Professional Documents
Culture Documents
The Bus Catalogue 2008/2009
The Bus Catalogue 2008/2009
This publication has been produced to help you select replacement air brake and suspension products for your buses. The
layout for each model of bus follows the same format and runs from the Compressor, through the brake and suspension system
components, to the Actuators, Slack Adjusters and Disc Brakes where fitted.
To help find the product quickly, "graphics" have been used to give a general representation of many of the products. These
are for guidance only and should not be used to identify a specific product variant as many products, such as Multi-Circuit
Protection Valves and Electronic Control Units, look similar but have very different operating characteristics. Wherever
possible, a product should be identified from the part number label on the old unit removed from the vehicle. Vehicle
manufacturers' part numbers and chassis numbers are included for reference only.
Whilst the greatest care has been taken in the preparation of the information in this publication, specification changes made
by the vehicle manufacturers may not be covered in some cases. Furthermore, products offered as equivalent to the original
equipment are based on the best information available at the time of printing and on the installation compatibility. If at any time
a problem is found, we would be pleased to receive your comments on the Technical Help Line (0117 9846222) or by e-mail to
technical@knorr-bremse.com.
The text, graphics and their arrangement are all subject to copyright and other intellectual property protection. Copying of this
publication or parts of it must be authorised by Knorr-Bremse Systems for Commercial Vehicles.
Disclaimer
The information contained in this document is intended for the exclusive use of trained persons within the commercial vehicle
industry, and must not be passed on to any third party. All recommendations regarding products and their servicing or usage
are with reference to Knorr-Bremse products and should not be considered applicable to products from other manufacturers.
This information does not purport to be all-inclusive and no responsibility is assumed as a result of its use. We cannot accept
any liability nor offer any guarantee regarding data accuracy, completeness or timeliness. The information does not represent
any guarantee or ensured characteristics of the Products or Systems described. No liability can be accepted based on the
information, its use, recommendations or advice provided. In no event may we be held liable for any damage or loss except in
the case of wilful intent or gross negligence on our part, or if any mandatory legal provisions apply. Any legal disputes arising
from the use of this information shall be subject to German law.
Note: If service work is carried out on the vehicle, it is the responsibility of the workshop to ensure the vehicle is fully tested and in
full functional order before the vehicle is returned into service. Knorr-Bremse accepts no liability for problems caused as a result
of appropriate tests not being carried out.
This disclaimer is an English translation of a German text, which should be referred to for all legal purposes.
General Information
i
BMC Falcon 1100
4x2
Air Suspension
M16 ports
Double Check Valve 295358 295358 Bracket mounted
ABS Modulator
BR9131 BR9152
0265351101000 II16278
ABS Electronic
Control Unit 0486104033000 0486104033100
(CI-12)
Air Suspension
Control Module
0501100038000 0501100038100
Brake Disc
M16 ports
Double Check Valve 295358 295358 Bracket mounted
Snap-on
Alternative Silencers:
Exhaust Silencer SIL68A SIL68ASP 0484210017000
or ZB3163-I92999
M22 thread
Alternative Silencers:
Exhaust Silencer SIL68B SIL68B 0484210001000
or ZB3150-I78074
ABS Modulator
BR9131 BR9152
0265351101000 II16278
ABS Electronic
Control Unit 0486104033000 0486104033100
(Type CI-12)
Wabco
Single Check Valve 0288495
434 014 000 0 1194016 M22 ports
Wabco
Hand Control Valve 0371274
961 723 001 0
Wabco
Dual Foot Valve 1226132 With pneumatic retarder control
461 324 031 0
Wabco
Stop Lamp Switch 0578466
441 014 003 0
Wabco
Solenoid Valve 0091645
472 132 158 0
Air Suspension
Levelling Valve
0644520 0500005007000 0500005007000 Left side
Air Suspension
Levelling Valve
0644521 0500005006000 0500005006000 Right side
Wabco
BX3419
Brake Chamber 0751727 423 105 080 0 II33782A M16 port, M14 push rod
(Type 20 LS) (423 105 900 0) + Yoke Diaphragm 20LS
Front 295517
Axle
Wabco
BX3419
Brake Chamber 0751728 423 105 081 0 II33782A M16 port, M14 push rod
(Type 20 LS) (423 105 900 0) + Yoke Diaphragm 20LS
295517
BZ9559
Spring Brake 1192712 Wabco II37098 M16 ports, M14 push rod
(Type 27/30) 1245769 925 329 021 0 + Yoke Diaphragm 1190023
Rear 295517
Axle
BZ9559
Spring Brake 1192713 Wabco II37098 M16 ports, M14 push rod
(Type 27/30) 1245770 925 329 031 0 + Yoke Diaphragm 1190023
295517
Left side
Automatic Slack Haldex 38 mm offset, 140 mm hole
Adjuster 72816 KB3000 centre
Rear Dana Part No. R9641/F
Axle
Right side
Automatic Slack Haldex 38 mm offset, 140 mm hole
Adjuster 72815 KB3005 centre
Dana Part No. R9640/F
DAF SB120
Bodied by Plaxton (Centro) and Wrightbus (Cadet), also sold as Volvo Merit 4x2
Air Suspension
Air Suspension
Wabco
Hand Control Valve 1293853 85o handle travel
961 723 025 0
1143275 Wabco
Hand Control Valve 73o handle travel
1309815 961 723 030 0
1136096
Wabco
Dual Foot Valve 1141676
461 318 601 0
With electrical retarder control
1141679
Wabco
Dual Foot Valve 1144648
461 318 605 0
With electrical retarder control
Anti-compounding 1259856
Wabco
Voss ports
Relay Valve 973 011 200 0
Anti-compounding 1302103
Wabco
Voss ports, with silencer
Relay Valve 973 011 205 0
1143378
Relay Valve 0481026022000 0481026022000 0.15 bar threshold
1238501
0533880 Wabco
Quick Release Valve 973 500 000 0 KX2000/1 M22 ports
0711960
4.2 bar
Pressure Limiting 1193483
Wabco
M22 Voss ports
Valve 475 010 322 0
Door brake system
Wabco
Low Pressure Switch 441 024 006 0
5.4 - 6.2 bar
Wabco
Stop Lamp Switch 1195063
441 024 007 0
0.5 - 0.7 bar
Voss
Tilt Drain Valve 0 258 865 052 KW2350/2
M16(F) thread
Test Connector 0512733
ZB1218 Alternative - use KW4282/2 with
SEB00253 a M16 socket adapter
M22 thread
1193486 Wabco Alternative Silencers:
Exhaust Silencer 432 407 060 0 SIL68B 0484210001000
1311739
or ZB3150-I78074
Snap-on
Wabco Alternative Silencers:
Exhaust Silencer 1193201
432 407 070 0 SIL68ASP 0484210017000
or ZB3163-I92999
M22 Voss ports
ABS Modulator 1304635
Wabco BR9159 DIN bayonet electrical
472 195 016 0 II40864FN00 connector
ABS Electronic
Control Unit
Air Suspension
Air Suspension
Solenoid Block
Wabco
Air Suspension 1296494 441 040 006 0
Pressure Sensor 441 040 007 0
Air Suspension
Electronic Control
Unit
BS3270
Front Brake Chamber 1142081 II39214F BS3251 Diaphragm C67204
Axle (Type 14) 1142080 BS3271 II31782SP
II39215F
BS9373
Rear Spring Brake 1142164 II39213F BS9397 Diaphragm C60491
Axle (Type16/16) 1142163 BS9374 II31227
II39212F
Left Side
1154212 o
Air Disc Brake Dana SB6556 Caliper Actuator mounting 5
SM486/27K II39252F K003825 Pad Set II376580062
Pad Wear Indicator II39116F0061
Front
Axle
Right Side
1154213 o
Air Disc Brake Dana SB6546 Caliper Actuator mounting 5
SM486/28K II39251F K003826 Pad Set II376580062
Pad Wear Indicator II39116F0061
Left Side
1142133 o
Air Disc Brake Dana SB6545 Caliper Actuator mounting 5
829691 II39068F K003826 Pad Set II376580062
Pad Wear Indicator II39116F0061
Rear
Axle
Right Side
1142131 o
Air Disc Brake Dana SB6555 Caliper Actuator mounting 5
829692 II39069F K003825 Pad Set II376580062
Pad Wear Indicator II39116F0061
o
Actuator mounting 5
Air Disc Brake
Dana SN6575 Caliper Pad Set II376580062
Front
829771 K006843 K003780 Pad Wear Indicator K000683
2005 onwards
and
Rear o
Axles Actuator mounting 5
Air Disc Brake
Dana SN6585 Caliper Pad Set II376580062
829772 K006844 K003779 Pad Wear Indicator K000683
2005 onwards
Disc Brake Pad Set 1142152 II376580062 II376580062 SB6 and SN6 Disc Brakes
377 mm dia.
Front
Axle Brake Disc 1142086 II39280F 10 x 14.75 mm dia holes
2 x M14 x 1.5 holes
14
DAF SB220
Bodied by Alexander (ALX300), East Lancs/Darwen (Myllennium), Ikarus (Citibus 4x2
and Polaris), Northern Counties (Paladin), Optare (Delta) and Plaxton (Prestige)
Air Suspension
Wabco
Hand Control Valve 0371274
961 723 001 0
0533880 Wabco
Quick Release Valve 973 500 000 0 KX2000/1 M22 all ports
0711960
Wabco DB1103
Pressure Limiting Set replacement valve to
0223439 (475 010 008 0) I61236
Valve 475 010 313 0
3.3 bar
see Remarks
DB1103
Pressure Limiting Wabco Set replacement valve to
0745062 I61236
Valve 475 010 002 0 1.8 bar
see Remarks
Wabco
0578466
Low Pressure Switch 1332000
441 014 003 0 5 bar, M12 thread
441 014 015 0
0299533
Low Pressure Switch 0649130
Wabco
Tilt Drain Valve 0505294
934 300 003 0 KW2350/2 M22 thread
Wabco
Test Connector 0709671
463 703 100 0 AC784D M22(M) thread
M22(F) thread
Test Connector
0117628 ZB1219 Alternative - use AC784D with
1260000 SEB00254 a M22 socket adapter
M16(F) thread
Test Connector 0512733
ZB1218 Alternative - use KW4282/2 with
SEB00253 a M16 socket adapter
Air Suspension
Levelling Valve
0644520 0500005007000 0500005007000 Front axle
Air Suspension
Levelling Valve
0644521 0500005006000 0500005006000 Rear axle
Wabco
ECAS Three 0892110
472 900 030 0
Solenoid Control 1304587
472 900 055 0
Front axle
Valve 1240836
472 900 033 0
0527488 Wabco
ECAS Three
1302682 472 900 001 0
Solenoid Control 1240847 472 900 053 0
Rear axle
Valve 1249402 472 900 008 0
Wabco
0387886
ECAS Pressure 1249721
441 040 000 0 M16 thread, Kostal electrical
Sensor 1253621
441 040 004 0 connector
441 040 005 0
Wabco
Solenoid Valve 1285545
472 172 604 0
Wabco
0629166
Solenoid Valve 1327108
472 103 108 0 EDP25AA/1
472 123 108 0
Wabco
Exhaust Brake Valve 463 013 015 0
Wabco
Solenoid Valve 0091645
472 132 158 0 0481511102100 For retarder control.
Wabco
Solenoid Valve 0091647
472 128 758 0
For engine control.
s e
r e m
r r -B
o e r
e Kn o n g
u i n t l
n l a s
Ge r t s
p a
Left side
Front Automatic Slack Haldex
Axle Adjuster
0740321
72608 KB2400 13mm offset, 140mm hole
centre
Right side
Automatic Slack Haldex
Adjuster
0740322
72609 KB2425 13mm offset, 140mm hole
centre
Left side
Rear Automatic Slack Haldex 38mm offset, 140mm hole
Axle Adjuster 72816 KB3000 centre.
Dana Part No. R9641/F
Right side
Automatic Slack Haldex 38mm offset, 140mm hole
Adjuster 72815 KB3005 centre.
Dana Part No. R9640/F
MK I
Air Compressor 2 Bolt flange mounted
(1W250D)
652439 KZ1143/3 KZ1143/3X50 Disc Valve head
Cummins Part No. 3279175
Mk I & Mk II
Air Compressor 653613 1186551 2 Bolt flange mounted
(1W250R) 657033 1194215 1194215X50 Reed Valve head
Cummins Part No. 3283968
Mk I
Air Dryer 652885 KZ1310/2 LA8223 8.4 bar cut-out, Imperial ports
(AD6) II30178-B Replacement Cartridge is
272897SP
Mk I
Air Dryer 653865 1188801 LA8223 8.4 bar cut-out, Imperial ports
(AD6-S) II30178-B Replacement Cartridge for
1188801 is SK2914/1
Mk II
Air Dryer 656882 1194188 LA8226 8.4 bar cut-out, Metric ports
(AD6) II30180-B Replacement Cartridge is
272897SP
Mk II
Air Dryer 654755 1189089 LA8226 8.4 bar cut-out, Metric ports
(AD6-S) II30180-B Replacement Cartridge for
1189089 is SK2914/1
Mk II
Air Dryer 654729 1189163 LA8227 10.0 bar cut-out, Metric ports
(AD6-S) II30181-B Replacement Cartridge for
1189163 is SK2914/1
Four Circuit Mk II
Protection Valve
614922 VPS48H VPS48H Metric ports
605293 Mk I
Single Check Valve KW2966/1 KW2966/1 1/2" NPTF ports
612503
Mk II
Single Check Valve 654733 KW4455/1 KW4455/1 M22 ports
Mk II from 1998
Hand Control Valve 657493 DPM92AB DPM92AB With red handle knob
Mk I
Dual Foot Valve 3/8" NPTF ports
(E6)
611529 KY1916/1 KY1916/1 Replacement base valve is
295579XU
Mk II
Dual Foot Valve 654756 KY1916/3 M16 ports
(E6) 657262 KY1916/4 KY1916/3 Replacement base valve is
1189389XU
M16 ports
Double Check Valve 654734 295358 295358 Bracket mounted
Relay Valve
(R15)
653885 1186715 AC574AXY AC574AXY has integral silencer
614927
Quick Release Valve 654757
KX1294/1 KX1294/1 Mk II
Pressure 653826
DB2116 DB2116 Rear service brake
Proportioning Valve I86155 I86155
Low Pressure Switch 610582-A 1185782 295476 5.4 bar, 1/4" NPTF thread
Mk I
Pressure Relief 11 bar, 1/4" NPTF thread
(Safety) Valve
613553 KX2073/7 KX2073/7 Note: LA8... Air Dryers have an
internal safety valve
Mk II
Pressure Relief 10.7 bar, M16 thread
(Safety) Valve
658257 KX1729/3 KX1729/3 Note: LA8... Air Dryers have an
internal safety valve
Mk II
Pressure Relief 13.5 bar, M16 thread
(Safety) Valve
654729 KX1729/4 KX1729/4 Note: LA8... Air Dryers have an
internal safety valve
609956 Mk I
Tilt Drain Valve 653147
KW2350/5 KW2350/1 1/2" NPTF thread
Mk II
Tilt Drain Valve 654728 VA12A KW2350/2 M22 thread
Mk I
Drain Cock 607688 KW718/2 KW718/2 In Ping Tank
1/4" NPTF thread
Mk I
Test Connector 650367 KW3405/1 KW3405/1 1/4" NPTF thread
Mk II
Test Connector 655026 KW4282/2 M16 thread
Mk II
Exhaust Silencer 655136 KW4069/3 0484210002000 For Quick Release Valve
M16 thread
652881 Mk I
Brake Chamber 652883 3.8" NPTF ports, 1.75" UNF
(Type 9) 654280
1186733-01 1186733-01 tube thread
654281 Diaphragm 272489
Mk II
Front Brake Chamber
Axle (Type 9)
654758 1189072-01 1189072-01 M16 ports, M48 tube thread
Diaphragm 272489
Mk II
Brake Chamber M16 ports, M48 tube thread
(Type 9)
655834 EF90YE EF90YE Diaphragm 234433K
Tube lock nut is Dennis 428350
Note: The Dart had many changes to its brake components at the end of March 1993.
For simplification buses built up to that date are referred to as Mk I.
Buses built after March 1993 are referred to as Mk II.
26
DENNIS Dart SLF & SPD
(Alexander Dennis) 4x2
Bodied by Alexander (ALX200), Caetano (Compass and Nimbus), East Lancs/Darwen (Esteem and Air Suspension
Spryte), Marshall/MCV (Capital and Evolution), Plaxton (Pointer) and Wrightbus (Crusader and Handybus)
From 1998
Hand Control Valve 657493 DPM92AB DPM92AB With red handle knob
610668
Low Pressure Switch 610669
Dennis only
Later vehicles
Exhaust Silencer 659280 0484210002000 0484210002000 For Quick Release Valve
M16 thread
Wabco BR9156
ABS Modulator 657942-2
472 195 018 0 II32612
On ramp interlock
Wabco Normally 'Open', M12 ports,
Solenoid Valve 655776
472 173 700 0 EDP26AA/1 Kostal electrical connector.
EDP26AA/1 has female Port 1
ECAS Three
Wabco For air suspension and ferry lift
Solenoid Control 655713
472 900 013 0 systems
Valve
Air Suspension
Air suspension
Single Solenoid 609355 454ATF
Dennis only
Control Valve
SPD
Brake Chamber Diaphragm 234226K
(Type 12)
657346 EF120YES EF120YES Tube lock nut is
Dennis 428350
SPD
Spring Brake 658499
BY9274 BY9274 Spring portion II39608F0061
(Type 14/16) II39606F II39606F Diaphragm B79883
Note: The NG3 type Spring Brake BY9... and K2E type Spring Brakes must not be mixed on one axle. Replacement of K2E units
by BY9... requires Elbow (Dennis 657240) and Adaptor (Dennis 654909-3). The Spring Portions are not interchangeable.
32
DENNIS Enviro 200 & 300
(Alexander Dennis) 4x2
Note: Alexander Dennis manufactures Enviro 200 and 300 chassis and fits Enviro 200 and 300 bodies onto them. Air Suspension
However, they also fit the Enviro 200 and 300 bodies onto chassis from other manufacturers and other body
builders fit bodies to the Enviro 200 and 300 chassis.
From 1998
Hand Control Valve 657493 DPM92AB DPM92AB With red handle knob
Enviro 200
Wabco With Allison 2100 or Voith gearbox
Dual Foot Valve 660687
461 318 609 0 Replacement base valve is
ADL 658719-1
Enviro 300
Wabco With Allison T280R gearbox
Dual Foot Valve 659319
461 315 071 0 Replacement base valve is
ADL 659319-1
Enviro 300
Quick Release Valve 661052 KX1294/4 KX1294/4 M22 Supply port, M16 Delivery
ports
Pressure Protection
Valve 612049 277148 277148DK 5.9 bar, 1/4" NPTF ports
(PR2)
Pressure Reducing
With Voith gearbox
Valve 661077 KX2045/17000 KX2045/17000 2.0 bar, M12 ports
(RV1)
Wabco BR9156
ABS Modulator 657942-2
472 195 018 0 II32612
ABS Electronic
Wabco
Control Unit 660811
446 004 607 0
(ABS-E)
Rear axle
ABS Wheel Speed 658685-30
Wabco
Straight sensor,
Sensor 441 032 476 0
cable length 0.5 m
On ramp interlock
Wabco Normally 'Open', M12 ports,
Solenoid Valve 655776
472 173 700 0 EDP26AA/1 Kostal electrical connector.
EDP26AA/1 has female Port 1
ECAS Three
Wabco For air suspension and ferry lift
Solenoid Control 655713
472 900 013 0 systems
Valve
Air Suspension
On suspension systems
Single Solenoid 609355 454ATF
with ferry lift facility
Control Valve
Front
and Air Disc Brake 659743
Wabco
Enviro 200 & 300, right side
Rear (PAN19-1plus) 40 195 020
Axles
Wabco
Disc Brake Pad Set 659742-1
12 999 770
Enviro 200 & 300
Front Wabco
Axle Brake Disc 658621
13 162 046
Enviro 200 & 300
Rear Wabco
Axle Brake Disc 658622
13 162 047
Enviro 200 & 300
Hand Control Valve 657493 DPM92AB DPM92AB With red handle knob
Double Check Valve 654734 295358 295358 M16 ports, bracket mounted
654499
Test Connector 655026 KW4282/2 M16 thread
ABS Electronic
Control Unit 659974 0486104115000 0486104115100 J1939 CAN version
(ABS 2X)
BS3471
Brake Chamber 659387-1
BS3471 K001214 Left side
(Type 22) K001214 or BS3453 Diaphragm C52066
Front II31099
Axle
BS3472
Brake Chamber 659387-2
BS3472 K001215 Right side
(Type 22) K001215 or BS3453 Diaphragm C52066
II31099
BS9520
Rear Spring Brake 658517-38 BS9520 II34388 Spring Portion II175670061
Axle (Type 24/24) II34388 or BS9500 Diaphragm B64322
K004050000
Front
Axle
Brake Disc 658470-39 Z000557 K013569
Rear ZF axle
Axle Brake Disc 657303-126 II37191 II371910061 ZF Part No. 0501 316 953
Air Dryer
(AD2)
652283 269827 269827X50
Four Circuit
Protection Valve
650209 KY1671/1 VPS48AI Imperial ports
Later buses
Single Check Valve 654733 KW4455/1 KW4455/1 M22 ports
Later buses
Hand Control Valve 657493 DPM92AB DPM92AB With red handle knob
Wabco
Dual Foot Valve 651847
461 324 008 0
With pneumatic retarder control
M16 ports
Double Check Valve 654734 295358 295358 Bracket mounted
Relay Valve
(R6)
609010 280375 280375DK Early buses
Early buses
Quick Release Valve 609011 274997 274997 Imperial ports
Later buses
Quick Release Valve 654757 KX1294/1 KX1294/1 Metric ports
Pressure Protection
Valve 612049 277148 277148DK 5.9 bar, 1/4" NPTF ports
(PR2)
Differential
Protection Valve
650060 KX1058/1 KX1058/1
Wabco
ABS Electronic
Control Unit
657082 (446 004 034 0) 0265150328000
446 004 064 0
Rear
Axle
Automatic Slack Haldex
Adjuster
651777
72367 KB2335 140 mm hole centre
Haldex
Condenser 654730
92693
Four Circuit
Protection Valve
655201 VPS48HI VPS48HI Imperial ports
Wabco
Single Check Valve 605293
APSA/2099/2 KW2966/1 1/2" NPTF ports
Wabco
Dual Foot Valve 651847
461 315 495 0
With pneumatic retarder control
Wabco SLF
Dual Foot Valve 651847
461 324 008 0 With pneumatic retarder control
M16 ports
Double Check Valve 654734 295358 295358 Bracket mounted
)
Relay Valve
(R6)
609010 280375 280375DK Early buses
Early buses
Quick Release Valve 609011 274997 274997 Imperial ports
Pressure Protection
Valve 612049 277148 277148DK 5.9 bar, 1/4" NPTF ports
(PR2)
Differential
Protection Valve
650060 KX1058/1 KX1058/1
Wabco
Load Sensing Valve 654731
475 714 500 0
Low Pressure
Switch
610582/A 1185782 295476 5.4 bar, 1/4" NPTF thread
Wabco
Tilt Drain Valve 609956
934 300 029 0 KW2350/1 1/2" NPTF thread
SV1399 SLF
Air Suspension 655687
Wabco II30525 Wabco valve is supplied with
Levelling Valve 464 006 002 0 plus ZB3131 round lever and rubber link
II19422
Front
3/8" NPTF ports, 5/8" UNF
Axle - Brake Chamber
Drum (Type 24)
653802 1188782-01 1188782-01 push rod, 64 mm stroke.
Diaphragm 234100K
Brakes
Front
Axle
Automatic Slack Haldex
Adjuster
611484
70859 KB2325 140 mm hole centre
Rear
Axle
Automatic Slack Haldex
Adjuster
651777
72367 KB2335 140 mm hole centre
Brake Disc
i n e
n u
g e t !
s e e s
e m e b
B r t h
r r p l y
n o im
K - s
r t s
pa
Hand Control Valve 657493 DPM92AB DPM92AB With red handle knob
Wabco
With switched retarder control
Dual Foot Valve 657185 461 318 025 0
for Voith gearbox
461 318 655 0
Double Check Valve 654734 295358 295358 M16 ports, bracket mounted
Relay Valve
(R15)
653885 1186715 AC574AXY AC574AXY has integral silencer
659372
Relay Valve 653885
AC574AXY AC574AXY
605208
Stop Lamp Switch 659171
274746 274746 1/4" NPTF thread
654499
Test Connector 655026 KW4282/2 M16 thread
ABS Electronic
Up to Jan 2003
Control Unit 658880 0486104104000 0486104104100 Non-CAN version
(ABS 2X)
ABS Electronic
From Jan 2003
Control Unit 659974 0486104115000 0486104115100 J1939 CAN version
(ABS 2X)
Left side
Brake Chamber
Front (Type 24)
423749 1194259 295555 Up to Chassis No. 1298
Diaphragm 234100K
Axle
with
Drum
Brakes Brake Chamber Right side
(Type 24)
423750 1194258 295555 Up to Chassis No. 1298
Diaphragm 234100K
Left side
Automatic Slack Haldex
Front Adjuster
656007-30 79157 KB3330 38 mm offset, 165 mm hole
centre
Axle
with
Drum
Brakes Automatic Slack Right side
Haldex
Adjuster
656007-29 79156 KB3325 38 mm offset, 165 mm hole
centre
Left side
Automatic Slack Haldex
Rear Adjuster
656995-104 79429 KB3180 25 mm offset, 145 mm hole
centre
Axle
with
Drum
Brakes Automatic Slack Right side
Haldex
Adjuster
656995-105 79430 KB3175 25 mm offset, 145 mm hole
centre
BS3471
Left side
Brake Chamber 659387-1 BS3471 K001214 From Jan 2003
Front (Type 22) K001214 or BS3453 Diaphragm C52066
Axle II31099
with
Disc BS2506 Right side
Brakes Brake Chamber
658470-48 BS2506 II39965F From Chassis No. 1299
(Type 24) II39965F or BS3509 up to Jan 2003
II30618 Diaphragm B64322
BS3472
Right side
Brake Chamber 659387-2 BS3472 K001215 From Jan 2003
(Type 22) K001215 or BS3453 Diaphragm C52066
II31099
Rear BS9520
From Chassis No. 1299
Axle Spring Brake 658517-38 BS9520 II34388 Spring Portion II175670061
Disc (Type 24/24) II34388 or BS9500 Diaphragm B64322
Brakes K004050000
Front
Axle
Brake Disc 658470-39 Z000557 K013569
Rear ZF axle
Brake Disc 657303-126 II37191 II371910061 ZF Part No. 0501 316 953
Axle
s e
r e m
r - B a
o r o n
K n s s
n e s l e i s
u i s t a s
n o b
Ge c t c i l e
d u r m
p r o p e
c e
e n
p
11 bar cut-out.
Air Dryer 4205 8277
LA6215 LA8242 Replacement cartridge is
I89326 II30650N00 272897SP
Four Circuit
Protection Valve
9840 0429 VPS45A VPS45A
Dual Foot Valve 5003 17963 DX75BA DX75BAY DX75BAY has integral silencer
Anti-compounding
Relay Valve
5006 303955 AC586AAX AC586AAX
Relay Valve 4103 1426 AC574AXY AC574AXY AC574AXY has integral silencer
Pressure Limiting
Valve
0816 9586 AC156B AC156B 8.5 bar, M16 ports
M22 thread
4253 1613 0484210001000 Alternative Silencers:
Exhaust Silencer 5006 304173 SIL68B SIL68B 0484210001000
or ZB3150-I78074
Snap-on
ZB3163 Alternative Silencers:
Exhaust Silencer 4212 2650
I92999 SIL68ASP 0484210017000
or ZB3163-I92999
BR9154 BR9154
ABS Modulator 5006 143819 M22 Voss ports
II17776 II17776N00
Left side
ABS Wheel Speed 5006 143953
Sensor 5010 344190
0486000041000 0486000041000 90° sensor, cable length
2.0 m, round socket
Right side
ABS Wheel Speed 5040 06366
Sensor 5010 344189
0486000042000 0486000183100 90° sensor, cable length
1.99 m, round plug
Left side
ABS Wheel Speed
Sensor
5041 33882 0486000182000 0486000182100 90° sensor, cable length
2.0 m, round socket
Right side
ABS Wheel Speed
Sensor
5041 33883 0486000183000 0486000183100 90° sensor, cable length
1.99 m, round plug
ABS Electronic
Control Unit 5006 142737 0486104050000 0486104050100
(EU12)
ABS Electronic
Control Unit 5040 89276 0486107103000 0486107103100
(ABS6)
ABS Electronic
Control Unit 5041 00391 0486107108000 0486107108100
(ABS6)
Air Suspension
Levelling Valve
9944 4042 0500005101000 0500005101000
Air Suspension
Levelling Valve
9944 4043 0500005102000 0500005102000
Air Suspension
Height Control 9944 4041 0504003001000 0504003001000 Both sides
Element
Air Suspension
Height Control 5040 45232 0504003003000 0504003003100 Left side
Element
Air Suspension
Height Control 5040 45231 0504003004000 0504003004100 Right side
Element
Air Suspension
Control Module
5010 207861 0501100016000 0501100041100 With kneeling function
Air Suspension
Control Module
5010 347767 0501100025000 0501100025000 Without kneeling function
Air Suspension
Electronic Control 5010 393211 0504004112000 No longer available
Unit
Air Suspension
Electronic Control 5041 00354 0504004114000 0504004114000
Unit
Horn Distributor
Valve
0475 0599 DPE1GB DPE1GB
Brake Chamber
(Type 12)
0483 5038 EF120FY EF120FY Diaphragm 234226K
Front
Axle
with
Drum
Brakes Brake Chamber
(Type 18)
9945 9885 EF180FY EF180FY Diaphragm 234189K
BS3201
Brake Chamber 4103 1955
II36967
BS3201 Diaphragm C34578F
(Type 12) 4121 1446
K008766 K008766
BS3313
Brake Chamber 4103 1957
II36969
BS3313 Diaphragm C72596
Front (Type 16)) 4121 1452
K003840 K003840
Axle
with
Disc
Brakes BS3354
Brake Chamber 4103 1958
II36778
BS3354 Diaphragm C72231
(Type 18) 4121 1454
K003030 K003030
BS3458
Brake Chamber 4103 1960
II36780
BS3458 Diaphragm C72337
(Type 22) 4121 1458
K003012 K003012
66
LEYLAND Olympian
Note: see also VOLVO Olympian 4x2
Bodied by Alexander, C.H. Roe, Eastern Coach Works, Mechanical & Air Suspension
Northern Counties and Optare
Air Compressor
(Tu-Flo 500)
ACU 5896 274838 274838X50 On Gardner engine
Air Compressor
(Tu-Flo 700)
LB 10609 101255 101255RM On Gardner engine
Governor Valve
(D2)
AAU 3506 277812 275491DK 8.3 bar Cut-out
Wabco
Unloader Valve CAL 0778 APSA 2878/S1
975 390 043 0
Air Dryer
(AD2)
ACU 2307 267000 269827X50
Three Circuit
Protection Valve
ACU 3864 KY1671/12 VPS38AIY
Mechanical & Air Suspension Bodied by Alexander, C.H. Roe, Eastern Coach Works,
Northern Counties and Optare
Single Circuit
Protection Valve
AAU 5633 KW4081/1 KW4081/1
Wabco
Hand Control Valve ABU 7384
APGA 6377/F KY932/7
Wabco
BCU5532
Hand Control Valve ACU 9400
APGA 6710/B
961 710 001 0
Wabco
Dual Foot Valve ACU 5113
APGA 6653
585179
Double Check Valve 528984
295036 295036
CAL 0992
Relay Valve
(R6)
1089854 280375 280375DK
1692Z165
3173150
Relay Valve 3173824
0481026032000 AC574AXY AC574AXY has integral silencer
10898550
Quick Release Valve 10898797
274999 274999
Exhaust Check Valve ACU 2709 KX2016/1 KX2016/1 For Quick Release Valve
Pressure Protection
823523
Valve ACU 4952
274785 274785 4.8 bar, 1/4" NPTF ports
(PR1)
CAL 0129
Low Pressure Switch AAU 2497
295482 295476 5.4 bar, 1/4" NPTF thread
Wabco
Stop Lamp Switch CAL 0984
APSA 4872 274746 1/4" NPTF thread
Pressure Relief
(Safety) Valve
13H7035 KX175/1 KX175/1 11 bar, 1/4" NPTF thread
Tilt Drain Valve AJU 1653 KW2350/5 KW2350/1 1/2" NPTF thread
Mechanical & Air Suspension Bodied by Alexander, C.H. Roe, Eastern Coach Works,
Northern Counties and Optare
Left side
Automatic Slack Haldex
Adjuster
ACU 3627
70943 KB2475 16 mm offset, 155 mm hole
centre
Right side
Automatic Slack Haldex
Adjuster
ACU 3628
70944 KB2480 16 mm offset, 155 mm hole
centre
Front
Axle
Left side
Automatic Slack Haldex
Adjuster
BCU 5767
72439 KB2345 16 mm offset, 155 mm hole
centre
Right side
Automatic Slack Haldex
Adjuster
BCU 5768
72440 KB2350 16 mm offset, 155 mm hole
centre
10 bar cut-out
Air Dryer 81.52102-6103
LA8210 LA8210 Replacement cartridge is
II19207 II19207 272897SP
10 bar cut-out
Air Dryer 81.52102-6104
Wabco LA8210 Replacement cartridge is
432 410 116 0 II19207 272897SP
EBS Dual Foot Valve 81.52130-6268 0486200007000 0486200007000 Voss 232 NG8 ports
Anti-compounding 81.52116-6071
Wabco
Voss ports
Relay Valve 973 011 200 0
8.5 bar
Pressure Limiting 81.52101-6269
Wabco
Port 1 M22 Voss thread.
Valve 475 010 300 0
On outlet from 4CPV
Left side
Wheel Speed Sensor 81.27120-6077 0486000049000 0486000238000 Cable length 2.0 m
Front
Axle
Right side
Wheel Speed Sensor 81.27120-6078 0486000051000 0486000240000 Cable length 2.0 m
Left side
Wheel Speed Sensor 81.27120-6067 0486000052000 0486000241000 Cable length 2.0 m
Rear
Axle
Right side
Wheel Speed Sensor 81.27120-6068 0486000053000 0486000242000 Cable length 2.0 m
ABS Electronic
Control Unit 81.25935-6639 0265150315000 0265150315000
(Gamma 2E)
Rear
Axle
Front
Brake Disc 81.50803-0044 With 19.5" wheels
Axle
Rear
Brake Disc 81.50803-0057 With 19.5" wheels
Axle
76
MAN 18.220
See Notes on different Marks at the end of this section
4x2
Bodied by Alexander (ALX300), East Lancs/Darwen (Kinetic) and Ikarus Air Suspension
10 bar cut-out
Air Dryer 81.52102-6103
LA8210 LA8210 Replacement cartridge is
II19207 II19207 272897SP
10 bar cut-out
Air Dryer 81.52102-6104
Wabco LA8210 Replacement cartridge is
432 410 116 0 II19207 272897SP
EBS Dual Foot Valve 81.52130-6268 0486200007000 0486200007000 Voss 232 NG8 ports
Air Suspension Bodied by Alexander (ALX300), East Lancs/Darwen (Kinetic) and Ikarus
Anti-compounding 81.52116-6071
Wabco
Voss ports
Relay Valve 973 011 200 0
8.5 bar
Pressure Limiting 81.52101-6269
Wabco
Port 1 M22 Voss thread.
Valve 475 010 300 0
On outlet from 4CPV
Left side
Wheel Speed Sensor 81.27120-6077 0486000049000 0486000238000 Cable length 2.0 m
Front
Axle
Right side
Wheel Speed Sensor 81.27120-6078 0486000051000 0486000240000 Cable length 2.0 m
Left side
Wheel Speed Sensor 81.27120-6067 0486000052000 0486000241000 Cable length 2.0 m
Rear
Axle
Right side
Wheel Speed Sensor 81.27120-6068 0486000053000 0486000242000 Cable length 2.0 m
ABS Electronic
Control Unit 81.25935-6639 0265150315000 0265150315000
(Gamma 2E)
Air Suspension Bodied by Alexander (ALX300), East Lancs/Darwen (Kinetic) and Ikarus
Left side,
Brake Chamber Wabco with Meritor Disc Brake
81.51101-6422 M22 ports, 73 mm stroke
Front (Type 16) 423 104 712 0 20 mm push rod protrusion
Axle Diaphragm 16LS
Mk 2
Disc Right side,
Brake Chamber Wabco with Meritor Disc Brake
Brakes 81.51101-6423 M22 ports, 73 mm stroke
(Type 16) 423 104 711 0 20 mm push rod protrusion
Diaphragm 16LS
Left side,
BS2407 with Knorr-Bremse Disc Brake
Brake Chamber 81.51101-6479 K002942
BS2407 M22 ports, 64 mm stroke
Front (Type 20) K015584 K015584 15 mm push rod protrusion
Axle Diaphragm C72336
Mk 3
Disc Right side,
BS2406 with Knorr-Bremse Disc Brake
Brakes Brake Chamber 81.51101-6478 K002941
BS2406 M22 ports, 64 mm stroke
(Type 20) K015583 K015583 15 mm push rod protrusion
Diaphragm C72336
Left side
Spring Brake M16 ports, 64 mm stroke
81.50410-6537
BZ9631 BZ9631 Diaphragm B75383
Rear (Type 30/30) II19749 II19749 Note: push rod is 300 mm long - fully threaded rods are not
Axle strong enough and rationalised units should not be used
Mk 1
Drum Right side
Spring Brake M16 ports, 64 mm stroke
Brakes
81.50410-6536
BZ9630 BZ9630 Diaphragm B75383
(Type 30/30) II19748 II19748 Note: push rod is 300 mm long - fully threaded rods are not
strong enough and rationalised units should not be used
Left side
Spring Brake Wabco M22 ports, 57 mm stroke
Rear 81.50410-6789 Diaphragm 234100K
(Type 24/30) 925 421 454 0
Note: push rod is 300 mm long - fully threaded rods are not
Axle strong enough and rationalised units should not be used
Mk 2
Drum Right side
Brakes Spring Brake Wabco M22 ports, 57 mm stroke
81.50410-6788 Diaphragm 234100K
(Type 24/30) 925 421 455 0
Note: push rod is 300 mm long - fully threaded rods are not
strong enough and rationalised units should not be used
Front
Axle
Automatic Slack
Adjuster
Mk 1
Rear
Axle Automatic Slack
Adjuster
Mk 1
Rear
Axle
Automatic Slack
Adjuster
Mk 2
Meritor
Air Disc Brake LRG574 Left side
LRG590
Meritor
Air Disc Brake LRG575 Right side
LRG591
Meritor
Air Disc Brake LRG704
Left side, with EBS
Front
Axle
Mk 2
Meritor
Air Disc Brake LRG705
Right side, with EBS
Meritor
Disc Brake Pad Set MDP5038
For Meritor Air Disc Brakes
Front
Axle Brake Disc
Mk 3
Rear
Axle Brake Disc
Mk 3
NOTES
Vehicle Mark
82
MERCEDES-BENZ Citaro
4 x 2, 6 x 2 & Artic
Air Suspension
Haldex
Condenser 78200
Wabco
EBS Dual Foot Valve A004 431 36 05
480 002 000 0
Up to 2003
Wabco
EBS Dual Foot Valve A004 431 64 05
480 002 004 0
From 2004
Wabco
Base Foot Valve A004 431 50 05
480 001 004 0
For EBS Foot Valve
Voss ports
Wabco
Relay Valve A004 429 38 44
973 011 001 0 AC574AXY Note: AC574AXY has standard
Metric ports
Wabco
Quick Release Valve A004 429 23 44
973 500 028 0
Voss ports
On Condensate Reservoir
Wabco M22 thread
Exhaust Silencer A000 430 29 70
432 407 060 0 SIL68B Alternative Silencers:
0484210001000 or ZB3150-I78074
On QRV, Anti-compounding
Wabco Relay Valve and Relay Valve.
Exhaust Silencer A000 430 24 70
432 407 070 0 SIL68ASP Snap-on
Alternative Silencers:
0484210017000 or ZB3163-I92999
Wabco
Test Connector A000 420 60 71
463 703 116 0
M12(F) thread
Front axle.
ABS Modulator A004 429 65 44
Wabco BR9159 Voss Supply port 1
472 195 016 0 II40864FN00 Electrical Connector DIN 72585
Bayonet
Wabco
EBS Axle Modulator A000 429 08 24
480 103 006 0
Drive axle up to Sept 1999
Drive axle
Wabco
EBS Axle Modulator A000 429 14 24
480 103 066 0
From Mar 1999 to 2002
Voss ports
Drive axle
Wabco
EBS Axle Modulator A000 429 23 24
480 103 063 0
With Redundancy Valve
From Sept 2000
Voss ports
Solenoid Control A004 997 93 36
Wabco Electrical Connector DIN 72585
Valve 472 170 636 0 Bayonet.
Normally closed
Wabco
ECAS Solenoid Valve A000 327 74 25
472 900 056 0
With kneeling function
Emergency Charge
Coupling
Artic
Brake Chamber BS2410
(Type 20) K004764 ZF only ZF Part No. 0501 321 400
Diaphragm C60489
Artic
Brake Chamber BS2409
(Type 20) K004763 ZF only ZF Part No. 0501 321 399
Diaphragm C60489
4 x 2, both sides
Spring Brake BS9520 BS9520 Up to Feb 2000
Voss 230 ports
(Type 24/24) II34388 II34388 ZF Part No. 0501 316 050
Diaphragm C64322
4 x 2 & Artic, both sides
Spring Brake BS9476 BS9476 From Mar 2000 to Feb 2004
Voss 230 ports
(Type 20/24) II38408F II38408F ZF Part No. 0501 317 952
Diaphragm C72336
6 x 2, both sides
Spring Brake BS9478 BS9478 From Mar 2000 to Mar 2004
Voss 230 ports
(Type 20/27) II38522F II38522F ZF Part No. 0501 317 951
Diaphragm C72336
6 x 2, both sides
Spring Brake BS9478 BS9478 From Apr 2004
M22 Voss ports
(Type 20/27) K004075 K004075 ZF Part No. 0501 317 951
Diaphragm C72336
6 x 2, both sides
Brake Chamber BS3314 BS3314 Up to May 2005
A050 131 67 75 M16 centre port
(Type 16) II37110 K002978 ZF Part No. 0501 316 775
Trailing Diaphragm C72596
Axle
6x2 6 x 2, both sides
Brake Chamber A021 420 71 18
BS3314 BS3314 From May 2005
(Type 16 OBC) K002978 K002978 M16 centre port
ZF Part No. 0501 322 277
s -
a r t
e p e
r e ms va l u
r -B l i f e
o r g
Kn lo n
i n e f o r
n u e d
Ge n e e r
g i
e n
SN7081
A628 420 07 01 4 x 2 & 6 x 2, left side
Air Disc Brake A628 420 09 01
K008172 Caliper From Nov 2005
(Axial) A628 420 11 01
K008170 K003800 Actuator mounting -12°
K008168
SN7091
A628 420 08 01 4 x 2 & 6 x 2, right side
Air Disc Brake A628 420 10 01
K008173 Caliper From Nov 2005
(Axial) A628 420 12 01
K008171 K003799 Actuator mounting -12°
K008169
4 x 2, left side
Air Disc Brake SB7118 Caliper Up to Dec 1998
(Radial) II35397 K002964 Actuator mounting +93°
ZF Part No. 0501 006 008
4 x 2, left side
Air Disc Brake SB7134 Caliper From Dec 1998 to June 2001
(Radial) II37815 K002964 Actuator mounting +93°
ZF Part No. 0501 006 600
4 x 2, left side
Air Disc Brake SB7190 Caliper From July 2001 to mid 2003
(Radial) Z0021122 K002964 Actuator mounting +93°
ZF Part No. 0501 007 173
4 x 2, left side
Air Disc Brake SB7197 Caliper From mid 2003
(Radial) K010173 K002964 Actuator mounting +93°
Drive ZF Part No. 0501 007 976
Axle
4x2 4 x 2, right side
Air Disc Brake SB7108 Caliper Up to Dec 1998
(Radial) II35396 K002965 Actuator mounting +93°
ZF Part No. 0501 006 007
4 x 2, right side
Air Disc Brake SB7124 Caliper From Dec 1998 to June 2001
(Radial) II37814 K002965 Actuator mounting +93°
ZF Part No. 0501 006 599
4 x 2, right side
Air Disc Brake SB7180 Caliper From July 2001 to mid 2003
(Radial) Z0021121 K002965 Actuator mounting +93°
ZF Part No. 0501 007 172
4 x 2, right side
Air Disc Brake SB7187 Caliper From mid 2003
(Radial) K010172 K002965 Actuator mounting +93°
ZF Part No. 0501 007 975
6 x 2, left side
Air Disc Brake SB7118 Caliper Up to Dec 1998
(Radial) II35397 K002964 Actuator mounting +93°
ZF Part No. 0501 006 008
6 x 2, left side
Air Disc Brake SB7134 Caliper From Dec 1998 to Feb 2000
(Radial) II37815 K002964 Actuator mounting +93°
ZF Part No. 0501 006 600
6 x 2, left side
Air Disc Brake SB7156 Caliper From Mar 2000
(Radial) II39007F K002964 Actuator mounting +93°
Drive ZF Part No. 0501 006 851
Axle
6x2 6 x 2, right side
Air Disc Brake SB7108 Caliper Up to Dec 1998
(Radial) II35396 K002965 Actuator mounting +93°
ZF Part No. 0501 006 007
6 x 2, right side
Air Disc Brake SB7124 Caliper From Dec 1998 to Feb 2000
(Radial) II37814 K002965 Actuator mounting +93°
ZF Part No. 0501 006 599
6 x 2, right side
Air Disc Brake SB7146 Caliper From Mar 2000
(Radial) II39006F K002965 Actuator mounting +93°
ZF Part No. 0501 006 850
left side
Air Disc Brake SB7118 Caliper Up to Dec 1998
(Radial) II35397 K002964 Actuator mounting +93°
ZF Part No. 0501 006 008
left side
Air Disc Brake SB7134 Caliper From Dec 1998 to Feb 2000
(Radial) II37815 K002964 Actuator mounting +93°
ZF Part No. 0501 006 600
left side
Air Disc Brake SB7156 Caliper From Mar 2000
(Radial) II39007F K002964 Actuator mounting +93°
Trailing ZF Part No. 0501 006 851
Axle
6x2 right side
Air Disc Brake SB7108 Caliper Up to Dec 1998
(Radial) II35396 K002965 Actuator mounting +93°
ZF Part No. 0501 006 007
right side
Air Disc Brake SB7124 Caliper From Dec 1998 to Feb 2000
(Radial) II37814 K002965 Actuator mounting +93°
ZF Part No. 0501 006 599
right side
Air Disc Brake SB7146 Caliper From Mar 2000
(Radial) II39006F K002965 Actuator mounting +93°
ZF Part No. 0501 006 850
4 x 2 front axle.
Brake Disc A942 421 21 12 II376380061 4 x 2 rear axle up to June 2001
Brake Disc A000 420 02 72 II371910061 4 x 2 rear axle from July 2001
Voss
Air Distribution Valve 0833124000
Meritor
Hydraulic Disc Brake LRG510
Left side, 16" wheels
Meritor
Hydraulic Disc Brake LRG511
Right side, 16" wheels
Front
Axle
Meritor
Hydraulic Disc Brake LRG520
Left side, 17.5" wheels
Meritor
Hydraulic Disc Brake LRG521
Right side, 17.5" wheels
Meritor
Hydraulic Disc Brake LRG624
Left side, 16" wheels
Meritor
Hydraulic Disc Brake LRG625
Right side, 16" wheels
Rear
Axle
Meritor
Hydraulic Disc Brake LRG626
Left side, 17.5" wheels
Meritor
Hydraulic Disc Brake LRG627
Right side, 17.5" wheels
Meritor
Disc Brake Pad Set MDP5040
Brake Disc
7 port valve
Four Circuit Wabco
Protection Valve
A002 431 93 06
934 702 221 0 0481062104000 Alternative valve is
AE4162-I73329
Four Circuit
Protection Valve
A003 431 41 06 0481062413000 0481062413000 5 port valve
Wabco
Dual Foot Valve A003 431 15 05
461 315 258 0
Wabco
Dual Foot Valve A002 431 87 05
461 315 250 0 0481064103000
Wabco
Dual Foot Valve A002 431 88 05
461 319 260 0 0481064205000 With front axle modulation
Wabco
Relay Valve A002 429 84 44
973 001 021 0 0481026005000
Wabco
Load Sensing Valve A003 431 22 12 475 711 024 0
For Laden AIr Suspension
(Air Suspension) 475 711 118 0
pressure of 3.0 bar
Wabco
Load Sensing Valve A003 431 23 12 475 711 017 0
For Laden AIr Suspension
(Air Suspension) 475 711 119 0
pressure of 4.5 bar
Wabco
Tilt Drain Valve A000 432 11 07
934 300 001 0 KW2350/2 M22 thread
ECAS Single
Wabco
Solenoid Control A000 327 66 25
472 900 058 0
Front axle
Valve
Brake Chamber
for Air/Hydraulic A001 431 97 14
Wabco
Diaphragm 16LS
Actuator 423 060 004 0
(Type 14)
Meritor
Hydraulic Disc Brake LRG520
Left side
Front
Axle
Meritor
Hydraulic Disc Brake LRG521
Right side
Meritor
Hydraulic Disc Brake LRG626
Left side
Rear
Axle
Meritor
Hydraulic Disc Brake LRG627
Right side
Meritor
Disc Brake Pad Set MDP5040
Brake Disc
++
DR3238
Unloader Valve 11021610
I78861
0481039221000 8.1 bar cut-out
Wabco
Unloader Valve 11027335
975 303 473 0 0481039221000 8.1 bar cut-out
AE5101
AE5115
Single Check Valve 12006518
I25351
I75598 M22(F) ports
or 1194016
Wabco
AE5115
Single Check Valve 11017366
434 014 000 0 I75598 M22(F) ports
or 1194016
AE5115
AE5115
Single Check Valve 11017249
I75598
I75598 M22(F) ports
or 1194016
Wabco
Dual Foot Valve 11024035
461 307 200 0
Pressure 11021900
DB2116 DB2116 Reduction ratio 1.15:1
Proportioning Valve I86155 I86155 Mercedes-Benz axle
Pressure 11024735
Wabco DB2116 Reduction ratio 1.15:1
Proportioning Valve 473 301 003 0 I86155 Mercedes-Benz axle
Pressure 11021910
DB2115 DB2115 Reduction ratio 1.5:1
Proportioning Valve I86154 I86154 ZF axle
Pressure 11017237
DB2142 DB2142 Reduction ratio 1.35:1
Proportioning Valve II36021 II36021 Complete with snap-on silencer
EE1100
Tilt Drain Valve 11017276
I94095
KW2350/2 M22 thread
Wabco
Tilt Drain Valve 11017398
934 300 003 0 KW2350/2 M22 thread
M16 thread
Fitted near Double Check Valve,
Test Connector 11019034 KW4282/2 Pressure Proportioning Valve
and ABS Modulator
Snap-on
ZB3163 Alternative Silencers:
Exhaust Silencer 11017349
I92999
SIL68ASP 0484210017000
or ZB3163-I92999
M22 thread
ZB3150 Alternative Silencers:
Exhaust Silencer 11017348
I78074
SIL68B 0484210001000
or ZB3150-I78074
M22 thread
Wabco Alternative Silencers:
Exhaust Silencer 11018653
432 407 060 0 SIL68B 0484210001000
or ZB3150-I78074
ABS Electronic
Control Unit
11018714 0486104039000 0486104039100
Front
Brake Chamber 080240000
Wabco BZ3555 ZF axle
(Type 24) 423 106 106 0 I77744 Diaphragm 234100K
Axle
with
Drum
Brakes
Brake Chamber 07010020
Wabco BX3419 Mercedes-Benz axle
(Type 20) 423 105 900 0 II33782A Diaphragm 20LS
Trailing
Axle - Spring Brake Wabco
Drum (Type 20/20) 890 110 328 0 K2B0525X50 Diaphragm 234099K
Brakes
Right side.
Automatic Slack Haldex
Adjuster
070114305
70771 KB3130 15 mm offset, 115 mm hole
centre, 26 tooth spline
Front
Brake Chamber 11015698
BS3402 BS3402 Left side.
(Type 20) II30616 II30616 Diaphragm C60489
Axle
with
Disc
Brakes
Brake Chamber 11015699
BS3403 BS3403 Right side.
(Type 20) II30617 II30617 Diaphragm C60489
Trailing
Axle - Spring Brake 11014289
BS9398 BS9397 Diaphragm C72596
Disc (Type 16/16) II18224 II31227
Brakes
Drive
Axle - Spring Brake 11018612
BS9535 BS9535 Diaphragm C72337
Disc (Type 24/24HFL1) II37468 II37468
Brakes
Left side.
SB7716 Caliper
Air Disc Brake 11014054 Actuator mounting 0°
II34459 K003803 ZF Part No. 0501 005 860
Front &
Trailing
Axle Right side.
SB7706 Caliper
Air Disc Brake 11014053 Actuator mounting 0°
II34458 K003804 ZF Part No. 0501 005 859
Left side.
SB7894 Caliper
Air Disc Brake Actuator mounting 0°
K000046 K003809 ZF Part No. 0501 007 244
Drive
Axle
Right side.
SB7884 Caliper
Air Disc Brake Actuator mounting 0°
K000045 K003810 ZF Part No. 0501 007 243
106
OPTARE Alero
4x2
Air Suspension
Four Circuit
Protection Valve
20170027 VPS45HY VPS45HY With "Safety Feature"
Low Pressure Switch 21070180 295474 295474 5.2 bar, 1/4" NPTF thread
Pressure Relief
(Safety) Valve
21070340 KX175/1 KX175/1 11 bar, 1/4" NPTF thread
Snap-on
Alternative Silencers:
Exhaust Silencer L2230331 SIL68A SIL68ASP 0484210017000
or ZB3163-I92999
M22 thread
Alternative Silencers:
Exhaust Silencer 21070032 0481210001000 SIL68B 0484210001000
or ZB3150-I78074
ABS Electronic
Control Unit 21070029 0486104119000 0486104119100
(ABS 2X)
ABS Electronic
Control Unit 21070343 0486107308000 0486107308000 From Jan 2008
(ABS6)
Level Sensor
Linkage
21070075 SEB00256 SEB00256
Air Suspension
Replacement ECU needs to be
Electronic Control 20170013 0504004106000 0504004106100 programmed before use
Unit
Air/Hydraulic
Actuator Diaphragm 24LS
(Type 24 with MC19
R2200054 EF624CY EF624CY Master Cylinder 758188.01SP
Master Cylinder)
Disc Parking
Up to May 2003
Actuator 21070184 1186754 1186754 Diaphragm 1188902
(Type 61)
Rear
Axle
Disc Parking
From May 2003
Actuator X2216643 1186753 1186753 Diaphragm 1188902
(Type 50)
Front
Hydraulic Disc Brake Right side
Axle
Brake Disc
Rear
Axle
Hydraulic Disc Brake Right side
Brake Disc
110
OPTARE Excel
4x2
Air Suspension
Air Compressor
(1W250R)
1186551 1194215X50 Cummins Part No. 3279412
Up to Sept 1999.
10.0 bar cut-out
Air Dryer L2210058 1189163
LA8227 Replacement cartridge for
(AD6-S) II30181-B 1189163 is SK2914/1 and for
LA8227-II30181 is 272897SP
M16 ports
Double Check Valve L2230010 295358 295358 Bracket mounted
Up to March 2002.
Relay Valve
(R15)
L2220011 1186715 AC574AXY Buses without ABS
AC574AXY has integral silencer
Up to Sept 1999.
Quick Release Valve L2230014 KX1294/1 KX1294/1 M16 exhaust port
Low Pressure Switch L2230006 272295 272295 5.2 bar, M12 thread
Up to June 2001
Tilt Drain Valve X22312247 KW2350/1 KW2350/1 1/2" NPTF thread
M16 thread
Test Connector X22312172 AC784B AC784B Alternative is KW4282/2
Snap-on
Alternative Silencers:
Exhaust Silencer X22312474 SIL68A SIL68ASP 0484210017000
or ZB3163-I92999
M22 thread
Alternative Silencers:
Exhaust Silencer L2200287 SIL68B SIL68B 0484210001000
or ZB3150-I78074
ABS Electronic
Control Unit 24070023 0486104028000 0486104028100
(CI-12)
Air Suspension
Solenoid Valve
L2230025 EDP25AA/1 EDP25AA/1 Normally closed
Pressure Retention
Valve
L2230026 SEB01237 SEB01237
BZ3491
Brake Chamber L2210060
BZ3491 I98817 Diaphragm 234099K
(Type 20) I98817 or BZ3443
Front I75269
Axle
BZ3490
Brake Chamber L2210012
BZ3490 I98818 Diaphragm 234099K
(Type 20) I98818 or BZ3443
I75269
Rear Automatic Slack Haldex Rockwell axle, left and right side
Axle Adjuster
L2220055 KB2955 140 mm hole centre
79177
Four Circuit
Protection Valve
X2216639 VPS48A VPS48A Up to 1997
Four Circuit
Protection Valve
X2210077 VPS48H VPS48H From 1997
Low Pressure Switch X2216644 295481 295473 4.1 bar, 1/4" NPTF thread
X2216645
Stop Lamp Switch X2222947
274746 274746 1/4" NPTF thread
M16 thread
Test Connector X22312172 AC784B AC784B Alternative is KW4282/2
Snap-on
Alternative Silencers:
Exhaust Silencer X22312474 SIL68A SIL68ASP 0484210017000
or ZB3163-I92999
e r ! s e
m b r e m
m e r - B
Re o r s
K n a r t
in e t p
n u e n
G e e m
F i t l a c
re p
Air/Hydraulic
Actuator Diaphragm 24LS
(Type 24 with MC19
X2205454 EF624AX EF624AX Master Cylinder 758188.01SP
Master Cylinder)
Rear
Disc Parking
Axle
Actuator X2216643 1186753 1186753 Diaphragm 1188902
(Type 50)
Meritor
Hydraulic Disc Brake LRG514
Left side
Meritor
Hydraulic Disc Brake LRG515
Right side
Front
Axle
Meritor
Disc Brake Pad Set MDP5429
X1857658
Brake Disc X2057948
R2000005
Meritor
Hydraulic Disc Brake LRG620
Left side
Meritor
Hydraulic Disc Brake LRG621
Right side
Rear Meritor
Axle
Disc Brake Pad Set MDP5429
Meritor
Disc Brake Pad Set MBR1831
From Jan 1989
X1857658
Brake Disc X2057948
R2000005
118
OPTARE Solo
4x2
Air Suspension
Integral on Mercedes-Benz
Air Compressor 4 cylinder OM904LA SCR
engine
Up to Dec. 1999
Air Dryer R2200037 1194211
LA8227 10.0 bar cut-out
(AD6) II30181-B Replacement cartridge is
272897SP
Four Circuit
Protection Valve
L2210077 VPS48H VPS48H With air/hydaulic brakes
Anti-compounding RE2221
RE2221
R2200220 I63354 With full air brakes
Relay Valve I63354
or AC586AY
X2216645
Stop Lamp Switch X2222947
274746 274746 1/4" NPTF thread
Pressure Relief
(Safety) Valve
R2200246 KX2073/13 KX2073/13 14 bar, 1/4" NPTF thread
24070012 EE1100
Tilt Drain Valve L2230005 I94095
KW2350/2 M22 thread
Up to March 2003
Signalled Automatic R2200210
EE4103 EE4103 Signalled from Air Dryer
Drain Valve I74772 I74772 Unloader
M22 thread, M12 Control port
Snap-on
SIL68A
L2230006 Alternative Silencers:
Exhaust Silencer L2230331
or ZB3163 SIL68ASP 0484210017000
I92999
or ZB3163-I92999
ABS Modulator
21070030 BR9152 BR9152 With full air brakes
L2220009 II16278 II16278
ABS Electronic
Control Unit 24070023 0486104028000 0486104028100 With full air brakes
(CI-12)
Pressure Retention
Valve
L2230026 SEB01237 SEB01237
Air/Hydraulic
With air/hydraulic brakes
Actuator EF624AY
(Type 24 with MC19
R2200054
EF624CY EF624CY Diaphragm 24LS
Master Cylinder 758188.01SP
Master Cylinder)
X1857658
Brake Disc X2057948 With air/hydraulic brakes
R2000005
X1857658
Brake Disc X2057948 With air/hydraulic brakes
R2000005
Meritor
Disc Brake Pad Set MDP5049
With air/hydraulic brakes
Air Disc Brake Wabco Left side with full air brakes
(PAN 17)
Air Disc Brake Wabco Left side with full air brakes
(PAN 17)
Rear Air Disc Brake Wabco Right side with full air brakes
Axle (PAN 17)
124
OPTARE Tempo
4x2
Air Suspension
On Mercedes-Benz 6 cylinder
Air Compressor OM906LA engine
On MAN 6 cylinder
Air Compressor D0836LOH51 engine
Four Circuit
Protection Valve
20170027 VPS45HY VPS45HY With "Safety Feature"
Low Pressure Switch L2230006 272295 272295 5.2 bar, M12 thread
EE1100
Tilt Drain Valve L2230005
I94095
KW2350/2 M22 thread
Snap-on
Alternative Silencers:
Exhaust Silencer L2230331 SIL68A SIL68ASP 0484210017000
or ZB3163-I92999
M22 thread
Alternative Silencers:
Exhaust Silencer L2200287 SIL68B SIL68B 0484210001000
or ZB3150-I78074
ABS Modulator
L2220009 BR9152 BR9152
L2230009 II16278 II16278
ABS Electronic
Control Unit 25100013 0486104045000 0486104045100 With drum brakes
(EU12)
ABS Electronic
Control Unit 32070014 0486107007100 0486107007100 With disc brakes
(ABS6)
Air Suspension
Replacement ECU needs to be
Electronic Control 20170013 0504004106000 0504004106100 programmed before use
Unit
BZ3491
Brake Chamber L2210060
BZ3491 I98817 Diaphragm 234099K
Front
(Type 20) I98817 or BZ3443
Axle - I75269
Drum
Brakes
BZ3490
Brake Chamber L2210012
BZ3490 I98818 Diaphragm 234099K
(Type 20) I98818 or BZ3443
I75269
Rear
Axle - Spring Brake Spring Portion K2B0004X50
Drum (Type 20-80)
L2210059 K2B1162 K2B0504X50 Diaphragm 234099K
Brakes
Brake Chamber
Front
Axle -
Disc
Brakes
Brake Chamber
Rear
Axle -
Disc Spring Brake
Brakes
Front
Axle
Brake Disc
Rear
Axle
Brake Disc
Integral on Mercedes-Benz
Air Compressor 4 cylinder OM904LA engine
Four Circuit
Protection Valve
20170027 VPS45HY VPS45HY With "Safety Feature"
Anti-compounding
Relay Valve
AC586AY AC586AY
Low Pressure Switch L2230006 272295 272295 5.5 bar, M12 thread
Pressure Relief
(Safety) Valve
R2200246 KX2073/13 KX2073/13 14 bar, 1/4" NPTF thread
Snap-on
SIL68A
L2230006 Alternative Silencers:
Exhaust Silencer L2230331
or ZB3163 SIL68ASP 0484210017000
I92999
or ZB3163-I929997
ABS Modulator
21070030 BR9152 BR9152
L2220009 II16278 II16278
ABS Electronic
Control Unit 0486107007100 0486107007100
(ABS6)
Front
Axle
Rear
Spring Brake Wabco
Axle
Front
Brake Disc
Axle
Rear
Brake Disc
Axle
132
PLAXTON Primo
Built on EBL Plasma chassis 4x2
Air Suspension
AE5101
Single Check Valve I25351
1194016 M22(F) ports
Air Suspension
Pressure Limiting
Valve
AC157C AC157C M22 ports, 8.0 bar
Snap-on
Alternative Silencers:
Exhaust Silencer SIL68A SIL68ASP 0484210017000
or ZB3163-I92999
ABS Electronic
Control Unit 0486104039000 0486104039100
(EU12)
M22 ports
ABS Modulator
BR9152 BR9152 Kostal electrical
II16278 II16278 connector
Levelling Valve
Linkage
SEB00256 SEB00256 In-line link
Levelling Valve
Linkage
K001406 K001406 Offset link
Air Suspension
Solenoid Valve
EDP26AAX EDP26AAX
Air Suspension
Front
Axle Brake Disc
Rear
Axle Brake Disc
Air Compressor
(2W440D)
301525 KZ996/1 KZ996/2X50 3 bolt flange mounted
Air Compressor
(2W440D)
394441 KZ1228/1 KZ1228/1X50 3 bolt flange mounted
Up to Chassis 1823419
Wabco 9.5 bar cut-out
Unloader Valve 469239
975 303 089 0 0481039213000 Adjust replacement valve to
9.5 bar
Wabco
Hand Control Valve 469271
961 723 021 0
Wabco
Interlock Valve 303883
434 205 028 0
"Broms" brake
M16 ports,
Double Check Valve 290017 295358 295358 bracket mounted
Relay Valve
(R6)
217385 295198 295198
Relay Valve
(R15)
350001 KY2308/1 AC574AXY AC574AXY has integral silencer
Low Pressure Switch 303499 267013 267037 5.0 bar, M12 thread
Up to Chassis 1822998
Low Pressure Switch 303500 267024 272295 5.5 bar, M12 thread
Wabco BR9152
ABS Modulator 1307040 Front axle
475 195 004 0 II16278
BR9152
ABS Modulator 369543 0265351101000 Front & rear axle
II16278
Wabco
1107495 Front and ASA60 tag axles
Wheel Speed Sensor 1342971
441 032 771 0
90° sensor, cable length 1.55 m
441 032 577 0
ABS Electronic
374008 0265150201000
Control Unit 1326135 0265150315000 0265150315000 4 x 2 up to Chassis 1822877
(Gamma 2M)
ABS Electronic
Control Unit 460757 0265150301000 6 x 2 up to Chassis 1821460
(Gamma 2E)
ABS Electronic
Control Unit 463361 0265150302000 0486104023000 6 x 2 from Chassis 1821461
(Gamma 2M)
ABS Electronic
Wabco
Control Unit 1326134
446 004 054 0
Replaced by 1334350
(Type C2)
ABS Electronic
Wabco
Control Unit 1334350
446 004 064 0
(Type C3)
ECAS Three
Wabco
Solenoid Control 1309501
472 900 007 0
For kneeling system
Valve
Air Suspension
Chassis Lowering 423964 0481007022000 0481007022000
Valve
374116 Kongsberg
Clutch Servo 575184 KA622190 622190AM
Kongsberg
Clutch Servo 360717
KA622107 622107AM
Kongsberg
Clutch Servo 360719
KA622109 622109AM
Kongsberg
Clutch Servo 360720
KA622110
Kongsberg
Clutch Servo 1337966
KA624199 624199AM
1305774 Wabco
423 105 084 0
Front Brake Chamber 1313761
425 105 451 0
BX3419 75 mm stroke
Axle (Type 20LS) 1313841 425 105 450 0 II33782A Diaphragm 20LS
1313886 425 105 457 0
Wabco
Brake Chamber 1305777
423 106 088 0
BX3538 75 mm stroke
(Type 24LS) 1313844 425 106 450 0 II33783A Diaphragm 24LS
Wabco
Spring Brake 1313829 Spring Portion K2B0004X50
(Type 20/24) 1446037
925 430 006 0 K2B0504X50 Diaphragm 234099K
925 430 036 0
Spring Brake
(Type 24-80)
1350234 K2D0706 K2D0706X50 Diaphragm 24LS
Up to Chassis 1823246
Rear Spring Brake
Axle (Type 30-105)
1350236 K2D0722 K2D0722X50 Spring Portion K2D0222X50
Diaphragm 30LS
Up to Chassis 1823247 to
Spring Brake 1825372
(Type 30-105)
1361987 K2G0822 K2G0822X50 Spring Portion K2D0222X50
Diaphragm 30LS
Left side
Spring Brake Wabco
(Type 30/30)
1354877
925 431 411 0 K2B0522X50 Spring Portion K2B0022X50
Diaphragm 234101K
Right side
Spring Brake Wabco
(Type 30/30)
1354878
925 431 412 0 K2B0522X50 Spring Portion K2B0022X50
Diaphragm 234101K
Brake Chamber
(Type 12)
309418 267316 295530 Diaphragm 234226K
Tag
Axle
Left side
Manual Slack
Adjuster
1448111 267083 267083 50 mm offset, 165 mm hole
centre
Front
Axle
Right side
Manual Slack
Adjuster
1448112 267084 267084 50 mm offset, 165 mm hole
centre
Left side
Manual Slack
Adjuster
1448115 267026 267026 25 mm offset plus crank,
165 mm hole centre
Rear
Axle
Right side
Manual Slack
Adjuster
1448114 267027 267027 25 mm offset plus crank,
165 mm hole centre
Left side
Manual Slack
Adjuster
1448116 272862 272862 15.9 mm offset, 130 mm hole
centre
Tag
Axle
Right side
Manual Slack
Adjuster
1448117 272863 272863 15.9 mm offset, 130 mm hole
centre
Left side
Automatic Slack Haldex
Adjuster
1112833
72660 KB2220 25 mm offset, 165 mm hole
centre
Rear
Axle
Right side
Automatic Slack Haldex
Adjuster
1112834
72661 KB2260 25 mm offset, 165 mm hole
centre
Left side
Automatic Slack Haldex
Adjuster
394189
72727 KB2585 16 mm offset, 165 mm hole
centre
Tag
Axle
Right side
Automatic Slack Haldex
Adjuster
394190
72728 KB2590 16 mm offset, 165 mm hole
centre
146
SCANIA 4 Series Bus
Bodied by East Lancs/Darwen (Esteem, Olympus and OmniDekka), 4x2&6x2
Irizar (Century), Plaxton (Derwent), Scania (Omnicity, Omnilink and
Omnitown) and Wrightbus (Axcess and Solar) Mechanical & Air Suspension
1541705 LK4941
Air Compressor 1728435 K003960 LK4941 5 bolt flange mounted with ESS
1770607 K012799
(2W600R) 1784109 K014896 K016615000 and through drive
1796663 K016615
1514066
Air Compressor 1537798
LK4930 LK4930 Universal flange mounted
(2W720R) 1745702
K009403 K009403X00
Wabco
Hand Control Valve 469271
961 723 021 0
With Interlock Valve
Wabco
Hand Control Valve 1108720
961 722 214 0
Wabco
Interlock Valve 1373080
434 205 032 0
"Broms" brake
Wabco
Dual Foot Valve 1324663
461 315 180 0 0481064603000 Manifold porting
M16 ports
Double Check Valve 290017 295358 295358 Bracket mounted
1350118 Wabco
Relay Valve 1425183 973 011 050 0 0481026027000
Wabco
1313871
Relay Valve 1411244
973 011 002 0 AC574AXY AC574AXY has integral silencer
973 011 010 0
371574 KX2552/2
Quick Release Valve 1422152 KX2552/3 KX2552/3 With internal by-pass
Wabco
Trailer Control Valve 1350096
973 009 010 0 AC597A For articulated vehicles
1382866
Tilt Drain Valve 1403463 KW2350/2 M22 thread
Wabco BR9152
ABS Modulator 1307040
475 195 004 0 II16278
Wabco
483425 (LH) With drum brakes
Wheel Speed Sensor 483426 (RH)
441 032 470 0
90° sensor, cable length 2.26 m
441 032 469 0
438423
Wheel Speed Sensor 1441274
0486000028000 Left side with drum brakes
Drive
Axle
438424
Wheel Speed Sensor 1441277
0486000029000 Right side with drum brakes
Wabco
483425 (LH) With drum brakes
Wheel Speed Sensor 483426 (RH)
441 032 470 0
90° sensor, cable length 2.26 m
441 032 469 0
1340231 Norgren-Herion
ASR Solenoid Valve 1421322 T.61.01.003
Steering Angle
Sensor 1427269 0486021003000 0486021003N00
(ESP)
Air Suspension
483114
Electronic Control 489555
0504004109000 0504004109000
Unit
Air Suspension
Control Module
481830 0501100027000 0501100040100 Rear axle
Air Suspension
Solenoid Valve
481832 0501100032000 0501100038100 Load transfer control
Kongsberg
Clutch Servo 1367453
(Servomaster) 1421186
KA625359 629683AM
KA627692
Wabco
Exhaust Brake 1376474
421 411 312 0
Cylinder 1400769
421 411 314 0
Wabco
Throttle Control 1336634 421 442 005 0
Cylinder 421 442 008 0
Wabco
Spring Brake 1372913 Spring Portion K2B0014X50
(Type 24/20) 1446053
925 431 402 0 K2B0514X50 Diaphragm 234100K
925 431 422 0
Rear
Axle Wabco
Spring Brake 1372914 Spring Portion K2B0014X50
with
(Type 24/30) 1446054
925 431 403 0 K2B0514X50 Diaphragm 234100K
Drum 925 431 423 0
Brakes
Wabco
Spring Brake 1369994
925 431 410 0 Diaphragm 234100K
(Type 24/30HF) 1446052
925 431 490 0
Wabco
Spring Brake 1313829 Spring Portion K2B0004X50
(Type 20/24) 1446037
925 430 006 0 K2B0504X50 Diaphragm 234099K
925 430 036 0
Left side
Manual Slack 1342543
Adjuster 1448120
1189483 1189483 65 mm offset, 165 mm hole
centre
Front
Axle
Right side
Manual Slack 1342544
Adjuster 1448121
1189484 1189484 65 mm offset, 165 mm hole
centre
Left side
Manual Slack
Adjuster
1448115 267026 267026 25 mm offset plus crank,
165 mm hole centre
Rear
Axle
Right side
Manual Slack
Adjuster
1448114 267027 267027 25 mm offset plus crank,
165 mm hole centre
Left side
Manual Slack 1342543
Adjuster 1448120
1189483 1189483 65 mm offset, 165 mm hole
centre
Tag
Axle
Right side
Manual Slack 1342544
Adjuster 1448121
1189484 1189484 65 mm offset, 165 mm hole
centre
Left side
Automatic Slack Haldex
Adjuster
1358635
79443 KB2740 65 mm offset, 165 mm hole
centre
Front
Axle
Right side
Automatic Slack Haldex
Adjuster
1358634
79442 KB2735 65 mm offset, 165 mm hole
centre
Left side
Automatic Slack Haldex
Adjuster
1112833
72660 KB2220 25 mm offset, 165 mm hole
centre
Rear
Axle
Right side
Automatic Slack Haldex
Adjuster
1112834
72661 KB2260 25 mm offset, 165 mm hole
centre
Left side
Automatic Slack Haldex
Adjuster
1358635
79443 KB2740 65 mm offset, 165 mm hole
centre
Tag
Axle
Right side
Automatic Slack Haldex
Adjuster
1358634
79442 KB2735 65 mm offset, 165 mm hole
centre
e y !
o n
r m i n e
f o n u
l u e g e t
V a a a r
b e e p
t' l l m s
a e
Th r - B r
o r
K n
NOTE: X00 and X50 suffixes refer to Exchange
156 Products which may be Remanufactured.
SCANIA 4 Series Bus
Bodied by East Lancs/Darwen (Esteem, Olympus and OmniDekka), 4x2&6x2
Irizar (Century), Plaxton (Derwent), Scania (Omnicity, Omnilink and
Omnitown) and Wrightbus (Axcess and Solar) Mechanical & Air Suspension
Front
Axle
with
Brake Chamber 1420134
BS3540 BS3509 From Chassis 1832704
Disc (Type 24) II37474 II30618 Diaphragm C72337
Brakes
BS2503
Brake Chamber 1427479
BS2503 K006490N00 Diaphragm C72337
(Type 24) II38475F or BS3509
II30618
BS2503
Brake Chamber 1851934
BS2503 K006490N00
(Type 24 OBC) K006490 or BS3509
II30618
Rear
Axle
with
Spring Brake 1427480
BS8500 BS8500 On Axial Air Disc Brakes
Disc (Type 24/30) II38470F II38470F000 Diaphragm C72337
Brakes
Front
Axle
Brake Disc 1402272 K000810
Rear ZF axle
Axle
Brake Disc II371910061 ZF Part No. 0501 316 953
Tag
Axle
160
VOLVO B6 & B6LE
Bodied by Alexander (ALX200 and Dash), East Lancs/Darwen (EL2000, Flyte and Spryte), 4x2
Marshall (C33), Northern Counties (Paladin), Plaxton (Pointer) and Wrightbus (Crusader)
Air Suspension
B6LE
Air Compressor 3194908
LP4989 LK4921 3 bolt flange mounted
(2W600R) II38142F K001268000 Replaced by 70303446
B6LE
Air Compressor 70303446
LP4996 LK4921 3 bolt flange mounted
(2W600R) II38845F K001268000 Replaced by 70305892
B6LE
Air Compressor 70305892
LK4921 LK4921 3 bolt flange mounted
(2W600R) II39080F K001268000 Replaced by 70330004
B6LE
Air Compressor 70330004
LK4921 LK4921 3 bolt flange mounted
(2W600R) K000233 K001268000 Replaced by 70330094
Governor Valve
(D2)
3126287 267014 1189395000 8.5 bar cut-out
Governor Valve
(D2)
3944255 1189394 1189394000 8.1 bar cut-out
Haldex
Air Dryer 6795914
71239
Up to Chassis 5556
Air Dryer
9957299 Haldex LA8226 8.5 bar cut-out
3194896 87296 II30180-B
M22 ports
Single Check Valve 1609497 KW4648/1 KW4648/1 By Air Dryer
Replaced by 1629727
M22 ports
Single Check Valve 1629727 KW4455/1 By Air Dryer
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Double Check Valve 9522564
434 208 035 0
295358 M16 ports, bracket mounted
Double Check Valve 1505044 295358 295358 M16 ports, bracket mounted
On rear axle
Quick Release Valve 1588769 KX2196/1 KX2196/1 Replaced by 9518619
Wabco
Quick Release Valve 3173152
973 500 047 0
KX1294/1 Up to Chassis 5994
Wabco
Quick Release Valve 9518619
973 500 039 0
KX2000/1 From Chassis 5995
Volvo only
Pressure Sensor 1594236
Replaced by 3987498
Up To Chassis 5556
Pressure Relief 13 bar, M16 thread
(Safety) Valve
1622432 KX1729/5 KX1729/5 Note: LA6710 and LA6711 Air
Dryers have an Internal Pressure
Relief Valve
For QRV
M22 thread
Exhaust Silencer 1197476 0484210001000 SIL68B Alternative Silencers:
0484210001000 or ZB3150-I78074
Up to Chassis 5971
Wabco M22 ports, Volvo electrical
ABS Modulator 1609241
472 195 002 0 connector
Replaced by 9520836
ABS Electronic
Wabco
Control Unit 3943981
446 004 085 0
(Type C3 - ABS & ASR)
Norgren-Herion
Solenoid Valve 3962640
9042006374302400
For engine stop control
Kongsberg
Clutch Servo 1655639
KA622080 626392AM
Up to Chassis 1651
Air Dryer 3194899
Haldex LA8286 12.0 bar cut-out
(Single Cartridge) 87297 II39752F00 Replaced by 70313308
Up to Chassis 1764
Air Dryer 3197854 Haldex LA8286 12.0 bar cut-out
(Single Cartridge) 20392573 78990 II39752F00 Replaced by 70313308
Haldex
Air Dryer 70313308 89292
LA8286 Up to Chassis 103362
(Single Cartridge) 90548 II39752F00 12.5 bar cut-out
Haldex
Condenser 9519475
92695
B7L
Haldex
Condenser 20518595
92793
M22 Ports
In Four Circuit Protection
Single Check Valve 1626982 KW4455/1 Valve and supply to front Air
Suspension Control Module
M22 Ports
Single Check Valve 1629727 KW4455/1 External charging circuit
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Dual Foot Valve 70313349
461 318 608 0
Replaced by 70313310
Wabco
Dual Foot Valve 70313310
461 318 604 0
From Chassis 1697
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Wabco
Quick Release Valve 9518619 973 500 039 0 KX2000/1 All ports M22
973 500 044 0
Pressure Limiting
Valve
1606720 0481009040000 0481009047000 7.5 bar, M22 ports
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
Wabco
Wheel Speed Sensor 20528660
441 032 956 0
Drive axle, left side
Wabco
Wheel Speed Sensor 20528661
441 032 957 0
Drive axle, right side
ABS Electronic
Control Unit 8141342
Wabco
4 x 2, 4 channel system
(Type C2, ABS & 446 004 054 0
ASR)
ABS Electronic
Control Unit 8141345
Wabco
Artic, 6 channel system
(Type C2, ABS & 446 003 054 0
ASR)
Up to Chassis 103522
EBS Electronic
Replacement ECU must be
Control Unit 3198461 0486106028000
programmed before use
(EBS 2.3) Volvo only
4x2
EBS Electronic 20540723
Replacement ECU must be
Control Unit 20555374 0486106063000
programmed before use
(EBS5) 20589475
Volvo only
Artic
EBS Electronic 20537336
Replacement ECU must be
Control Unit 70377449 0486106068000
programmed before use
(EBS5) 70377486
Replaced by 20589476
Artic
EBS Electronic
Replacement ECU must be
Control Unit 20589476 0486106064000
programmed before use
(EBS5) Volvo only
Independent suspension up to
Brake Chamber Chassis 780
(Type 20HE)
3112670 1186883-08 1186883-08 On Meritor Disc Brake
Diaphragm 20LS
Front
Axle Independent suspension from
Brake Chamber Wabco Chassis 781
with
(Type 24)
70306611
423 106 202 0
1186701-01 On Meritor Disc Brake
Disc
Diaphragm 234100K
Brakes
Non-independent suspension
Brake Chamber 70330019
Wabco BS2504 On Meritor Disc Brake
(Type 24) 423 506 120 0 K002556 15 mm push rod protrusion
Diaphragm 234100K
Rear
Axle - Spring Brake With Meritor Disc Brakes
Wabco
Disc 20535924 20 mm push rod protrusion,
(Type 24/24) 925 461 154 0
stroke 75 mm
Brakes
Artic
Centre With Meritor Disc Brakes
Axle - Spring Brake 20535924
Wabco
20 mm push rod protrusion,
Disc (Type 24/24) 925 461 154 0
stroke 75 mm
Brakes
Left side
Automatic Slack Haldex
Adjuster
3193400
79275
KB3910 50 mm offset, 165 mm hole
centre
Rear
Axle
Right side
Automatic Slack Haldex
Adjuster
3193401
79276
KB3915 50 mm offset, 165 mm hole
centre
Left side
Automatic Slack 3193402
Haldex
45 mm offset, 145 mm hole
Adjuster 79713
centre
Artic
Centre
Axle
Right side
Automatic Slack 3193403
Haldex
45 mm offset, 145 mm hole
Adjuster 79714
centre
9957385
70301332 Meritor Left side, Independent
Air Disc Brake 70306886
LRG592 Suspension
70311512
70330022
9957386
70301333 Meritor Right side, Independent
Air Disc Brake 70306887
LRG593 Suspension
70311513
70330023
8550611
3093919 Meritor
Disc Brake Pad Set 85105485 MDP5061
Independent Suspension
20825594
Front
Axle
Air Disc Brake 20424072 Meritor
Left side, Non-independent
(Axial) Suspension
Meritor
Disc Brake Pad Set 20918891
MDP5057
Non-independent Suspension
Rear
and
Artic 85107768 Meritor
Disc Brake Pad Set 20976509 MDP5099
Centre
Axles
Rear
and
Artic Brake Disc 20564467
Centre
Axles
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Dual Foot Valve 3028741
461 317 006 0
Without retarder control
Wabco
Dual Foot Valve 70313310
461 318 604 0
With D7C engine
1589620 Wabco
Dual Foot Valve 6886123 461 315 041 0
With pendant pedal
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Wabco
Quick Release Valve 9518619 973 500 039 0 KX2000/1 All ports M22
973 500 044 0
0.8 bar
Stop Lamp Switch 20382514 Gearbox to neutral system with
multiplex wiring
Pressure Relief
(Safety) Valve
1622432 KX1729/5 KX1729/5 13 bar, M16 thread
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
ABS Electronic
Wabco
Control Unit 3197782
446 004 423 0
(ABS + ASR)
ABS Electronic
Wabco
Control Unit 3198879
446 004 305 0
Multiplex wiring generation 2
(Type D, ABS only)
4x2
EBS Electronic 20540723
Replacement ECU must be
Control Unit 20555374 0486106063000
programmed before use
(EBS5) 20589475
Volvo only
6x2
EBS Electronic 20537336
Replacement ECU must be
Control Unit 70377449 0486106068000
programmed before use
(EBS5) 70377486
Replaced by 20589476
6x2
EBS Electronic
Replacement ECU must be
Control Unit 20589476 0486106064000
programmed before use
(EBS5) Volvo only
Air Suspension
Control Module
3944717 0501100014000 0501100029000 Rear axle
Air Suspension
20503188 Replacement ECU must be
Electronic Control 20569213 programming before use
Unit
Norgren-Herion
Solenoid Valve 1078316
9041025374602400
For door system.
Auxiliary Charge 3113946 K019270 Forster & Hales Part No. CX6
Coupling
Kongsberg
Clutch Servo 1673067
KA622050 626392AM
1521371
Kongsberg
Clutch Servo 1668501
KA626639 626639AM With G8 gearbox
1671953
Front
Axle From Chassis 5643
Brake Chamber
with
(Type 30)
20504557 1186702-01 1186702-01 On Volvo 8" S-cam Brake
Drum Diaphragm 234101K
Brakes
Front
Axle
with Brake Chamber 20512414
Wabco BS3570 On Meritor Disc Brake
Disc (Type 27) 423 509 020 0 K002162 15 mm push rod protrusion
Brakes
Trailing
Axle - Brake Chamber
Drum (Type 16)
3028017 1185199 1185199 Diaphragm 234189K
Brakes
Haldex
Automatic Slack
Adjuster
1196322 72167 KB2295 152 mm hole centre
72726
Front
Axle
Haldex
Automatic Slack
Adjuster
1196321 72166 KB2275 140 mm hole centre
72678
Meritor
Disc Brake Pad Set 20918891
MDP5057
Front
and
Rear
Axles
Air Disc Brake 21024417 Meritor Left side
Up to Chassis 1651
Air Dryer 3194899
Haldex LA8286 12.0 bar cut-out
87297 II39752F00 Replaced by 70313308
Air Dryer
3197854 Haldex LA8286 12.0 bar cut-out
20392573 78990 II39752F00 Replaced by 70313308
Haldex
Air Dryer 70313308 89292
LA8286 Up to Chassis 103362
90548 II39752F00 12.5 bar cut-out
Haldex
Condenser 9519475
92695
Haldex
Condenser 20518595
92793
M22 ports
Single Check Valve 1629727 KW4455/1 External charging circuit
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Dual Foot Valve 70313349
461 318 608 0
Replaced by 70313310
Wabco
Dual Foot Valve 70313310
461 318 604 0
From Chassis 1697
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Wabco
Quick Release Valve 9518619 973 500 039 0 KX2000/1 All ports M22
973 500 044 0
Pressure Limiting
Valve
1606720 0481009040000 0481009047000 7.5 bar, M22 ports
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
Wabco
Wheel Speed Sensor 20528660
441 032 956 0
Drive axle, left side
Wabco
Wheel Speed Sensor 20528661
441 032 957 0
Drive axle, right side
ABS Electronic
Wabco
Control Unit 3943980
884 903 944 0
Up to Chassis 202
(ABS + ASR)
ABS Electronic
Wabco
Control Unit 3197782
446 004 423 0
From Chassis 203
(ABS + ASR)
ABS Electronic
Control Unit 8141342
Wabco
4 x 2, 4 channel system
(Type C2, ABS + 446 004 054 0
ASR)
Air Suspension
Control Module
3944717 0501100014000 0501100029000 Rear axle
Air Suspension
Replacement ECU must be
Electronic Control 3118073 0540004105000 0504004105000 programmed before use
Unit
Auxiliary Charge 3113946 K019270 Forster & Hales Part No. CX6
Coupling
Independent suspension up to
Brake Chamber Chassis 1619
(Type 20HE)
3112670 1186883-08 1186883-08 On Meritor Disc Brake
Diaphragm 20LS
Front
Axle Independent suspension from
Brake Chamber Wabco Chassis 1620
with
(Type 24)
70306611
423 106 202 0
1186701-01 On Meritor Disc Brake
Disc
Diaphragm 234100K
Brakes
Non-independent suspension
Brake Chamber 70330019
Wabco BS2504 On Meritor Disc Brake
(Type 24) 423 506 120 0 K002556 15 mm Push Rod protrusion
Diaphragm 234100K
Rear
Axle - Spring Brake With Meritor Disc Brakes
Wabco
20535924 20 mm Push Rod protrusion,
Disc (Type 24/24) 925 461 154 0
stroke 75 mm
Brakes
Left side
Automatic Slack Haldex
Adjuster
3193400
79275
KB3910 50 mm offset, 165 mm hole
centre
Front
Axle
Right side
Automatic Slack Haldex
Adjuster
3193401
79276
KB3915 50 mm offset, 165 mm hole
centre
Left side
Automatic Slack Haldex
Adjuster
3193400
79275
KB3910 50 mm offset, 165 mm hole
centre
Rear
Axle
Right side
Automatic Slack Haldex
Adjuster
3193401
79276
KB3915 50 mm offset, 165 mm hole
centre
70301332
70306886 Meritor Left side, Independent
Air Disc Brake 70311512 LRG592 Suspension
70330022
70301333
70306887 Meritor Right side, Independent
Air Disc Brake 70311513 LRG593 Suspension
70330023
8550611
Meritor
Disc Brake Pad Set 3093919
MDP5061
Independent Suspension
20825594
Front
Axle
Air Disc Brake 20424072 Meritor
Left side, Non-independent
(Axial) Suspension
Meritor
Disc Brake Pad Set 20918891
MDP5057
Non-independent Suspension
85107768 Meritor
Disc Brake Pad Set 20976509 MDP5099
Front
Axle
Rear
Axle Brake Disc 20564467
Haldex
Condenser 20745320
92939
Wabco
Single Check Valve 1629982
434 012 003 0 KW4455/1 M22 ports
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Air Suspension
Pressure Limiting
Valve
1606720 0481009040000 0481009047000 7.5 bar, M22 ports
Pressure Relief
(Safety) Valve
1622431 KX1729/2 KX1729/2 10 bar, M16 thread
Pressure Relief
(Safety) Valve
1622432 KX1729/5 KX1729/5 13 bar, M16 thread
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
4x2
EBS Electronic 20540723
Replacement ECU must be
Control Unit 20555374 0486106063000
programmed before use
(EBS5) 20589475
Volvo only
Artic
EBS Electronic 20537336
Replacement ECU must be
Control Unit 70377449 0486106068000
programmed before use
(EBS5) 70377486
Replaced by 20589476
Artic
EBS Electronic
Replacement ECU must be
Control Unit 20589476 0486106064000
programmed before use
(EBS5) Volvo only
Air Suspension
Control Module
3944717 0501100014000 0501100029000 Rear and B9LA Artic trailing axle
Air Suspension
Replacement ECU must be
Electronic Control 20569213
programmed before use
Unit
Air Suspension
Rear
& Artic Spring Brake Wabco On Meritor Disc Brakes
20535924 20 mm Push Rod protrusion,
Trailing (Type 24/24) 925 461 154 0 stroke 75 mm
Axles
Meritor
Disc Brake Pad Set 20918891
MDP5057
Rear
& Artic Air Disc Brake Meritor
20535920 Right side
Trailing (Radial) LRG669
Axles
Meritor
Disc Brake Pad Set 20976509
MDP5099
Artic
Trailing Brake Disc 20564467
Axle
r t s
p a
s e
r e m l i fe
r - B n g
o r l o
K n f o r
i n e e d
n u e r
G e i n e
n g
- e
200
VOLVO B9TL
Bodied by Alexander Dennis (Enviro 400), East Lancs/Darwen (Nordic, 4 x 2 double deck
Olympus, Visionaire and Vyking) and Wrightbus (Eclipse)
Air Suspension
Haldex
Air Dryer 70313308 89292
LA8286 12.0 bar cut-out
90548 II39752F00
Haldex
Condenser 20518595
92793
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Dual Foot Valve 1698694
461 315 479 0
Base Foot Valve for 70313310
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Wabco
Quick Release Valve 9518619 973 500 039 0 KX2000/1
973 500 044 0
Pressure Relief
(Safety) Valve
1622432 KX1729/5 KX1729/5 13 bar, M16 thread
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
ABS Electronic
Wabco
Control Unit 3195235
446 003 420 0
(Type D, ABS only)
Air Suspension
Control Module
3944717 0501100014000 0501100029000 Drive axle
Air Suspension
Replacement ECU must be
Electronic Control 3118073 0504004105000 0504004105000 programmed before use
Unit
Norgren-Herion
Solenoid Valve 1078316
9041025374602400
For door system
Auxiliary Charge 3113946 K019270 Forster & Hales Part No. CX6
Coupling
3093919
Meritor
Disc Brake Pad Set 85105485
MDP5061
20825594
Front
Axle
Vehicles with EBS, left side
Air Disc Brake 20424072 Meritor
Later Meritor Disc Brake
Meritor
Disc Brake Pad Set 20918891
MDP5057
Left side
Automatic Slack Haldex
Adjuster
3193400
79275
KB3910 50 mm offset, 165 mm hole
centre
Rear
Axle
Right side
Automatic Slack Haldex
Adjuster
3193401
79276
KB3915 50 mm offset, 165 mm hole
centre
Haldex
Trailing Automatic Slack
Axle Adjuster
1196321 72166 KB2275 140 mm hole centre
72678
208
VOLVO B10B & B10BLE
Bodied by Alexander (ALX300 and Strider), Northern Counties (Paladin), Plaxton 4x2
(Prestige and Verde) and Wrightbus (Endurance, Liberator and Renown)
Mechanical & Air Suspension
Air Dryer
(AD2)
1190405 267113 267121X50
9517283
Air Dryer 9957313
Haldex LA8286 12.0 bar cut-out
(Single Cartridge) 3194899
87297 II39752F00 Replaced by 71313308
Haldex
9519475
Condenser 20518595
92695 Replaced by 20745320
92793
Haldex
Condenser 20745320
92939
Wabco
Single Check Valve 1626982
434 012 003 0 KW4455/1 M22 ports
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Dual Foot Valve 3028741
461 317 006 0
Without retarder control
Wabco
Dual Foot Valve 70313310
461 318 604 0
Double Check Valve 1505044 295358 295358 M16 ports, bracket mounted
Wabco
Quick Release Valve 3173152
973 500 047 0 KX1294/1 Front axle
Quick Release Valve 1588769 KX2196/1 KX2196/1 Rear axle up to Chassis 1833
Wabco
From Chassis 1834
Quick Release Valve 9518619 973 500 039 0 KX2000/1 M22 Voss ports
973 500 044 0
Pressure Limiting
Valve
1606720 0481009040000 0481009047000 7.5 bar, M22 ports
Volvo only
Low Pressure Switch 1594236
Replaced by 3987498
Air suspension
Pressure Switch 3034073
Replaced by 20382504
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
Up to Chassis 2097
Wabco M22 ports, Volvo electrical
ABS Modulator 1609241
472 195 002 0 connector
Replaced by 9520836
Wabco
Wheel Speed Sensor 20490824
441 032 964 2
Replaced by 20490830
Wabco
Wheel Speed Sensor 20490830
441 032 965 0
ABS Electronic
Wabco
Control Unit 3944519
446 004 054 0
Replaced by 3943981
(Type C2 - ABS & ASR)
ABS Electronic
Wabco
Control Unit 3943981
446 004 085 0
(Type C3 - ABS & ASR)
ABS Electronic
Wabco
Control Unit 3962455
446 004 079 0
(Type C3 - ABS & ASR)
Up to Chassis 3890.
Air Suspension Level When replaced by
Sensor
9517678 0504002106000 0504002112100 0504002112100 Volvo plug
3177294 is required.
Air Suspension
Replacement ECU must be
Electronic Control 3118073 0540004105000 0504004105000 programmed before use
Unit
Kongsberg
Clutch Servo 1655435
KA622090 626639AM With G7 gearbox
1521371
Kongsberg
Clutch Servo 1668501
KA626639 626639AM With G8 gearbox
1671953
MGM
Brake Chamber B10B with S-cam Brakes
(Type 30)
3035900 1430202 1186702-01 Diaphragm 234101K
1430223
MGM
Brake Chamber B10B with Z-cam Brakes
Front (Type 30)
3036656 1430202 1186702-01 Diaphragm 234101K
Axle 1430279
with
Drum
Brakes Brake Chamber MGM
B10BLE with S-cam Brakes
(Type 24)
9518358 1427202 1186701-01 Diaphragm 234100K
1427218
Left side
Automatic Slack Haldex
Adjuster
1197965
72784
KB3140 15 mm offset, 165 mm hole
centre
Rear
Axle
Right side
Automatic Slack Haldex
Adjuster
1197966
72785
KB3135 15 mm offset, 165 mm hole
centre
Front
Axle
Left side from Chassis 2824 to
Air Disc Brake 9524029 Meritor
3719
9957385
70301332 Meritor
Air Disc Brake 70306886
LRG592
Left side from Chassis 3720
70311512
70330022
9957386
70301333 Meritor
Air Disc Brake 70306887
LRG593
Right side from Chassis 3720
70311513
Front 70330023
Axle
(contd)
3093919
Meritor
Disc Brake Pad Set 85105485
MDP5061
20825594
n ly
t o
r u s r t s
e t p a
s a k s e
y ' s r e m
f e t - B
s a o r r
r n
Fo e K
u i n
n
ge
NOTE: X00 and X50 suffixes refer to Exchange
Products which may be Remanufactured. 219
u r
yo
i se
r o m i n e
m p n u
c o g e t s
’t fi t a r
o n e – p
D i c l s e
h e m
ve r - B r
o r
Kn
220
VOLVO B10L & B10LA
Bodied by Alexander (ALX300 and Ultra), Jonckheere (Mistral), Säffle 4 x 2 & Artic
and Wrightbus (Eclipse Fusion, Liberator and Renown)
Air Suspension
LP4934
Air Compressor 3037346 II15992
LP4934 3 bolt flange mounted with ESS
(2W600R) II30895 II30895X00
LK4922
70305893 3 bolt flange mounted with
Air Compressor 70330005
II39141F
through drive.
(2W600R) 70330096
K000234
Volvo only
K002030
LK4919
70305890
Air Compressor 70330002
II39078F LK4919 3 bolt offset flange mounted
(2W600R) 70330090
K000231 K002029X00 with through drive.
K002029
LP4993
Air Compressor 70303443
II38779F
LK4918 3 bolt offset flange mounted
(2W600R) 70305889
II39077F K001267X00 Replaced by 70330001
Wabco
Single Check Valve 1571924
434 023 000 0 KW4648/1 M22 ports
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
222
NOTE: X00 and X50 suffixes refer to Exchange
Products which may be Remanufactured.
VOLVO B10L & B10 LA
Bodied by Alexander (ALX300 and Ultra), Jonckheere (Mistral), Säffle 4 x 2 & Artic
and Wrightbus (Eclipse Fusion, Liberator and Renown)
Air Suspension
Up to Chassis 2007
Wabco
Dual Foot Valve 9519903
461 318 023 0
With microswitch retarder
control for Voith gearbox
Up to Chassis 2007
Wabco
Dual Foot Valve 3118798
461 324 042 0
With pneumatic retarder control
for ZF HP500 gearbox
Wabco
Dual Foot Valve 70313310
461 318 604 0
Double Check Valve 1505044 295358 295358 M16 ports, bracket mounted
Wabco
From Chassis 1834
Quick Release Valve 9518619 973 500 039 0 KX2000/1 M22 Voss ports
973 500 044 0
Pressure Limiting
Valve
1606720 0481009040000 0481009047000 7.5 bar, M22 ports
Pressure Relief
(Safety) Valve
1622431 KX1729/2 KX1729/2 10 bar, M16 thread
Pressure Relief
(Safety) Valve
1622432 KX1729/5 KX1729/5 13 bar, M16 thread
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
224
NOTE: X00 and X50 suffixes refer to Exchange
Products which may be Remanufactured.
VOLVO B10L & B10 LA
Bodied by Alexander (ALX300 and Ultra), Jonckheere (Mistral), Säffle 4 x 2 & Artic
and Wrightbus (Eclipse Fusion, Liberator and Renown)
Air Suspension
Up to Chassis 2097
Wabco M22 ports, Volvo electrical
ABS Modulator 1609241
472 195 002 0 connector
Replaced by 9520836
ABS Electronic
8141342 Wabco B10L
Control Unit 3944519 446 004 054 0 Replaced by 3943981
(Type C2 - ABS & ASR)
ABS Electronic
Wabco
Control Unit 3943981
446 004 085 0
B10L
(Type C3 - ABS & ASR)
ABS Electronic
Wabco
Control Unit 3962455
446 004 079 0
B10L
(Type C3 - ABS & ASR)
ABS Electronic
Wabco B10LA Artic
Control Unit 3930452
446 004 064 0 6S6M system
(Type C3 - ABS & ASR)
Up to Chassis 1227.
Air Suspension Level When replaced by
Sensor
9517678 0504002106000 0504002112100 0504002112100 Volvo plug
3177294 is required.
Air Suspension
Replacement ECU must be
Electronic Control 3118073 0540004105000 0504004105000 programmed before use
Unit
Norgren-Herion
Solenoid Valve 1078316
9041025374602400
Door brake system
226
NOTE: X00 and X50 suffixes refer to Exchange
Products which may be Remanufactured.
VOLVO B10L & B10 LA
Bodied by Alexander (ALX300 and Ultra), Jonckheere (Mistral), Säffle 4 x 2 & Artic
and Wrightbus (Eclipse Fusion, Liberator and Renown)
Air Suspension
Drive
Axle
with Spring Brake 20499852
Wabco Rear axle with S-cam Brakes
Drum (Type 30/30HF) 925 492 103 0 M22 ports, M16 push rod
Brakes
70301333
70306887 Meritor
Air Disc Brake 70311513 LRG593
Right side from Chassis 1142
70330023
3093919
Meritor
Disc Brake Pad Set 85105485
MDP5061
20825594
Left side
Automatic Slack 3193402
Haldex
45 mm offset, 145 mm hole
Drive Adjuster 79713
centre
and
B10LA
Centre
Right side
Axles Automatic Slack Haldex
3193403 45 mm offset, 145 mm hole
Adjuster 79714
centre
228
NOTE: X00 and X50 suffixes refer to Exchange
Products which may be Remanufactured.
VOLVO B10M/MA Mk 1, 2, 3 & 4
See Notes on Chassis Nos. for different
Marks at the end of this section 4 x 2, Artic & City Bus (double deck)
Bodied by Alexander (PS and Q), Duple (300), East Lancs (Flyte), Jonckheere
(Deauville and Jubilee), Northern Counties (Paladin), Plaxton (Excalibur, Expression, Mechanical & Air Suspension
Paragon, Paramount and Premiere), Säffle and Van Hool (Alizee, Astral and Exeter)
Air Compressor
(2W440D)
3018546 KZ433/6 KZ433/6X50 Mk 1 & 2, 3 bolt flange mounted
LK4921
70305892
Air Compressor 70330004
II39080F LK4921 Mk 4, 3 bolt flange mounted
(2W600R) 70330094
K000233 K001268000
K001268
Alcohol Evaporator
Check Valve
1591676 KW1873/10 KW1873/10 Mk 1 & 2 without Air Dryer
Haldex
Air Dryer 70313308 89292
LA8286 12.5 bar cut-out
90548 II39752F00
Air Dryer
3194897 Haldex LA8227 Mk 4 special vehicles
70313302 87337 II30181-B 10.0 bar cut-out
Mk 2 vehicles
Charging Valve 366695
Wabco DR4340 4.5 bar, M22 ports
without Feedback 434 100 102 0 K000639 Replaced by 1590129
Wabco
Single Check Valve 1571924
434 023 000 0 KW4648/1 M22 ports
1585876
Single Check Valve 1629727
KW4455/1 KW4455/1 M22 ports
1626982 Wabco
Single Check Valve 1505049 434 012 003 0 KW4455/1 M22 ports
8120600 434 023 010 0
HB1143
Hand Control Valve
4822431
I61720
HB1143
9515443
I82171 I82171N00
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
MK 1 and Mk 2 vehicles
Wabco
Dual Foot Valve 1134518
461 310 562 0
With microswitch retarder
control for Voith gearbox
MK 1 and Mk 2 vehicles
Wabco
Dual Foot Valve 1193173
461 324 016 0
With pneumatic retarder control
for ZF gearbox
Mk 1, Mk 2, Mk 3 and Mk 4
vehicles up to Chassis 46957
Double Check Valve 1505044 295358 295358 and 60445, and City Bus
M16 ports, bracket mounted
Relay Valve
(R6)
1505036 295199 295199 MK 1 and Mk 2 vehicles
Mk 3 vehicles
Relay Valve 1197892 0481026021000 AC574AXY AC574AXY has integral silencer
Replaced by 1082666
Mk 3 vehicles
Wabco
Relay Valve 1082666
973 011 000 0 AC574AXY AC574AXY has integral silencer
Replaced by 3173824
6886834 Mk 4 vehicles
Relay Valve 3162118
0481026005000 0481026005000 Replaced by 3173150
Exhaust Check Valve 6865728 KX2016/1 KX2016/1 Fitted to QRV on City Bus
Pressure Limiting
Valve
1606720 0481009040000 0481009047000 7.5 bar, M22 ports
Mk 4 vehicles
Pressure Relief 1607454 18 bar, M16 thread
(Safety) Valve Volvo only
Wabco
1081328
Tilt Drain Valve 1581425
934 300 001 0 KW2350/2 M22 thread
934 300 033 0
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
Mk 3 vehicles
Wabco M22 ports, Volvo electrical
ABS Modulator 1609241
472 195 002 0 connector
Replaced by 9520836
Mk 3 and Mk 4 vehicles
Wabco
ABS Modulator 9520836
472 195 051 0
M22 ports, Volvo electrical
connector
Wabco
Wheel Speed Sensor 20490824
441 032 964 2
ABS Electronic
Wabco Mk 3 vehicles
Control Unit 1610913
446 004 011 0 Replaced by 3943981
(Type C1 - ABS & ASR)
ABS Electronic
3944519 Wabco Mk 3 vehicles and City Bus
Control Unit 8141342 446 004 054 0 Replaced by 3943981
(Type C2 - ABS & ASR)
ABS Electronic
Wabco
Control Unit 3943981
446 004 085 0
Mk 4 vehicles
(Type C3 - ABS & ASR)
ABS Electronic
Wabco
Control Unit 3962455
446 004 079 0
Mk 4 vehicles
(Type C3 - ABS & ASR)
ABS Electronic
Wabco Mk 4 B10MA vehicles
Control Unit 3930452
446 004 064 0 6S6M system
(Type C3 - ABS & ASR)
30 mm dia., 45 mm stroke
Actuating Cylinder 1136085 0482005015000 0482005015000 Air suspension lift facility
30 mm dia., 80 mm stroke
Actuating Cylinder 1194376 0482005018000 0482005018000 Air suspension lift facility
MK 4 vehicles up to Chassis
Air Suspension Level 48590 and 60725.
Sensor
9517678 0504002106000 0504002112100 When replaced by
0504002112100 Volvo plug
3177294 is required.
Kongsberg
Clutch Servo 1655639
KA622080 626392AM Replaced by 1673067
Kongsberg
Clutch Servo 1673067
KA622050 626392AM
Kongsberg
Clutch Servo 1655435
KA622090 626639AM With G7 gearbox
1521371
Kongsberg
Clutch Servo 1668501
KA626639 626639AM With G8 gearbox
1671953
Brake Chamber
295555 B10M Mk 1 and Mk 2 vehicles
(Type 24)
1194637 272098 + Yoke B10MA Mk 2 and Mk 3 vehicles
1185157 Diaphragm 234100K
Mk 3 vehicles up to Chassis
Front Brake Chamber
Axle (Type 30)
3027758 1185225 1186702-01 26793 and City Bus
Diaphragm 234101K
MGM Mk 1, Mk 2, Mk 3 and
Spring Brake Mk 4 vehicles and City Bus
(Type 30/30)
1608006 4130057 K2B1101X50 M16 ports, 5/8" UNF push rod
4131200 Diaphragm 234101K
B10M
Rear
Axle
Spring Brake Wabco Mk 1, Mk 2, Mk 3 and
20499852 Mk 4 vehicles and City Bus
(Type 30/30HF) 925 492 103 0 M22 ports, M16 push rod
MGM
Spring Brake M16 ports, 5/8" UNF push rod
(Type 30/30)
1608006 4130057 K2B1101X50 Diaphragm 234101K
4131200
Left side
Automatic Slack Haldex
Adjuster
1195461
72782
KB2280 15 mm offset, 145 mm hole
centre
B10MA
Centre
Axle
Right side
Automatic Slack Haldex
Adjuster
1195462
72783
KB2300 15 mm offset, 145 mm hole
centre
Haldex
Automatic Slack 8.0 tonne steering axle
Adjuster
1196321 72166 KB2275 140 mm hole centre
72678
NOTES
1. Chassis Designations:
2. References quoting “up to/from Chassis 4..... and 6.....” show the
vehicles built in the two locations.
! -
d o
i l l
t w i n e
e s n u
e b g e
t h s e
n ly r e m
O B t s
o r r a r
K n p
Haldex
Condenser 20518595
92793
Haldex
Condenser 20745320
92939
Charging Valve
with Limited 1598426
Wabco DR4260 6.2 bar, M22 ports
Feedback
434 100 222 0 K000634
Wabco
Single Check Valve 1571924
434 023 000 0 KW4648/1 M22 ports
Wabco
Single Check Valve 1629982
434 012 003 0 KW4455/1 M22 ports
6 x 2 trailing axle
3028396 M12(F)-M16(M) ports
Single Check Valve 70313312 Fitted to Air Suspension Control
Module
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Wabco
Quick Release Valve 9518619
973 500 039 0 KX2000/1 All ports M22
Pressure 1082318
Wabco DB2118 6 x 2 trailing axle
Proportioning Valve 473 301 002 0 I86156 Ratio 1.35:1
20382505
Pressure Switch 20382509
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
Wabco
Wheel Speed Sensor 70351557
441 032 110 0
6 x 2 front axle
Wabco
Wheel Speed Sensor 20390737
441 032 919 0
6 x 2 second and third axles
ABS Electronic
Wabco
Control Unit 3943980
446 004 423 0
(Type D - ABS only)
ABS Electronic
Wabco
Control Unit 3962455
446 004 079 0
(Type C3 - ABS & ASR)
4x2
EBS Electronic 20540723
Replacement ECU must be
Control Unit 20555374 0486106063000
programmed before use
(EBS5) 20589475
Volvo only
6 x 2 and Artic
EBS Electronic 20537336
Replacement ECU must be
Control Unit 70377449 0486106068000
programmed before use
(EBS5) 70377486
Replaced by 20589476
6 x 2 and Artic
EBS Electronic
Replacement ECU must be
Control Unit 20589476 0486106064000
programmed before use
(EBS5) Volvo only
Steering Angle
Sensor 3198466 0486021001000 0486021001N00
(ESP)
Air Suspension
Control Module
3944717 0501100014000 0501100029000 4 x 2, 6 x 2 and Artic drive axles
Air Suspension
3118073 Replacement ECU must be
Electronic Control 20503188 programmed before use
Unit
Kongsberg
Clutch Servo 8171721
KA627804 629277AM
Kongsberg
Clutch Servo 8171722
KA627805 628494AM
Left side
Brake Chamber 70369120
Wabco BS2504 On Meritor Disc Brake
(Type 24) 423 506 123 0 K002556 15 mm push rod protrusion
Diaphragm 234100K
Right side
Brake Chamber 70369119
Wabco BS2504 On Meritor Disc Brake
(Type 24) 423 506 124 0 K002556 15 mm push rod protrusion
Diaphragm 234100K
Front
Axle
Long wheelbase vehicles with
Brake Chamber 20512414
Wabco BS3570 non-independent suspension
(Type 27) 423 509 020 0 K002162 On Meritor Disc Brake
15 mm push rod protrusion
Left side
Spring Brake 3177336
Wabco On Meritor Disc Brakes
(Type 24/30) 925 461 471 0 15 mm push rod protrusion, with
quick release wind-off feature
Right side
Spring Brake 3177337
Wabco On Meritor Disc Brakes
(Type 24/30) 925 461 470 0 15 mm push rod protrusion, with
quick release wind-off feature
Drive
Axle Short wheelbase vehicles,
Spring Brake Wabco pre-EBS, left side
20527597 On Meritor Disc Brakes
(Type 24/30) 925 481 103 0 15 mm push rod protrusion, with
quick release wind-off feature
Up to Chassis 753
Brake Chamber 3177338
Wabco BS3532 On Meritor Disc Brake
(Type 24) 423 506 070 0 K002420 15 mm push rod protrusion
Diaphragm 234100K
Up to Chassis 753
Brake Chamber 3177339
Wabco BS2504 On Meritor Disc Brake
(Type 24) 423 506 071 0 K002556 15 mm push rod protrusion
6x2 Diaphragm 234100K
Trailing
Axle
On Meritor Disc Brake
Brake Chamber 70330019
Wabco BS2504 15 mm push rod protrusion
(Type 24) 423 506 120 0 K002556 Diaphragm 234100K
85105485 Meritor
Disc Brake Pad Set 20825594 MDP5061
Front
and Air Disc Brake 20424074 Meritor Left side from Chassis 202
Drive (Axial)
Axles
Air Disc Brake 20424075 Meritor Right side from Chassis 202
(Axial)
6x2
Air Disc Brake 20424073 Meritor Right side
Trailing
Axle
(Axial)
Meritor
Disc Brake Pad Set 20918891
5057
6x2
Trailing Air Disc Brake
20424075 Meritor Right side
Axle (Axial)
(contd)
Artic
Trailing
Air Disc Brake 20535921
Meritor
Right side
Axle
(Radial) LRG670
Meritor
Disc Brake Pad Set 20976509
MDP5099
Air Dryer
3194898 Haldex LA8219 11.0 bar cut-out
70313304 87282 II19483N00 Replaced by 70313304
Haldex
Condenser 20745320
92939
Wabco
Single Check Valve 1571924
434 023 000 0 KW4648/1 M22 ports
6 x 2 trailing axle
3028396 M12(F)-M16(M) ports
Single Check Valve 70313312 Fitted to Air Suspension Control
Module
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Dual Foot Valve 70313310
461 318 604 0
With D7C engine
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Wabco
Quick Release Valve 9518619
973 500 039 0 KX2000/1 All ports M22
Pressure Limiting
Valve
1606720 0481009040000 0481009047000 7.5 bar, M22 ports
Pressure 1082318
Wabco DB2118 6 x 2 trailing axle
Proportioning Valve 473 301 002 0 I86156 Ratio 1.35:1
20382505
Pressure Switch 20382509
20528336
Pressure Sensor 20829689
For cab pressure gauges
Pressure Relief
(Safety) Valve
1622431 KX1729/2 KX1729/2 10 bar, M16 thread
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
ABS Electronic
3197782 Wabco
Control Unit 3943980 446 004 423 0
4S4M system
(Type D - ABS only)
ABS Electronic
Wabco
Control Unit 3962455
446 004 079 0
4S4M system
(Type C3 - ABS & ASR)
4x2
EBS Electronic 20540723
Replacement ECU must be
Control Unit 20555374 0486106063000
programmed before use
(EBS5) 20589475
Volvo only
6 x 2 and Artic
EBS Electronic 20537336
Replacement ECU must be
Control Unit 70377449 0486106068000
programmed before use
(EBS5) 70377486
Replaced by 20589476
6 x 2 and Artic
EBS Electronic
Replacement ECU must be
Control Unit 20589476 0486106064000
programmed before use
(EBS5) Volvo only
Steering Angle
Sensor 3198466 0486021001000 0486021001N00
(ESP)
Air Suspension
Control Module
3944717 0501100014000 0501100029000 4 x 2, 6 x 2 and Artic drive axles
Air Suspension
3118073 Replacement ECU must be
Electronic Control 20503188 programmed before use
Unit
Norgren-Herion
Solenoid Valve 1078316
9041025374602400
Door brake system
Norgren-Herion
Solenoid Valve 1610566
9042006374302400
For engine stop control
Kongsberg
Clutch Servo 1655435
KA622090 626639AM With G7 gearbox
Kongsberg
Clutch Servo 1671953
KA626639 626639AM With G8 gearbox
Kongsberg
Clutch Servo 1655639
KA622080 626392AM Replaced by 1673067
Kongsberg
Clutch Servo 1673067
KA622050 626392AM
Kongsberg
Clutch Servo 3192126
KA627208 629276AM Replaced by 8171721
Kongsberg
Clutch Servo 8171721
KA627804 629277AM
Kongsberg
Clutch Servo 3192977
KA627303 628494AM Replaced by 8171722
Kongsberg
Clutch Servo 8171722
KA627805 628494AM
Left side
Spring Brake 3177336
Wabco On Meritor Disc Brakes
Rear (Type 24/30) 925 461 471 0 15 mm push rod protrusion, with
Axle quick release wind-off feature
with
Disc Right side
Brakes Spring Brake Wabco On Meritor Disc Brakes
3177337
(Type 24/30) 925 461 470 0 15 mm push rod protrusion, with
quick release wind-off feature
Haldex
Front Automatic Slack
Axle Adjuster
1196322 72167 KB2295 152 mm hole centre
72726
With non-independent
Air Disc Brake 20424072 Meritor suspension
Left side
With non-independent
Air Disc Brake 20424073 Meritor suspension
Right side
Meritor
Disc Brake Pad Set 20918891
MDP5057
Drive
Air Disc Brake 20424073 Meritor Right side
Axle
Meritor
Disc Brake Pad Set 20918891
MDP5057
Meritor
Disc Brake Pad Set 20918891
MDP5057
6x2
Trailing
Axle
Air Disc Brake 21024417 Meritor Left side
Meritor
Disc Brake Pad Set 20918891
MDP5057
Artic
Trailing
Axle
(Contd)
10.5 tonne axle
Air Disc Brake 21024417 Meritor
Left side
266
VOLVO Olympian
Bodied by Alexander (Royale), East Lancs/Darwen (Pyoneer) 4x2
and Northern Counties (Palatine)
Air Suspension
Cummins
Air Compressor 3067469
On Cummins engine
Governor Valve
(D2)
3126287 1189395 1189395000 8.5 bar cut-out, M10 ports
Air Dryer
(AD2)
1599631 267113 267121X50
Single Circuit
Protection Valve
3113259 KW4081/1 KW4081/1
Wabco
Single Check Valve 1571924
434 023 000 0 KW4648/1 M22 ports
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Double Check Valve 1505044 295358 295358 M16 ports, bracket mounted
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Up to Chassis 26576
Quick Release Valve 1588769 KX2196/1 KX2196/1 Supply port M22, delivery and
exhaust ports M16
Wabco
From Chassis 26577
Quick Release Valve 9518619 973 500 039 0 KX2000/1 M22 Voss ports
973 500 044 0
1594236
Low Pressure Switch 3987498
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
Wabco
Wheel Speed Sensor 20490824
441 032 964 2
ABS Electronic
Control Unit 3943981
Wabco
(Type C3, ABS + 446 004 079 0
ASR)
Norgren-Herion
Solenoid Valve 8158342
9041005374302400
3962640 Norgren-Herion
Solenoid Valve 3986621 9042006374302400
Throttle control
Early vehicles
Air Compressor 70303446 LP4996 LK4921 3 bolt flange mounted
(2W600R) II38845F K001268000 Replaced by 70305892
Wabco
Single Check Valve 1626982
434 012 003 0 KW4455/1 M22 ports
Air Suspension
Wabco
Interlock Valve 1580024
434 205 026 0
"Broms" brake
Wabco
Double Check Valve 9522564
434 208 035 0 295358 M16 ports, bracket mounted
Wabco
From Chassis 26577
Quick Release Valve 9518619 973 500 039 0 KX2000/1 M22 Voss ports
973 500 044 0
Wabco
Supply Dump Valve 1585345
973 002 422 0 SDM2GA
Pressure Relief
(Safety) Valve
1622431 KX1729/2 KX1729/2 10 bar, M16 thread
Pressure Relief
(Safety) Valve
1622432 KX1729/5 KX1729/5 13 bar, M16 thread
Wabco
Tilt Drain Valve 1081328
934 300 033 0 KW2350/2 M22 thread
Wabco
Test Connector 1592924
463 703 120 0 KW4282/2 M16 thread
Wabco
Wheel Speed Sensor 20490824
441 032 964 2
ABS Electronic
Control Unit 3943981
Wabco
(Type C3, ABS + 446 004 079 0
ASR)
Air Suspension
Air Suspension
Control Module
3944717 0501100014000 0501100029000 Rear axle
Norgren-Herion
Solenoid Valve 3986621
9042006374302400
Throttle control
Front
Axle Brake Chamber On Meritor Disc Brakes
with
(Type 20HE)
3112670 1186883-08 1186883-08 Diaphragm 20LS
Disc
Brakes
Rear
Axle Spring Brake 1066850 MGM On Z-cam Brakes
with K2B0521X50
Drum (Type 30/30) 70330015 4130063 Diaphragm 234101K
Brakes
Trailing
Axle Spring Brake 1066851 On Z-cam Brakes
with Wabco
Drum (Type 20/ ) 70330017 Diaphragm 234099K
Brakes
70301332
70306886 Meritor
Air Disc Brake 70311512 LRG592
Left side
70330022
70301333
70306887 Meritor
Air Disc Brake 70311513 LRG593
Right side
70330023
Front
Axle
85105485 Meritor
Disc Brake Pad Set 20825594 MDP5061
276
Knorr-Bremse Air Disc Brakes
Service Parts
In addition Knorr-Bremse offers a wide range of service kits for the maintenance
of Air Disc Brakes. The part numbers for these are listed within this catalogue.
Remember: Always wind out and check the Tappets and Boots within the
Caliper at every Pad change. If the Brake Pads have been in the Air Disc Brake
for more than two years, when you are changing the Pads, fit new Tappets and
Boots regardless of their appearance. Obtain and read the Service Manual from
our website: www.Knorr-BremseCVS.com or from the Applics CD.
Brake Pad
Tappet and
Boot Kit
Caliper
Carrier
Brake Disc
277
p l e
e o
n p
l l i o e
b i t h
n 1 t i n e
h a u s m s
e t r t r r e
o r e i r - B
M t t h o r a y
p u K n y d
o f v e r
e t y s e
s a f c t
d u
p r o
278
Commercial Vehicle Systems
This publication is subject to alteration without notice. A printed copy of this document may not be the latest revision. Please check our website www.knorr-bremseCVS.com for the latest update or contact your local
Knorr-Bremse representative. The figurative mark “K” and the trademarks KNORR and KNORR-BREMSE are registered in the name of Knorr-Bremse AG. Copyright 2007 © Knorr-Bremse AG - all rights reserved,
Knorr-Bremse Knorr-Bremse
Austria Sistemi per Autoveicoli System for Tunga Fordon AB Australia
Knorr-Bremse GmbH Commerciali S.p.A. Malmö Knorr-Bremse
Systeme für Nutzfahrzeuge Arcore Tel: +46 40 680 5880 Australia Pty. Ltd.
Mödling Tel: +39 039 6075-1 Fax: +46 40 937490 Granville NSW
Tel: +43 2236 409-436 Fax: +39 039 6075-435 Tel: +61 2 8863-6500
Fax: +43 2236 409-434 Switzerland Fax: +61 2 8863-6151
Netherlands Knorr-Bremse
Belgium Knorr-Bremse Benelux B.V.B.A. Systeme für Nutzfahrzeuge GmbH China
Knorr-Bremse Benelux B.V.B.A. Mydrecht Bassersdorf Knorr-Bremse
Heist-op-den-Berg Tel: +31 297 239-330 Tel: +41 44 888 77-55 Brake Equipment (Shanghai)
including industrial property rights applications. Knorr-Bremse AG retains any power of disposal, such as for copying and transferring. Released 12/2007
Tel: +32 1525 7900 Fax: +31 297 239-339 Fax: +41 44 888 77-50 Co. Ltd.
Fax: +32 1524 9240 Shanghai
Poland Turkey Tel: +86 21 6891-7500
Czech Republic Knorr-Bremse Polska SfN Sp. z o.o. Knorr-Bremse Fax: +86 21 6891-7510
Knorr-Bremse Systémy pro Warsaw Systeme für Nutzfahrzeuge GmbH
uzitková vozidla, CR, s.r.o. Tel: +48 22 887-3870 Findikli - Istanbul China
Hejnice Fax: +48 22 531-4170 Tel: +90 212 293-4742 Knorr-Bremse
Tel: +420 482 363-611 Fax: +90 212 293-4743 Asia Pacific (Holding) Limited
Fax: +420 482 363-711 Russia Truck Brake Systems Division
Knorr-Bremse RUS United Kingdom Hong Kong
France Nizhniy Novgorod Knorr-Bremse Tel: +852 3657-9800
Knorr-Bremse Tel: +7 8312 57-6661 Systems for Commercial Fax: +852 3657-9901
Systèmes pour Véhicules Fax: +7 8312 57-6791 Vehicles Ltd.
Utilitaires France S.A. Bristol India
Lisieux Cedex Russia Tel: +44 117 9846-100 Knorr-Bremse
Tel: +33 2 3132 1200 Knorr-Bremse Fax: +44 117 9846-101 Systems for Commercial Vehicles
Fax: +33 2 3132 1303 Systeme für Nutzfahrzeuge GmbH India Private Ltd.
Moscow America Pune
Germany Tel: +7 495 234-4995 Tel: +91 20 2293-9141-47
Hasse & Wrede GmbH Fax: +7 495 234-4996 Brazil Fax: +91 20 2293-9148
Berlin Knorr-Bremse
Tel: +49 30 9392-3101 South Africa Sistemas para Veículos Japan
Fax: +49 30 7009-0811 Knorr-Bremse S.A. Pty. Ltd. Comerciais Brasil Ltda. Knorr-Bremse
Kempton Park São Paulo Commercial Vehicle Systems
Germany Tel: +27 11 961-7800 Tel: +55 11 5681 1104 Japan Ltd.
Knorr-Bremse Systeme für Fax: +27 11 975-8249 Fax: +55 11 5686 3905 Tokyo
Nutzfahrzeuge GmbH Tel: +81 3 3971-8501
Spain USA Fax: +81 3 3971-8579
Munich
Bost Ibérica, S.L. Bendix Commercial Vehicle
Tel: +49 89 3547-0 Systems LLC
Irun (Guipuzcoa) Korea
Fax: +49 89 3547-2767 Elyria, OH
Tel: +34 902 100-569 Knorr-Bremse
Fax: +34 943 614-063 Tel: +1 440 329-9100 Korea Ltd. Truck Brake Division
Hungary Fax: +1 440 329-9105 Seoul
Knorr-Bremse
Tel: +82 2 2273-1182
Fékrendszerek Kft.
Fax: +82 2 2273-1184
Kecskemét
Tel: +36 76 511 100
Fax: +36 76 481 100
Y049693_EN_000
(KBP2175/4)
w w w. k n o r r - b r e m s e C V S . c o m