1) The document describes the steps for operating an air shower and conveyor belt system.
2) It involves turning off the emergency stop switch, placing cartons on the conveyor belt, pressing start to begin the conveyor and air shower processes.
3) The conveyor and air systems will stop automatically if no cartons are removed within 20 seconds of reaching the end of the conveyor, or if the emergency stop switch is pressed.
1) The document describes the steps for operating an air shower and conveyor belt system.
2) It involves turning off the emergency stop switch, placing cartons on the conveyor belt, pressing start to begin the conveyor and air shower processes.
3) The conveyor and air systems will stop automatically if no cartons are removed within 20 seconds of reaching the end of the conveyor, or if the emergency stop switch is pressed.
1) The document describes the steps for operating an air shower and conveyor belt system.
2) It involves turning off the emergency stop switch, placing cartons on the conveyor belt, pressing start to begin the conveyor and air shower processes.
3) The conveyor and air systems will stop automatically if no cartons are removed within 20 seconds of reaching the end of the conveyor, or if the emergency stop switch is pressed.
Original State (原始状态) Steps of Air shower and Conveyor (Forward)
Turn off the E-stop switch
复位E-STOP急停开关 Put cartons conveyor 把纸箱放在运输机上
Press Start 按 启动键
Conveyer moving, air shower
working, Ionizer blower , Ionizer bar are working Operator pick up cartons 运输机正转,风淋室吹淋, 工作人员拿走纸箱 离子风棒工作,离子风机工
Conveyor, air shower Ionizer bar
and ionizer blower stop working Cartons pass through air 运输机,风淋室,离子风棒,离 shower 纸箱通过风淋吹淋 子风机全部停止工作 Nobody pick up cartons, sensor on for 20seconds, trigger to stop 没人拿走 Cartons arrive at sensor (end 纸箱,光电继续感应20s of conveyor) 纸箱到到自动运 左右 (10-60s 可调) 纸 输机末端的光电位置 Converyor and air shower, 箱没拿走后,触发系统停 ionizer bar, Inoizer blower 止工作 Sensor 2 off for few stop working, 运输机,风 mintus, trigger to stop . 淋室,离子风机,离子风 Or Press the each one of 棒全部停止工作 E-stop switch Conveyer still moving,air 光电2如果空载运行几 shower ,ionizer bar, Ionizer 分钟后,触发系统停止, All bags is cleared, no bags on 或者 按E-STOP急停开关 blower are still working, 运输 conveyor for few minutes , 机机械运转,风淋室,离子 (controlled by PLC) 风棒离子风机继续工作 纸箱吹淋好,运输机的纸箱全部拿 Operator pick up cartons,拿走纸箱