Professional Documents
Culture Documents
Shutdown SIS
Previous Screen
SENR10630017
NOTE: The 3408E Engine is equipped with one fuel filter element and the 3412E Engine
is equipped with two fuel filter elements.
1. Disconnect fuel lines (1) and (5). Cap and plug all openings immediately.
2. Remove fuel filter or filters (2) from fuel filter base (4) with Tool (A).
5. If necessary, remove the fuel filter mounting stud or studs from the fuel filter base.
NOTE: The following steps are for the installation of the fuel filter or filters and fuel filter
base.
6. If the fuel filter mounting stud or studs were removed from the fuel filter base, reinstall
them. Put 9S-3263 Thread Lock on the tapered end of the stud or studs a distance of 7.6
mm (.30 in). Install the stud or studs in the fuel filter base, and tighten them to a torque of
70 ± 15 N·m (50 ± 11 lb ft).
7. Put fuel filter base (4) in position on the engine, and install two washers, nuts and bolts
(3) that hold it.
8. Connect fuel lines (1) and (5) to the fuel filter base.
9. Install new fuel filter or filters (2). Follow the instructions with the filters for the
installation procedure.
Copyright 1993 - 2020 Caterpillar Inc. Sun Mar 08 2020 09:22:37 GMT+0200 (Eastern
All Rights Reserved. European Standard Time)
Private Network For SIS Licensees.
https://s1.remotelab.space:501/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.js… 2/2