Professional Documents
Culture Documents
Shutdown SIS
Previous Screen
SENR10630052
1. Turn the crankshaft until pistons are clear of the piston cooling jet to be removed.
2. Remove screw (1) that holds the piston cooling jet. Remove the piston cooling jet.
https://s1.remotelab.space:501/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.js… 1/2
3/8/2020 3412E Industrial Engine 4CR00001-UP(SEBP2510 - 68) - Systems & Components
NOTE: If the piston cooling jets are to be reused, check the alignment of the piston cooling
jet with Tool (A). See Special Instruction, SMHS7267, for instructions on the use of the
piston cooling jet alignment tool group.
1. Put the piston cooling jet in position on the cylinder block and install the screw that
holds the piston cooling jet to the block.
3. With the piston at the bottom of the bore, check the clearance between piston and piston
cooling jet with a piece of wire (1) 0.63 mm (.025 in) thick. If the clearance is less than
0.63 mm (.025 in), make a replacement of the tube.
NOTE: The piston cooling jets must fit evenly against the cylinder block. If they do not, it
will cause an oil loss in the engine oil system.
End By:
Copyright 1993 - 2020 Caterpillar Inc. Sun Mar 08 2020 07:41:43 GMT+0200 (Eastern
All Rights Reserved. European Standard Time)
Private Network For SIS Licensees.
https://s1.remotelab.space:501/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.js… 2/2