Professional Documents
Culture Documents
SPECIFIC OBJECTIVES:
MATERIALS:
1 – compass
1- technical pen (0.2)
1- triangle sets (30-60 and 45-45)
1- T-square
PROCEDURE:
1. Set up the compass and measure the desired radius of the arcs and circles
that would fit the sets of geometrical figures shown on the next page in your
drawing sheet.
2. Sketch the figures shown in plate no.6 and divide the spaces between at your
desired length as long as it would look presentable and clean.
Note: There is no standard measurement on this drawing simply make sure that
your drawing covers 80% of the template.
Plate No. 5
Geometrical Design