Professional Documents
Culture Documents
This warranty applies to the following part numbers: A400002748, A400002048, A400002036 and A400002043.
authorized source, provide (at MCFA’s choice) a new, remanufactured or MCFA-approved repaired part and service is the responsibility of the customer. The customer is required to keep documented evidence
needed to correct the defect. of when and by whom maintenance and service are performed.
MCFA is not responsible for a defect resulting from: Warranty Limitations and Disclaimers
• Any use or installation which MCFA determines is improper The foregoing shall constitute the sole and exclusive remedy of any customer of an MCFA Cat lift trucks
• The use of attachments, accessory items and parts not distributed by MCFA hand pallet truck and the sole and exclusive responsibility of MCFA and in lieu of all other warranties,
• Repairs by other than an MCFA authorized repair facility expressed, implied, or statutory, including but not limited to any implied warranty of merchantability, or
• Abuse, accident, neglect and/or improper repair or storage, including the installation of a part or fitness for a particular purpose. MCFA neither assumes nor authorizes any person to assume for it any
assembled component in a contaminated system other obligation or responsibility in connection with this Cat lift trucks hand pallet truck warranty. In no
• Customer’s unreasonable delay in making the defective part or assembled component available event shall MCFA be responsible for direct, indirect, special or consequential damages, or for any delay
after being notified of a potential product problem or any economic or commercial loss resulting from MCFA’s performance or non-performance under this
warranty. This warranty is expressly in lieu of all warranties, obligations or responsibilities of MCFA Cat
MCFA reserves the right to make changes in design and improvement without incurring any obligation to lift truck dealers, expressed, implied or statutory.
incorporate such improvements in any product already shipped from its factory premises of which is in
the hands of the customer. Known failed or defective parts or assembled components must be immediately removed from service.
Copyright © 2009 by MCFA. All rights reserved. CAT, CATERPILLAR, their respective logos, "Caterpillar Yellow" and the POWER EDGE trade dress, as well as corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.