ⇌ C + S
where S is a surface active site. If the reaction is rst order with respect to the partial pressure of A and -1th order
with respect to the partial pressure of B. What can be said about the surface of the catalyst?
An Arrhenius analysis is performed on a reaction. T is temperature in Kelvin and k is the apparent rate constant. The
following Arrhenius plot is obtained. What can we say about the reaction regime at high temperatures?
Click Save and Submit to save and submit. Click Save All Answers to save all answers. Save All Answe
Con guration A
Con guration B
Con guration C
Con guration D
The reaction pathways for the hydrogenation of cinnamaldehyde (CAL) is shown below. All four reactions are rst
order with respect to the partial pressure of hydrogen gas. In order to maximise the yield of cinnamyl alcohol (CAL),
what would be the best reactor con guration?
PFR
CSTR
2NO + O2 = 2NO2
CH4 + 4Cl2 = CCl4 + 4HCl
Click Save and Submit to save and submit. Click Save All Answers to save all answers. Save All Answe
QUESTION 11 5 points Saved
For a bimolecular surface reaction A (g) + B (g) → C (g), with the elemental steps:
A + S ⇌ AS
Remaining Time: 14 minutes, 31 seconds.
B + S ⇌ BS
AS + BS ⇌ CS
Question Completion Status:
CS ⇌ C + S
if the adsorption of C is much stronger than the adsorption of A and B, what would be the rate determining step?
The desorption of C
Surface reaction
Which of the following variable a ects the equilibrium conversion of the water-gas-shift reaction:
CO + H2O ⇌ CO2 + H2?
Total pressure
Temperature
Reactor design
Given that adsorption is always an exothermic process, how would the equilibrium surface coverage change with as
temperature increase?
Increase
Remain constant
Decrease
For the heterogeneous catalytic reaction A ⇌ R, which step is rate controlling is the pressure dependency of the
apparent rate is as follows?
The desorption of R.
The adsorption of A.
Intra-particle di usion
Surface reaction.
Click Save
A PFR andrecycle
with Submitisto save
not and submit.
suitable for: Click Save All Answers to save all answers. Save All Answe
Parallel reactions
Reactions
Remaining 14 minutes,
Time:with 31 seconds.
low single-pass conversion, e.g. Fischer-Tropsch synthesis
Autocatalytic reactions
Question Completion Status:
Which of the following equation is the most appropriate for describing the adsorption isotherm of ozone molecules
(O3) on an catalyst surface at 100 °C?
Always requires a larger reactor than the case without volumetric expansion
Always requires a smaller reactor than the case without volumetric expansion
The reaction pathways for the hydrogenation of cinnamaldehyde (CAL) is shown below. All four reactions are first order
with respect to the partial pressure of hydrogen gas.
Click Save and Submit to save and submit. Click Save All Answers to save all answers. Save All Answe
Remaining Time: 14 minutes, 31 seconds.
If the activation energies of k1, k2, k3 and k4 are E1, E2, E3, and E4, respectively. Also E3>E1>E2>E4. Which reactor
con guration will maximise the yield of hydrocinnamyl alcohol (CAL)?
Click Save and Submit to save and submit. Click Save All Answers to save all answers. Save All Answe