Professional Documents
Culture Documents
w acceptable. w
Conical
bottom d
Min. 120°
Min. 120°
φda
φdk
φds
φdk
e
Unit: mm Unit: mm
Nominal Nominal diameter of
M2 M2.5 M3 M4 M5 M6 M8 M10 M12 M16 M20 M24
diameter of M2 M2.5 M3 M4 M5 M6 M8 M10 M12 M16 M20 M24 thread (d)
thread (d) L* ℓs and ℓg
Thread pitch 0.4 If mouth0.5
0.45 of hex socket
0.7 is rounded
0.8 or chamfered
1 1.25 1.5 1.75 2 2.5 3 Nominal
Max. state of radius under head ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg ℓs ℓg
Diameter min max
b*1 (Reference) 16 17 18 20 22 24 28 32 36 44 f (Max.)52
= 1. 7r (Max.)
60 min max min max min max min max min max min max min max min max min max min max min max min max
Length
Radius
Max.*2 3.8 4.5 5.5 7 8.5 10 f 13 16 18 24 30 36 3 2.8 3.2
da (Max.) - ds (Max.)
v
dk Max.*3 3.98 4.68 5.68 7.22 8.72 10.22 r 13.27 16.27 18.27 r (Max.) = 30.33
24.33 36.39 4 3.76 4.24
2
r
φdw
Min. 3.62 4.32 5.32 6.78 8.28 9.78 12.73 15.73 17.73 23.67 29.67 35.61 5 4.76 5.24
φdk
da Max. 2.6 3.1 3.6 4.7 5.7 6.8 9.2 11.2 13.7 17.7= based
r (Min.) 22.4 26.4 table
on attached 6 5.76 6.24
Max. 2 2.5 3 4 5 6 8 10 12 16 20 24 8 7.71 8.29
r
ds
Min. 1.86 v
2.36 2.86 3.82 4.82 5.82 7.78 9.78 11.73 15.73 19.67 23.67 10 9.71 10.29
φda
φds
* Range of nominal length generally distributed is between thick stepwise lines. Shaded nominal length shall be full thread, and length of
imperfect thread under head shall be 3P or less.
Non-shaded values show ℓg and ℓs values based on the next formula: ℓg max = ℓnom - b, ℓs min = ℓg max - 5P